Bulletins
Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
---|---|---|---|---|---|
ENGINE AND ENGINE COOLING | |||||
PIP-4568K | 01/01/2011 | 10037941 | Gm: service engine soon light is on with a misfire and a possible tick noise. *rm | 06/08/2011 | |
PIP-4568K | 01/01/2011 | 10037941 | Ready | 06/08/2011 | |
PIP-4138K | 01/01/2011 | 10037933 | Ready | 06/08/2011 | |
PIP-4138K | 01/01/2011 | 10037933 | Gm: the service engine soon light is on, there is also a misfire or engine noise. there are multiple possible causes. *rm | 06/08/2011 | |
ENGINE AND ENGINE COOLING - COOLING SYSTEM - HOSE | |||||
08-04-19-004 | 08/01/2008 | 10026624 | Gmc: correct front axle vent hose routing. the front axle vent hose is mounted in the left side of the engine compartment, and may not be correctly routed. *pe | 11/19/2008 | |
ENGINE AND ENGINE COOLING - ENGINE | |||||
PIT-4769B | 03/01/2011 | 10038624 | Gm: the air bag light is on with a stored trouble code. *rm | 06/24/2011 | |
PIT-4769B | 03/01/2011 | 10038624 | Ready | 06/24/2011 | |
PIP-3783C | 12/01/2010 | 10037809 | Ready | 06/06/2011 | |
PIP-3783C | 12/01/2010 | 10037809 | Gm: the engine light is on and the vehicle lacks power. there are multiple possible trouble codes. *rm | 06/06/2011 | |
PIP-4851 | 11/01/2010 | 10037492 | Ready | 05/24/2011 | |
PIP-4851 | 12/01/2010 | PIP-4851A | 10037492 | Gm: there is an intermittent engine light on due to five possible internal trouble codes. there may also be an extended crank after filling the fuel tank. *rm updated 5/31/11. *pe | 05/24/2011 |
PIP-4851 | 11/01/2010 | 10037492 | Gm: there is an intermittent engine light on due to five possible internal trouble codes. there may also be an extended crank after filling the fuel tank. *rm | 05/24/2011 | |
SB-07-06-03-002C | 07/01/2010 | 10036524 | Cadillac/chevrolet/gmc: information on inspecting top post battery cable bolts, clamps and nuts during pre-delivery inspection (pdi). *pe | 03/28/2011 | |
PIP-4492P | 08/01/2010 | 10036464 | Buick/cadillac/chevrolet/gmc/hummer/pontiac/saab: oil consumption and/or exhaust smoke-possible pcv baffle or lifter concern. upon inspection, obvious oil will be found in the intake manifold and/or pcv vacuum tube. *pe | 03/16/2011 | |
PIP-4492P | 09/01/2010 | PIP-4492Q | 10036464 | Buick/cadillac/chevrolet/gmc/hummer/pontiac/saab: oil consumption and/or exhaust smoke-possible pcv baffle or lifter concern. upon inspection, obvious oil will be found in the intake manifold and/or pcv vacuum tube. *pe updated 3/21/ | 03/16/2011 |
PIT-5028 | 09/01/2010 | 10036324 | Pontiac/saturn/buick/gmc/chevrolet/cadillac/hummer: vehicle start and stalls after theft deterrent module replacement. model years 2006-2011. does not apply to vehicles with keyless access system. *pe | 03/14/2011 | |
SB-10-06-01-008 | 09/01/2010 | 10035804 | Cadillac/chevrolet/gmc/pontiac: engine oil consumption on aluminum block engines with active fuel management (afm) (install afm oil deflector and clean carbon from cylinder). caused by an uncovered afm valve that sprays oil on the bottom o | 03/04/2011 | |
SB-09-06-01-006 | 05/01/2009 | 10030724 | Gmc/cadillac/chevrolet: check engine light on, engine misfire, hard start, rough idle, hesitation, loss of power, poor performance, noise, dtcs p0300, p0301, p0302,p0303, p0304, p0305, p0306, p0307, p0308 set (replace engine). *pe | 11/23/2009 | |
PIT-4846A | 05/06/2009 | 10030244 | Cadillac/chevrolet/gmc: locations of high speed gmlan wiring concerns. gauges inoperative, no crank, harsh transmission shifting, no transmission shifting, door locks cycling and indicators on. *pe | 09/02/2009 | |
08-06-04-012B | 11/19/2008 | 10026627 | Gmc: ei08047-intermittent mil/ses, dtc(s) p2120, 02122, 02123, 02125, p2127, p2128, p2138 with reduced engine power (replace accelerator pedal). this may be caused by corrosion at the accelerator pedal connector. *pe | 11/19/2008 | |
08-06-03-007 | 07/01/2008 | 10026007 | Gmc: no start, no crank, intermittent electrical operations (check for poor connections within engine wiring harness junction block). *pe | 09/23/2008 | |
08-07-30-021 | 05/01/2008 | 10025668 | Loss of high speed gmlan communications, intermittent no crank, ipc gauge fluctuation, intermittent door lock cycling, transmission may not shift, dtcs u0073, u0100, u0101, u0102, u0121, u0140 set (repair backed out terminal in transmission | 08/28/2008 | |
08-07-30-021 | 04/01/2008 | 10025402 | Loss of high speed gmlan communications, intermittent no crank, ipc gauge fluctuation, intermittent door lock cycling, transmission may not shift, dtcs u0073, u0100, u0101, u0102, 70140 (repair backed out terminal in transmission harness co | 08/06/2008 | |
08-06-04-012 | 03/01/2008 | 080604012A | 10024742 | Ei08047 - intermittent mil/ses, dtc's p2120, p2122, p2123, p2125, p2127, p2128, p2138 with reduced engine power. *nj | 05/15/2008 |
PIT4284 | 02/01/2008 | PIT4284A | 10024282 | Engine stalls after being remote started. *nj | 04/01/2008 |
PIP4321 | 02/01/2008 | PIP4321A | 10024285 | Oil leak at rear of engine. equipped with a 4.8, 5.3, 6.0 or 6.2 v8 engine. *nj | 04/01/2008 |
060603013 | 09/01/2007 | 060603013B | 10021448 | Intermittent low battery voltage, engine will not crank, engine cranks but will not start, charging system light on, service battery charging system message displayed, dtc b1405 and/or b1516 set. (reprogram bcm). *kb updated 11/02 | 04/27/2007 |
060603011 | 01/01/2007 | 060603011A | 10021118 | Humming or buzzing from rear of vehicle and/or possible dead battery. (check fuel pump relay and replace, if necessary). *kb | 03/07/2007 |
4006 | 10021023 | Whine howl noise from the rear differential on vehicles equipped with an 8.6 rear axle. *kb | 02/22/2007 | ||
060602007 | 05/01/2006 | 10020955 | Ly2, ly5, ly6, lh6, l76, lmg, lc9, l92, coolant or rubber type odor, loss of engine coolant and/or overheat condition. *kb | 02/01/2007 | |
060603009 | 10/01/2006 | 10020948 | Diagnostic information on battery draw no start - body control module, bcm power timer. *kb | 02/01/2007 | |
3845 | 10/12/2006 | 3845C | 10020926 | Malfunction indicator light (mil) illuminated diagnostic trouble code (dtc) p1825 and/or p1915. in the tcm no prndl display no crank. *kb | 01/30/2007 |
3996 | 10020911 | No movement or slipping or binding in forward range, mil illuminated, dtc p0777 or p2723. *kb | 01/29/2007 | ||
060845007 | 09/01/2006 | 10020889 | No start/loss of low speed lan, dtc's set. *kb | 01/26/2007 | |
060604042 | 09/01/2006 | 060604042A | 10020880 | Lr4, ly2, l33, lh6, lm7, l59, lc9, lmg, ly5, ls2, lq9, lq4, l76, ly6 throttle actuator control (tac). module codes, mil/ses dtc's p2108, p1516, u0107, reduced engine power. *kb | 01/25/2007 |
060604029 | 05/01/2006 | 10020836 | Information on performing an engine wiring harness modification for l92 replacement engines built without active fuel management. *kb | 01/24/2007 | |
ENGINE AND ENGINE COOLING - EXHAUST SYSTEM - EMISSION CONTROL - CRANKCASE (PCV) | |||||
PIP-4492P | 09/01/2010 | PIP-4492Q | 10036464 | Buick/cadillac/chevrolet/gmc/hummer/pontiac/saab: oil consumption and/or exhaust smoke-possible pcv baffle or lifter concern. upon inspection, obvious oil will be found in the intake manifold and/or pcv vacuum tube. *pe updated 3/21/ | 03/16/2011 |
PIP-4492P | 08/01/2010 | 10036464 | Buick/cadillac/chevrolet/gmc/hummer/pontiac/saab: oil consumption and/or exhaust smoke-possible pcv baffle or lifter concern. upon inspection, obvious oil will be found in the intake manifold and/or pcv vacuum tube. *pe | 03/16/2011 | |
PIP3343 | 02/01/2008 | PIP3343A | 10024344 | Possible engine oil leak due to pcv freeze-up, equipped with the 4.8, 5.3, 6.0, and 6.2 v-8 engines. *nj | 04/07/2008 |
Investigations
NHTSA ID | Manufacturer | Date open | Date close | Subject | Recall campaign | |
---|---|---|---|---|---|---|
ENGINE AND ENGINE COOLING | ||||||
EA08010 | GENERAL MOTORS CORP. | 06/12/2008 | 09/08/2008 | NON-CRASH ENGINE COMPARTMENT FIRES | 08V441000 | |
In a letter dated august 27, 2008, general motors corp. (gm) notified nhtsa that it will conduct a safety recall (nhtsa recall number 08v-441) to address a safety relateddefect that can result in engine compartment fire in approximately 850,000 vehicles equipped with a heated windshield washer fluid option.the subject vehicles of this investigation comprise over three-quarters of the recall population. according to gm, a short circuit on the printed circuit board for the windshield washer fluid heater module may overheat the control-circuit ground wire. this may cause other electrical features to malfunction, create an odor or cause smoke and in rare cases it may cause a fire.as a remedy, gm dealers will install a wire harness with an in-line fuse. in addition to the subject vehicles, several other gm models with the heated windshield washer fluid option are included in recall 08v-441: my 2006-2008 buick lucerne (manufactured august 2005 through november 2007); my 2008 buick enclave (manufactured february 2007 through april 2007); my 2006-2008 cadillac dts (manufactured may 2007 through november 2007); my 2007-2008 saturn outlook (manufactured august 2006 through april 2007); and my 2007-2008 gmc acadia (manufactured august 2006 through april 2007) vehicles.gm is instructing owners to take their vehicle to a dealer for service if they experience symptoms of windshield washer heater module short circuits. gm's recall resolves the safety defect concerns pursued by this investigation.this engineering analysis is closed. | ||||||
PE08010 | GENERAL MOTORS CORP. | 02/04/2008 | 06/12/2008 | NON-CRASH ENGINE COMPARTMENT FIRES | ||
In response to an information request letter sent by the office of defects investigation(odi) during preliminary evaluation pe08-010, gm provided odi with 41 allegations of non-crash engine compartment fires including 16 allegations of fires originating with the ignition in the off position.one of the fires was determined to be caused by an arson event.odi has also received 5 reports, 4 of which are of duplicative of reports provided by gm, alleging non-crash engine compartment fires in the subject vehicles.in total, odi is aware of 41 non-crashengine compartment fires in the subject vehicles that are unrelated to arson.eight of the 41 fire allegations also allege property damage as a result of the fires.this preliminary evaluation has been upgraded to an engineering analysis (ea08-010) to further assess the scope, frequency, origin and cause of the alleged non-crash related engine compartment fires in the subject vehicles. | ||||||
ENGINE AND ENGINE COOLING - ENGINE | ||||||
EA08010 | GENERAL MOTORS CORP. | 06/12/2008 | 09/08/2008 | NON-CRASH ENGINE COMPARTMENT FIRES | 08V441000 | |
In a letter dated august 27, 2008, general motors corp. (gm) notified nhtsa that it will conduct a safety recall (nhtsa recall number 08v-441) to address a safety relateddefect that can result in engine compartment fire in approximately 850,000 vehicles equipped with a heated windshield washer fluid option.the subject vehicles of this investigation comprise over three-quarters of the recall population. according to gm, a short circuit on the printed circuit board for the windshield washer fluid heater module may overheat the control-circuit ground wire. this may cause other electrical features to malfunction, create an odor or cause smoke and in rare cases it may cause a fire.as a remedy, gm dealers will install a wire harness with an in-line fuse. in addition to the subject vehicles, several other gm models with the heated windshield washer fluid option are included in recall 08v-441: my 2006-2008 buick lucerne (manufactured august 2005 through november 2007); my 2008 buick enclave (manufactured february 2007 through april 2007); my 2006-2008 cadillac dts (manufactured may 2007 through november 2007); my 2007-2008 saturn outlook (manufactured august 2006 through april 2007); and my 2007-2008 gmc acadia (manufactured august 2006 through april 2007) vehicles.gm is instructing owners to take their vehicle to a dealer for service if they experience symptoms of windshield washer heater module short circuits. gm's recall resolves the safety defect concerns pursued by this investigation.this engineering analysis is closed. | ||||||
PE08010 | GENERAL MOTORS CORP. | 02/04/2008 | 06/12/2008 | NON-CRASH ENGINE COMPARTMENT FIRES | ||
In response to an information request letter sent by the office of defects investigation(odi) during preliminary evaluation pe08-010, gm provided odi with 41 allegations of non-crash engine compartment fires including 16 allegations of fires originating with the ignition in the off position.one of the fires was determined to be caused by an arson event.odi has also received 5 reports, 4 of which are of duplicative of reports provided by gm, alleging non-crash engine compartment fires in the subject vehicles.in total, odi is aware of 41 non-crashengine compartment fires in the subject vehicles that are unrelated to arson.eight of the 41 fire allegations also allege property damage as a result of the fires.this preliminary evaluation has been upgraded to an engineering analysis (ea08-010) to further assess the scope, frequency, origin and cause of the alleged non-crash related engine compartment fires in the subject vehicles. |
Consumer Complaints
Fail date | miles | occurences | Purchase date |
---|---|---|---|
ENGINE | |||
10/01/2011 | 42000 | 1 | |
Noticed excessive exhaust fumes inside the car while at idle during stops. all windows up during winter season driving. inspected exhaust system for leaks. noticed exhaust manifold bolts on both sides of engine missing and subsequent leaks at each exhaust port with missing bolts. noticed excessive rusting and corrosion of exhaust manifold and bolts. this seems to be caused by a metal defect creating premature corrosion of exhaust manifolds and bolts. intern, causing exhaust leaks and excessive amounts of exhaust gases under hood an in the cabin. this is a major safety concern to me and my family. please investigate. *tr | |||
10/01/2011 | 42000 | ||
Noticed excessive exhaust fumes inside the car while at idle during stops. all windows up during winter season driving. inspected exhaust system for leaks. noticed exhaust manifold bolts on both sides of engine missing and subsequent leaks at each exhaust port with missing bolts. noticed excessive rusting and corrosion of exhaust manifold and bolts. this seems to be caused by a metal defect creating premature corrosion of exhaust manifolds and bolts. inturn, causing exhaust leaks and excessive amounts of exhaust gasses under hood an in the cabin. this is a major safety concern to me and my family. please investigate. | |||
06/01/2012 | 88000 | ||
Heard from dealer my manifold bolt is broken... said $500-600 to fix | |||
ENGINE AND ENGINE COOLING | |||
05/31/2008 | 25000 | ||
Tl*the contact owns a 2007 cadillac escalade. while driving approximately 55 mph on normal road conditions, the vehicle came to a stop and the gear shifter was placed into reverse. the reverse mode, tilt down exterior mirrors failed to operate. in addition, the vehicle failed to respond when the accelerator pedal was depressed. the vehicle lurched forward unexpectedly. the failures occurred whenever the vehicle was in operation. the vehicle was taken to the authorized dealer for inspection and they stated that there was no program available to repair the reverse mirror failure. they could not determine the cause of the other failures. the vehicle has not been repaired. the failure mileage was 25,000 and current mileage was 45,000. | |||
08/05/2008 | 10000 | 1 | |
2007 model cadillac escalade while parked in a garage, not driven for about 2 days caught fire all on its own and burnt down causing extensive damage to property and other vehicles. *tr | |||
06/01/2006 | 3900 | 1 | 02/17/2006 |
Dt*: the contact stated while depressing the accelerator pedal from a stopped position the vehicle hesitated. the problem occurred intermittently. the vehicle was driven to the dealer who could not duplicate the problem. updated 07/05/06. *jb | |||
ENGINE AND ENGINE COOLING - EXHAUST SYSTEM | |||
10/09/2010 | 34000 | ||
2007 escalade ext ,34k miles. heat shield on exh manifold rusted thru mounts , fell into steering column. steering locked in a rt hand turn, went loc, very hard jerk on steering wheel broke it free. checked passenger side, it had also fallen off but didn't cause any problem. |