Bulletins
| Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
|---|---|---|---|---|---|
| POWER TRAIN - AUTOMATIC TRANSMISSION | |||||
| 070730007 | 04/01/2007 | 10022265 | Automatic transaxle/transmission shift lever may not shift out of park (replace brake transaxle shift interlock (btsi) solenoid). *kb | 07/24/2007 | |
| 01132005 | 01/13/2005 | 10013577 | Automatic transmission operating characteristic for the 2004 through 2005 aveo. *tt | 04/21/2005 | |
| 3297 | 10013558 | Cold shift characteristics. *eh | 04/21/2005 | ||
Consumer Complaints
| Fail date | miles | occurences | Purchase date |
|---|---|---|---|
| POWER TRAIN | |||
| 07/17/2007 | 74000 | 1 | |
| The shift gear does not work my back lights are all out i did not know this my check engine light stay on i have had new sensors put in one week and the next week check engine light comes back on what is wrong with this car why wont they recall it i have to drive this car clock wont keep right time gear shift light goes on an doff and my low beam and have had this car right out of the show room only 13 miles on it when i got it and know it is all mess up i don't know what to do about it! *tr | |||
| 04/02/2012 | 54000 | ||
| 2005 aveo (bought new) with timing belt failure destroying engine. had this happened on the interstate at 70 miles an hour it could have been fatal. from my research gmc has known about this issue since at least 2006 and yet have not assisted consumers to correct this nor recalled their car. i have read reports on almost all years of aveo having this problem well before the 60000 recommended timing belt replacement. two different mechanics confirmed timing belt failure. all i get from gmc is the run around. upset over money but more concerned about these cars being on the highways and creating some horrible accident when the engine suddenly stops working and controlling the car is difficult or impossible. planning to get rid of mine, can't afford the thousands of dollars to fix nor do i trust this car. | |||
| 04/01/2011 | 93000 | ||
| Tl- the contact owns a 2005 chevrolet aveo. the contact stated that the vehicle would hesitate when changing gears and in addition, the heater was inoperable. the contact would also smell smoke coming from the vents sporadically. the dealer and a local mechanic were unable to diagnose the failure. the manufacturer was not contacted. the failure mileage was 93,000 and the current mileage was 105,000. the vin was unavailable. kmj | |||
| 04/01/2011 | 93000 | ||
| Tl- the contact owns a 2005 chevrolet aveo. the contact stated that the vehicle would hesitate while changing gears. the heater was inoperative. the contact would also smell smoke coming from the vents. the dealer and local mechanic were unable to diagnose the failure. the manufacturer was not contacted. the failure mileage was 93,000 and the current mileage was 105,000. the vin was unavailable. nw | |||
| 06/08/2010 | |||
| I have a 2005 chevrolet aveo that has given me numerous problems. a little over a year ago i noticed i could not shift my car out of park i have to use a screwdriver to shift my gear out of park. soon after i noticed my brake lights stopped working. i brought a box of fuses but this only fixed the problem for less than a week. every time i put a new fuse in the brake lights went back out in a day or two. one day while i was on the freeway my car just suddenly stopped without any warning. i took the car to the dealer it was still under the power train warranty. it was a electrical problem causing all of these problems and cost over $2,000 to fix. a year later the problems started again i can't move my gear without using a screw driver, my brake lights and headlights are out. if i slam the hood of my car one headlight will come on which shows that something is wrong with the wiring. the engine light and hold mode light flashes constantly. i feel this car is dangerous because there are no brake lights which can easily cause a accident. i was pulled over by the police because of no brake lights a $125 ticket. i am in a bind because i really need my car for work but i do not have $2,000 (no longer under warranty) to fix this car only to have the same problem happen again months from now. also, i have noticed a strong gas smell from the car that has me concerned. i have read so many internet post from other people complaining about the same problems. this car seriously need to be recalled because it is endangering people lives. | |||
| 08/27/2009 | 85000 | 1 | |
| Tl* the contact owns a 2005 chevrolet aveo. while driving the vehicles engine was became hot. the vehicle was taken to a local repair facility for inspection. the technician replaced the main computer. the current and failure mileages were 85000. updated 01/05/10. *lj the consumer stated the vehicle was manufactured with a plastic temperature housing which eventually melted due to extreme heat in texas, which caused the vehicle to get hot and the engine to burn up. the engine and computer were replaced. after 2 months of driving, the transmission failed. updated 01/07/10.*jb | |||
| 11/15/2009 | 60000 | 1 | |
| On sunday evening i attempted to put my 2005 chevy aveo into drive after putting my key in the ignition and starting the vehicle but the shifter was stuck in park. the aveo has a feature called the shift lock release which is a hole on the shifter console you can put a screwdriver or other tool into to release the shifter into drive in these situations. i was able to put the car in drive and make it home safely after using the shift lock release but when i got home i realized my key was stuck in the ignition. my car sat unlocked overnight because i could not get the key out. on monday i called my local gm dealership in salem, oh and they stated they would not be able to take a look at my car until tuesday. i spent the entire day researching online and found many customers who have experienced this same issue with the aveo. later on in the evening i realized my brake lights weren't working but there was not a blown fuse or switch. i tested both of the brake lights and they were still good. on tuesday i took my car to the dealership and it cost me $80 for the mechanic to tell me the shifter is bad, which i already knew. they also stated it would be $300 to repair the shifter. i strongly believe the failure of the brake lights, the shifter and the ignition are tied together and should be replaced by gm at no cost to me. my vehicle is sitting unattended with the key in it, which runs the risk of it being stolen. not to mention when i am driving i have no brake lights to alert the other drivers i am slowing down or stopping which could cause an accident. each time i attempt to put the car in drive i have to insert something into the shift lock release to shift the car and this has been going on since sunday. *tr | |||
| 05/15/2007 | 30000 | 1 | |
| I traded in a 2004 p.t.cruiser to get a 2005 chevy aveo at the time it had 21000 miles when i got it. my warranty was good till 36000. i had lots of issues with a noise that still to this day has not been corrected even after three attempts under my car by the chevy service dept. i then had a computer recall or something that had to be replaced i also had a gas cap that malfunctioned and a clock that had to be replaced. those are the non life threatening issues. i had an incident inside of the original warranty where the car threw parts out of the engine. it was the serpentine belt and the bracket that was metal that it was mounted on broke out of the engine as i was driving it. i am currently at 55000 and i have the power train on it. in the last month i have had the car in my possession 1 week the rest it's been in the service dept. a month ago the plastic and yes that's plastic housing for the thermostat blew apart on the interstate causing us to have to dial 911 to get help because we were trapped. two weeks ago it spit out the timing belt and the valves got bent and the valve cover was damaged. we don't know what particles ended up in the engine for now. i have contacted chevrolet on all these issues and i asked them before my warranty went out and right after the first incident to give me back the money for the car. they called me today and said i didn't have a case because the warranty was out i reminded them i had been asking since before at the first incident with the serpentine and bracket and they said sorry the warranty is out. i reminded them i have pictures of those parts and can prove it but that still wasn't good enough! i spoke to hannah a district specialist today and that is who lied to herself and said these occurrences were after the warranty. i have proof can you please help before my family dies and then we have dependents who will own the very company the gov't is trying to bail out. i need you to intervene before i go to court over this. *tr | |||
| 03/15/2006 | 1 | ||
| 2005 aveo 3rd time with this problem it will not come out of park it sticks .2 times the dealer told me it was the shifter. 3rd time they told me it was a bad connection to the brakes. know sense they stated it's fixed when you press the brake the shift clicks loud also you don't have to push the shifter down it just slides up and down.. not safe i need a good car that i feel safe in. *tr | |||
| POWER TRAIN - AUTOMATIC TRANSMISSION | |||
| 07/07/2009 | 1 | ||
| 2005 chevy aveo will not shift out of park. the vehicle has been in the shop several times and the problem is still occurring four years later. *tr | |||
| 05/14/2009 | 98000 | ||
| Tl*the contact owns a 2005 chevrolet aveo. the contact stated that the transmission locked up on his vehicle. while making a right turn, he stated that the front half of his vehicle stopped, but the rear continued to move. the speed was unknown. the vehicle rolled over three times down an embankment and was destroyed. the vehicle was taken to the dealer on three occasions and they stated that the computer control transmission system failed. the vehicle downshifts and locks into gear by itself. the failure began after a recall was issued by the manufacturer. the air bags failed to deploy. the contact was the only occupant in the vehicle and was not injured. a police report was filed. gm does not accept responsibility for the failure. the failure mileage was 98,000. | |||
| 09/21/2005 | 5 | 09/21/2005 | |
| Dt: went to enterprise rent-a-car, and rented a 2005 chevrolet aveo. vehicle was parked at a store. the consumer tried to back out of the parking space, and the car would not go into reverse. it seemed to just lock. the consumer had to use her strength to push it into reverse. then, took vehicle home, parked it, and tried it later. it did the same thing. the consumer refused to drive it. *ak *nm | |||
| POWER TRAIN - MANUAL TRANSMISSION | |||
| 10/09/2008 | 57000 | 1 | |
| I have a 2005 chevy aveo that has repeat problems with the clutch getting hot and seizing the transmission, i had this fixed one in june of this year and today the clutch is doing the same thing again, this time i almost got in 2 accidents, couldn't shift right and was unsafe to drive. *tr | |||
| 06/09/2008 | 56000 | 1 | |
| My clutch let go in my car, i was told by the mechanic that the clutch got too hot and cracked the plate and the flywheel, it was not supposed to do that, the car was having trouble shifting and i could of been hurt. *tr | |||
| 05/27/2008 | 48000 | 1 | |
| 2005 chevy aveo clutch defect. *tr | |||