Recalls
| Campaign | Manufacturer | Manufacturing date | Type | # of units affected | Date Owner notified Mfg | Recall Initiated by | Manufacturers of recalled vehicles/products | Report Recieved Date | Record Creation Date | Regulation Part Number | FMVSS Number | |||||
|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|
| FUEL SYSTEM, GASOLINE - FUEL INJECTION SYSTEM | ||||||||||||||||
| 96V116000 | GENERAL MOTORS CORP. | from 07/01/1995 to 05/01/1996 | V (Vehicle) | 275811 | 07/08/1996 | MFR | GENERAL MOTORS CORP. | 07/01/1996 | 07/08/1996 | |||||||
| Defect Summary | A backfire during engine starting can cause breakage of the upper intake manifold. | |||||||||||||||
| Consequence Summary | This condition can cause a no-start condition and possibly an engine compartment fire. | |||||||||||||||
| Corrective Summary | Dealers will update the powertrain control module programming. until the campaign repair is made, the vehicle hood should be shut whenever starting the vehicle to reduce the chance of personal injury. | |||||||||||||||
| Notes | Vehicle description: passenger vehicles equipped with 3.8l v6 engine. owner notification: owner notifications began during july 1996. note: owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact buick at 1-800-521-7300; pontiac at 1-800-762-2737; or oldsmobile at 1-800-442-6537. also contact the national highway traffic safety administration's auto safety hotline at 1-800-424-9393. | |||||||||||||||
| FUEL SYSTEM, OTHER - STORAGE - TANK ASSEMBLY - PRESSURE RELIEF DEVICES | ||||||||||||||||
| 07E021000 | DELPHI | E (Equipment) | 742 | 04/27/2007 | MFR | GENERAL MOTORS CORP. | 03/12/2007 | 03/12/2007 | ||||||||
| Defect Summary | Certain delphi fuel pressure regulators, p/nos. fp10020-11b1, fp10026-11b1, and fp10027-11b1, sold after january 9, 2007, as aftermarket equipment for various passenger vehicles listed above. the universal pressure regulators (upr) were produced without an o'ring and retainer. | |||||||||||||||
| Consequence Summary | Fuel may leak, possibly resulting in a fire. | |||||||||||||||
| Corrective Summary | Delphi will notify owners and replace the upr free of charge. the recall began on april 23, 2007. owners can contact delphi at 877-411-8770. | |||||||||||||||
| Notes | This recall only pertains to aftermarket delphi fuel pressure regulators and has no relation to any original equipment installed by general motors.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov. | |||||||||||||||
Bulletins
| Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
|---|---|---|---|---|---|
| FUEL SYSTEM, GASOLINE | |||||
| 736313 | 06/01/1997 | 52563 | Reduced engine performance, restricted fuel flow (clean fuel tank, replace in-line fuel filter and fuel pump strainer). *tw | 08/14/1997 | |
| FUEL SYSTEM, GASOLINE - FUEL INJECTION SYSTEM | |||||
| 971101776304 | 11/01/1997 | 54066 | Subject pertaining to driveability symptoms due to fuel injector deposits. *yc | 03/30/1998 | |
| FUEL SYSTEM, GASOLINE - FUEL INJECTION SYSTEM - INJECTORS | |||||
| 98776304A | 02/01/1998 | 600282 | Some vehicles may experience a driveability symptom of long or hard starts, chuggle, rough idle and light or intermittent misfire. *yc | 05/05/1998 | |
Investigations
| NHTSA ID | Manufacturer | Date open | Date close | Subject | Recall campaign | |
|---|---|---|---|---|---|---|
| FUEL SYSTEM, GASOLINE | ||||||
| EA02030 | GENERAL MOTORS CORP. | 10/22/2002 | 03/09/2004 | ENGINE COMPARTMENT FIRES | 03V473000 | |
| Ea02-030 is closed with gmea02-030 is closed with gm | ||||||
| EA02030 | GENERAL MOTORS CORP. | 10/22/2002 | 03/09/2004 | ENGINE COMPARTMENT FIRES | 04V090000 | |
| Ea02-030 is closed with gmea02-030 is closed with gm | ||||||
| FUEL SYSTEM, GASOLINE - DELIVERY | ||||||
| EA02030 | GENERAL MOTORS CORP. | 10/22/2002 | 03/09/2004 | ENGINE COMPARTMENT FIRES | 04V090000 | |
| Ea02-030 is closed with gmea02-030 is closed with gm | ||||||
| EA02030 | GENERAL MOTORS CORP. | 10/22/2002 | 03/09/2004 | ENGINE COMPARTMENT FIRES | 03V473000 | |
| Ea02-030 is closed with gmea02-030 is closed with gm | ||||||
| FUEL SYSTEM, GASOLINE - DELIVERY - HOSES, LINES/PIPING, AND FITTINGS | ||||||
| EA02030 | GENERAL MOTORS CORP. | 10/22/2002 | 03/09/2004 | ENGINE COMPARTMENT FIRES | 04V090000 | |
| Ea02-030 is closed with gmea02-030 is closed with gm | ||||||
| EA02030 | GENERAL MOTORS CORP. | 10/22/2002 | 03/09/2004 | ENGINE COMPARTMENT FIRES | 03V473000 | |
| Ea02-030 is closed with gmea02-030 is closed with gm | ||||||
Consumer Complaints
| Fail date | miles | occurences | Purchase date |
|---|---|---|---|
| FUEL SYSTEM, GASOLINE | |||
| 11/10/2008 | 90000 | 1 | |
| Vehicle back fire through the intake and smoke rolls out from under the hood when trying to start the vehicle, normally start good after sitting over night, but go to start it again it will back fire or the engine idle is very erratic before it will smooth out. i replace spark plug, spark plug wires, cam sensor, pcv valve, fuel filter check battery connection. *tr | |||
| 07/01/1997 | 2 | ||
| Twice when vehicle was parked facing downhill the vehicle could not be started the following morining, when the fuel tank is less than 1/4 full. | |||
| FUEL SYSTEM, GASOLINE - CARBURETOR SYSTEM | |||
| 01/01/2000 | |||
| Consumer states that the intake manifold has blown up once before in the vehicle while the vehicle was being started up. contacted dealer and the dealer noted that the vechile is not part of the recall. nlm | |||
| FUEL SYSTEM, GASOLINE - DELIVERY | |||
| 05/30/2002 | 1 | 02/01/1997 | |
| At 55mph, fuel line snapped, causing fluid to leak onto the motor. cause unknown. dealer notified.*ak the plastic connectors at the motor manifold broke off. dealer was notified but no call was returned to consumer. the steel tubing from the gas tank is connected to the steel manifold at the motor block with a thin walled plastic tubing. under the vehicle, the plastic tubing is heat-shrunk to the steel tubing in which no fittings are used. at the motor manifold, plastic fittings are used. the fitting broke, and fuel was spilling onto the hot motor block and formed a puddle of hot fuel, one person inhaled the gas fumes. *jg | |||
| FUEL SYSTEM, GASOLINE - DELIVERY - FUEL PUMP | |||
| 10/10/2005 | 156000 | 1 | 06/15/1996 |
| Had an electric fuel pump failure after a period of problems with difficulty starting and poor acceleration. when the fuel pump was removed, there is evidence of arcing at the connector. seems to be a fire hazard, as the pump is inside the fuel tank. *nm | |||
| 03/01/2002 | 1 | 12/29/1998 | |
| While vehicle was in a repair shop a burned up fuel pump was replaced in fuel tank. fuel pump available for analysis. *ak *yh | |||
| 01/24/2001 | 1 | ||
| Vehicle would not start. took vehicle to an independent mechanic who found fuel pump and fuel sending unit needed to be replaced. *ak there was electrical problem with the fuel pump. *yh | |||
| 08/19/2000 | 0 | ||
| Vehicle won't be able to crank at the time, and no electrical function. vehicle had to be towed to technician, and he said that fuel pump had melted inside of fuel tank. when a part melts like that it just makes sparks.*ak | |||
| 07/01/1996 | |||
| Car fails to accelerate past 30mph under normal driving conditions. increasing pressure on gas pedal at 30mph yields no response from car. when car hits passing gear, finally accelerates past 30mph. in addition, at interstate speeds ie. 70-75 mph car develops almost a stutter and cannot maintain speed and starts to decelerate. both problems occur in both drive and overdrive. has been in for repairs to 4 different repair shops, 2 of them authorized buick dealers. they have replaced throttle position sensor, cleaned fuel injectors, new fuel pump and fuel filter, new knock sensor and blown carbon out of engine twice. car still does not accelerate as described. *ak | |||
| 07/07/1997 | 09/01/1995 | ||
| The fuel pump shorted, causing an electrical arc in the gas tank. the fuse did not break the current. manufacturer contacted , owner was not pleased with outcome. *ak | |||
| FUEL SYSTEM, GASOLINE - DELIVERY - HOSES, LINES/PIPING, AND FITTINGS | |||
| 07/01/1996 | |||
| Car fails to accelerate past 30mph under normal driving conditions. increasing pressure on gas pedal at 30mph yields no response from car. when car hits passing gear, finally accelerates past 30mph. in addition, at interstate speeds ie. 70-75 mph car develops almost a stutter and cannot maintain speed and starts to decelerate. both problems occur in both drive and overdrive. has been in for repairs to 4 different repair shops, 2 of them authorized buick dealers. they have replaced throttle position sensor, cleaned fuel injectors, new fuel pump and fuel filter, new knock sensor and blown carbon out of engine twice. car still does not accelerate as described. *ak | |||
| FUEL SYSTEM, GASOLINE - FUEL INJECTION SYSTEM | |||
| 11/26/2008 | 78117 | 1 | 01/18/1997 |
| Tl*the contact owns a 1996 buick regal. the contact noticed that the vehicle sporadically experienced a no-start condition. there was also a backfire that occurred when the vehicle was started. the upper intake manifold failed prior to the upper intake manifold. the dealer stated that his vin was excluded from nhtsa campaign id number 96v116000 (fuel system, gasoline:fuel injection system). the contact would not assume responsibility for the repair. the vehicle has not been repaired. the failure and current mileages were 78,117. updated 02/05/09. *lj coolant was found in the oil when repairs were made on the manifold. updated 02/10/09. *jb | |||
| 04/09/2006 | 113000 | 1 | 03/04/2006 |
| Dt*: the contact stated while starting the vehicle the plastic upper intake manifold exploded. there is a nhtsa recall, # 96v116000, regarding the fuel injection system. the vehicle has the same problems as indicated in the recall; however it is not included in the recall due to the vin. updated 5/3/2006 - when the consumer started the vehicle an explosion was heard. the consumer exited the vehicle and opened the hood to find the engine on fire. the consumer was able to extinguish the fire with a garden hose. *nm | |||
| 02/05/2005 | 29050 | 3 | 09/19/2001 |
| After turning the ignition to start the vehicle there was an explosion, the engine was on fire. the fire department was called, and the fire was extinguished. this vehicle was not included in the intake manifold nhtsa recall 96v116000. *ak the egr valve was inoperative and on another occasion the vehicle had to be jump started. *sc *jb | |||
| 03/19/2002 | 1 | 12/08/1995 | |
| While vehicle was parked there was a loud noise that came from engine. when consumer opened the hood, the engine was on fire. contacted dealer. *ak consumer had tried to start the vehicle, once he turned the key a loud noise errupted from the hood area. vehicle was under recall for backfire during engine starting, dealer refuses to repair without payment. *jg referenced in ea02-030 | |||
| 05/13/2001 | 2 | ||
| When consumer started vehicle there was a loud bang that came from front of vehicle. smoke started coming from underneath hood, and the vehicle was on fire. the cause of this defect was that the fuel did not go into fuel relay system, and injector sprayed fuel backwards onto intake manifold which ignited the fuel. this happened once before july 28, 2000 and again on may 13, 2001. *ak *jb | |||
| 07/01/1996 | |||
| Car fails to accelerate past 30mph under normal driving conditions. increasing pressure on gas pedal at 30mph yields no response from car. when car hits passing gear, finally accelerates past 30mph. in addition, at interstate speeds ie. 70-75 mph car develops almost a stutter and cannot maintain speed and starts to decelerate. both problems occur in both drive and overdrive. has been in for repairs to 4 different repair shops, 2 of them authorized buick dealers. they have replaced throttle position sensor, cleaned fuel injectors, new fuel pump and fuel filter, new knock sensor and blown carbon out of engine twice. car still does not accelerate as described. *ak | |||
| FUEL SYSTEM, GASOLINE - STORAGE - TANK ASSEMBLY | |||
| 09/18/2001 | |||
| Whenever the fuel tank is filled, it would leak. leakage is occurring along the seam of fuel tank due to corrosion. once filled & driving away, fuel vapors can be smelled inside the vehicle.*ak | |||
| 04/21/1997 | 1 | ||
| Vehicle caught on fire. rear end of vehicle was incinerated. cause unknown. *ak the automotive specialists have determined the origion of the fire was electrical or electric trunk release or trank light assembly failure. *yh | |||
| FUEL SYSTEM, OTHER - STORAGE - FUEL GAUGE SYSTEM | |||
| 01/24/2001 | 1 | ||
| Vehicle would not start. took vehicle to an independent mechanic who found fuel pump and fuel sending unit needed to be replaced. *ak there was electrical problem with the fuel pump. *yh | |||