Recalls

CampaignManufacturerManufacturing dateType# of units affectedDate Owner notified MfgRecall Initiated byManufacturers of recalled vehicles/productsReport Recieved DateRecord Creation DateRegulation Part NumberFMVSS Number
ELECTRICAL SYSTEM
08V441000GENERAL MOTORS CORP.from 04/30/2007 to 11/30/2007V (Vehicle)85773509/12/2008ODIGENERAL MOTORS CORP.08/28/200808/28/2008
Defect SummaryGm is recalling 857,735 my 2006-2008 buick lucerne; cadillac dts; hummer h2; my 2007-2008 cadillac escalade, escalade esv, escalade ext; chevrolet avalanche, silverado, suburban, tahoe; gmc acadia, sierra, yukon, yukon xl, saturn outlook; and my 2008 buick enclave vehicles equipped with a heated wiper washer fluid system. a short circuit on the printed circuit board for the washer fluid heater may overheat the control-circuit ground wire.
Consequence SummaryThis may cause other electrical features to malfunction, create an odor, or cause smoke increasing the risk of a fire.
Corrective SummaryDealers will install a wire harness with an in-line fuse free of charge. the recall began on september 12, 2008. owners may contact buick at 1-866-608-8080; cadillac at 1-800-982-2339 or http://www.cadillac.com; chevrolet at 1-800-630-2438; saturn at 1-800-972-8876 or http://www.saturn.com, gmc at 1-866-996-9436; or hummer at 1-800-732-5493; or through their website at http://www.gmownercenter.com .
NotesGm recall no. 08048. customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov .
10V240000GENERAL MOTORS CORP. V (Vehicle)136507006/11/2010MFRGENERAL MOTORS CORP.06/04/201006/04/2010
Defect SummaryGm is recalling certain model year 2006-2009 buick, lucerne; cadillac dts; hummer h2; model year 2008-2009 buick enclave; cadillac cts; model year 2007-2009 cadillac escalade, escalade esv, escalade ext; chevrolet avalanche, silverado, suburban, tahoe; gmc acadia, sierra, yukon, yukon xl; saturn outlook; and model year 2009 chevrolet traverse vehicles equipped with a heated washer fluid system (hwfs). a recall was implemented in 2008 to add a fuse to the control circuit harness to address the potential consequences of a printed circuit board (pcb) electrical short. however, there have been new reports of thermal incidents on hwfs modules after this improvement was installed. these incidents resulted from a new failure mode attributed to the device's thermal protection feature. the significance varies from minor distortion to considerable melting of the plastic around the hwfs fluid chamber.
Consequence SummaryIt is possible for the heated washer module to ignite and a fire may occur.
Corrective SummaryDealers will permanently disable and remove the heated washer fluid module. an updated page for the owner manual will be provided and inserted in the owner manual to document that the feature has been permanently disabled and removed from the vehicle. the safety recall is expected to begin on or before june 11, 2010. owners may contact buick at 1-866-608-8080, cadillac at 1-866-982-2339, chevrolet at 1-800-630-2438, saturn at 1-800-972-8876, gmc at 1-866-996-9463 and hummer at 1-800-732-5493 or at the owner center at www.gmownercenter.com.
NotesOwners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov .

Bulletins

BulletinBulletin dateReplacement BulletinItem no.SummaryAdded
ELECTRICAL SYSTEM
PIT-518410/01/201210047839Cadillac/chevrolet/gmc: will have inoperative cruise control; inoperative or unwanted activation of radio controls; backlighting flashes, flickers or inoperative due to possible short to ground on steering wheel coil connector x2. models12/10/2012
PIT5074F05/01/201210044242Gm: j-35616-64b terminal test probe and replacement terminal. also included models verano, regal, lacrosse, cts, srx, volt, sonic, malibu, impala, equinox, cruze, avalanche, tahoe suburban, silverado, sierra, yukon, and terrain for model05/24/2012
PIP-496610/01/201110042386Chevrolet/cadillac/gmc: certain vehicles experiencing erratic or inoperative speedometer or anti-lock brake system message or malfunctioning indicator light displaying in driver's information center. *pe12/06/2011
PB-10037A04/01/201110038759Gm: onstar is making incomplete calls without the driver knowing. when have a data connection. *rm06/27/2011
PB-10037A04/01/201110038759Ready06/27/2011
PIT-4730A06/01/201010036550Buick/cadillac/chevrolet/gmc/hummer/pontiac/saturn: additional diagnostic information for u0140 or u0073. vehicle may exhibits some symptom(s) as door locks cycle while driving; intermittent no start; service stabilitrak dic message; spee03/28/2011
PIT-4816A08/01/200910032396Chevrolet/gmc/cadillac: multiple electrical concerns with dtc c0900 - keywords battery c/k cable clock crank cycle door dimming flicker gage gauge gmc hvac inop inoperative instrument intermittent ipc lock no panel power radio stall start03/15/2010
PIT-4665A11/01/200810028264General motors: during normal diagnostics and/or repair verification the abs light, traction control and/or stabilitrak indicators may be on with no dtc's displayed by the ebcm. *pe03/19/2009
ELECTRICAL SYSTEM - BATTERY
SB-07-06-03-002C07/01/201010036524Cadillac/chevrolet/gmc: information on inspecting top post battery cable bolts, clamps and nuts during pre-delivery inspection (pdi). *pe03/28/2011
PIC-487206/01/200910032866Gmc/chevrolet/cadillac: sir mil on with dtc b1325 sym 03. during a low battery/voltage condition the passenger presence system may set a b1325 sym 03 along with other faults that are caused by the low batter/voltage condition. *pe06/04/2010
PIT-4613A06/01/200810026697Gmc: intermittent no crank and/or discharged battery. could be caused by a loose connection at the 175 amp mega fuse located on the passenger side of the cowl. *pe12/03/2008
ELECTRICAL SYSTEM - BATTERY - CABLES
SB-07-06-03-002C07/01/201010036524Cadillac/chevrolet/gmc: information on inspecting top post battery cable bolts, clamps and nuts during pre-delivery inspection (pdi). *pe03/28/2011
PIT-4613A06/01/200810026697Gmc: intermittent no crank and/or discharged battery. could be caused by a loose connection at the 175 amp mega fuse located on the passenger side of the cowl. *pe12/03/2008
ELECTRICAL SYSTEM - FUSES AND CIRCUIT BREAKERS
PI0639A03/01/201210043887Gm: the service stabilitrak message being displayed in dic. the stabilitrak indicator light may also be on. *js05/01/2012
PIT-4613A06/01/200810026697Gmc: intermittent no crank and/or discharged battery. could be caused by a loose connection at the 175 amp mega fuse located on the passenger side of the cowl. *pe12/03/2008
ELECTRICAL SYSTEM - SOFTWARE
PIT-4665A11/01/200810028264General motors: during normal diagnostics and/or repair verification the abs light, traction control and/or stabilitrak indicators may be on with no dtc's displayed by the ebcm. *pe03/19/2009
ELECTRICAL SYSTEM - WIRING
PIT-4730A06/01/201010036550Buick/cadillac/chevrolet/gmc/hummer/pontiac/saturn: additional diagnostic information for u0140 or u0073. vehicle may exhibits some symptom(s) as door locks cycle while driving; intermittent no start; service stabilitrak dic message; spee03/28/2011

Investigations

NHTSA IDManufacturerDate openDate closeSubjectRecall campaign
ELECTRICAL SYSTEM
EA08010GENERAL MOTORS CORP.06/12/200809/08/2008NON-CRASH ENGINE COMPARTMENT FIRES08V441000
 In a letter dated august 27, 2008, general motors corp. (gm) notified nhtsa that it will conduct a safety recall (nhtsa recall number 08v-441) to address a safety relateddefect that can result in engine compartment fire in approximately 850,000 vehicles equipped with a heated windshield washer fluid option.the subject vehicles of this investigation comprise over three-quarters of the recall population. according to gm, a short circuit on the printed circuit board for the windshield washer fluid heater module may overheat the control-circuit ground wire. this may cause other electrical features to malfunction, create an odor or cause smoke and in rare cases it may cause a fire.as a remedy, gm dealers will install a wire harness with an in-line fuse. in addition to the subject vehicles, several other gm models with the heated windshield washer fluid option are included in recall 08v-441: my 2006-2008 buick lucerne (manufactured august 2005 through november 2007); my 2008 buick enclave (manufactured february 2007 through april 2007); my 2006-2008 cadillac dts (manufactured may 2007 through november 2007); my 2007-2008 saturn outlook (manufactured august 2006 through april 2007); and my 2007-2008 gmc acadia (manufactured august 2006 through april 2007) vehicles.gm is instructing owners to take their vehicle to a dealer for service if they experience symptoms of windshield washer heater module short circuits. gm's recall resolves the safety defect concerns pursued by this investigation.this engineering analysis is closed.
ELECTRICAL SYSTEM - BATTERY
EA08010GENERAL MOTORS CORP.06/12/200809/08/2008NON-CRASH ENGINE COMPARTMENT FIRES08V441000
 In a letter dated august 27, 2008, general motors corp. (gm) notified nhtsa that it will conduct a safety recall (nhtsa recall number 08v-441) to address a safety relateddefect that can result in engine compartment fire in approximately 850,000 vehicles equipped with a heated windshield washer fluid option.the subject vehicles of this investigation comprise over three-quarters of the recall population. according to gm, a short circuit on the printed circuit board for the windshield washer fluid heater module may overheat the control-circuit ground wire. this may cause other electrical features to malfunction, create an odor or cause smoke and in rare cases it may cause a fire.as a remedy, gm dealers will install a wire harness with an in-line fuse. in addition to the subject vehicles, several other gm models with the heated windshield washer fluid option are included in recall 08v-441: my 2006-2008 buick lucerne (manufactured august 2005 through november 2007); my 2008 buick enclave (manufactured february 2007 through april 2007); my 2006-2008 cadillac dts (manufactured may 2007 through november 2007); my 2007-2008 saturn outlook (manufactured august 2006 through april 2007); and my 2007-2008 gmc acadia (manufactured august 2006 through april 2007) vehicles.gm is instructing owners to take their vehicle to a dealer for service if they experience symptoms of windshield washer heater module short circuits. gm's recall resolves the safety defect concerns pursued by this investigation.this engineering analysis is closed.
ELECTRICAL SYSTEM - FUSES AND CIRCUIT BREAKERS
EA08010GENERAL MOTORS CORP.06/12/200809/08/2008NON-CRASH ENGINE COMPARTMENT FIRES08V441000
 In a letter dated august 27, 2008, general motors corp. (gm) notified nhtsa that it will conduct a safety recall (nhtsa recall number 08v-441) to address a safety relateddefect that can result in engine compartment fire in approximately 850,000 vehicles equipped with a heated windshield washer fluid option.the subject vehicles of this investigation comprise over three-quarters of the recall population. according to gm, a short circuit on the printed circuit board for the windshield washer fluid heater module may overheat the control-circuit ground wire. this may cause other electrical features to malfunction, create an odor or cause smoke and in rare cases it may cause a fire.as a remedy, gm dealers will install a wire harness with an in-line fuse. in addition to the subject vehicles, several other gm models with the heated windshield washer fluid option are included in recall 08v-441: my 2006-2008 buick lucerne (manufactured august 2005 through november 2007); my 2008 buick enclave (manufactured february 2007 through april 2007); my 2006-2008 cadillac dts (manufactured may 2007 through november 2007); my 2007-2008 saturn outlook (manufactured august 2006 through april 2007); and my 2007-2008 gmc acadia (manufactured august 2006 through april 2007) vehicles.gm is instructing owners to take their vehicle to a dealer for service if they experience symptoms of windshield washer heater module short circuits. gm's recall resolves the safety defect concerns pursued by this investigation.this engineering analysis is closed.
ELECTRICAL SYSTEM - WIRING
EA08010GENERAL MOTORS CORP.06/12/200809/08/2008NON-CRASH ENGINE COMPARTMENT FIRES08V441000
 In a letter dated august 27, 2008, general motors corp. (gm) notified nhtsa that it will conduct a safety recall (nhtsa recall number 08v-441) to address a safety relateddefect that can result in engine compartment fire in approximately 850,000 vehicles equipped with a heated windshield washer fluid option.the subject vehicles of this investigation comprise over three-quarters of the recall population. according to gm, a short circuit on the printed circuit board for the windshield washer fluid heater module may overheat the control-circuit ground wire. this may cause other electrical features to malfunction, create an odor or cause smoke and in rare cases it may cause a fire.as a remedy, gm dealers will install a wire harness with an in-line fuse. in addition to the subject vehicles, several other gm models with the heated windshield washer fluid option are included in recall 08v-441: my 2006-2008 buick lucerne (manufactured august 2005 through november 2007); my 2008 buick enclave (manufactured february 2007 through april 2007); my 2006-2008 cadillac dts (manufactured may 2007 through november 2007); my 2007-2008 saturn outlook (manufactured august 2006 through april 2007); and my 2007-2008 gmc acadia (manufactured august 2006 through april 2007) vehicles.gm is instructing owners to take their vehicle to a dealer for service if they experience symptoms of windshield washer heater module short circuits. gm's recall resolves the safety defect concerns pursued by this investigation.this engineering analysis is closed.
ELECTRICAL SYSTEM - WIRING - FRONT UNDERHOOD
EA08010GENERAL MOTORS CORP.06/12/200809/08/2008NON-CRASH ENGINE COMPARTMENT FIRES08V441000
 In a letter dated august 27, 2008, general motors corp. (gm) notified nhtsa that it will conduct a safety recall (nhtsa recall number 08v-441) to address a safety relateddefect that can result in engine compartment fire in approximately 850,000 vehicles equipped with a heated windshield washer fluid option.the subject vehicles of this investigation comprise over three-quarters of the recall population. according to gm, a short circuit on the printed circuit board for the windshield washer fluid heater module may overheat the control-circuit ground wire. this may cause other electrical features to malfunction, create an odor or cause smoke and in rare cases it may cause a fire.as a remedy, gm dealers will install a wire harness with an in-line fuse. in addition to the subject vehicles, several other gm models with the heated windshield washer fluid option are included in recall 08v-441: my 2006-2008 buick lucerne (manufactured august 2005 through november 2007); my 2008 buick enclave (manufactured february 2007 through april 2007); my 2006-2008 cadillac dts (manufactured may 2007 through november 2007); my 2007-2008 saturn outlook (manufactured august 2006 through april 2007); and my 2007-2008 gmc acadia (manufactured august 2006 through april 2007) vehicles.gm is instructing owners to take their vehicle to a dealer for service if they experience symptoms of windshield washer heater module short circuits. gm's recall resolves the safety defect concerns pursued by this investigation.this engineering analysis is closed.

Consumer Complaints

Fail datemilesoccurencesPurchase date
ELECTRICAL SYSTEM
01/08/20131
 It is well known that chevrolet/gm has a major quality problem with powerdoor locks that has been going on for many years. one only need to google chevy door locks to get an idea of the magnitude of the problem. (see http://townhall-talk.edmunds.com/direct/view/.f206d4b as an example). as a frequent transporter of small children it is hard for me to understand why the nhtsa does not consider this a major safety issue. doors lock or unlock without warning leaving small children in the back of these vehicles either exposed to risks of inadvertent opening doors or being locked into vehicles at the time of potential accidents where there is no easy or safe way to open the doors from inside or outside of the vehicle. these vehicles are also subject to increased risks from ranging from car theft to hijackers to simple burglary as you never know whether a door is locked or not unless you go around and try each one from the outside of the vehicle. general motors has consistently refused to address this or improve the quality of the product and will not do so until the nhtsa takes a public stand on the continued safety risks that these defective doorlocks present to all who ride in these vehicles. *tr
01/08/2013
 It is well known that chevorlet/gm has a major quality problem with powerdoor locks that has been going on for many years. one only need to google chevy door locks to get an idea of the magnitude of the problem. (see http://townhall-talk.edmunds.com/direct/view/.f206d4b as an example). as a frequent transporter of small childern it is hard for me to understand why the nhsa does not consider this a major safety issue. doors lock or unlock without warning leaving small children in the back of these vehicles either exposed to risks of inadvertent opening doors or being locked into vehicles at the time of potential accidents where there is no easy or safe way to open the doors from inside or outside of the vehicle. these vehicles are also subject to increased risks from ranging from car theft to hijackerers to simple burgulry as you never know wheter a door is locked or not unless you go around and try each one from the outside of the vehicle. general motors has consistently refused to address this or improve the quality of the product and will not do so until the nhsa takes a public stand on the continued safety risks that these defective doorlocks present to all who ride in these vehicles.
04/01/201132000
 Tl- the contact owns a 2008 chevrolet avalanche. the contact stated the rear driver's side automatic door lock failed to function. the vehicle was taken to an authorized dealer and repaired. seven months later, the front driver's side automatic door lock failed to operate when engaging the control mechanism. in addition, the liftgate would not lock with the key fob. the vehicle was not repaired for the most recent failures. the manufacturer was made aware of the malfunction. the approximate failure mileage was 32,000. rvk
10/01/201112500
 Electronic door locks have failed on three of the 4 doors on this car. the neither the key fob or the door mounted locking switch will toggle them between locked and unlocked position. you can hear the actuator trying to work but their is something wrong with the linkage preventing this. this is a major in convenience, as well as a potential safety hazard.
02/15/201050001
 2008 chevrolet avalanche. windshield washer and wiper occasionally comes on and washes the windshield 3 times. there is no way to stop it. the wiper is completely off during the 3 wash cycles. may go a month between incidents. the consumer has not received a response regarding his complaint. updated 03/22/10

Some parts © 2024 Advameg, Inc.
Based on public records. Inadvertent errors are possible.
This web site is not associated with, endorsed by, or sponsored by and has no official or unofficial affiliation with the vehicle's manufacturer.