Recalls
| Campaign | Manufacturer | Manufacturing date | Type | # of units affected | Date Owner notified Mfg | Recall Initiated by | Manufacturers of recalled vehicles/products | Report Recieved Date | Record Creation Date | Regulation Part Number | FMVSS Number | |||||
|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|
| ELECTRICAL SYSTEM | ||||||||||||||||
| 08V441000 | GENERAL MOTORS CORP. | from 04/30/2006 to 06/30/2007 | V (Vehicle) | 857735 | 09/12/2008 | ODI | GENERAL MOTORS CORP. | 08/28/2008 | 08/28/2008 | |||||||
| Defect Summary | Gm is recalling 857,735 my 2006-2008 buick lucerne; cadillac dts; hummer h2; my 2007-2008 cadillac escalade, escalade esv, escalade ext; chevrolet avalanche, silverado, suburban, tahoe; gmc acadia, sierra, yukon, yukon xl, saturn outlook; and my 2008 buick enclave vehicles equipped with a heated wiper washer fluid system. a short circuit on the printed circuit board for the washer fluid heater may overheat the control-circuit ground wire. | |||||||||||||||
| Consequence Summary | This may cause other electrical features to malfunction, create an odor, or cause smoke increasing the risk of a fire. | |||||||||||||||
| Corrective Summary | Dealers will install a wire harness with an in-line fuse free of charge. the recall began on september 12, 2008. owners may contact buick at 1-866-608-8080; cadillac at 1-800-982-2339 or http://www.cadillac.com; chevrolet at 1-800-630-2438; saturn at 1-800-972-8876 or http://www.saturn.com, gmc at 1-866-996-9436; or hummer at 1-800-732-5493; or through their website at http://www.gmownercenter.com . | |||||||||||||||
| Notes | Gm recall no. 08048. customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov . | |||||||||||||||
| 10V240000 | GENERAL MOTORS CORP. | V (Vehicle) | 1365070 | 06/11/2010 | MFR | GENERAL MOTORS CORP. | 06/04/2010 | 06/04/2010 | ||||||||
| Defect Summary | Gm is recalling certain model year 2006-2009 buick, lucerne; cadillac dts; hummer h2; model year 2008-2009 buick enclave; cadillac cts; model year 2007-2009 cadillac escalade, escalade esv, escalade ext; chevrolet avalanche, silverado, suburban, tahoe; gmc acadia, sierra, yukon, yukon xl; saturn outlook; and model year 2009 chevrolet traverse vehicles equipped with a heated washer fluid system (hwfs). a recall was implemented in 2008 to add a fuse to the control circuit harness to address the potential consequences of a printed circuit board (pcb) electrical short. however, there have been new reports of thermal incidents on hwfs modules after this improvement was installed. these incidents resulted from a new failure mode attributed to the device's thermal protection feature. the significance varies from minor distortion to considerable melting of the plastic around the hwfs fluid chamber. | |||||||||||||||
| Consequence Summary | It is possible for the heated washer module to ignite and a fire may occur. | |||||||||||||||
| Corrective Summary | Dealers will permanently disable and remove the heated washer fluid module. an updated page for the owner manual will be provided and inserted in the owner manual to document that the feature has been permanently disabled and removed from the vehicle. the safety recall is expected to begin on or before june 11, 2010. owners may contact buick at 1-866-608-8080, cadillac at 1-866-982-2339, chevrolet at 1-800-630-2438, saturn at 1-800-972-8876, gmc at 1-866-996-9463 and hummer at 1-800-732-5493 or at the owner center at www.gmownercenter.com. | |||||||||||||||
| Notes | Owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov . | |||||||||||||||
Bulletins
| Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
|---|---|---|---|---|---|
| ELECTRICAL SYSTEM | |||||
| PIT5074F | 05/01/2012 | 10044242 | Gm: j-35616-64b terminal test probe and replacement terminal. also included models verano, regal, lacrosse, cts, srx, volt, sonic, malibu, impala, equinox, cruze, avalanche, tahoe suburban, silverado, sierra, yukon, and terrain for model | 05/24/2012 | |
| PB-10037A | 04/01/2011 | 10038759 | Ready | 06/27/2011 | |
| PB-10037A | 04/01/2011 | 10038759 | Gm: onstar is making incomplete calls without the driver knowing. when have a data connection. *rm | 06/27/2011 | |
| PIT-4730A | 06/01/2010 | 10036550 | Buick/cadillac/chevrolet/gmc/hummer/pontiac/saturn: additional diagnostic information for u0140 or u0073. vehicle may exhibits some symptom(s) as door locks cycle while driving; intermittent no start; service stabilitrak dic message; spee | 03/28/2011 | |
| PIC-4816 | 07/01/2008 | 10026106 | Gmc: the windshield wiper washers turn on by themselves. *pe | 09/30/2008 | |
| 070847004 | 08/01/2007 | 070847004A | 10022963 | Information on body control module (bcm) grounds. *nj | 10/09/2007 |
| ELECTRICAL SYSTEM - IGNITION - SWITCH | |||||
| 4016 | 10/19/2006 | 4016B | 10020967 | Delayed or extended cranking dtc p1682. *kb | 02/02/2007 |
| ELECTRICAL SYSTEM - WIRING | |||||
| PIT-4730A | 06/01/2010 | 10036550 | Buick/cadillac/chevrolet/gmc/hummer/pontiac/saturn: additional diagnostic information for u0140 or u0073. vehicle may exhibits some symptom(s) as door locks cycle while driving; intermittent no start; service stabilitrak dic message; spee | 03/28/2011 | |
| PIC-4871A | 06/01/2008 | 10026687 | Gmc: service air bag; sir indicator on (dtc b0012, b0013, b0019, b0020). the sir indicator is on and the driver information center (dic) displays service air bag. *pe | 12/01/2008 | |
| 4671 | 12/01/2007 | 10023738 | No start gauges inop warning messages (insp near park brake) *nj | 01/29/2008 | |
Investigations
| NHTSA ID | Manufacturer | Date open | Date close | Subject | Recall campaign | |
|---|---|---|---|---|---|---|
| ELECTRICAL SYSTEM | ||||||
| EA08010 | GENERAL MOTORS CORP. | 06/12/2008 | 09/08/2008 | NON-CRASH ENGINE COMPARTMENT FIRES | 08V441000 | |
| In a letter dated august 27, 2008, general motors corp. (gm) notified nhtsa that it will conduct a safety recall (nhtsa recall number 08v-441) to address a safety relateddefect that can result in engine compartment fire in approximately 850,000 vehicles equipped with a heated windshield washer fluid option.the subject vehicles of this investigation comprise over three-quarters of the recall population. according to gm, a short circuit on the printed circuit board for the windshield washer fluid heater module may overheat the control-circuit ground wire. this may cause other electrical features to malfunction, create an odor or cause smoke and in rare cases it may cause a fire.as a remedy, gm dealers will install a wire harness with an in-line fuse. in addition to the subject vehicles, several other gm models with the heated windshield washer fluid option are included in recall 08v-441: my 2006-2008 buick lucerne (manufactured august 2005 through november 2007); my 2008 buick enclave (manufactured february 2007 through april 2007); my 2006-2008 cadillac dts (manufactured may 2007 through november 2007); my 2007-2008 saturn outlook (manufactured august 2006 through april 2007); and my 2007-2008 gmc acadia (manufactured august 2006 through april 2007) vehicles.gm is instructing owners to take their vehicle to a dealer for service if they experience symptoms of windshield washer heater module short circuits. gm's recall resolves the safety defect concerns pursued by this investigation.this engineering analysis is closed. | ||||||
| ELECTRICAL SYSTEM - BATTERY | ||||||
| EA08010 | GENERAL MOTORS CORP. | 06/12/2008 | 09/08/2008 | NON-CRASH ENGINE COMPARTMENT FIRES | 08V441000 | |
| In a letter dated august 27, 2008, general motors corp. (gm) notified nhtsa that it will conduct a safety recall (nhtsa recall number 08v-441) to address a safety relateddefect that can result in engine compartment fire in approximately 850,000 vehicles equipped with a heated windshield washer fluid option.the subject vehicles of this investigation comprise over three-quarters of the recall population. according to gm, a short circuit on the printed circuit board for the windshield washer fluid heater module may overheat the control-circuit ground wire. this may cause other electrical features to malfunction, create an odor or cause smoke and in rare cases it may cause a fire.as a remedy, gm dealers will install a wire harness with an in-line fuse. in addition to the subject vehicles, several other gm models with the heated windshield washer fluid option are included in recall 08v-441: my 2006-2008 buick lucerne (manufactured august 2005 through november 2007); my 2008 buick enclave (manufactured february 2007 through april 2007); my 2006-2008 cadillac dts (manufactured may 2007 through november 2007); my 2007-2008 saturn outlook (manufactured august 2006 through april 2007); and my 2007-2008 gmc acadia (manufactured august 2006 through april 2007) vehicles.gm is instructing owners to take their vehicle to a dealer for service if they experience symptoms of windshield washer heater module short circuits. gm's recall resolves the safety defect concerns pursued by this investigation.this engineering analysis is closed. | ||||||
| ELECTRICAL SYSTEM - FUSES AND CIRCUIT BREAKERS | ||||||
| EA08010 | GENERAL MOTORS CORP. | 06/12/2008 | 09/08/2008 | NON-CRASH ENGINE COMPARTMENT FIRES | 08V441000 | |
| In a letter dated august 27, 2008, general motors corp. (gm) notified nhtsa that it will conduct a safety recall (nhtsa recall number 08v-441) to address a safety relateddefect that can result in engine compartment fire in approximately 850,000 vehicles equipped with a heated windshield washer fluid option.the subject vehicles of this investigation comprise over three-quarters of the recall population. according to gm, a short circuit on the printed circuit board for the windshield washer fluid heater module may overheat the control-circuit ground wire. this may cause other electrical features to malfunction, create an odor or cause smoke and in rare cases it may cause a fire.as a remedy, gm dealers will install a wire harness with an in-line fuse. in addition to the subject vehicles, several other gm models with the heated windshield washer fluid option are included in recall 08v-441: my 2006-2008 buick lucerne (manufactured august 2005 through november 2007); my 2008 buick enclave (manufactured february 2007 through april 2007); my 2006-2008 cadillac dts (manufactured may 2007 through november 2007); my 2007-2008 saturn outlook (manufactured august 2006 through april 2007); and my 2007-2008 gmc acadia (manufactured august 2006 through april 2007) vehicles.gm is instructing owners to take their vehicle to a dealer for service if they experience symptoms of windshield washer heater module short circuits. gm's recall resolves the safety defect concerns pursued by this investigation.this engineering analysis is closed. | ||||||
| ELECTRICAL SYSTEM - WIRING | ||||||
| EA08010 | GENERAL MOTORS CORP. | 06/12/2008 | 09/08/2008 | NON-CRASH ENGINE COMPARTMENT FIRES | 08V441000 | |
| In a letter dated august 27, 2008, general motors corp. (gm) notified nhtsa that it will conduct a safety recall (nhtsa recall number 08v-441) to address a safety relateddefect that can result in engine compartment fire in approximately 850,000 vehicles equipped with a heated windshield washer fluid option.the subject vehicles of this investigation comprise over three-quarters of the recall population. according to gm, a short circuit on the printed circuit board for the windshield washer fluid heater module may overheat the control-circuit ground wire. this may cause other electrical features to malfunction, create an odor or cause smoke and in rare cases it may cause a fire.as a remedy, gm dealers will install a wire harness with an in-line fuse. in addition to the subject vehicles, several other gm models with the heated windshield washer fluid option are included in recall 08v-441: my 2006-2008 buick lucerne (manufactured august 2005 through november 2007); my 2008 buick enclave (manufactured february 2007 through april 2007); my 2006-2008 cadillac dts (manufactured may 2007 through november 2007); my 2007-2008 saturn outlook (manufactured august 2006 through april 2007); and my 2007-2008 gmc acadia (manufactured august 2006 through april 2007) vehicles.gm is instructing owners to take their vehicle to a dealer for service if they experience symptoms of windshield washer heater module short circuits. gm's recall resolves the safety defect concerns pursued by this investigation.this engineering analysis is closed. | ||||||
| ELECTRICAL SYSTEM - WIRING - FRONT UNDERHOOD | ||||||
| EA08010 | GENERAL MOTORS CORP. | 06/12/2008 | 09/08/2008 | NON-CRASH ENGINE COMPARTMENT FIRES | 08V441000 | |
| In a letter dated august 27, 2008, general motors corp. (gm) notified nhtsa that it will conduct a safety recall (nhtsa recall number 08v-441) to address a safety relateddefect that can result in engine compartment fire in approximately 850,000 vehicles equipped with a heated windshield washer fluid option.the subject vehicles of this investigation comprise over three-quarters of the recall population. according to gm, a short circuit on the printed circuit board for the windshield washer fluid heater module may overheat the control-circuit ground wire. this may cause other electrical features to malfunction, create an odor or cause smoke and in rare cases it may cause a fire.as a remedy, gm dealers will install a wire harness with an in-line fuse. in addition to the subject vehicles, several other gm models with the heated windshield washer fluid option are included in recall 08v-441: my 2006-2008 buick lucerne (manufactured august 2005 through november 2007); my 2008 buick enclave (manufactured february 2007 through april 2007); my 2006-2008 cadillac dts (manufactured may 2007 through november 2007); my 2007-2008 saturn outlook (manufactured august 2006 through april 2007); and my 2007-2008 gmc acadia (manufactured august 2006 through april 2007) vehicles.gm is instructing owners to take their vehicle to a dealer for service if they experience symptoms of windshield washer heater module short circuits. gm's recall resolves the safety defect concerns pursued by this investigation.this engineering analysis is closed. | ||||||
Consumer Complaints
| Fail date | miles | occurences | Purchase date |
|---|---|---|---|
| ELECTRICAL SYSTEM | |||
| 03/13/2013 | 36300 | ||
| Daytime running lamp (drl) / turn signal bulb appears to have melted the headlight housing. bulb failure caused owner to discover problem. melted housing will no longer accept bulb fixture. this seems flawed and results in a safety issue where turn signal on front of car is inoperable without expensive replacement of entire headlight housing. new housing may not solve heating problem that causes melting. this problem, and similar consequences of excess lamp heat, is reported by other owners on the cadillac forum. | |||
| 11/07/2012 | 98000 | 1 | |
| My battery constantly goes dead, everytime it rains, snows or even gets cold. i brought a brand new battery and a brand new alternator and it still does the same thing. the air-bag message keeps coming up along with every electrical component there is on this car. i have taken it to dealerships to get diagnostics and they never find anything wrong. this is not safe for my kids to ride in please advise. *tr | |||
| 11/07/2012 | 98000 | ||
| My battery constantly goes dead, everytime it rains, snows or even gets cold. i brought a brand new batterry and a brand new alternator and it still does the same thing. the air-bag message keeps coming up along with every electrical component there is on this car. i have taken it to dealrships to get diagnostics and they never find anything wrong. this is not safe for my kids to ride in please advise. | |||
| 08/12/2007 | 112 | ||
| Like many other caddy owners are having problems with the twilight sensors operation. problem being the headlamps come on too early and go off too late resulting in a dimming of the interior dash illumination. this causes the driver not to be able to determine vehicle speed...especially if its still bright enough out for sun glasses to be used. my 2007 dts and others. see this link also http://www.cadillacforums.com/forums/cadillac-forum/t-92975.html i had my car to the garage just today and they did nothing to fix this safety issue. not going to argue with them any more.... something must be done to help us. the rental dts i had while my car was in repair did not have the same problem yet they said my car twilight was ok. thanks | |||
| 09/02/2010 | 45000 | ||
| 9-02-2010 driving 70 miles per hour on i-75 n, 1. cruise suddenly cuts off. 2. car slows to 4-5 miles per hour. 3. speed odometer cuts off 4. all safety lights come on 5. no brakes 6. anti lock brake light is on. very dangerous situation. since then car has been to dealer for the same type of thing six times. after first incident dealer kept car approximately three weeks. they could not duplicate the incident. local dealer very helpful but cannot fix. filed complaint with cadillac, case number 7185228594, no help. | |||
| 10/23/2009 | 38000 | 1 | |
| Ref.odi number 10289768 unexplained acceleration. upon further study i believe the problem originated in the electrical system in the engine control module ( ecm). has a solution to this problem been presented? *tr | |||
| 10/23/2009 | 38000 | 1 | |
| When at idle speed the engine suddenly accelerate to a high speed. i was surprised and placed the car in reverse. i shot backwards, where as i shifted to drive. i hit a solid object and the car was heavily damaged. i could not hold the car with the brakes. i totally panicked. *tr | |||