Bulletins
Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
---|---|---|---|---|---|
ENGINE AND ENGINE COOLING | |||||
709 | 09/01/2005 | 10018126 | Oil life system reset procedures - cars. gm tech link. *tt | 12/15/2005 | |
040604024 | 04/01/2004 | 10012634 | Powertrain control module will not properly communicate on board diagnostic freeze frame information to nontech2 service or test equipment. *eh | 03/09/2005 | |
040604023 | 04/01/2004 | 10012596 | Powertrain control module will not properly communicate on board diagnostic egr test result information to non-tech2 service or test equipment. *eh | 03/08/2005 | |
03034 | 07/01/2003 | 10003430 | Engine coolant may leak at the upper intake manifold throttle body gasket, or at the upper intake manifold to lower intake manifold to lower intake manifold gasket. this condition may result in a low engine coolant level and higher engine | 10/20/2003 | |
990603009A | 02/01/2004 | 040861001 | 10001285 | Floor pan corrosion perforation in battery compartment. *tt update *eh | 04/25/2003 |
ENGINE AND ENGINE COOLING - COOLING SYSTEM | |||||
03019 | 07/18/2003 | 10006144 | Engine coolant may leak at the upper intake manifold throttle body gasket, or at the upper intake manifold to lower intake manifold to lower intake manifold gasket. this condition may result in a low engine coolant level and higher engine | 04/22/2004 | |
030601016 | 05/01/2003 | 10002372 | Loss of coolant, milky colored oil. *tt | 08/26/2003 | |
ENGINE AND ENGINE COOLING - ENGINE | |||||
3157A | 10017172 | Engine whine or buzz noise sounds like a generator type noise on 3.1l or 3.8l engines. *tt | 10/26/2005 | ||
0804 | 08/01/2004 | 10014346 | Oil life system reset procedures - cars. *nm | 04/29/2005 | |
040601021 | 06/01/2004 | 10012148 | New rear main seal and special tool for installation. *tt | 02/15/2005 | |
3007 | 01/01/2004 | 10008786 | 3.8l engine oil consumption. *tt | 08/23/2004 | |
01353 | 01/01/2004 | 01353A | 10007937 | Engine misfire due to injector fretting corrosion. *tt | 07/16/2004 |
030604030 | 03/01/2007 | 030604030C | 10002166 | Multiple driveability symptoms of long or hard starts, chuggle, rough idle and light or intermittent misfire due to clogged fuel injectors. *tt | 08/14/2003 |
ENGINE AND ENGINE COOLING - EXHAUST SYSTEM - MANIFOLD/HEADER/MUFFLER/TAIL PIPE | |||||
040601017 | 06/01/2004 | 10008471 | New upper intake manifold and gasket kits. *tt | 08/02/2004 |
Consumer Complaints
Fail date | miles | occurences | Purchase date |
---|---|---|---|
ENGINE AND ENGINE COOLING | |||
01/03/2012 | 169000 | ||
Noticed lots of white smoke coming out tail pipe while driving. very unusual. car then stopped on freeway. had to get pushed by another car to side if freeway. towed car home to driveway. tried to crank egine and heard real loud pop coming from under hood. car did not turn on. tried to start 5 more times but each time it just sounded like a real short crank type sound like as if engine is having a hard time turning. after fifth time, engine started and this time the smoke coming out tail pipe was white/blueish and lots of it. engine stopped. also noticed that all the coolant was gone from coolant container and there is a high burning smell of coolant coming from engine. this might be a cracked upper intake or lower intake. these are made of real cheap hard plastic which could be the primary reason of engine failure. car is now parked in my backyard. | |||
11/22/2010 | 59750 | ||
Tl-the contact owns a 2002 buick lesabre. while the vehicle was parked he noticed anti freeze leaking from the vehicle. the vehicle was taken to a local mechanic and the mechanic advised him that the intake manifold was leaking anti freeze. the mechanic was replacing the intake manifold and the gasket. the manufacture had not been contacted. the failure mileage was 59,750 and the current mileage was 60,200. vwb | |||
02/01/2006 | 80278 | ||
Tl* the contact owns a 2002 buick lesabre. while starting the vehicle, a fire occurred in the engine without warning. the vehicle was towed to an authorized dealer for repairs. the failure mileage was 80,278 and the current mileage was 148,000. | |||
07/14/2006 | 38000 | 8 | 01/15/2006 |
Engine stalls while driving. no warning. engine will restart, but will only run for a few seconds, then stalls and will not restart. no check engine lights or other indications that there is a problem. happens at high and low speeds. car will restart and operate normally after sitting for a few hours, usually overnight. car has been towed 7 times for this problem. dealer has replaced two ignition modules, and one crankshaft position sensor. car has been at the dealer for this problem for a total of twelve weeks since initial occurrence, while the dealer tries to duplicate the problem. dealer most of the time cannot duplicate the problem. most recent occurrence, the car displayed the following codes: b1009 and b2734. mileage between incidents ranges from as high as 15,000 miles to 1,500 miles. car is undependable, and much more important, unsafe. *tr | |||
10/07/2007 | 80000 | 6 | 03/24/2003 |
2002 buick lesabre 3.8 l engine would be hard to start after it was driven and restarted after 15 minutes (or more) of being off. the car sometimes has to wait for .5 hours before it will start. this happened a year ago also. i have checked the maf sensor. the car has also stalled while driving at low speeds. if i wait for 3 minutes to restart after stalling it will restart and usually go long distances 100 miles without failure. *tr | |||
04/06/2004 | 9000 | 2 | |
Upon starting the vehicle engine turns over approximately 3 times before the vehicle starts. this failure has almost caused an accident while attempting to merge onto a highway. dealership ran an diagnostic test in which no failure code was found, although the failure occurred 3 times . *ak | |||
1 | |||
Questions concerning 2002 buick lesabre recall notice in regards to engine coolant leak in upper intake manifold. *mr which lead to the throttle body gasket or the lower intake gasket. the consumer also noticed an oil leak in the vicintity of the shroud (plastic). the consumer did not agree with quick fix that the manual stated . *scc *jb | |||
ENGINE AND ENGINE COOLING - COOLING SYSTEM | |||
07/01/2005 | 75000 | 1 | 09/01/2001 |
Routine service revealed that i have an antifreeze leak in the manifold area. *nm | |||
01/03/2003 | 1 | 03/04/1998 | |
I have been told by two mechanics that i need to change my antifreeze from dex-cool to ethylen glycol, as the dexcoolant is dirty and sugary and i am looking at electrolisis problems in my cooling system if i don't change it. why would a reputable company like buick put an inferior product in their vehicle? is there a class action suit being filed against dex coolant?. *ak | |||
1 | |||
Engine coolant leak at upper intake manifold.*mr the consumer received a recall letter in reference to an engine coolant leak. the recall said that the dealer would replace the engine throttle body fasteners with redesigned fasteners and add coolant systems sealant to the radiator tank. the consumer thinks this is a quick fix and that they should replace the gaskets and bolts. *nlm | |||
ENGINE AND ENGINE COOLING - ENGINE | |||
07/18/2008 | 42000 | 1 | 10/01/2001 |
Tl* the contact owns a 2002 buick lesabre. she noticed that both rear windows had fallen inside of the door. the vehicle has not been taken to the dealer for inspection. the same failure occurred on the front passenger-side window. the current and failure mileages were 42000. updated 1/28/10 *cn the fuel pressure regulator was leaking. the manifold was cracked and had to be replaced as well as the crankshaft sensor. updated 02/03/10.*jb | |||
01/16/2003 | 9864 | 1 | 09/30/2001 |
I noticed engine oil drop on driveway. dealer had to replace rear main seal as rear main seal housing cover and oil pan gasket. this first noticed with only 9864 miles on the new car. i am submitting this complaint to you to see if there is an inherent problem with this model vehicle.*ak | |||
01/09/2002 | 30 | 01/08/2002 | |
Consumer had engine problems. also, every time consumer turns off vehicle at night time ,he comes back next morning , and has no battery. manufacturer and dealer were contacted, and would not acknowledge the problem. ts......*ak | |||
ENGINE AND ENGINE COOLING - ENGINE - GASOLINE | |||
12/29/2003 | 41000 | 07/03/2002 | |
Nhtsa#100003430 upper intkae manifold leaking | |||
ENGINE AND ENGINE COOLING - EXHAUST SYSTEM - MANIFOLD/HEADER/MUFFLER/TAIL PIPE | |||
07/18/2008 | 42000 | 1 | 10/01/2001 |
Tl* the contact owns a 2002 buick lesabre. she noticed that both rear windows had fallen inside of the door. the vehicle has not been taken to the dealer for inspection. the same failure occurred on the front passenger-side window. the current and failure mileages were 42000. updated 1/28/10 *cn the fuel pressure regulator was leaking. the manifold was cracked and had to be replaced as well as the crankshaft sensor. updated 02/03/10.*jb | |||
02/15/2007 | 46000 | 1 | 09/07/2002 |
Tl*- the contact stated that upon checking the oil on the 2002 buick lesabre with 46000 failure mileage he discovered that the manifold gaskets were leaking. this had been an ongoing problem. also, had a 1996 oldsmobile delta 88 t with the same problem. *ak | |||
01/27/2007 | 37800 | 1 | 12/11/2002 |
Tl* - the contact owns a 2002 buick lesabre. the contact stated that he he took the vehicle to dealer for service when the mechanic told him that he found a small crack in the intake manifold. the contact has not been to the buick dealer, and the mechanic told him that the crack was possibly caused by an error in the vehicles computer. *ak |