Bulletins
Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
---|---|---|---|---|---|
ENGINE AND ENGINE COOLING | |||||
PIP-4138K | 01/01/2011 | 10037933 | Ready | 06/08/2011 | |
PIP-4568K | 01/01/2011 | 10037941 | Gm: service engine soon light is on with a misfire and a possible tick noise. *rm | 06/08/2011 | |
PIP-4138K | 01/01/2011 | 10037933 | Gm: the service engine soon light is on, there is also a misfire or engine noise. there are multiple possible causes. *rm | 06/08/2011 | |
PIP-4568K | 01/01/2011 | 10037941 | Ready | 06/08/2011 | |
ENGINE AND ENGINE COOLING - COOLING SYSTEM - HOSE | |||||
08-04-19-004 | 08/01/2008 | 10026624 | Gmc: correct front axle vent hose routing. the front axle vent hose is mounted in the left side of the engine compartment, and may not be correctly routed. *pe | 11/19/2008 | |
ENGINE AND ENGINE COOLING - ENGINE | |||||
PIT-4769B | 03/01/2011 | 10038624 | Ready | 06/24/2011 | |
PIT-4769B | 03/01/2011 | 10038624 | Gm: the air bag light is on with a stored trouble code. *rm | 06/24/2011 | |
PIP-3783C | 12/01/2010 | 10037809 | Gm: the engine light is on and the vehicle lacks power. there are multiple possible trouble codes. *rm | 06/06/2011 | |
PIP-3783C | 12/01/2010 | 10037809 | Ready | 06/06/2011 | |
SB-07-06-03-002C | 07/01/2010 | 10036524 | Cadillac/chevrolet/gmc: information on inspecting top post battery cable bolts, clamps and nuts during pre-delivery inspection (pdi). *pe | 03/28/2011 | |
PIP-4492P | 09/01/2010 | PIP-4492Q | 10036464 | Buick/cadillac/chevrolet/gmc/hummer/pontiac/saab: oil consumption and/or exhaust smoke-possible pcv baffle or lifter concern. upon inspection, obvious oil will be found in the intake manifold and/or pcv vacuum tube. *pe updated 3/21/ | 03/16/2011 |
PIP-4492P | 08/01/2010 | 10036464 | Buick/cadillac/chevrolet/gmc/hummer/pontiac/saab: oil consumption and/or exhaust smoke-possible pcv baffle or lifter concern. upon inspection, obvious oil will be found in the intake manifold and/or pcv vacuum tube. *pe | 03/16/2011 | |
PIT-5028 | 09/01/2010 | 10036324 | Pontiac/saturn/buick/gmc/chevrolet/cadillac/hummer: vehicle start and stalls after theft deterrent module replacement. model years 2006-2011. does not apply to vehicles with keyless access system. *pe | 03/14/2011 | |
SB-10-06-01-008 | 09/01/2010 | 10035804 | Cadillac/chevrolet/gmc/pontiac: engine oil consumption on aluminum block engines with active fuel management (afm) (install afm oil deflector and clean carbon from cylinder). caused by an uncovered afm valve that sprays oil on the bottom o | 03/04/2011 | |
SB-09-06-01-006 | 05/01/2009 | 10030724 | Gmc/cadillac/chevrolet: check engine light on, engine misfire, hard start, rough idle, hesitation, loss of power, poor performance, noise, dtcs p0300, p0301, p0302,p0303, p0304, p0305, p0306, p0307, p0308 set (replace engine). *pe | 11/23/2009 | |
PIT-4846A | 05/06/2009 | 10030244 | Cadillac/chevrolet/gmc: locations of high speed gmlan wiring concerns. gauges inoperative, no crank, harsh transmission shifting, no transmission shifting, door locks cycling and indicators on. *pe | 09/02/2009 | |
08-06-03-007 | 07/01/2008 | 10026007 | Gmc: no start, no crank, intermittent electrical operations (check for poor connections within engine wiring harness junction block). *pe | 09/23/2008 | |
ENGINE AND ENGINE COOLING - ENGINE - DIESEL | |||||
PIP-4574M | 08/01/2010 | 10036485 | Buick/chevrolet/gmc/pontiac/saab: excessive oil consumption and/or blue exhaust smoke-investigation update. in most cases did not start until the engine accumulated approximately 30,000 miles or more. *pe | 03/21/2011 | |
ENGINE AND ENGINE COOLING - EXHAUST SYSTEM | |||||
PIP-4574M | 08/01/2010 | 10036485 | Buick/chevrolet/gmc/pontiac/saab: excessive oil consumption and/or blue exhaust smoke-investigation update. in most cases did not start until the engine accumulated approximately 30,000 miles or more. *pe | 03/21/2011 | |
ENGINE AND ENGINE COOLING - EXHAUST SYSTEM - EMISSION CONTROL - CRANKCASE (PCV) | |||||
PIP-4492P | 09/01/2010 | PIP-4492Q | 10036464 | Buick/cadillac/chevrolet/gmc/hummer/pontiac/saab: oil consumption and/or exhaust smoke-possible pcv baffle or lifter concern. upon inspection, obvious oil will be found in the intake manifold and/or pcv vacuum tube. *pe updated 3/21/ | 03/16/2011 |
PIP-4492P | 08/01/2010 | 10036464 | Buick/cadillac/chevrolet/gmc/hummer/pontiac/saab: oil consumption and/or exhaust smoke-possible pcv baffle or lifter concern. upon inspection, obvious oil will be found in the intake manifold and/or pcv vacuum tube. *pe | 03/16/2011 |
Investigations
NHTSA ID | Manufacturer | Date open | Date close | Subject | Recall campaign | |
---|---|---|---|---|---|---|
ENGINE AND ENGINE COOLING | ||||||
EA08010 | GENERAL MOTORS CORP. | 06/12/2008 | 09/08/2008 | NON-CRASH ENGINE COMPARTMENT FIRES | 08V441000 | |
In a letter dated august 27, 2008, general motors corp. (gm) notified nhtsa that it will conduct a safety recall (nhtsa recall number 08v-441) to address a safety relateddefect that can result in engine compartment fire in approximately 850,000 vehicles equipped with a heated windshield washer fluid option.the subject vehicles of this investigation comprise over three-quarters of the recall population. according to gm, a short circuit on the printed circuit board for the windshield washer fluid heater module may overheat the control-circuit ground wire. this may cause other electrical features to malfunction, create an odor or cause smoke and in rare cases it may cause a fire.as a remedy, gm dealers will install a wire harness with an in-line fuse. in addition to the subject vehicles, several other gm models with the heated windshield washer fluid option are included in recall 08v-441: my 2006-2008 buick lucerne (manufactured august 2005 through november 2007); my 2008 buick enclave (manufactured february 2007 through april 2007); my 2006-2008 cadillac dts (manufactured may 2007 through november 2007); my 2007-2008 saturn outlook (manufactured august 2006 through april 2007); and my 2007-2008 gmc acadia (manufactured august 2006 through april 2007) vehicles.gm is instructing owners to take their vehicle to a dealer for service if they experience symptoms of windshield washer heater module short circuits. gm's recall resolves the safety defect concerns pursued by this investigation.this engineering analysis is closed. | ||||||
ENGINE AND ENGINE COOLING - ENGINE | ||||||
EA08010 | GENERAL MOTORS CORP. | 06/12/2008 | 09/08/2008 | NON-CRASH ENGINE COMPARTMENT FIRES | 08V441000 | |
In a letter dated august 27, 2008, general motors corp. (gm) notified nhtsa that it will conduct a safety recall (nhtsa recall number 08v-441) to address a safety relateddefect that can result in engine compartment fire in approximately 850,000 vehicles equipped with a heated windshield washer fluid option.the subject vehicles of this investigation comprise over three-quarters of the recall population. according to gm, a short circuit on the printed circuit board for the windshield washer fluid heater module may overheat the control-circuit ground wire. this may cause other electrical features to malfunction, create an odor or cause smoke and in rare cases it may cause a fire.as a remedy, gm dealers will install a wire harness with an in-line fuse. in addition to the subject vehicles, several other gm models with the heated windshield washer fluid option are included in recall 08v-441: my 2006-2008 buick lucerne (manufactured august 2005 through november 2007); my 2008 buick enclave (manufactured february 2007 through april 2007); my 2006-2008 cadillac dts (manufactured may 2007 through november 2007); my 2007-2008 saturn outlook (manufactured august 2006 through april 2007); and my 2007-2008 gmc acadia (manufactured august 2006 through april 2007) vehicles.gm is instructing owners to take their vehicle to a dealer for service if they experience symptoms of windshield washer heater module short circuits. gm's recall resolves the safety defect concerns pursued by this investigation.this engineering analysis is closed. |
Consumer Complaints
Fail date | miles | occurences | Purchase date |
---|---|---|---|
ENGINE AND ENGINE COOLING | |||
04/04/2011 | 99000 | ||
Exhaust manifold bolt heads are breaking off causing there to be an exhaust leak. pollution recall should be inforced to have gm cover all repairs of the exhaust manifold bolts. check engine light comes on and vehicle can not pass emissions with this problem. | |||
02/10/2012 | 77912 | ||
Traveling at a normal rate and speed on a 5-lane highway. vehicle loss power, engine lights activated. after maneuvering the vehicle off the highway, i shut the engine off. no signs of smoke or any leaks from engine (topside or underneath). i attempted to restart the vehicle and upon doing so the engine turned over and ran at a rough idle, clearly not on all 8 cylinders. i shut the engine off again. from that point on it was towed. the chevrolet dealership (after 8 days and 449 miles later) then told me they could not find a problem. when they received the vehicle the original codes had been taken by a precision tune mechanic (nearest facility from location of break down) the dealership then informed me they could not duplicate the problem and was apologetic for any inconvenience. i received a bill for $103.95 and my vehicle which had only a 1/8 of a tank of fuel. after a little research i found gm recall no:08048 consequence: may cause electrical features to malfunction. thanks chevrolet and chevrolet service technicians for taking care of your customers. unfortunately their dealerships and district specialist do not follow their own executive director of safety who is quoted on the gm website we always want to make sure customers can count on the safety and quality of their gm vehicle. says, jeff boyer. |