Recalls
Campaign | Manufacturer | Manufacturing date | Type | # of units affected | Date Owner notified Mfg | Recall Initiated by | Manufacturers of recalled vehicles/products | Report Recieved Date | Record Creation Date | Regulation Part Number | FMVSS Number | |||||
---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|
FUEL SYSTEM, GASOLINE | ||||||||||||||||
06E043000 | HONEYWELL INTERNATIONAL, INC. | E (Equipment) | 88303 | 10/18/2006 | MFR | GENERAL MOTORS CORP. | 05/19/2006 | 05/22/2006 | ||||||||
Defect Summary | Certain replacement fuel filters, fram brand name p/n g3727, with date codes x52911 through x60801 sequentially or x600141 and a mexico country or origin marking on the fuel filter housing manufactured from october 18, 2005, through march 21, 2006, sold for use on the vehicles listed above and on certain school buses. (to see the school bus engine sizes, click on document search and then bus applications). the connector on the fuel filter was not manufactured to honeywell's specification. as a result, the o-ring may not seat correctly on the fuel line. | |||||||||||||||
Consequence Summary | This condition may cause an inadequate seal at the connection, potentially leading to a fuel leak. in the presence of an ignition source, a fire could occur. | |||||||||||||||
Corrective Summary | Honeywell will notify owners and replace the fuel filters free of charge. the recall began on october 18, 2006. owners may contact fram customer service at 1-800-890-2075 (option 1). | |||||||||||||||
Notes | This recall only pertains to aftermarket fram fuel filters and has no relation to any original equipment installed on the vehicles listed.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov. |
Bulletins
Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
---|---|---|---|---|---|
FUEL SYSTEM, GASOLINE - FUEL INJECTION SYSTEM | |||||
01624 | 01/01/2004 | 01624A | 10007238 | Gen iii engines with maf (mass airflow) sensor code p0101. *tt | 06/04/2004 |
FUEL SYSTEM, GASOLINE - STORAGE - TANK ASSEMBLY | |||||
020604012A | 06/01/2003 | 020604012 | 10002838 | Slow, difficult fuel fill, short fill, fuel gauge inaccurate. *tt | 09/26/2003 |
020604112 | 03/01/2002 | 631241 | Some customers may comment that the fuel tank on 2002 chevrolet and gmc c/k series is difficult to fill from approximately 3/4 to full . *slc | 05/21/2002 | |
220102 | 01/22/2002 | 629714 | Customers may comment that it may be difficult to completely fill the fuel tank. *tt | 04/05/2002 | |
201101 | 11/20/2001 | 628140 | Information on full size 3/4 ton uitility trucks equipped with dual fuel tanks. *tt | 03/05/2002 | |
010102 | 01/01/2002 | 627657 | Information regarding fuel nozzle shuts off prematurely. *yh | 02/13/2002 | |
FUEL SYSTEM, OTHER - STORAGE - FUEL GAUGE SYSTEM | |||||
PIT-3046E | 08/01/2008 | 10026704 | Gmc: fuel gauge fluctuation in park or neutral, causing the low fuel light to illuminate. *pe | 12/04/2008 |
Consumer Complaints
Fail date | miles | occurences | Purchase date |
---|---|---|---|
FUEL SYSTEM, GASOLINE | |||
02/04/2004 | 2000 | ||
Fuel pump failed 3 times already. all door electrical solenoids/cable system failed-possible poor ventilation causing excessive condensation resulting in rusting of cables. note: a friend with the same year model has exact problems and more. all costly and non-warranty items! could have been cause of accidents when fuel pumps failed but for the grace of god. | |||
09/18/2007 | 80000 | 1 | |
Fuel leaking from top of fuel pump feed/return pipes. pipes where corroded and leaking fuel on to the top of the fuel pump where fuel pools until vehicle stops or accelerates at which point the puddled fuel spills to ground, or blows up under vehicle causing a potential fire hazard. *tr | |||
1 | |||
When attempting to refuel the truck, the metal ring with the rubber hose behind ring is faulty in diameter which does not allow proper fuel flow. no matter what gas station this always occurs. owner has to use a wrench or other people to assist with fueling. please describe details.*jb | |||
FUEL SYSTEM, GASOLINE - DELIVERY - FUEL PUMP | |||
07/30/2009 | 101000 | ||
Tl*the contact owns a 2002 chevrolet avalanche. the contact stated that the fuel pump started to leak fuel due to rust. the insurance company inspected the fuel pump and confirmed the pump was defective. the contact is aware of the safety risk involved since the fuel leak could potentially cause a fire. the current mileage was 102,000 and the failure mileage was 101,000. | |||
05/21/2005 | 75000 | 4 | 05/18/2005 |
Fuel pump has quit on 3 chevrolet products over the past 4 years - each at about 75,000 miles. last one on an avalanche while driving down the highway. no accident occurred. father-in-law also had fuel pump failure on chevrolet pickup at about 75,000 miles. | |||
06/24/2004 | 28000 | 4 | 04/27/2002 |
Vehicle has problem with fuel system. either the fuel gauge goes out indicating that you have more gas than you really do. the fuel pump goes out causing the vehicle to stall. for example, i was driving up a winding hill when all of a sudden, my truck stopped with no warning on a blind curve. this created a safety issue as this incident could have caused a traffic collision. my truck has been to rally chevrolet for this problem 4 times in less than 12 months. the first time was february 2003. the second time was april 2003. the third time was june 2003 and the fourth time was january 21, 2005. there is obviously a problem with the vehicles fuel system. there is also a problem with the cooling system. every since my husband and i bought the vehicle, we have been smelling coolant after either short trips or long driving trips. there were a couple of times where once the water pump was replaced and then a freeze plug was replaced. to this day, we still smell coolant and the dealer can not find a leak. i don't think this is normal. *jb | |||
07/07/2002 | |||
While driving at 70mph fuel pump went out, causing vehicle to stall out.*ak | |||
FUEL SYSTEM, GASOLINE - DELIVERY - HOSES, LINES/PIPING, AND FITTINGS | |||
08/12/2004 | 41000 | 3 | 09/14/2003 |
Gas tank and fuel system became contaminated with rust and was clogging the fuel injectors. chevrolet dealer replaced 2 fuel injectors and fuel lines and cleaned existing gas tank. $1300 worth of repairs.*ak | |||
FUEL SYSTEM, GASOLINE - FUEL INJECTION SYSTEM | |||
08/12/2004 | 41000 | 3 | 09/14/2003 |
Gas tank and fuel system became contaminated with rust and was clogging the fuel injectors. chevrolet dealer replaced 2 fuel injectors and fuel lines and cleaned existing gas tank. $1300 worth of repairs.*ak | |||
FUEL SYSTEM, GASOLINE - STORAGE - TANK ASSEMBLY | |||
08/12/2004 | 41000 | 3 | 09/14/2003 |
Gas tank and fuel system became contaminated with rust and was clogging the fuel injectors. chevrolet dealer replaced 2 fuel injectors and fuel lines and cleaned existing gas tank. $1300 worth of repairs.*ak | |||
11/26/2001 | 11/01/2001 | ||
No summary listed for above vehicle. *ak | |||
FUEL SYSTEM, GASOLINE - STORAGE - TANK ASSEMBLY - FILLER PIPE AND CAP | |||
02/10/2002 | 10 | 02/10/2002 | |
Very difficult to fill fuel tank. must hold nozzled tightly against filler opening. i have complained to the dealer about this since i purchased it. they fixed it, but the difficulty continues. | |||
FUEL SYSTEM, OTHER | |||
06/16/2009 | 156323 | 1 | |
Engine shut down completely while driving. brakes wasn't working properly. *tr | |||
FUEL SYSTEM, OTHER - STORAGE - FUEL GAUGE SYSTEM | |||
06/24/2004 | 28000 | 4 | 04/27/2002 |
Vehicle has problem with fuel system. either the fuel gauge goes out indicating that you have more gas than you really do. the fuel pump goes out causing the vehicle to stall. for example, i was driving up a winding hill when all of a sudden, my truck stopped with no warning on a blind curve. this created a safety issue as this incident could have caused a traffic collision. my truck has been to rally chevrolet for this problem 4 times in less than 12 months. the first time was february 2003. the second time was april 2003. the third time was june 2003 and the fourth time was january 21, 2005. there is obviously a problem with the vehicles fuel system. there is also a problem with the cooling system. every since my husband and i bought the vehicle, we have been smelling coolant after either short trips or long driving trips. there were a couple of times where once the water pump was replaced and then a freeze plug was replaced. to this day, we still smell coolant and the dealer can not find a leak. i don't think this is normal. *jb |