Bmw 325is 1993
Model 325is made in 1993 by Bmw got 27 consumer complains there are 3 recalls as well as 1 service bulletin. Consumer complaints with reference, among others things, to air bags, engine and engine cooling and exterior lighting. Technical service bulletines regarding structure. There were some recalls concerningengine and engine cooling, service brakes, hydraulic and vehicle speed control.
Model 1993
Recalls
| Campaign | Manufacturer | Manufacturing date | Type | # of units affected | Date Owner notified Mfg | Recall Initiated by | Manufacturers of recalled vehicles/products | Report Recieved Date | Record Creation Date | Regulation Part Number | FMVSS Number | |||||
|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|
| ENGINE AND ENGINE COOLING - COOLING SYSTEM | ||||||||||||||||
| 98V178000 | BAYERISCHE MOTOREN WERKE | from 03/01/1991 to 11/30/1994 | V (Vehicle) | 340000 | 03/31/1999 | MFR | BAYERISCHE MOTOREN WERKE | 08/04/1998 | 08/14/1998 | |||||||
| Defect Summary | Vehicle description: passenger vehicles. a malfunction or failure of a coolant system component, such as a thermostat, water pump, or fan belt, can result in significantly increased coolant temperature and system pressure. if the indications of a critical overheating condition is not noticed by the driver, it is possible that damage to, or failure of, a coolant system component could occur. | |||||||||||||||
| Consequence Summary | If a crack were to form or a seam were to separate in the heater core end piece, hot coolant could suddenly be expelled, increasing the risk of personal injury to a vehicle occupant. | |||||||||||||||
| Corrective Summary | Dealers will install a new design radiator cap to control pressure and provide greater coolant overflow in the event of overheating. | |||||||||||||||
| Notes | Owner notification began march 31, 1999. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact bmw at 1-800-831-1117.also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236). | |||||||||||||||
| SERVICE BRAKES, HYDRAULIC - SWITCHES - BRAKE LIGHT | ||||||||||||||||
| 96V111000 | BAYERISCHE MOTOREN WERKE | from 01/01/1990 to 03/01/1994 | V (Vehicle) | 180000 | 09/30/1996 | MFR | BAYERISCHE MOTOREN WERKE | 07/01/1996 | 07/08/1996 | |||||||
| Defect Summary | The brake light switch can fail allowing the switch to remain in the brake lights off position or in the brake lights on position. | |||||||||||||||
| Consequence Summary | If this happens, the brake lights either will not operate or will be continuously on, regardless of brake pedal position. following drivers would not be able to determine whether the vehicle is stopping, increasing the potential for a vehicle accident. | |||||||||||||||
| Corrective Summary | Dealers will replace the existing brake light switch with a newly designed switch. | |||||||||||||||
| Notes | System: brakes; hydraulic; switch; brake light. vehicle description: passenger vehicles. owner notification: owner notification is expected to begin august 5, 1996. note: owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact bmw at 1-800-831-1117. also contact the national highway traffic safety administration's auto safety hotline at 1-800-424-9393. | |||||||||||||||
| VEHICLE SPEED CONTROL | ||||||||||||||||
| 97V131000 | BAYERISCHE MOTOREN WERKE | from 01/01/1991 to 10/30/1995 | V (Vehicle) | 410000 | 10/30/1997 | MFR | BAYERISCHE MOTOREN WERKE | 08/19/1997 | 08/29/1997 | |||||||
| Defect Summary | The cruise control and throttle cables are attached to the same throttle valve actuating lever at the throttle housing. it is possible that the plastic bushing on either cable could break due to environmental influences coupled with vibration. if the bushing breaks, the outer cable housing can separate from the bushing. in this case, during application of the throttle pedal without cruise control being engaged, the outer tube could catch on the edge of the broken bushing. | |||||||||||||||
| Consequence Summary | This could cause the throttle valve to remain partially open. it his were to occur, the car might not decelerate as expected increasing the risk of a vehicle crash. | |||||||||||||||
| Corrective Summary | Dealers will install a spring steel clip on the outer tube of each cable in the area of the adjusting screw and plastic bushing. the clip is designed to prevent the outer tube from dislodging from the bushing. | |||||||||||||||
| Notes | Owner notification is expected to begin by the end of october 1997. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact bmw at 1-800-831-1117.also contact the national highway traffic safety administration's auto safety hotline at 1-800-424-9393. | |||||||||||||||
Bulletins
| Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
|---|---|---|---|---|---|
| STRUCTURE - FRAME AND MEMBERS | |||||
| 41/03/96 | 11/01/1996 | 50679 | Wind noise diagnostics. *tw | 05/27/1997 | |
Consumer Complaints
| Fail date | miles | occurences | Purchase date |
|---|---|---|---|
| AIR BAGS - FRONTAL | |||
| 08/28/2001 | 80000 | 1 | 08/01/1993 |
| Airbag failure in bmw 1993 325is 40 mph head on collision. *nlm | |||
| ENGINE AND ENGINE COOLING - COOLING SYSTEM | |||
| 03/01/2005 | 8 | ||
| I have a 1993 325is bmw. and there are a number of problems. on rainy days i can hear water in the floor boards. the door panels are both coming ungluded and bubbling. my driver side floor mat hits the gas petal. the check coolant light on my computer is always on, the the coolant is low even after i fill it. i am afaid my car will overheat.*ak | |||
| 07/03/2003 | 92800 | 20 | 07/03/2003 |
| Puchased with email and verbal guarantee no problems with car. have valid consumer complaints against same dealer with misrepresentation of veh.(s) purchased. 1: tcm light on. veh. will not shift. occurred 2nd day of ownership. dealer denies. 2: lights were non-functional upon arrival to dealer. had detailer rewire (4 hours). brake failure light still on computer. 3: dealer ordered and promised pass. window motor. replaced 2 relays while at dealer. did not repair. refuses to send motor for functional window. window will not, and did not roll down even at dealers. 4: verified with dealer guibo joint (propellar shaft front flex disc) at front of driveshaft severely damaged causing steering problems. dealer insisted nothing wrong in email and phone. have 2 witnessed that contacted him in regards to this matter. cost: 330. dealer finally sends funds for repair. refuses in lieu of this to send power window motor. 5: veh. overheats in short stops 6: dealer refuses to make repairs he was fully aware of at time of sale. 7: dealer stated would have emissions tested as i am relocating to calif. failed to do so. 8: power steering pump leaking from 2 lines. verified by my own mechanic. leaking p/s fluid onto other hoses.*ak | |||
| 1 | |||
| Vehicle overheated and when the consumer raised the hood to check the radiator the top flange of the composite radiator broke off under the pressure of the overheating system and sprayed the consumer with scalding coolant causing severe burn injuries (attorney for consumer), the defect was possibly related to recall campaign #93v-015 and 98v-178. *mjs | |||
| 03/05/1999 | 1 | ||
| Vehicle experienced failure of the recall component prior to notice resulting in damage to engine cooling system components (98v-178). mjs | |||
| 05/06/1999 | |||
| Consumer went through a car wash. at the end when pressing the accelerator engine was slow and power gone, also, when starting to go through an intersection, power failed. washed car at home same thing happened , but less. went back to car wash and vehicle had to be pushed out. consumer waited for parts to dry. dealership said the drain hose got clogged, and the water got into the computer component and vehicle would not start for three days. dme was replaced, a bigger drain hose installed, and drilled a hole into the component so tha t access water could drain out. bmw sent a bulletin to dealership on this matter. there were a total of 20 car washes in the san franando and los angelas counties that received reports of similar problems with this make/model and year.*ak | |||
| ENGINE AND ENGINE COOLING - EXHAUST SYSTEM - EMISSION CONTROL | |||
| 07/03/2003 | 92800 | 20 | 07/03/2003 |
| Puchased with email and verbal guarantee no problems with car. have valid consumer complaints against same dealer with misrepresentation of veh.(s) purchased. 1: tcm light on. veh. will not shift. occurred 2nd day of ownership. dealer denies. 2: lights were non-functional upon arrival to dealer. had detailer rewire (4 hours). brake failure light still on computer. 3: dealer ordered and promised pass. window motor. replaced 2 relays while at dealer. did not repair. refuses to send motor for functional window. window will not, and did not roll down even at dealers. 4: verified with dealer guibo joint (propellar shaft front flex disc) at front of driveshaft severely damaged causing steering problems. dealer insisted nothing wrong in email and phone. have 2 witnessed that contacted him in regards to this matter. cost: 330. dealer finally sends funds for repair. refuses in lieu of this to send power window motor. 5: veh. overheats in short stops 6: dealer refuses to make repairs he was fully aware of at time of sale. 7: dealer stated would have emissions tested as i am relocating to calif. failed to do so. 8: power steering pump leaking from 2 lines. verified by my own mechanic. leaking p/s fluid onto other hoses.*ak | |||
| EXTERIOR LIGHTING | |||
| 03/01/2005 | 8 | ||
| I have a 1993 325is bmw. and there are a number of problems. on rainy days i can hear water in the floor boards. the door panels are both coming ungluded and bubbling. my driver side floor mat hits the gas petal. the check coolant light on my computer is always on, the the coolant is low even after i fill it. i am afaid my car will overheat.*ak | |||
| EXTERIOR LIGHTING - BRAKE LIGHTS - SWITCH | |||
| 12/31/1998 | 12/01/1998 | ||
| Brake lights work intermittently! display on dash readsbrake light failure. (also, intermittently!) dealer has informed us that defective brake switch has already been replaced. they will replace switch for $100.00. would this be a normal failure rate on a 6 year old vehicle? *ak | |||
| EXTERIOR LIGHTING - FOG LIGHTS - SWITCH | |||
| 03/01/2005 | 8 | ||
| I have a 1993 325is bmw. and there are a number of problems. on rainy days i can hear water in the floor boards. the door panels are both coming ungluded and bubbling. my driver side floor mat hits the gas petal. the check coolant light on my computer is always on, the the coolant is low even after i fill it. i am afaid my car will overheat.*ak | |||
| EXTERIOR LIGHTING - HEADLIGHTS | |||
| 1 | 02/01/1996 | ||
| Headlights have turned a yellow milky color. i have observed this in other cars of similar type and been told by a bmw mechanic that this is a common occurence with the bmw's. the interior door panel has come unglued and is bubbling. i have also been told by a bmw mechanic and an upholstery repairman that this is a common occurence with the bmw's. i have contacted bmw of north america concerning both problems and been told that the dealer must make the repairs. i contacted a dealer to make the repairs and was told it was not their problem. *ak | |||
| EXTERIOR LIGHTING - TAIL LIGHTS | |||
| 07/03/2003 | 92800 | 20 | 07/03/2003 |
| Puchased with email and verbal guarantee no problems with car. have valid consumer complaints against same dealer with misrepresentation of veh.(s) purchased. 1: tcm light on. veh. will not shift. occurred 2nd day of ownership. dealer denies. 2: lights were non-functional upon arrival to dealer. had detailer rewire (4 hours). brake failure light still on computer. 3: dealer ordered and promised pass. window motor. replaced 2 relays while at dealer. did not repair. refuses to send motor for functional window. window will not, and did not roll down even at dealers. 4: verified with dealer guibo joint (propellar shaft front flex disc) at front of driveshaft severely damaged causing steering problems. dealer insisted nothing wrong in email and phone. have 2 witnessed that contacted him in regards to this matter. cost: 330. dealer finally sends funds for repair. refuses in lieu of this to send power window motor. 5: veh. overheats in short stops 6: dealer refuses to make repairs he was fully aware of at time of sale. 7: dealer stated would have emissions tested as i am relocating to calif. failed to do so. 8: power steering pump leaking from 2 lines. verified by my own mechanic. leaking p/s fluid onto other hoses.*ak | |||
| FUEL SYSTEM, GASOLINE - DELIVERY - FUEL PUMP | |||
| 10/18/2004 | 1 | ||
| While the vehicle was parked, the consumer noticed a liquid leaking from underneath the vehicle. the consumer was able to drive to the dealer for inspection. the mechanic informed the consumer that the fuel sending unit and fuel pump needed replacement. please fill in additional information. *jb | |||
| LATCHES/LOCKS/LINKAGES | |||
| 03/01/2005 | 8 | ||
| I have a 1993 325is bmw. and there are a number of problems. on rainy days i can hear water in the floor boards. the door panels are both coming ungluded and bubbling. my driver side floor mat hits the gas petal. the check coolant light on my computer is always on, the the coolant is low even after i fill it. i am afaid my car will overheat.*ak | |||
| POWER TRAIN - AUTOMATIC TRANSMISSION - CONTROL MODULE (TCM, PCM) | |||
| 07/03/2003 | 92800 | 20 | 07/03/2003 |
| Puchased with email and verbal guarantee no problems with car. have valid consumer complaints against same dealer with misrepresentation of veh.(s) purchased. 1: tcm light on. veh. will not shift. occurred 2nd day of ownership. dealer denies. 2: lights were non-functional upon arrival to dealer. had detailer rewire (4 hours). brake failure light still on computer. 3: dealer ordered and promised pass. window motor. replaced 2 relays while at dealer. did not repair. refuses to send motor for functional window. window will not, and did not roll down even at dealers. 4: verified with dealer guibo joint (propellar shaft front flex disc) at front of driveshaft severely damaged causing steering problems. dealer insisted nothing wrong in email and phone. have 2 witnessed that contacted him in regards to this matter. cost: 330. dealer finally sends funds for repair. refuses in lieu of this to send power window motor. 5: veh. overheats in short stops 6: dealer refuses to make repairs he was fully aware of at time of sale. 7: dealer stated would have emissions tested as i am relocating to calif. failed to do so. 8: power steering pump leaking from 2 lines. verified by my own mechanic. leaking p/s fluid onto other hoses.*ak | |||
| POWER TRAIN - DRIVELINE - CENTER SUPPORT BEARING | |||
| 07/03/2003 | 92800 | 20 | 07/03/2003 |
| Puchased with email and verbal guarantee no problems with car. have valid consumer complaints against same dealer with misrepresentation of veh.(s) purchased. 1: tcm light on. veh. will not shift. occurred 2nd day of ownership. dealer denies. 2: lights were non-functional upon arrival to dealer. had detailer rewire (4 hours). brake failure light still on computer. 3: dealer ordered and promised pass. window motor. replaced 2 relays while at dealer. did not repair. refuses to send motor for functional window. window will not, and did not roll down even at dealers. 4: verified with dealer guibo joint (propellar shaft front flex disc) at front of driveshaft severely damaged causing steering problems. dealer insisted nothing wrong in email and phone. have 2 witnessed that contacted him in regards to this matter. cost: 330. dealer finally sends funds for repair. refuses in lieu of this to send power window motor. 5: veh. overheats in short stops 6: dealer refuses to make repairs he was fully aware of at time of sale. 7: dealer stated would have emissions tested as i am relocating to calif. failed to do so. 8: power steering pump leaking from 2 lines. verified by my own mechanic. leaking p/s fluid onto other hoses.*ak | |||
| POWER TRAIN - DRIVELINE - DIFFERENTIAL UNIT | |||
| 2 | 02/01/1997 | ||
| Original limited slip rear differential assembly was faulty at 14,347 miles and replaced at 18,700 miles by dealer for original owner. second owner complained of similar problems at 70,000 miles and second replacement of limited slip rear differential is in process at 76. *ak | |||
| SEAT BELTS - FRONT - BUCKLE ASSEMBLY | |||
| 10/02/1998 | 5 | ||
| The passenger side seat belt will not latch properly. the locking mechanisim is not catching so the latch fails to lock. *ak | |||
| SEAT BELTS - FRONT - RETRACTOR | |||
| Rear seat belts will not release from the retracting mechanism, causing the seat belts to become inoperable. please give any further details.*ak | |||
| SEAT BELTS - REAR | |||
| 07/03/2003 | 92800 | 20 | 07/03/2003 |
| Puchased with email and verbal guarantee no problems with car. have valid consumer complaints against same dealer with misrepresentation of veh.(s) purchased. 1: tcm light on. veh. will not shift. occurred 2nd day of ownership. dealer denies. 2: lights were non-functional upon arrival to dealer. had detailer rewire (4 hours). brake failure light still on computer. 3: dealer ordered and promised pass. window motor. replaced 2 relays while at dealer. did not repair. refuses to send motor for functional window. window will not, and did not roll down even at dealers. 4: verified with dealer guibo joint (propellar shaft front flex disc) at front of driveshaft severely damaged causing steering problems. dealer insisted nothing wrong in email and phone. have 2 witnessed that contacted him in regards to this matter. cost: 330. dealer finally sends funds for repair. refuses in lieu of this to send power window motor. 5: veh. overheats in short stops 6: dealer refuses to make repairs he was fully aware of at time of sale. 7: dealer stated would have emissions tested as i am relocating to calif. failed to do so. 8: power steering pump leaking from 2 lines. verified by my own mechanic. leaking p/s fluid onto other hoses.*ak | |||
| STEERING - HYDRAULIC POWER ASSIST - HOSE, PIPING, AND CONNECTIONS | |||
| 07/03/2003 | 92800 | 20 | 07/03/2003 |
| Puchased with email and verbal guarantee no problems with car. have valid consumer complaints against same dealer with misrepresentation of veh.(s) purchased. 1: tcm light on. veh. will not shift. occurred 2nd day of ownership. dealer denies. 2: lights were non-functional upon arrival to dealer. had detailer rewire (4 hours). brake failure light still on computer. 3: dealer ordered and promised pass. window motor. replaced 2 relays while at dealer. did not repair. refuses to send motor for functional window. window will not, and did not roll down even at dealers. 4: verified with dealer guibo joint (propellar shaft front flex disc) at front of driveshaft severely damaged causing steering problems. dealer insisted nothing wrong in email and phone. have 2 witnessed that contacted him in regards to this matter. cost: 330. dealer finally sends funds for repair. refuses in lieu of this to send power window motor. 5: veh. overheats in short stops 6: dealer refuses to make repairs he was fully aware of at time of sale. 7: dealer stated would have emissions tested as i am relocating to calif. failed to do so. 8: power steering pump leaking from 2 lines. verified by my own mechanic. leaking p/s fluid onto other hoses.*ak | |||
| STRUCTURE | |||
| 07/15/2004 | 142450 | 1 | 08/19/2003 |
| The rear subframe mount points have ripped in at least one place from the unibody resulting in not being able to safely drive the car. i caught it early so no injury has resulted. this is a common (unacceptable) problem with these cars (bmw e36). *jb | |||
| STRUCTURE - FRAME AND MEMBERS | |||
| 02/27/1997 | 1 | 06/01/1995 | |
| Rear sub frame torn at 2 right points, and cracked around the left forward most mount point. vehicle had not been abused, driven off-road, or on a race track. all original whell, suspension and driveline components were in good working order. *ak | |||
| STRUCTURE - FRAME AND MEMBERS - UNDERBODY SHIELDS | |||
| 06/18/2004 | 1 | ||
| I own a 1993 325is which has a tear in the subframe where the suspension component meet. car was not modified in anyway. i just noticed this loud sound coming from the differential or rear area. took the car into my mechanic and found out that the subframe was torn apart. lucky it didn't come out in the highway or i would i have cause an accident and probably get killed. my mechanic has stated he seen many bmw's with this kind of problems. i have search and contacted other bmw's and it look like its a common failure in early bmw's between 1992-1995's e36. newer model seems to have the subframe reinforce with thicker brackets and new suspension components. total cost for the repair $3600 labor and parts. *jb | |||
| 11/24/2003 | 139829 | 1 | 08/29/2003 |
| My 1993 bmw 325is has a failure of the chassis mounting points for the rear subframe of the car. the car had been feeling funny for weeks prior to this until one day the car started to shudder when taking a turn and accelerating out of it. from that day on the car felt completely detached from my steering inputs, it was obvious something was wrong. had i not caught it when i did, more than just financial damage would have surely occured; after all, these are what hold the whole rear of the suspension and drive train the the chassis. after shelling out over $1500 for repairs to my car which included replacement of a chassis member, new bushings, reinforcement plates, and other small misc items. i did some research to find out that this is a problem that is all to common. if the rear rubber subframe mounts become weak it puts excessive stress on the unitbody. once this happens the chassis will eventually tear, leaving the subframe completely detached from the car. the later model bmw m3's came with reinforcement plates, indicating bmw knows there is a problem. it is unethical to let such a dangerous and wide spread problem go unattended. bmw needs to do something about this important issue.*ak | |||
| VISIBILITY - POWER WINDOW DEVICES AND CONTROLS | |||
| 07/03/2003 | 92800 | 20 | 07/03/2003 |
| Puchased with email and verbal guarantee no problems with car. have valid consumer complaints against same dealer with misrepresentation of veh.(s) purchased. 1: tcm light on. veh. will not shift. occurred 2nd day of ownership. dealer denies. 2: lights were non-functional upon arrival to dealer. had detailer rewire (4 hours). brake failure light still on computer. 3: dealer ordered and promised pass. window motor. replaced 2 relays while at dealer. did not repair. refuses to send motor for functional window. window will not, and did not roll down even at dealers. 4: verified with dealer guibo joint (propellar shaft front flex disc) at front of driveshaft severely damaged causing steering problems. dealer insisted nothing wrong in email and phone. have 2 witnessed that contacted him in regards to this matter. cost: 330. dealer finally sends funds for repair. refuses in lieu of this to send power window motor. 5: veh. overheats in short stops 6: dealer refuses to make repairs he was fully aware of at time of sale. 7: dealer stated would have emissions tested as i am relocating to calif. failed to do so. 8: power steering pump leaking from 2 lines. verified by my own mechanic. leaking p/s fluid onto other hoses.*ak | |||
| VISIBILITY - WINDSHIELD WIPER/WASHER - LINKAGES | |||
| 03/01/2005 | 8 | ||
| I have a 1993 325is bmw. and there are a number of problems. on rainy days i can hear water in the floor boards. the door panels are both coming ungluded and bubbling. my driver side floor mat hits the gas petal. the check coolant light on my computer is always on, the the coolant is low even after i fill it. i am afaid my car will overheat.*ak | |||
Car dealers selling
| State | City | Zip | Name | Phone |
|---|---|---|---|---|
| FL | MIAMI | 33155 | A+CAR SALES | 305-260-4445 |
| WA | FIFE | BMW NORTHWEST |