Bulletins
| Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
|---|---|---|---|---|---|
| STRUCTURE - BODY | |||||
| 4114 | 10020462 | Clunk noise felt through the floor pan. *kb | 10/23/2006 | ||
| 57 | 07/01/2003 | 10016473 | Water leak in front floor carpet area. gm tech link. *tt | 09/13/2005 | |
| 030857005 | 11/01/2003 | 10005591 | Water found in rear cupholder or on floor of vehicle. *tt | 03/04/2004 | |
| STRUCTURE - FRAME AND MEMBERS | |||||
| PIT-3749D | 11/01/2010 | 10037570 | Ready | 05/25/2011 | |
| PIT-3749D | 11/01/2010 | 10037570 | Gm: on some truck models there is some frame corrosion. *rm | 05/25/2011 | |
| STRUCTURE - FRAME AND MEMBERS - UNDERBODY SHIELDS | |||||
| 01136C | 11/18/2003 | 10004206 | Clunk noise felt through floor pan. *tt | 11/21/2003 | |
Consumer Complaints
| Fail date | miles | occurences | Purchase date |
|---|---|---|---|
| STRUCTURE | |||
| 06/15/2003 | 30037 | ||
| I have a 02 blazer and i believe the fuel gauge is not working properly. after i have gone only about 40 miles on a full tank of gas the gauge shows ? full. can that be correct? in the owner?s manual it states that i am to have an 18-gallon fuel tank. with an average of 20 mpg on the highway it should go to ? tank at about 90 miles. | |||
| STRUCTURE - BODY | |||
| 10/22/2008 | 910256 | 1 | |
| Crash- i was doing 25 mph when after hitting a deer swerved hit my front end on the corner of a hill and my vehicle went on to its side. there was hardly any damage done to the front end because i didn't hit very hard ,but because of the side damage the vehicle was 500 dollars from being totaled. 2003 chevy blazer. *tr | |||
| 08/22/2004 | 15000 | 4 | |
| Body seams leaks water to the inside of my car. it was thought to be my sunroof, which dealer repaired and then replaced. the water caused all inside lights to short out (third repair). it was on the the fourth time to the service that it was found the actual body seams were leaking.*ak | |||
| STRUCTURE - BODY - DOOR | |||
| 01/27/2009 | 50999 | 1 | |
| Right passenger door on my 2003 chevrolet blazer 2 door drops when open and lifts up when closed. same situation as my 2004 four door blazer. upper and lower hinge pins and bushings failed causing the door to become difficult to open and close a real safety problem. *tr | |||
| 01/01/1901 | 1 | ||
| 2003 chevy blazer door safety issues. consumer states that the doors will not close properly or will come open while driving. he states that he has had the pins and bushings replaced. *kb | |||
| 1 | |||
| When it rained water seeped into the cabin of the vehicle and flooded it. dealership replaced the rubbers around the doors, but the problem still occurred. consumer indicated that water was coming into the vehicle from somewhere under the dashboard.*ak | |||
| STRUCTURE - BODY - DOOR - HINGE AND ATTACHMENTS | |||
| 03/26/2004 | 13850 | 1 | 12/29/2003 |
| I opened the drivers door on my 2003 chevrolet blazer with only 13,000 miles and the door dropped down in my hands. the pins that hold the door hinge had partly lifted out. it would not have been out of the question for the pin to have fallen out completly in which case the hinge would have come completely apart and the door would have fallen off the vehicle. when i called the chevy dealer they were well aware of the problem. apparently this happens all the time with s10 pickiups and blazers. aside from the frustration of such a shoddy design i am afraid to think of the effect of such a failure at 65 mph or of a door coming off in an accident as a result of faulty hinges. *ak | |||
| STRUCTURE - BODY - HATCHBACK/LIFTGATE | |||
| 09/28/2003 | 250 | 1 | 09/27/2003 |
| Heat actuator defective, had to be replaced-constant warm air blows on feet without anything on. moon-roof improperly assembled at factory-water pours into my truck. rear lift gate seal defective-leaking, rear side small triangular window seals-defective-leaking; seams on roof of truck leaking-found a hole in roof where more water was seeping in. *la | |||
| STRUCTURE - BODY - TAILGATE | |||
| 09/21/2004 | 1 | ||
| Tailgate failed to open. took vehicle to the dealer, and consumer was informed that the tailgate could not be opened without drilling a hole in tailgate or removing the panel.*ak | |||
| STRUCTURE - FRAME AND MEMBERS | |||
| 04/18/2010 | 110000 | ||
| Tl* the contact owns a 2003 chevrolet blazer. the contact stated when inspecting under the vehicle, he noticed the frame behind the front wheels had fractured. he did not observe any visible signs or rust or corrosion. the vehicle had not yet been taken to the dealer for further inspection or repairs. the failure and current mileages were 110,000. | |||