Bigdog Ridgeback 2005
Model Ridgeback made in 2005 by Bigdog got 4 consumer complains there are 6 recalls as well as 25 service bulletins. Consumer complaints with reference to wheels. . Technical service bulletines regarding communications, electrical system and engine and engine cooling. There were some recalls concerningelectrical system, power train and structure.
Model 2005
Recalls
Campaign | Manufacturer | Manufacturing date | Type | # of units affected | Date Owner notified Mfg | Recall Initiated by | Manufacturers of recalled vehicles/products | Report Recieved Date | Record Creation Date | Regulation Part Number | FMVSS Number | |||||
---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|
ELECTRICAL SYSTEM | ||||||||||||||||
06V305000 | BIG DOG MOTORCYCLES, LLC | V (Vehicle) | 2101 | 09/19/2006 | MFR | BIG DOG MOTORCYCLES, LLC | 08/11/2006 | 08/11/2006 | ||||||||
Defect Summary | On certain motorcycles, the electronic harness control (ehc) module can fail resulting in a total shut down of the vehicle's electronic power. | |||||||||||||||
Consequence Summary | This condition could occur without any prior warning and could result in a crash. | |||||||||||||||
Corrective Summary | Dealers will replace the ehc modules free of charge. the recall began on september 19, 2006. owners may contact big dog at 316-267-9121. | |||||||||||||||
Notes | Customers may also contact the national highway traffic safety administration | |||||||||||||||
ELECTRICAL SYSTEM - ALTERNATOR/GENERATOR/REGULATOR | ||||||||||||||||
07V356000 | BIG DOG MOTORCYCLES, LLC | from 09/10/2004 to 08/10/2005 | V (Vehicle) | 7611 | 10/01/2007 | MFR | BIG DOG MOTORCYCLES, LLC | 08/08/2007 | 08/15/2007 | |||||||
Defect Summary | On certain motorcycles, a warped bus bar within the voltage regulator can cause a short circuit. | |||||||||||||||
Consequence Summary | This could possibly result in a fire. | |||||||||||||||
Corrective Summary | Dealers will replace the existing circuit breaker located between the voltage regulator positive battery lead (b+ lead) and the positive battery terminal with an alternative circuit protection device that will prevent a thermal event if there is a short to ground. the recall began on october 1, 2007. owners may contact big dog at 1-316-219-9129 or email to customer.service@bigdogmotorcycles.com. | |||||||||||||||
Notes | Customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov. | |||||||||||||||
POWER TRAIN | ||||||||||||||||
05V149000 | BIG DOG MOTORCYCLES, LLC | from 08/01/2004 to 01/22/2005 | V (Vehicle) | 1418 | 05/13/2005 | MFR | BIG DOG MOTORCYCLES, LLC | 04/14/2005 | 04/14/2005 | |||||||
Defect Summary | On certain motorcycles, the primary drive sprocket nut may back off the engine main shaft. | |||||||||||||||
Consequence Summary | This could cause the primary drive to lock up and cause a crash. this condition could occur without any prior warning. | |||||||||||||||
Corrective Summary | Dealers will inspect and replace the drive sprocket nut free of charge. the recall began on may 13, 2005. owners may contact big dog at 316-267-9121. | |||||||||||||||
Notes | Customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov. | |||||||||||||||
STRUCTURE - MOTORCYCLE KICKSTAND/CENTER STAND | ||||||||||||||||
06V019000 | BIG DOG MOTORCYCLES, LLC | from 08/08/2003 to 01/13/2006 | V (Vehicle) | 9726 | 02/17/2006 | MFR | BIG DOG MOTORCYCLES, LLC | 01/25/2006 | 01/25/2006 | |||||||
Defect Summary | On certain motorcycles, the kickstand spring may stretch and detach from the mounting bracket or the kickstand. | |||||||||||||||
Consequence Summary | This will allow the kickstand to deploy into the extended position and cause a crash. | |||||||||||||||
Corrective Summary | Dealers will install a new kickstand spring free of charge. the recall began on february 17, 2006. owners may contact big dog at 316-267-9121. | |||||||||||||||
Notes | Customers may also contact the national highway traffic safety administration | |||||||||||||||
WHEELS - CENTER SECTION | ||||||||||||||||
09V147000 | BIG DOG MOTORCYCLES, LLC | from 09/10/2004 to 07/25/2005 | V (Vehicle) | 1257 | 05/29/2009 | MFR | BIG DOG MOTORCYCLES, LLC | 05/01/2009 | 05/01/2009 | |||||||
Defect Summary | Big dog is recalling 1,257 my 2005 ridgeback motorcycles. the rear wheel may have weak spots in the design, which may cause the wheel to crack under certain operating conditions. | |||||||||||||||
Consequence Summary | If undetected, this condition may lead to a crash. | |||||||||||||||
Corrective Summary | Dealers will inspect and replace the wheels free of charge. the recall began on june 1, 2009. owners may contact big dog motorcycles customer service department at 1-316-267-9121. | |||||||||||||||
Notes | Owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov . | |||||||||||||||
WHEELS - LUGS/NUTS/BOLTS | ||||||||||||||||
05V432000 | BIG DOG MOTORCYCLES, LLC | from 09/20/2004 to 06/01/2005 | V (Vehicle) | 3294 | 10/14/2005 | MFR | BIG DOG MOTORCYCLES, LLC | 09/28/2005 | 09/29/2005 | |||||||
Defect Summary | On certain motorcycles, the rear wheel hub bolts could loosen and back out allowing the hub and brake rotor to detach from the wheel with an associated loss of stopping power. | |||||||||||||||
Consequence Summary | This condition could occur without any prior warning and could result in a crash. | |||||||||||||||
Corrective Summary | Dealers will remove, clean and reattach the rear hub bolts free of charge. the recall began on october 14, 2005. owners may contact big dog at 1-312-267-9121. | |||||||||||||||
Notes | Customers may also contact the national highway traffic safety administration |
Bulletins
Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
---|---|---|---|---|---|
COMMUNICATIONS - HORN ASSEMBLY | |||||
1088 | 06/30/2006 | 10020152 | Horn harness wires may break. *tt | 07/28/2006 | |
ELECTRICAL SYSTEM | |||||
1069 | 11/03/2006 | 1069A | 10020064 | Intermittent printed circuit board operation. *tt | 07/18/2006 |
1078 | 06/23/2006 | 1078A | 10020045 | Ehc contact improvement procedure (revised). current seal does not allow connector pins to seat properly and moisture may be present in connector. *tt | 07/14/2006 |
1075 | 05/03/2006 | 10019909 | Dielectric grease addition to connectors. *tt | 05/10/2006 | |
1072 | 03/27/2006 | 1072 | 10018991 | Inaccurate speedometer operation - vibrations at high speed are causing signal loss to needle from speed sensor. *tt | 01/26/2006 |
ELECTRICAL SYSTEM - IGNITION | |||||
1058 | 08/22/2005 | 10017597 | Engine running only on one cylinder and/or damaged ignition coil or ignition module. *tt | 11/14/2005 | |
ELECTRICAL SYSTEM - STARTER ASSEMBLY | |||||
1055 | 07/10/2005 | 10017541 | Primary drive fluid seeping from the starter housing. *tt | 11/09/2005 | |
ENGINE AND ENGINE COOLING - ENGINE | |||||
1079 | 04/13/2006 | 10019776 | Upper engine mount screw is loose or missing. *ak | 04/26/2006 | |
1061 | 09/10/2005 | 10016969 | 1/2 - 20 inch upper engine mount bolt retention. big dog. *tt | 10/18/2005 | |
ENGINE AND ENGINE COOLING - ENGINE - GASOLINE - BELTS AND ASSOCIATED PULLEYS | |||||
1059 | 09/10/2005 | 10017598 | Abnormal primary chain noise resulting from displacement of the adjusting shoe 10mm external snap ring retainer. *tt | 11/14/2005 | |
ENGINE AND ENGINE COOLING - EXHAUST SYSTEM | |||||
1056 | 07/10/2005 | 10017596 | Exhaust end cap resonating rattling noise. *tt | 11/14/2005 | |
EQUIPMENT | |||||
SB-1102 | 04/11/2008 | 10027045 | Bigdog motorcycle: hidden shock electrical cover hardware replacement. electrical side covers may crack or break. 243-000011-00 for all models except 2006 k9. 243-000013-00 for 2006 k9 model. *pe | 01/06/2009 | |
EQUIPMENT ADAPTIVE | |||||
SB-1102 | 04/11/2008 | 10027045 | Bigdog motorcycle: hidden shock electrical cover hardware replacement. electrical side covers may crack or break. 243-000011-00 for all models except 2006 k9. 243-000013-00 for 2006 k9 model. *pe | 01/06/2009 | |
EQUIPMENT - ELECTRICAL | |||||
SB-1102 | 04/11/2008 | 10027045 | Bigdog motorcycle: hidden shock electrical cover hardware replacement. electrical side covers may crack or break. 243-000011-00 for all models except 2006 k9. 243-000013-00 for 2006 k9 model. *pe | 01/06/2009 | |
EQUIPMENT - OTHER - OWNERS/SERVICE/OTHER MANUAL | |||||
SB-1106 | 04/18/2008 | 10026833 | Bigdog motorcycle: new primary inspection cover gasket. install new inspection cover gasket on all 2005-2008 big dog motorcycles. *pe | 12/23/2008 | |
SIL-0008 | 05/11/2008 | 10026442 | Big dog motorcycle: electrical side cover contact with belt guard. a wire bundle may protrude into the right electrical side cover. *pe | 10/29/2008 | |
SIL-0001 | 04/18/2008 | 10026428 | Bigdog motorcycles: this letter highlights the difference between the various electronic harness controllers (ehcs). for models years 2005-2009 motorcycles. *pe | 10/28/2008 | |
EXTERIOR LIGHTING - HEADLIGHTS | |||||
1077 | 06/16/2006 | 10020065 | Headlamp connector may melt, making bulb replacement difficult. *tt | 07/18/2006 | |
FUEL SYSTEM, OTHER - STORAGE - TANK ASSEMBLY | |||||
SB-1099 | 01/11/2008 | 10026832 | Bigdog motorcycle: fuel tank vent may become flooded with fuel, causing the motorcycle to run poorly due to a fuel mixture that is too rich. *pe | 12/23/2008 | |
POWER TRAIN | |||||
1090 | 08/25/2006 | 10020374 | Rough shifting, or noisy transmission caused by loose transmission countershaft screw. *tt | 09/25/2006 | |
POWER TRAIN - CLUTCH ASSEMBLY | |||||
143 | 08/02/2005 | 10018960 | 05 clutch bearing carrier identification. *ak | 01/25/2006 | |
POWER TRAIN - MANUAL TRANSMISSION | |||||
1054 | 06/02/2006 | 1054A | 10015923 | Baker 6-speed main shaft snap ring. *sc | 08/16/2005 |
STRUCTURE | |||||
1080 | 04/27/2006 | 10019984 | Tachometer board replacement - inaccurate tachometer readings or fluctuation in readings due to moisture. *ak | 05/18/2006 | |
1060 | 09/10/2005 | 10017599 | Seat pan contact with left rear corner and edge of battery case. *tt | 11/14/2005 | |
VEHICLE SPEED CONTROL | |||||
1092 | 05/18/2007 | 10023092 | Bigdog motorcycles - revised speedometer and mount. *nj | 10/22/2007 |
Consumer Complaints
Fail date | miles | occurences | Purchase date |
---|---|---|---|
WHEELS | |||
08/20/2009 | 1520 | ||
Tl*the contact owns a 2005 bigdog ridgeback motorcycle. he stated that the dealer repaired recall 09v147000 component: wheels:center section; however, the failure continued to occur. the dealer wasn't able to balance the wheels; therefore he was unable to drive the motorcycle. the current and the failure mileages were 1,520. | |||
WHEELS - CENTER SECTION | |||
05/29/2009 | 2100 | 1 | 05/01/2005 |
Tl* the contact owns a 2005 big dog ridgeback motorcycle. the vehicle was taken to an authorized dealer in reference to recall campaign id number 09v147000 (wheels:center section). the recall remedy has not been performed due to the unavailability of the part required for the repair. the part was on national back-order. he has been waiting for six months for a remedy. the current mileage was 2,100. updated 11/23/09 *bf updated 11/24/09.*jb | |||
01/01/1901 | 1 | ||
Consumer received recall notice #09v-147 on may 29th for big dog motorcycle's wheel remedy but the dealership do not know when the parts are arriving. *nj recall# 09v147000. *jb | |||
05/29/2009 | 9600 | ||
Tl*the contact owns a 2005 bigdog ridgeback motorcycle. the contact received a recall notice for nhtsa campaign id number 09v147000 (wheels:center section) in may of 2009 and immediately called the dealer. the dealer stated that the wheel was on back order for approximately six months, but advised the contact to schedule an appointment. the manufacturer confirmed that the part was on back order and stated that nothing could be done to assist. the contact feels that a reasonable amount of time has passed in order to receive the recall repair. the failure and current mileages were 9,600. |