Recalls
| Campaign | Manufacturer | Manufacturing date | Type | # of units affected | Date Owner notified Mfg | Recall Initiated by | Manufacturers of recalled vehicles/products | Report Recieved Date | Record Creation Date | Regulation Part Number | FMVSS Number | |||||
|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|
| ELECTRICAL SYSTEM | ||||||||||||||||
| 10V240000 | GENERAL MOTORS CORP. | V (Vehicle) | 1365070 | 06/11/2010 | MFR | GENERAL MOTORS CORP. | 06/04/2010 | 06/04/2010 | ||||||||
| Defect Summary | Gm is recalling certain model year 2006-2009 buick, lucerne; cadillac dts; hummer h2; model year 2008-2009 buick enclave; cadillac cts; model year 2007-2009 cadillac escalade, escalade esv, escalade ext; chevrolet avalanche, silverado, suburban, tahoe; gmc acadia, sierra, yukon, yukon xl; saturn outlook; and model year 2009 chevrolet traverse vehicles equipped with a heated washer fluid system (hwfs). a recall was implemented in 2008 to add a fuse to the control circuit harness to address the potential consequences of a printed circuit board (pcb) electrical short. however, there have been new reports of thermal incidents on hwfs modules after this improvement was installed. these incidents resulted from a new failure mode attributed to the device's thermal protection feature. the significance varies from minor distortion to considerable melting of the plastic around the hwfs fluid chamber. | |||||||||||||||
| Consequence Summary | It is possible for the heated washer module to ignite and a fire may occur. | |||||||||||||||
| Corrective Summary | Dealers will permanently disable and remove the heated washer fluid module. an updated page for the owner manual will be provided and inserted in the owner manual to document that the feature has been permanently disabled and removed from the vehicle. the safety recall is expected to begin on or before june 11, 2010. owners may contact buick at 1-866-608-8080, cadillac at 1-866-982-2339, chevrolet at 1-800-630-2438, saturn at 1-800-972-8876, gmc at 1-866-996-9463 and hummer at 1-800-732-5493 or at the owner center at www.gmownercenter.com. | |||||||||||||||
| Notes | Owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov . | |||||||||||||||
Bulletins
| Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
|---|---|---|---|---|---|
| ELECTRICAL SYSTEM | |||||
| PIT5074F | 05/01/2012 | 10044242 | Gm: j-35616-64b terminal test probe and replacement terminal. also included models verano, regal, lacrosse, cts, srx, volt, sonic, malibu, impala, equinox, cruze, avalanche, tahoe suburban, silverado, sierra, yukon, and terrain for model | 05/24/2012 | |
| PIT-4730A | 06/01/2010 | 10036550 | Buick/cadillac/chevrolet/gmc/hummer/pontiac/saturn: additional diagnostic information for u0140 or u0073. vehicle may exhibits some symptom(s) as door locks cycle while driving; intermittent no start; service stabilitrak dic message; spee | 03/28/2011 | |
| PIC-5199 | 06/01/2009 | 10032901 | Cadillac: sir indicator on dtc b0080 stored. there is an error in si. if you follow gm document id#1891761 for b0080 in the circuit/system testing section , step 4, it states to check for ignition voltage (which is 12-14 volts). if less | 06/08/2010 | |
| PIC-4816 | 07/01/2008 | 10026106 | Gmc: the windshield wiper washers turn on by themselves. *pe | 09/30/2008 | |
| ELECTRICAL SYSTEM - SOFTWARE | |||||
| 08-08-46-008C | 01/01/2011 | 10037553 | Ready | 05/25/2011 | |
| 08-08-46-008C | 01/01/2011 | 10037553 | Gm: there are multiple concerns with the onstar system. it is not working correctly and the battery may drain. *rm | 05/25/2011 | |
| ELECTRICAL SYSTEM - WIRING | |||||
| PIT-4730A | 06/01/2010 | 10036550 | Buick/cadillac/chevrolet/gmc/hummer/pontiac/saturn: additional diagnostic information for u0140 or u0073. vehicle may exhibits some symptom(s) as door locks cycle while driving; intermittent no start; service stabilitrak dic message; spee | 03/28/2011 | |
| SB-10142 | 05/01/2010 | 10033884 | Update for inventory and customer vehicles ebcm harness contact-expires with base warranty. procedure to secure the electronic brake control module (ebcm) wire harness to eliminate contact on certain vehicles equipped with a v8 engine. * | 09/29/2010 | |
Consumer Complaints
| Fail date | miles | occurences | Purchase date |
|---|---|---|---|
| ELECTRICAL SYSTEM | |||
| 06/15/2012 | 43575 | ||
| Vehicle failed to start after being parked overnight. engine would crank but not fire. dealer found rear fuse assembly to be in a melted condition; fuel pump fuse/relay was charred. entire fuse assembly required replacement. dealer could find no cause for problem. my main concern is this assembly is located under the rear passenger seat next to the batteries. the power surge that caused such heat damage could, in my opinion, result in a fire in the vehicle, or at the very least burn anyone sitting in the rear seat compartment of the vehicle. | |||