Recalls
Campaign | Manufacturer | Manufacturing date | Type | # of units affected | Date Owner notified Mfg | Recall Initiated by | Manufacturers of recalled vehicles/products | Report Recieved Date | Record Creation Date | Regulation Part Number | FMVSS Number | |||||
---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|
ELECTRICAL SYSTEM - IGNITION - SWITCH | ||||||||||||||||
04V036000 | GENERAL MOTORS CORP. | from 03/01/1997 to 01/31/1998 | V (Vehicle) | 1415231 | 03/01/2004 | MFR | GENERAL MOTORS CORP. | 01/27/2004 | 02/05/2004 | |||||||
Defect Summary | On certain passenger vehicles. if the engine fails to start and the driver holds the key in the start position for an extended period, high current flows through the ignition switch, and sometimes produces enough heat to melt internal switch parts. | |||||||||||||||
Consequence Summary | If the switch is damaged, a fire could occur in the steering column, even with the engine off and the key removed. the fire could spread to the interior of the car, which could injure occupants or cause damage to adjoining structures. | |||||||||||||||
Corrective Summary | Dealers will install a relay kit in these vehicles to prevent high current from flowing through the ignition switch, and check that your car will start with a properly charged battery and, if necessary, replace the ignition switch. owner notification will begin on march 1, 2004. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact chevrolet at 1-800-630-2438, pontiac at 1-800-620-7668, buick at 1-866-608-8080, or oldsmobile at 1-800-630-6537. customers can also check their vehicle online by going to www.mygmlink.com and entering the vehicle's identification number. | |||||||||||||||
Notes | Gm recall no. 04002.customers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236). |
Bulletins
Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
---|---|---|---|---|---|
ELECTRICAL SYSTEM - BATTERY | |||||
98836416 | 06/01/1998 | 601912 | Conditions regarding weak or discharged battery, slow starting, gen or mil lamp on, various driveability symptoms. *yc | 08/28/1998 | |
ELECTRICAL SYSTEM - IGNITION | |||||
02232004 | 02/23/2004 | 10013000 | If the engine fails to start and the driver holds the key in the start position for an extended period, high current flows through the ignition switch and sometimes produces enough heat to melt internal switch parts. *tt | 04/05/2005 | |
04122004 | 04/12/2004 | 10009214 | Ignition circuit thermal events, three phase safety recall 04002. gm voicemail express. *tt | 09/17/2004 | |
04002 | 05/12/2004 | 10007858 | Product safety recall ignition circuit thermal events. *mj | 07/13/2004 | |
010849020 | 12/01/2001 | 631899 | Subject regarding revised ignition lock cylinder or ignition switch assembly replacement. *slc | 06/25/2002 | |
ELECTRICAL SYSTEM - IGNITION - MODULE | |||||
990604037 | 09/01/1999 | 608390 | Subject on on-board diagnostic (obd) system improvements. *mjs | 11/26/1999 |
Consumer Complaints
Fail date | miles | occurences | Purchase date |
---|---|---|---|
ELECTRICAL SYSTEM - ALTERNATOR/GENERATOR/REGULATOR | |||
08/16/2005 | 2 | 04/01/1999 | |
Dt: contact stated that on 7-11-05 had a new alternator put in. it failed on 8-13-05., and it was replaced on 8-14-05. it is not showing up on the tester as consistent. it was arching and draining the battery. the part number for the alternator was #8225-7. they will replace it in a certain amount of time; but that did not help the call now because car died the freeway. a mechanic told her they were putting bad regulators in these alternators. this included the following companies;: car quest, and bbb industries; 5640 commerce east, mobile, al 36619. palladium; box 2710 ronoake, va 24001. *ak | |||
ELECTRICAL SYSTEM - IGNITION | |||
93000 | 1 | 03/15/2002 | |
Sometimes when starting the vehicle driver has to hold the key in the crank position until the vehicle will start. there is a delay in starting. *ak | |||
ELECTRICAL SYSTEM - IGNITION - SWITCH | |||
03/05/2004 | 85000 | 1 | |
Consumer received recall 040025000 concerning ignition switch. dealer charged consumer for replacing the ignition switch .*ak | |||
82000 | 1 | ||
Consumer complained about ignition switch problem. when turning the key vehicle will not start. *ak |