Bulletins
| Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
|---|---|---|---|---|---|
| FUEL SYSTEM, GASOLINE | |||||
| 240708 | 11/19/2007 | 24 07 19 | 10022451 | Mil on (dtc p310b and/or p129f). *kb updated 5/13/08. *nj | 08/15/2007 |
| FUEL SYSTEM, GASOLINE - DELIVERY - FUEL PUMP | |||||
| KM-1379 | 06/30/2009 | 10030593 | Audi: mil light on and dtc p2294 (fuel pressure regulator 2 control circuit), p2295 (fuel pressure regulator 2 control circuit low), p2296 (fuel pressure regulator 2 control circuit high) in fault memory drivability is not affected. wiring | 10/23/2009 | |
| FUEL SYSTEM, GASOLINE - FUEL INJECTION SYSTEM - INJECTORS | |||||
| 0501 | 04/12/2005 | 0502 | 10015098 | Fuel injectors, unnecessary replacement. update. *tt | 05/19/2005 |
| 240501 | 02/15/2005 | 10012766 | Fuel injectors, unnecessary replacement. *tt | 03/14/2005 | |
| FUEL SYSTEM, GASOLINE - STORAGE - AUXILLARY TANK | |||||
| 200704 | 06/07/2007 | 10022450 | Thumping, knocking or popping noise in fuel tank area. *kb | 08/15/2007 | |
| 20142931 | 03/05/2007 | 10021416 | Thumping, knocking or popping noise in fuel tank area. *kb | 04/25/2007 | |
| FUEL SYSTEM, GASOLINE - STORAGE - TANK ASSEMBLY | |||||
| 0501 | 07/08/2005 | 0503 | 10015575 | Fuel door does not function (can not be opened or closed). *tt update. *tt | 07/29/2005 |
| FUEL SYSTEM, GASOLINE - STORAGE - TANK ASSEMBLY - FILLER PIPE AND CAP | |||||
| 20143571 | 03/19/2007 | 10021425 | Fuel filling problems. *kb | 04/25/2007 | |
| FUEL SYSTEM, OTHER | |||||
| TSB-24-10-02 | 01/29/2010 | 10034344 | Audi: mil on and one or more of the following dtcs are stored in the ecm data memory-p310b (low pressure fuel system regulation, fuel pressure outside tolerance); p129f or p008b (low pressure fuel system, pressure too high); p129e or p008a | 11/05/2010 | |
| 0503 | 08/31/2005 | 10016507 | Fuel gauge does not go to full after filling up. when the fuel tank has been filled, the fuel gauge needle registers empty, stays in the reserve section, or slowing goes to full. *tt | 09/19/2005 | |
| FUEL SYSTEM, OTHER - DELIVERY - FUEL PUMP | |||||
| SB090111 | 09/01/2011 | 10040959 | Ready | 09/14/2011 | |
| SB090111 | 09/01/2011 | 10040959 | Volkswagen service campaign: see document search button for owner letter. production issues may cause premature wear on the intake camshaft and camshaft follower. malfunction light will illuminate. *rm | 09/14/2011 | |
| KM-1379 | 06/30/2009 | 10030593 | Audi: mil light on and dtc p2294 (fuel pressure regulator 2 control circuit), p2295 (fuel pressure regulator 2 control circuit low), p2296 (fuel pressure regulator 2 control circuit high) in fault memory drivability is not affected. wiring | 10/23/2009 | |
| FUEL SYSTEM, OTHER - STORAGE - FUEL GAUGE SYSTEM | |||||
| TSB-20-10-07 | 08/11/2010 | 10035265 | Audi: fuel gauge reads empty after refueling (dtcs 00438, 00771). due to the unattached section of cable in the area of the 2 pin plug in connections (inside the fuel tank) between the flange of the electric fuel pump and the fuel gauge s | 02/14/2011 | |
| FUEL SYSTEM, OTHER - STORAGE - TANK ASSEMBLY - PRESSURE RELIEF DEVICES | |||||
| TSB-24-10-01 | 01/12/2010 | 10033025 | Audi: due to fuel intrusion into the low pressure system fuel pressure sensor (g410), a false signal may be sent to the controller, resulting in a reading that is out of tolerance. comparing measure value block 103 with 106 is not an accu | 06/25/2010 | |
Investigations
| NHTSA ID | Manufacturer | Date open | Date close | Subject | Recall campaign | |
|---|---|---|---|---|---|---|
| FUEL SYSTEM, GASOLINE - STORAGE - TANK ASSEMBLY | ||||||
| PE08008 | VOLKSWAGEN OF AMERICA, INC | 01/31/2008 | 05/30/2008 | FUEL TANK LEAK | 08V156000 | |
| Volkswagen (vw) is recalling certain vw passat 4motion and audi a6 quattro and allroad quattro all-wheel drive passenger cars.vw vehicles subject to recall were manufactured from november 22, 2000 through may 31, 2005 and audi vehicles subject to recall were manufactured from june 2, 2001 to june 1, 2005.the nhtsa recall number for the vw vehicles is 08v-156 (vw also is correcting defects related to heat shield and fuel line hazards for these vehicles and for 1999-2000 passats in this recall action.)the nhtsa recall number for the audi vehicles is 08v-157.since 2006, odi has received 17 complaints of fuel leaking from the subject vehicles' fuel tanks.the 400 complaints shown above may include duplicate reports to odi and the manufacturer. while the consequence (fuel leaks from the top of the tank) is similar for both the passat and audi subject vehicles, differences in design and construction require a different remedy for each vehicle.on the passats, the ventilation line could have been installed improperly with tension and with an incorrectly positioned cable tie.the tension could cause cracked or broken nipples on the fuel tank rollover valve.on the audi vehicles, a material change (effective june 2, 2001) with different aging characteristics used for the rollover valve and the use of an inflexible aluminum ventilation line could cause cracking of the nipple on the rollover valve.vw is recalling all vehicles subject to these defects.it will inspect passats to ensure that the vent line is tension free and correct the installation if tension is found.if a crack or fuel leak is found, vw will replace the fuel tank.audi will repair all subject vehicles by reinforcing the fuel tank rollover valve with an epoxy adhesive.this investigation is closed. | ||||||
| PE08008 | VOLKSWAGEN OF AMERICA, INC | 01/31/2008 | 05/30/2008 | FUEL TANK LEAK | 08V157000 | |
| Volkswagen (vw) is recalling certain vw passat 4motion and audi a6 quattro and allroad quattro all-wheel drive passenger cars.vw vehicles subject to recall were manufactured from november 22, 2000 through may 31, 2005 and audi vehicles subject to recall were manufactured from june 2, 2001 to june 1, 2005.the nhtsa recall number for the vw vehicles is 08v-156 (vw also is correcting defects related to heat shield and fuel line hazards for these vehicles and for 1999-2000 passats in this recall action.)the nhtsa recall number for the audi vehicles is 08v-157.since 2006, odi has received 17 complaints of fuel leaking from the subject vehicles' fuel tanks.the 400 complaints shown above may include duplicate reports to odi and the manufacturer. while the consequence (fuel leaks from the top of the tank) is similar for both the passat and audi subject vehicles, differences in design and construction require a different remedy for each vehicle.on the passats, the ventilation line could have been installed improperly with tension and with an incorrectly positioned cable tie.the tension could cause cracked or broken nipples on the fuel tank rollover valve.on the audi vehicles, a material change (effective june 2, 2001) with different aging characteristics used for the rollover valve and the use of an inflexible aluminum ventilation line could cause cracking of the nipple on the rollover valve.vw is recalling all vehicles subject to these defects.it will inspect passats to ensure that the vent line is tension free and correct the installation if tension is found.if a crack or fuel leak is found, vw will replace the fuel tank.audi will repair all subject vehicles by reinforcing the fuel tank rollover valve with an epoxy adhesive.this investigation is closed. | ||||||
| FUEL SYSTEM, OTHER - STORAGE - TANK ASSEMBLY - PRESSURE RELIEF DEVICES | ||||||
| PE08008 | VOLKSWAGEN OF AMERICA, INC | 01/31/2008 | 05/30/2008 | FUEL TANK LEAK | 08V157000 | |
| Volkswagen (vw) is recalling certain vw passat 4motion and audi a6 quattro and allroad quattro all-wheel drive passenger cars.vw vehicles subject to recall were manufactured from november 22, 2000 through may 31, 2005 and audi vehicles subject to recall were manufactured from june 2, 2001 to june 1, 2005.the nhtsa recall number for the vw vehicles is 08v-156 (vw also is correcting defects related to heat shield and fuel line hazards for these vehicles and for 1999-2000 passats in this recall action.)the nhtsa recall number for the audi vehicles is 08v-157.since 2006, odi has received 17 complaints of fuel leaking from the subject vehicles' fuel tanks.the 400 complaints shown above may include duplicate reports to odi and the manufacturer. while the consequence (fuel leaks from the top of the tank) is similar for both the passat and audi subject vehicles, differences in design and construction require a different remedy for each vehicle.on the passats, the ventilation line could have been installed improperly with tension and with an incorrectly positioned cable tie.the tension could cause cracked or broken nipples on the fuel tank rollover valve.on the audi vehicles, a material change (effective june 2, 2001) with different aging characteristics used for the rollover valve and the use of an inflexible aluminum ventilation line could cause cracking of the nipple on the rollover valve.vw is recalling all vehicles subject to these defects.it will inspect passats to ensure that the vent line is tension free and correct the installation if tension is found.if a crack or fuel leak is found, vw will replace the fuel tank.audi will repair all subject vehicles by reinforcing the fuel tank rollover valve with an epoxy adhesive.this investigation is closed. | ||||||
| PE08008 | VOLKSWAGEN OF AMERICA, INC | 01/31/2008 | 05/30/2008 | FUEL TANK LEAK | 08V156000 | |
| Volkswagen (vw) is recalling certain vw passat 4motion and audi a6 quattro and allroad quattro all-wheel drive passenger cars.vw vehicles subject to recall were manufactured from november 22, 2000 through may 31, 2005 and audi vehicles subject to recall were manufactured from june 2, 2001 to june 1, 2005.the nhtsa recall number for the vw vehicles is 08v-156 (vw also is correcting defects related to heat shield and fuel line hazards for these vehicles and for 1999-2000 passats in this recall action.)the nhtsa recall number for the audi vehicles is 08v-157.since 2006, odi has received 17 complaints of fuel leaking from the subject vehicles' fuel tanks.the 400 complaints shown above may include duplicate reports to odi and the manufacturer. while the consequence (fuel leaks from the top of the tank) is similar for both the passat and audi subject vehicles, differences in design and construction require a different remedy for each vehicle.on the passats, the ventilation line could have been installed improperly with tension and with an incorrectly positioned cable tie.the tension could cause cracked or broken nipples on the fuel tank rollover valve.on the audi vehicles, a material change (effective june 2, 2001) with different aging characteristics used for the rollover valve and the use of an inflexible aluminum ventilation line could cause cracking of the nipple on the rollover valve.vw is recalling all vehicles subject to these defects.it will inspect passats to ensure that the vent line is tension free and correct the installation if tension is found.if a crack or fuel leak is found, vw will replace the fuel tank.audi will repair all subject vehicles by reinforcing the fuel tank rollover valve with an epoxy adhesive.this investigation is closed. | ||||||