Bulletins
Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
---|---|---|---|---|---|
POWER TRAIN | |||||
00773 | 10017190 | 4l60e, 4l65e replacement valve body gaskets does not seem to fit. *tt | 10/27/2005 | ||
3002 | 3002D | 10008802 | 4l60e/4l65e intermittent neutral condition while accelerating from a stop or while driving. *tt 1999-2006 gm cars, light duty trucks and utilities. *tt | 08/23/2004 | |
02086 | 01/01/2004 | 10007782 | 4l60e, 4l65e intermittent neutral from a stop or steady speed. *tt | 07/12/2004 | |
990730016A | 10/01/2002 | 990730016B | 10007838 | Diagnostic information for intermittent transmission downshift, slip, busy/cycling tcc or noisy cooling fan. *tt | 07/12/2004 |
01599 | 01/01/2004 | 10007237 | 4l60e, 4l65e forward and low reverse waved steel clutch plate appearance change. *tt | 06/04/2004 | |
00822B | 01/01/2004 | 00822C | 10005474 | No 2nd, no 4th and no reverse. to include 2004 light duty automobiles and trucks equipped with 4l60e or 4l65e automatic transmission. *tt | 02/27/2004 |
020421005A | 02/01/2003 | 020421005 | 10001110 | Slips in 4-wheel drive, noise, vibration, leaks, hot odor. *tt | 04/15/2003 |
020421005 | 06/01/2002 | 634905 | Some vehicles will not move when 4-wheel drive is requested, noise, shudder, poor performance, transmission / transfer case slips, transmission will not upshift, slips in 4-wheel drive. *tt | 10/10/2002 | |
POWER TRAIN - AUTOMATIC TRANSMISSION | |||||
030730056 | 11/01/2003 | 10005566 | 4l60-e automatic transmission oil pump first and second design identification. *tt | 03/04/2004 | |
00702 | 01/01/2004 | 00702B | 10005476 | Slip condition in 2nd, 3rd or 4th damaged 2-4 band 3-4 clutch on the 4l60e/4l65e automatic transmission. *tt *mj | 03/01/2004 |
010730038B | 10/01/2005 | 010730038C | 10005162 | The service engine soon lamp is illuminated, no 3rd and 4th gear, the transmission does not shift correctly, the transmission feels like it shifts to neutral or a loss of drive occurs. *tt | 02/09/2004 |
010730038 | 12/01/2001 | 010730038D | 628934 | Some customers may comment that the service engine soon lamp is illuminated, no 3rd and 4th gear, the transmission does not shift correctly, the transmission feels like it shifts to neutral or a loss of drive occurs. *tt | 03/25/2002 |
010730043 | 12/01/2001 | 628815 | Subject regarding diagnostic tips for slipping or missing second, third and/or fourth gear. *tt | 03/21/2002 | |
POWER TRAIN - AUTOMATIC TRANSMISSION - COOLING UNIT AND LINES | |||||
PIT-4722 | 10/01/2008 | 10026804 | Gmc: fluid leak from transmission oil cooler lines due to corrosion. all 2000-2006 light duty trucks equipped with the light duty automatic transmission. *pe | 12/18/2008 | |
POWER TRAIN - AUTOMATIC TRANSMISSION - LEVER AND LINKAGE - COLUMN SHIFT | |||||
020730024A | 08/01/2005 | 020730024B | 634999 | Diagnosis of cracked or broken transmission case. *tt 2006 and prior cars and light duty trucks. *tt | 10/11/2002 |
POWER TRAIN - DRIVELINE | |||||
3300 | 3300A | 10013572 | 4wd models with noise, vibration on dry pavement. *eh | 04/21/2005 | |
POWER TRAIN - MANUAL TRANSMISSION | |||||
01895 | 01/01/2004 | 10006802 | 5sp manual shifter pops out of 2nd, 4th, or reverse gears. *tt | 05/14/2004 | |
010103 | 01/01/2003 | 10001295 | Manual transmission shifter pops out of 2nd, 4th or reverse gears. *tt | 04/28/2003 | |
010730036 | 11/01/2001 | 627912 | Service engine soon lamp illuminated, incorrect transmission shifts, poor performance of engine, transmission slipping. *yh | 02/26/2002 | |
POWER TRAIN - TRANSFER CASE (4-WHEEL DRIVE) | |||||
3424 | 3424A | 10017299 | Electronic transfer case unable to complete shift. *tt | 11/02/2005 | |
3349 | 10014809 | 4wd inoperative and diagnostic trouble code (dtc) u1026 atc fuse open. *tt | 05/10/2005 | ||
3012B | 3012A | 10008806 | The nvg 136 all wheel drive (awd) transfer case and the 236 and 246 nvg selectable transfer cases operating in the auto mode may exhibit a condition of a vibration/shudder during low speed turns such as a parking lot maneuver, up to approxi | 08/23/2004 |
Consumer Complaints
Fail date | miles | occurences | Purchase date |
---|---|---|---|
POWER TRAIN | |||
05/12/2001 | |||
Does not go into drive from park. instead goes into neutral. does not go into correct gear. | |||
POWER TRAIN - AUTOMATIC TRANSMISSION | |||
11/05/2006 | 125000 | 1 | |
My 2002 chevy blazer will no longer shift into 4-wheel drive. it has been this way for over a year now, and chevy won't even acknowledge my communications about it. *tr | |||
01/08/2006 | 40000 | 5 | 07/05/2004 |
While driving, engine cut out. unable to drive except in third gear despite being automatic transmission. otherwise, engine cuts out. *jb | |||
07/16/2005 | 69000 | 1 | 07/16/2002 |
Drove from ohio to florida, 1040 miles. 250 miles into the trip, my console became extremely hot. the side of the console touches the drivers seat and it was making my seat very hot. the items inside my console melted, the hand wash burnt my hand when i took it out to use it. now the console is getting hot only after 50 miles and sometimes less than that. also, the cd player gets hot. the cd's occasionally become so hot that i drop them when they get spit out by the player by itself. i have no idea what the problem is and i am worried my blazer may catch fire or blow up. also, at times when i start up again from a red light, the transmission sounds so loud like it is working very hard to get moving. i know these things are not normal. am i safe driving my blazer? i bought it brand new in 2002. now i am afraid of it. *jb | |||
07/12/2005 | 51000 | 1 | |
No warning signs. just put my 2002 blazer in reverse, heard a loud pop. wasn't sure what happened, so i got out on the road and couldn't accelerate fast enough up a hill and almost got rearended by a car going 60-65 mph. pulled over and finally figured out that it wouldn't shift out of 2nd and i had no reverse. called local chevy dealer and he immediately knew what had broken. (something called the sun shell casing or sun gear, i think). i only have 50k miles on that car and now have been told they wont just replace the part, they have to replace the entire tranny. | |||
09/28/2004 | 2 | 08/24/2002 | |
Immediately following purchase of a 2002 chevrolet blazer in august 2002, i noticed a loud roaring noise coming from under the hood which occured mostly upon startup when engine was cold and put into drive gear. this noise was also intermittently noticed after coming to a stop and then accelerating. by the time i drove it back to the dealership, it was not doing it. since purchase, 2 replacement batteries have been installed. service dept at dealership said alternator was draining the battery and replaced the alternator. car is still doing this but dealer is unable to duplicate and saying loud roar is most likely normal. now several acquaintances have said they had the exact same problem with their blazers even though they were a different year model. once the warranty runs out, this problem could add up to quite an expense.*ak | |||
11/18/2003 | 17900 | 3 | 08/30/2003 |
Consumer started the vehicle and pressed the gas pedal but the vehicle did not move. the consumer applied pressure to the accelerator, and it took little while for the vehicle to start moving. the dealer inspected the vehicle three times and could not resolve the problem.*ak *cb the consumer stated the transmission made some noises, the dealer discovered some parts of the transmission were damaged, however days later the vehicle went back to not accelerating and the engine racing. the consumer was told that the manufacturer would extended the warranty on the transmission. the brake light was inoperative there was a clicking noise in the drivers seat.*jb | |||
10/02/2003 | 1 | ||
The maximum speed while driving this vehicle is 40 mph, also vehicle wont engage in reverse. dealer not notified yet. *ak | |||
05/02/2002 | 200 | 2 | 04/01/2002 |
Not long after i purchased my 2002 blazer, i started noticing that at random times the motor would start racing when i started the engine. it ran very loud for a period of time and then would finally slow down. while driving the vehicle this would also happen. the rpms rapidly increase when accelerating, and it would make a loud roaring noise, but the vehicle doesn't go any faster. i took it in to the shop and was told this was normal, that it was the clutch fan. it is extremely hard to believe that this is normal for a new vehicle. i have had the blazer since april of 2002 and it continues to do this and has sometimes put me in very unsafe positions. this problem seems to me to be more of a transmission problem than a fan. i have also had problems with the fuel gauge. it will show empty when it has plenty of gas. it has showed low on fuel, and then when i stop to get fuel, it will not take any gas. but then i have run out of gas right after trying to put some in the tank. the third problem is the left front door hinge. the pin continuously works out of position and it feels like the door is about to fall off and it doesn't close properly and i have to have the pin knocked back into position. also, at the time i purchased the vehicle, it had a cassette player and the dealership agreed to install a cd player as part of the purchase agreement. the vehicle also had optional controls on the steering wheel. when they installed the cd player, the controls on the steering wheel no longer worked. when i asked them about this, they just said that this cd player could not be controlled from the steering wheel contols and left it at that. i think they should have installed one that could have functioned the same as the factory installed equipment. | |||
07/31/2003 | 8 | ||
While driving the vehicle, automatic transmission doesn't shift properly from the first to second gear. dealer has inspected eight times and wasn't available to duplicate or correct the problem. please provide any further information. *ph | |||
06/15/2003 | 1 | ||
Consumer states that the transmission slips when slowing down. dealer notified.*ak | |||
06/29/2002 | 120 | 110 | 06/26/2002 |
I have a 2002 blazer. since i have owned the vehicle it has performed unsatisfactorily. the engine randomly makes roaring noise, the rpms rise and there is concomitant loss of power. i am told this is normal and that it is related to the fan clutch motor and a sensor that works erratically. the fan clutch has been replaced once and the vehicle has been in the shop several times. i have been involved in several near misses as the vehicle does not perform in a predictable manner. chevrolet refuses to take any responsibility for this issue though i was offered $2000.00 toward the purchase/lease of another vehicle. in reviewing this website i note that there are several other complaints about this problem and in all cases gm/chevrolet has refused to accept any responsibility. is there nothing that can be done from a regulatory perspective or do we have to wait for another corvair/pinto debacle. *nlm | |||
04/24/2003 | 1 | ||
Fluid leaked from the vehicle, which caused the transmission to jerk when the gears were changed. *jb | |||
04/24/2003 | 6 | 12/29/2001 | |
The engine stalled without warning, which caused the consumer to pull over abruptly. *jb. the dealer was unable to determine the cause of the problem. the consumer stated at one point transmission fluid leaked onto the ground. *jb | |||
03/10/2003 | 1 | ||
The automatic transmission failed to shift properly.*jb | |||
03/01/2002 | |||
I had puchased this vehicle new from an authorized dealer. within a few months of purchase i had noticed that the gas mileage wasn't close to the estimated mpg which was 15 city and 17 highway. i was getting anywhere from 9.4 mpg to 10.5 mpg with average driving. i had also noticed the automatic transmission slipping. with these two major problems i had brought the vehicle back to the dealer from which i purchased the vehicle and reported the problems. they where no help. they insisted that it was the way that i was driving rather than the vehcile having defective parts. i am very unsatisfied with the product and the gm company. dt | |||
08/22/2002 | 08/01/2002 | ||
Power train-transmission is loud and almost is slipping when going into 1st and 2nd gear of automatic transmission. dealer says others have same complaint with no fix available. fan clutch engages due to faulty signal from sensor. engine sounds very loud when it engages. fan clutch replaced once already before taking delivery of car. another dealer states that this problem has also been present since 1999 for this car with no fix available. there is a tsb on the transmission problem with cause unknown and no available fix. seems that since others are having this problem manufacturer should be held responsible.*ak | |||
08/26/2001 | 3 | 07/01/2001 | |
Ever since i bought this vehicle i have had nothing but trouble with it. since i have bought it in july it has been in the shop for approx. 10 times. the first day i brought it home it would not go into reverse. needless to say it already has a new transmission. i have also had problems with the rear middle seat belt locking up and making it impossible to wear. i have brougt this problem up to the dealer several times and they have even replaced all of the seat belts, but it still persists. i have now been told that it is because of infant seats, however how can this vehicle be suited for five passengers when in reality it can only hold four. another problem i have had with this vehicle is the heater blower failed to work. i brought my vehicle back to the shop and they replaced it. i have also had problems with the 4wd system switching between 2hi. the dealer has installed a new switch as well, so the problem has been solved. one of my newest concerns is randomly when i start the vehicle in the morning the engine revs up really loud. the loud noise gets even louder when you accelerate the vehicle. when bringing in this problem to the shop they said that it is the fan clutch and that it is normal. i find this hard to believe. people that hear the noise are in disbelief that a new vehicle can make such a noise. i also am having a concern with squeaky breaks in the front end. the shop states that semimetallic brakes will make some noise at times. in all of the cars i have owned i would have never thought that a 2002 would have squeaky brakes and that it would be normal and unable to fix. i am very concerned about this vehicle and i question how reliable and safe we are driving it. gm will not help me in replacing this vehicle so i guess my next step is the attorney general. *ak | |||
06/01/2001 | 5 | 03/04/2001 | |
Transmission is defective, it takes more clicks to get to drive then it would in any other vehicle. *ak *slc | |||
POWER TRAIN - AUTOMATIC TRANSMISSION - COOLING UNIT AND LINES | |||
02/20/2007 | 69048 | 1 | 10/30/2006 |
Tl* - the contact owns a 2002 chevrolet trail blazer lp. the contact stated that transmission coolant lines design was flawed. the the coolant lines were close to the exhaust pipe manifold, and they heated up and cause damage to the coolant lines. the contact stated that this was very costly, and should be a safety recall. the current and failure mileage were both 69048.*ak | |||
10/01/2001 | |||
The first problem is that our car was not fully painted, you can see that primer in large areas all over that body of the car. second problem is the back cargo door will not lock. third problem is the electronic sets on driver and on passenger side will not move and are stuck in the same position, also seat warmers do not work. the fifth problem is that the transmission is leaking fluid. | |||
POWER TRAIN - AUTOMATIC TRANSMISSION - GEAR POSITION INDICATION (PRNDL) | |||
09/10/2003 | 8 | 10/15/2001 | |
Consumer was having a problem with vehicle jumping out of gear into neutral while driving. this happened about 8 times. the consumer took the vehicle to the repair shop 3 times and was told by a chevrolet representative that they had no answer for this behavior nor a solution. therefore, they did not know how to repair it. *ak *scc *jb | |||
POWER TRAIN - AUTOMATIC TRANSMISSION - LEVER AND LINKAGE - COLUMN SHIFT | |||
12/01/2001 | 2 | 09/01/2001 | |
On this occasion we had a heavy snow that day and as i was driving on the road i switched to 4 wheel drive. as i turned the corner, thinking i was in 4 wheel drive my car went out of control when it hit ice and i hit boulders and landed on a tree. earlier when we purchased the car we noticed a light kept coming on that said 4wd. we called to have it looked at but were told it was nothing to worry about. my husband called gm and complained about the malfunction. after my car was taken to the dealership gm reps came out to see it and agreed there had been a malfunction in the 4wd system. they claim to have fixed it but my car has never been the same. i hurt my neck but since i don't have health insurance never did go to the doctor. they reimbursed us $600 for the repair. my problem is worrying that there are other vehicles out there that could have the same problem. if mine did why can't there be others? next time someone could get killed. i was lucky. gm was hard to deal with and i will never buy one of their products again. i hate my car but can't afford to get out of it. i would have liked to sue them for my injuries but they really will only listen to you if your are dead! please check into this because gm won't call you and tell you of the problem with the 4wd. you need to get the exact details of the accident and why this failed. thank you. *ak | |||
Four-wheel drive is inoperable due to a malfunction with in transfer case control module.*ak | |||
12/10/2001 | 1 | 07/01/2001 | |
On 12-10 i reported lights on transfer case display flickered. advised needed updated transfer case switch. was advised ok to drive vehicle. on january 7 dialed selector to 4wd because of snowy weather to get out of my driveway. started up driveway--fishtailed. 4 wd would not engage. dealer advised, returned vehicle to dealer evening of january 7. advised today, new part unavailable. transferring from demo model in stock. how can a situation like this exist? especially with no notification or recall?*ak | |||
POWER TRAIN - AXLE ASSEMBLY | |||
09/07/2004 | 1 | ||
Real axle failure, front wheel bearing bad. *bf *tt | |||
06/27/2001 | 3 | 06/01/2001 | |
No summary listed for above vehicle. *ak | |||
POWER TRAIN - AXLE HUBS | |||
05/13/2005 | 33760 | 1 | 12/23/2001 |
Front wheel hub assembly went bad | |||
01/17/2005 | 0 | 01/23/2002 | |
I have been hearing a noise in the front end for a few weeks and i had the tires replaced but it did not cure the problem. i have found out that i need a hub assembly which is $500 for the part alone and i need an idler arm which i have taken my vehicle in faithfully for maintenance to the dealership and they never told my about it and just said to watch the tires. obviously with the wear on my tires (outside wear) they should of have known. i have been in twice for the front end replacement of bushings and many other things and i also have heard from many people having the same problem as i have with the hub assembly. not everyone has $500 to just fork out. please help. *nm | |||
POWER TRAIN - DRIVELINE - DRIVESHAFT | |||
06/01/2001 | 9999 | 06/01/2001 | |
Vehicle has a engine/drivetrain vibration that can be heard and felt throughout the cabin at speeds of 58-62 mph. the vibration cycles on and off constantly, being on for 1-2 sec and then off for 3-5 sec. we fear eventual engine/drivetrain failure, especially after front suspension recall and transfer case recalls. gm unsure of cause, but said it is happening on numerous trailblazers with no fix yet but feel it is related to engine harmonic balance. a friend of ours lost the #5 piston on their engine while passing, nearly causing a severe accident. local dealers confirm several other engines in 2002 trailblazers have blown - wondering if these problems are related. our vibration/noise problem makes us very uneasy in terms of family safety while inside our new vehicle at these highway speeds.*ak | |||
POWER TRAIN - MANUAL TRANSMISSION | |||
Consumer called complaining about having problems with a real loud noise on the front suspension area. dealer was contacted and stated that they lubricator and the problem still there this will actually make it the 6th time it is actually at the shop. ts | |||
07/05/2002 | 1 | ||
Consumer states while driving 55mph a loud noise occured and transmission was slipping. nlm |