Investigations
| NHTSA ID | Manufacturer | Date open | Date close | Subject | Recall campaign | |
|---|---|---|---|---|---|---|
| PARKING BRAKE | ||||||
| PE03057 | GENERAL MOTORS CORP. | 12/08/2003 | 04/09/2004 | PARKING BRAKE FAILURE | ||
| Odi opened pe03-057 to assess parking brake ineffectiveness in the subject vehicles.these vehicles are equipped with four wheel disc brakes that incorporate a single-shoe drum-in-hat parking brake independent of the service brakes.complaint and warranty data indicate that the parking brake linings tend to wear out early in the life of the vehicle (at an average of 24 months in service), reducing the parking brake system's torque below that needed to immobilize the vehicle.gm has attributed this accelerated wear to foreign material intrusion and a failure of the brake shoe to properly self-center within its brake drum.effective with the start of my 2003 production, a newer reduced force hold-down clip was introduced to facilitate brake shoe disengagement from the drum surface.this part is also available at the service level for the my 1999-2002 vehicles.gm has indicated that the paking brake is intended to operate in conjunction with the transmission to immobilze parked vehicles, and that in many cases, accelerated parking brake lining wear is caused by rough use, vehicle modifications, and driving with the parking engaged. odi has upgraded the preliminary evaluation to an engineering analysis to gather further information concerning parking brake usage factors and the circumstances surrounding the seventeen reported vehicle crashes. | ||||||
| EA04011 | GENERAL MOTORS CORP. | 04/09/2004 | 05/10/2005 | PARKING BRAKE FAILURE | 05V161000 | |
| In a letter dated april 20, 2005, gm notified nhtsa that it had decided that defects that relate to motor vehicle safety exist in certain model year (my) 1999-2002 c/k 1500 series (pbr parking brake system) and my 2001-2005 c/k 2500 and 3500 series (trw parking brake system) pickups with manual transmissions.according to gm, some of these vehicles may have conditions that cause the friction linings to wear to an extent where the parking brake can become ineffective in immobilizing a parked vehicle.gm's action covers an estimated total of 142,585 vehicles.dealers will install a low-force spring clip retainer for vehicles equipped with the pbr parking brake system and install a redesigned parking brake cable assembly on vehicles equipped with the trw parking brake system. a total of 58 non-duplicative complaints were received by odi and gm concerning the approximately 59,000 my 1999-2002 c/k 1500 series pickup trucks with the pbr parking brake system.these included 22 alleged rollaway incidents, resulting in a rate of 38.5 rollaway incidents per 100,000 vehicles.odi is aware of 24 complaints regarding the my 2001-2005 c/k 2500 and 3500 series manual transmission trucks recalled by gm, including 5 alleging rollaway incidents.though the conditions described in gm's letter are also present in the c/k trucks with automatic transmissions, the rollaway rate in those vehicles was similar to those observed in peer vehicles studied by odi in this investigation.this engineering analysis is closed. for additional information, see the attached closing report. | ||||||
| PARKING BRAKE - CONVENTIONAL | ||||||
| EA04011 | GENERAL MOTORS CORP. | 04/09/2004 | 05/10/2005 | PARKING BRAKE FAILURE | 05V161000 | |
| In a letter dated april 20, 2005, gm notified nhtsa that it had decided that defects that relate to motor vehicle safety exist in certain model year (my) 1999-2002 c/k 1500 series (pbr parking brake system) and my 2001-2005 c/k 2500 and 3500 series (trw parking brake system) pickups with manual transmissions.according to gm, some of these vehicles may have conditions that cause the friction linings to wear to an extent where the parking brake can become ineffective in immobilizing a parked vehicle.gm's action covers an estimated total of 142,585 vehicles.dealers will install a low-force spring clip retainer for vehicles equipped with the pbr parking brake system and install a redesigned parking brake cable assembly on vehicles equipped with the trw parking brake system. a total of 58 non-duplicative complaints were received by odi and gm concerning the approximately 59,000 my 1999-2002 c/k 1500 series pickup trucks with the pbr parking brake system.these included 22 alleged rollaway incidents, resulting in a rate of 38.5 rollaway incidents per 100,000 vehicles.odi is aware of 24 complaints regarding the my 2001-2005 c/k 2500 and 3500 series manual transmission trucks recalled by gm, including 5 alleging rollaway incidents.though the conditions described in gm's letter are also present in the c/k trucks with automatic transmissions, the rollaway rate in those vehicles was similar to those observed in peer vehicles studied by odi in this investigation.this engineering analysis is closed. for additional information, see the attached closing report. | ||||||
| PARKING BRAKE - CONVENTIONAL - MECHANICAL | ||||||
| EA04011 | GENERAL MOTORS CORP. | 04/09/2004 | 05/10/2005 | PARKING BRAKE FAILURE | 05V161000 | |
| In a letter dated april 20, 2005, gm notified nhtsa that it had decided that defects that relate to motor vehicle safety exist in certain model year (my) 1999-2002 c/k 1500 series (pbr parking brake system) and my 2001-2005 c/k 2500 and 3500 series (trw parking brake system) pickups with manual transmissions.according to gm, some of these vehicles may have conditions that cause the friction linings to wear to an extent where the parking brake can become ineffective in immobilizing a parked vehicle.gm's action covers an estimated total of 142,585 vehicles.dealers will install a low-force spring clip retainer for vehicles equipped with the pbr parking brake system and install a redesigned parking brake cable assembly on vehicles equipped with the trw parking brake system. a total of 58 non-duplicative complaints were received by odi and gm concerning the approximately 59,000 my 1999-2002 c/k 1500 series pickup trucks with the pbr parking brake system.these included 22 alleged rollaway incidents, resulting in a rate of 38.5 rollaway incidents per 100,000 vehicles.odi is aware of 24 complaints regarding the my 2001-2005 c/k 2500 and 3500 series manual transmission trucks recalled by gm, including 5 alleging rollaway incidents.though the conditions described in gm's letter are also present in the c/k trucks with automatic transmissions, the rollaway rate in those vehicles was similar to those observed in peer vehicles studied by odi in this investigation.this engineering analysis is closed. for additional information, see the attached closing report. | ||||||
| PARKING BRAKE - CONVENTIONAL - MECHANICAL - LINKAGE AND CABLE | ||||||
| EA04011 | GENERAL MOTORS CORP. | 04/09/2004 | 05/10/2005 | PARKING BRAKE FAILURE | 05V161000 | |
| In a letter dated april 20, 2005, gm notified nhtsa that it had decided that defects that relate to motor vehicle safety exist in certain model year (my) 1999-2002 c/k 1500 series (pbr parking brake system) and my 2001-2005 c/k 2500 and 3500 series (trw parking brake system) pickups with manual transmissions.according to gm, some of these vehicles may have conditions that cause the friction linings to wear to an extent where the parking brake can become ineffective in immobilizing a parked vehicle.gm's action covers an estimated total of 142,585 vehicles.dealers will install a low-force spring clip retainer for vehicles equipped with the pbr parking brake system and install a redesigned parking brake cable assembly on vehicles equipped with the trw parking brake system. a total of 58 non-duplicative complaints were received by odi and gm concerning the approximately 59,000 my 1999-2002 c/k 1500 series pickup trucks with the pbr parking brake system.these included 22 alleged rollaway incidents, resulting in a rate of 38.5 rollaway incidents per 100,000 vehicles.odi is aware of 24 complaints regarding the my 2001-2005 c/k 2500 and 3500 series manual transmission trucks recalled by gm, including 5 alleging rollaway incidents.though the conditions described in gm's letter are also present in the c/k trucks with automatic transmissions, the rollaway rate in those vehicles was similar to those observed in peer vehicles studied by odi in this investigation.this engineering analysis is closed. for additional information, see the attached closing report. | ||||||
Consumer Complaints
| Fail date | miles | occurences | Purchase date |
|---|---|---|---|
| PARKING BRAKE | |||
| 02/23/2009 | 250000 | 1 | |
| Tl*the contact owns a 2003 chevrolet k1500. the contact stated that the vehicle was parked on an incline in his carport with the emergency brake activated and the gear shifter positioned properly. the vehicle rolled and crashed into a house without warning. there were no personal injuries and the vehicle sustained moderate damages. in addition, there was damage to the property's foundation, siding, and gutters. the vehicle was driven to the contact's residence. two years prior to the failure, the dealer performed a free remedy repair on the emergency service brake. the vehicle has not been repaired and the cause of the failure has not been determined. the current and failure mileages were 250,000. updated 3/16/09 */cn the consumer stated the parking failure was the cause of the vehicle rolling down a hill and crashing into a neighbor's house. updated 03/19/09. *jb | |||
| 12/03/2002 | 8236 | 5 | 09/06/2002 |
| Five times truck (17 months old and 21000 miles) has been to dealerships for service 4 wheel drive message center indicator, abs light, parking brake light, alarms, and inoperable. also problems with clanking felt through the steering wheel. every time truck was fixed by replacing/reprogramming the transfer case module, and lubing of steering column (which manufacture indicates was a poor lube job at construction). problem recurred. now dealership informs that the manufacture issued a tsb that instructs dealerships to not replace modules anymore, as gm is aware of problem and new modules will be not fix the problem. were told that gm engineers are investigating it. now, if module fails again, our 4-whhel drive truck will be without 4-wheel drive. date is of first incident. numerous tsbs have been posted concerning these problems, gm does not respond. date indicated is date of first problem at 8000 miles. *ak | |||