Recalls
| Campaign | Manufacturer | Manufacturing date | Type | # of units affected | Date Owner notified Mfg | Recall Initiated by | Manufacturers of recalled vehicles/products | Report Recieved Date | Record Creation Date | Regulation Part Number | FMVSS Number | |||||
|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|
| ELECTRICAL SYSTEM | ||||||||||||||||
| 08V441000 | GENERAL MOTORS CORP. | from 04/30/2006 to 06/30/2007 | V (Vehicle) | 857735 | 09/12/2008 | ODI | GENERAL MOTORS CORP. | 08/28/2008 | 08/28/2008 | |||||||
| Defect Summary | Gm is recalling 857,735 my 2006-2008 buick lucerne; cadillac dts; hummer h2; my 2007-2008 cadillac escalade, escalade esv, escalade ext; chevrolet avalanche, silverado, suburban, tahoe; gmc acadia, sierra, yukon, yukon xl, saturn outlook; and my 2008 buick enclave vehicles equipped with a heated wiper washer fluid system. a short circuit on the printed circuit board for the washer fluid heater may overheat the control-circuit ground wire. | |||||||||||||||
| Consequence Summary | This may cause other electrical features to malfunction, create an odor, or cause smoke increasing the risk of a fire. | |||||||||||||||
| Corrective Summary | Dealers will install a wire harness with an in-line fuse free of charge. the recall began on september 12, 2008. owners may contact buick at 1-866-608-8080; cadillac at 1-800-982-2339 or http://www.cadillac.com; chevrolet at 1-800-630-2438; saturn at 1-800-972-8876 or http://www.saturn.com, gmc at 1-866-996-9436; or hummer at 1-800-732-5493; or through their website at http://www.gmownercenter.com . | |||||||||||||||
| Notes | Gm recall no. 08048. customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov . | |||||||||||||||
| 10V240000 | GENERAL MOTORS CORP. | V (Vehicle) | 1365070 | 06/11/2010 | MFR | GENERAL MOTORS CORP. | 06/04/2010 | 06/04/2010 | ||||||||
| Defect Summary | Gm is recalling certain model year 2006-2009 buick, lucerne; cadillac dts; hummer h2; model year 2008-2009 buick enclave; cadillac cts; model year 2007-2009 cadillac escalade, escalade esv, escalade ext; chevrolet avalanche, silverado, suburban, tahoe; gmc acadia, sierra, yukon, yukon xl; saturn outlook; and model year 2009 chevrolet traverse vehicles equipped with a heated washer fluid system (hwfs). a recall was implemented in 2008 to add a fuse to the control circuit harness to address the potential consequences of a printed circuit board (pcb) electrical short. however, there have been new reports of thermal incidents on hwfs modules after this improvement was installed. these incidents resulted from a new failure mode attributed to the device's thermal protection feature. the significance varies from minor distortion to considerable melting of the plastic around the hwfs fluid chamber. | |||||||||||||||
| Consequence Summary | It is possible for the heated washer module to ignite and a fire may occur. | |||||||||||||||
| Corrective Summary | Dealers will permanently disable and remove the heated washer fluid module. an updated page for the owner manual will be provided and inserted in the owner manual to document that the feature has been permanently disabled and removed from the vehicle. the safety recall is expected to begin on or before june 11, 2010. owners may contact buick at 1-866-608-8080, cadillac at 1-866-982-2339, chevrolet at 1-800-630-2438, saturn at 1-800-972-8876, gmc at 1-866-996-9463 and hummer at 1-800-732-5493 or at the owner center at www.gmownercenter.com. | |||||||||||||||
| Notes | Owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov . | |||||||||||||||
Bulletins
| Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
|---|---|---|---|---|---|
| ELECTRICAL SYSTEM | |||||
| PB-10037A | 04/01/2011 | 10038759 | Ready | 06/27/2011 | |
| PB-10037A | 04/01/2011 | 10038759 | Gm: onstar is making incomplete calls without the driver knowing. when have a data connection. *rm | 06/27/2011 | |
| PIT-4730A | 06/01/2010 | 10036550 | Buick/cadillac/chevrolet/gmc/hummer/pontiac/saturn: additional diagnostic information for u0140 or u0073. vehicle may exhibits some symptom(s) as door locks cycle while driving; intermittent no start; service stabilitrak dic message; spee | 03/28/2011 | |
| PIC-4816 | 07/01/2008 | 10026106 | Gmc: the windshield wiper washers turn on by themselves. *pe | 09/30/2008 | |
| 070847004 | 08/01/2007 | 070847004A | 10022963 | Information on body control module (bcm) grounds. *nj | 10/09/2007 |
| ELECTRICAL SYSTEM - IGNITION | |||||
| 4182 | 10020480 | Check engine light on, rough idle, or will not start. *kb | 10/26/2006 | ||
| ELECTRICAL SYSTEM - IGNITION - SWITCH | |||||
| 4016 | 10/19/2006 | 4016B | 10020967 | Delayed or extended cranking dtc p1682. *kb | 02/02/2007 |
| ELECTRICAL SYSTEM - WIRING | |||||
| PIT-4730A | 06/01/2010 | 10036550 | Buick/cadillac/chevrolet/gmc/hummer/pontiac/saturn: additional diagnostic information for u0140 or u0073. vehicle may exhibits some symptom(s) as door locks cycle while driving; intermittent no start; service stabilitrak dic message; spee | 03/28/2011 | |
| PIC-4871A | 06/01/2008 | 10026687 | Gmc: service air bag; sir indicator on (dtc b0012, b0013, b0019, b0020). the sir indicator is on and the driver information center (dic) displays service air bag. *pe | 12/01/2008 | |
| 4671 | 12/01/2007 | 10023738 | No start gauges inop warning messages (insp near park brake) *nj | 01/29/2008 | |
Investigations
| NHTSA ID | Manufacturer | Date open | Date close | Subject | Recall campaign | |
|---|---|---|---|---|---|---|
| ELECTRICAL SYSTEM | ||||||
| EA08010 | GENERAL MOTORS CORP. | 06/12/2008 | 09/08/2008 | NON-CRASH ENGINE COMPARTMENT FIRES | 08V441000 | |
| In a letter dated august 27, 2008, general motors corp. (gm) notified nhtsa that it will conduct a safety recall (nhtsa recall number 08v-441) to address a safety relateddefect that can result in engine compartment fire in approximately 850,000 vehicles equipped with a heated windshield washer fluid option.the subject vehicles of this investigation comprise over three-quarters of the recall population. according to gm, a short circuit on the printed circuit board for the windshield washer fluid heater module may overheat the control-circuit ground wire. this may cause other electrical features to malfunction, create an odor or cause smoke and in rare cases it may cause a fire.as a remedy, gm dealers will install a wire harness with an in-line fuse. in addition to the subject vehicles, several other gm models with the heated windshield washer fluid option are included in recall 08v-441: my 2006-2008 buick lucerne (manufactured august 2005 through november 2007); my 2008 buick enclave (manufactured february 2007 through april 2007); my 2006-2008 cadillac dts (manufactured may 2007 through november 2007); my 2007-2008 saturn outlook (manufactured august 2006 through april 2007); and my 2007-2008 gmc acadia (manufactured august 2006 through april 2007) vehicles.gm is instructing owners to take their vehicle to a dealer for service if they experience symptoms of windshield washer heater module short circuits. gm's recall resolves the safety defect concerns pursued by this investigation.this engineering analysis is closed. | ||||||
| ELECTRICAL SYSTEM - BATTERY | ||||||
| EA08010 | GENERAL MOTORS CORP. | 06/12/2008 | 09/08/2008 | NON-CRASH ENGINE COMPARTMENT FIRES | 08V441000 | |
| In a letter dated august 27, 2008, general motors corp. (gm) notified nhtsa that it will conduct a safety recall (nhtsa recall number 08v-441) to address a safety relateddefect that can result in engine compartment fire in approximately 850,000 vehicles equipped with a heated windshield washer fluid option.the subject vehicles of this investigation comprise over three-quarters of the recall population. according to gm, a short circuit on the printed circuit board for the windshield washer fluid heater module may overheat the control-circuit ground wire. this may cause other electrical features to malfunction, create an odor or cause smoke and in rare cases it may cause a fire.as a remedy, gm dealers will install a wire harness with an in-line fuse. in addition to the subject vehicles, several other gm models with the heated windshield washer fluid option are included in recall 08v-441: my 2006-2008 buick lucerne (manufactured august 2005 through november 2007); my 2008 buick enclave (manufactured february 2007 through april 2007); my 2006-2008 cadillac dts (manufactured may 2007 through november 2007); my 2007-2008 saturn outlook (manufactured august 2006 through april 2007); and my 2007-2008 gmc acadia (manufactured august 2006 through april 2007) vehicles.gm is instructing owners to take their vehicle to a dealer for service if they experience symptoms of windshield washer heater module short circuits. gm's recall resolves the safety defect concerns pursued by this investigation.this engineering analysis is closed. | ||||||
| ELECTRICAL SYSTEM - FUSES AND CIRCUIT BREAKERS | ||||||
| EA08010 | GENERAL MOTORS CORP. | 06/12/2008 | 09/08/2008 | NON-CRASH ENGINE COMPARTMENT FIRES | 08V441000 | |
| In a letter dated august 27, 2008, general motors corp. (gm) notified nhtsa that it will conduct a safety recall (nhtsa recall number 08v-441) to address a safety relateddefect that can result in engine compartment fire in approximately 850,000 vehicles equipped with a heated windshield washer fluid option.the subject vehicles of this investigation comprise over three-quarters of the recall population. according to gm, a short circuit on the printed circuit board for the windshield washer fluid heater module may overheat the control-circuit ground wire. this may cause other electrical features to malfunction, create an odor or cause smoke and in rare cases it may cause a fire.as a remedy, gm dealers will install a wire harness with an in-line fuse. in addition to the subject vehicles, several other gm models with the heated windshield washer fluid option are included in recall 08v-441: my 2006-2008 buick lucerne (manufactured august 2005 through november 2007); my 2008 buick enclave (manufactured february 2007 through april 2007); my 2006-2008 cadillac dts (manufactured may 2007 through november 2007); my 2007-2008 saturn outlook (manufactured august 2006 through april 2007); and my 2007-2008 gmc acadia (manufactured august 2006 through april 2007) vehicles.gm is instructing owners to take their vehicle to a dealer for service if they experience symptoms of windshield washer heater module short circuits. gm's recall resolves the safety defect concerns pursued by this investigation.this engineering analysis is closed. | ||||||
| ELECTRICAL SYSTEM - WIRING | ||||||
| EA08010 | GENERAL MOTORS CORP. | 06/12/2008 | 09/08/2008 | NON-CRASH ENGINE COMPARTMENT FIRES | 08V441000 | |
| In a letter dated august 27, 2008, general motors corp. (gm) notified nhtsa that it will conduct a safety recall (nhtsa recall number 08v-441) to address a safety relateddefect that can result in engine compartment fire in approximately 850,000 vehicles equipped with a heated windshield washer fluid option.the subject vehicles of this investigation comprise over three-quarters of the recall population. according to gm, a short circuit on the printed circuit board for the windshield washer fluid heater module may overheat the control-circuit ground wire. this may cause other electrical features to malfunction, create an odor or cause smoke and in rare cases it may cause a fire.as a remedy, gm dealers will install a wire harness with an in-line fuse. in addition to the subject vehicles, several other gm models with the heated windshield washer fluid option are included in recall 08v-441: my 2006-2008 buick lucerne (manufactured august 2005 through november 2007); my 2008 buick enclave (manufactured february 2007 through april 2007); my 2006-2008 cadillac dts (manufactured may 2007 through november 2007); my 2007-2008 saturn outlook (manufactured august 2006 through april 2007); and my 2007-2008 gmc acadia (manufactured august 2006 through april 2007) vehicles.gm is instructing owners to take their vehicle to a dealer for service if they experience symptoms of windshield washer heater module short circuits. gm's recall resolves the safety defect concerns pursued by this investigation.this engineering analysis is closed. | ||||||
| ELECTRICAL SYSTEM - WIRING - FRONT UNDERHOOD | ||||||
| EA08010 | GENERAL MOTORS CORP. | 06/12/2008 | 09/08/2008 | NON-CRASH ENGINE COMPARTMENT FIRES | 08V441000 | |
| In a letter dated august 27, 2008, general motors corp. (gm) notified nhtsa that it will conduct a safety recall (nhtsa recall number 08v-441) to address a safety relateddefect that can result in engine compartment fire in approximately 850,000 vehicles equipped with a heated windshield washer fluid option.the subject vehicles of this investigation comprise over three-quarters of the recall population. according to gm, a short circuit on the printed circuit board for the windshield washer fluid heater module may overheat the control-circuit ground wire. this may cause other electrical features to malfunction, create an odor or cause smoke and in rare cases it may cause a fire.as a remedy, gm dealers will install a wire harness with an in-line fuse. in addition to the subject vehicles, several other gm models with the heated windshield washer fluid option are included in recall 08v-441: my 2006-2008 buick lucerne (manufactured august 2005 through november 2007); my 2008 buick enclave (manufactured february 2007 through april 2007); my 2006-2008 cadillac dts (manufactured may 2007 through november 2007); my 2007-2008 saturn outlook (manufactured august 2006 through april 2007); and my 2007-2008 gmc acadia (manufactured august 2006 through april 2007) vehicles.gm is instructing owners to take their vehicle to a dealer for service if they experience symptoms of windshield washer heater module short circuits. gm's recall resolves the safety defect concerns pursued by this investigation.this engineering analysis is closed. | ||||||
Consumer Complaints
| Fail date | miles | occurences | Purchase date |
|---|---|---|---|
| ELECTRICAL SYSTEM | |||
| 12/05/2012 | 45000 | ||
| Tl- the contact owns a 2007 buick lucerne. the contact stated that while driving approximately 15 mph,h the vehicle suddenly stalled. the failure continued intermittently. the vehicle was towed to the dealer for diagnostic testing four different times. the technician replaced the fuse terminal, the battery, and the computer but the failure continued. the manufacturer was made aware of the failure. the vehicle was not repaired. the approximate failure mileage was 45,000. mah | |||
| 12/05/2012 | 45000 | ||
| Tl- the contact owns a 2007 buick lucerne. the contact stated while driving approximately 15 mph the vehicle suddenly stalled. the failure continued intermittently. the vehicle was towed to the dealer for diagnostic testing four different times. the technician replaced the fuse terminal, the battery and the computer but the failure continued. the manufacturer was made aware of the failure. the vehicle was not repaired. the approximate failure mileage was 45,000. da | |||
| 06/20/2012 | 51000 | ||
| I keep getting an error message that my air bags are not working i take my car in and they say my air bags are bad. the seats heaters/coolers stopped working about 6 months ago i checked into getting them fix and it is going to cost a lot of money. now i went to put air in my tires and i am getting an error message to have my systems for my tires checked. this is the third time the tire gage has been broken. | |||
| 01/14/2011 | 52454 | ||
| I own a 2007 buick lucerne. since i retired the car would sit in the garge for a few days whereupon it would go dead. i called onstar and had the car jump started but it kept happening. so the dealer finally took it in and tested the draw. they found a deffective onstar module and another module connected to the door and lights that were bad. it has been fixed and so far so good until today when i was drving down the road and it just stopped dead. so i do not know the outcome of this failure yet. the only problem being it is now 2,000 miles out of warranty> | |||
| 06/06/2010 | |||
| Tl-the contact owns a 2007 buick lucerne. the contact received a recall notification under nhtsa campaign id number 10v240000 (electrical system). the contact was not in agreement with the recall remedy repair which does not correct the problem. also, he stated the defective part should be replaced with a new part, not to disable and remove the part as mentioned in the recall. there was no failure mileage. js | |||
| 01/05/2009 | 22000 | 1 | |
| Re: 2007 buick lucerne. in daylight driving the instrument cluster is not visible. very hard to read odometer or gas gauge, have contacted dealers with no success in solving problem. *tr | |||
| 10/10/2006 | 1 | ||
| Unable to read information on the instrument panel cluster during the day light. *tr | |||
| 09/16/2008 | |||
| Tl*the contact owns a 2007 buick lucerne. the contact received a safety recall notice for nhtsa campaign id number 08v441000 (electrical system) and called the dealer. she was informed to wait until she gets another safety recall notice. there had been no failure to date. the current mileage was 20,296. | |||
| 10/15/2007 | 7 | 10/05/2007 | |
| 2007 buick lucerne engine will shut down without any notice. consumer states that the engine problems have been on-going for some time now and would like to have the vehicle replaced by the dealership. *nj the consumer stated the engine cranked, but would not start. the dealership claimed the problem was a defective ignition control module and various electrical connections were loose and corroded. the vehicle shut down on 7 different occasions. the left rear window would not close. the problem was diagnosed as a twisted regulator cable. *jb | |||
| 07/12/2008 | 8700 | 1 | |
| I parked my 2007 lucerne for 17 days while on vacation. when i returned, the battery was dead. there was nothing plugged into the car like a phone charger or anything else. after charging the battery, i took it to local dealer who kept it for over two weeks, performed a parasitic draw test, and basically found nothing except a 201ma current draw over 7 days. the battery and charging systems checked ok. they couldn't tell me when or for how long that 201ma draw lasted or what caused it. they claimed that since they could not duplicate the problem, they can't fix it since it's within specs at this time. i brought car home and let it sit untouched/undriven for 3 more weeks to try to duplicate it being parked on my vacation, and there was no battery discharge problem. however, i feel i can't trust the car to be parked, unused, for any length of time (more than 2 weeks) for fear the battery will discharge again. *tr | |||
| ELECTRICAL SYSTEM - BATTERY | |||
| 03/05/2008 | 1 | 02/14/2008 | |
| Battery located in passenger compartment under seat, infants or whoever rides in rear are at risk, a battery can let out sulfuric acid fumes and damage safety belt system. battery produces chemical that cause cancer,and acid & gas that can explode if a match is light. protection is minimal to passengers. *tr | |||
| ELECTRICAL SYSTEM - WIRING | |||
| 03/02/2008 | 1 | ||
| 2007 buick lucerne with safety issue concerning the wiring. the wiring harness in the engine compartment was found to be in contact with the pulley on the air conditioner compressor. the pulley perforated the wire causing the copper conductor to have contact with the pulley. *kb | |||
| ELECTRICAL SYSTEM - WIRING - REAR COMPARTMENT/TRUNK | |||
| 03/05/2008 | 1 | 02/14/2008 | |
| Battery located in passenger compartment under seat, infants or whoever rides in rear are at risk, a battery can let out sulfuric acid fumes and damage safety belt system. battery produces chemical that cause cancer,and acid & gas that can explode if a match is light. protection is minimal to passengers. *tr | |||