Bulletins
| Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
|---|---|---|---|---|---|
| ENGINE AND ENGINE COOLING - ENGINE | |||||
| 010601002A | 12/01/2002 | 010601002 | 10000782 | Revised piston pin removal / installation procedure. *tt | 03/31/2003 |
| 576124 | 08/01/1995 | 45815 | Cold engine tick or rattle after start-up (replace piston/pin assembly). *sd | 04/25/1996 | |
| 476135 | 10/01/1994 | 39725 | Oil leak at the rocker cover. *tw | 11/01/1995 | |
| 576113 | 05/01/1995 | 43036 | Unknown | 11/01/1995 | |
| 436604 | 01/01/1995 | 39083 | Exhaust manifold seal squeak. *tw | 03/06/1995 | |
| ENGINE AND ENGINE COOLING - ENGINE - GASOLINE | |||||
| 990604005A | 04/01/2001 | 990604005 | 619360 | Some owners may comment on driveability symptons of long or hard starts, chuggle, rough idle and light or intermittent misfire due to clogged fuel injectors. *tt | 05/24/2001 |
| 876002A | 07/01/1998 | 876002 | 615073 | Some v6 engines may, on a very infrequent basis, have an oil odor condition that is generally encountered after the engine's oil has been changed.typically the odor lasts approximately 1000 miles after the change of oil and then does not re | 12/26/2000 |
| 990604005 | 02/01/1999 | 776304A | 604343 | Some owners may experience a driveability symptom of long or hard starts, chuggle, rough idle and light or intermittent misfire. *tt | 04/26/1999 |
| 98576124A | 06/01/1998 | 57-61-24 | 601915 | Comments on a ticking type noise that begins shortly after cold engine start-up and gradually diminishes as the engine warms up. *yc | 08/28/1998 |
Consumer Complaints
| Fail date | miles | occurences | Purchase date |
|---|---|---|---|
| ENGINE AND ENGINE COOLING | |||
| 07/15/2003 | 105000 | ||
| I have been experiencing major paint peeling off my 1994 buick regal. it is occuring in several places on the hood and quarter panel. it blisters and then it just flakes off. the 1993 gm press release describes my exact problem, stating that they would cover the cost off repainting a car within the first six years. so, unfortunatly i'm probably out of luck, but i was going to make an attempt at getting gm to cover some of the cost. the car has just under 105,000 miles and otherwise in very good condition. | |||
| 02/25/2004 | 1 | 12/01/2003 | |
| While driving, the consumer smelled an odor coming through the vents. the consumer pulled to the shoulder and noticed smoke coming from underneath the hood. the vehicle was towed to the dealer for inspection, and the mechanic informed the consumer that certain parts were not under warranty. *ak the vehicle had an electrical problem where the vehicle felt as if it were going to die out. the voltage readings were always low. the vehicle had problems getting out of gear. the consumer was told that the initial problem was with the upper intake manifold. the brakes were bad and the muffler had a big hole in it. also, coolant leaked from the intake manifold. *sc *jb | |||
| 10/15/2004 | 3 | 01/05/1995 | |
| While driving at low speeds and without warning the vehicle stalled causing the driver to lose control of the vehicle. the consumer took vehicle to dealer on three separate occasions, but dealer was not able to resolve the problem. *ak when slowing down or when taking turns, the engine stalled causing a loss of the power steering , brakes, and engine missing with rpm of 1500-2000. the transmission would have to be placed in neutral to restart the vehicle. while on a trip, the check engine light had come on, and when slowing down to check the vehicle, the engine stalled. the vehicle was taken to the nearest dealer and was told that there was a lagged fuel filter and to drive home. another could not find the problem but suggested thta it could be the transmission. another service dealer could not find the problem either and referred the consumer to another servce dealer for the transmission and they replaced the sol valve but still wasn't able to find the problem. *sc | |||
| ENGINE AND ENGINE COOLING - COOLING SYSTEM | |||
| 02/09/2004 | 120394 | 1 | 04/02/2002 |
| Had intake upper intake manifold replaced due to a cooling problem. wagamon brothers said there was nothing i could have done to prevent it. voltage gauge reading 18. replaced alternator/generator. problem still existed. checked battery. battery failed. replaced battery. voltage gauge still read 18. drove car. car died in middle of the freeway. smell of burnt wires. towed car to garage. fiance was able to start car and noticed gauges still lit when should have been not lit. figures electrical under dash or in wiring harness. | |||
| 04/01/2003 | 27478 | 03/30/2003 | |
| Plastic intake manifold cracked. *nlm | |||
| 09/09/1999 | 1 | 12/20/1996 | |
| The fuel line was incorrectly installed at factory and is ruptured by the abs pump caused fuel to leak. yh | |||
| ENGINE AND ENGINE COOLING - ENGINE | |||
| 05/17/2007 | 100000 | 1 | 01/01/1995 |
| Tl*the contact owns a 1994 buick regal. the contact went to the dealer to have the condition of her vehicle inspected and for a new paint job. approximately three to four days later, the vehicle shut off at a stop light. she could not roll down the windows or exit the vehicle. the failure was a result of a button being pushed inside the vehicle. the contact was stuck inside the vehicle for half an hour on a hot day. the # of cylinders and engine size were unknown. the current and failure mileages were 100,000. | |||
| 04/24/2003 | 5 | ||
| The vehicle stalled at various times, and now the vehicle does not start at all. *jb | |||
| 11/15/1994 | 1 | ||
| Oil leak. *skd | |||
| ENGINE AND ENGINE COOLING - ENGINE - GASOLINE | |||
| 12/29/2001 | |||
| While driving at 35-40 mph vehicle shutdown without any warning. dealer notified. please feel free to provide any further details concerning this matter*ak. | |||
| 04/02/2000 | 6 | 08/01/1998 | |
| The car keeps dying while at speed and is not safe. *ak | |||
| 07/05/1999 | 1 | 01/01/1998 | |
| While driving car engine stopped with no warning. imagine drving on i95and the engine stops and nowhere to go. *ak | |||
| 11/28/1994 | 1 | ||
| Engine noise. *skd | |||
| ENGINE AND ENGINE COOLING - EXHAUST SYSTEM - EMISSION CONTROL - CATALYTIC CONVERTOR | |||
| 02/20/2005 | 117245 | 2 | |
| Car running poorly, then strange sounds of air swishing and car won't stay running, smoke coming from floor, fire under car. won't run. fuel injection fuel rail corroded, injectors plugged, one wide open. too much fuel in catalytic converter, got red hot, melted internally and plugged exhaust flow, which bypassed front pipe gasket at manifold, also forcing exhaust past egr valve. had to replace fuel rail, fuel injectors, catalytic converter, clean and new gasket on egr, many plastic parts melted.smoke damage to inside of car.*ak | |||
| ENGINE AND ENGINE COOLING - EXHAUST SYSTEM - MANIFOLD/HEADER/MUFFLER/TAIL PIPE | |||
| 02/20/2005 | 117245 | 2 | |
| Car running poorly, then strange sounds of air swishing and car won't stay running, smoke coming from floor, fire under car. won't run. fuel injection fuel rail corroded, injectors plugged, one wide open. too much fuel in catalytic converter, got red hot, melted internally and plugged exhaust flow, which bypassed front pipe gasket at manifold, also forcing exhaust past egr valve. had to replace fuel rail, fuel injectors, catalytic converter, clean and new gasket on egr, many plastic parts melted.smoke damage to inside of car.*ak | |||
| 02/25/2004 | 1 | 12/01/2003 | |
| While driving, the consumer smelled an odor coming through the vents. the consumer pulled to the shoulder and noticed smoke coming from underneath the hood. the vehicle was towed to the dealer for inspection, and the mechanic informed the consumer that certain parts were not under warranty. *ak the vehicle had an electrical problem where the vehicle felt as if it were going to die out. the voltage readings were always low. the vehicle had problems getting out of gear. the consumer was told that the initial problem was with the upper intake manifold. the brakes were bad and the muffler had a big hole in it. also, coolant leaked from the intake manifold. *sc *jb | |||