Recalls
Campaign | Manufacturer | Manufacturing date | Type | # of units affected | Date Owner notified Mfg | Recall Initiated by | Manufacturers of recalled vehicles/products | Report Recieved Date | Record Creation Date | Regulation Part Number | FMVSS Number | |||||
---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|
FUEL SYSTEM, GASOLINE | ||||||||||||||||
06E043000 | HONEYWELL INTERNATIONAL, INC. | E (Equipment) | 88303 | 10/18/2006 | MFR | GENERAL MOTORS CORP. | 05/19/2006 | 05/22/2006 | ||||||||
Defect Summary | Certain replacement fuel filters, fram brand name p/n g3727, with date codes x52911 through x60801 sequentially or x600141 and a mexico country or origin marking on the fuel filter housing manufactured from october 18, 2005, through march 21, 2006, sold for use on the vehicles listed above and on certain school buses. (to see the school bus engine sizes, click on document search and then bus applications). the connector on the fuel filter was not manufactured to honeywell's specification. as a result, the o-ring may not seat correctly on the fuel line. | |||||||||||||||
Consequence Summary | This condition may cause an inadequate seal at the connection, potentially leading to a fuel leak. in the presence of an ignition source, a fire could occur. | |||||||||||||||
Corrective Summary | Honeywell will notify owners and replace the fuel filters free of charge. the recall began on october 18, 2006. owners may contact fram customer service at 1-800-890-2075 (option 1). | |||||||||||||||
Notes | This recall only pertains to aftermarket fram fuel filters and has no relation to any original equipment installed on the vehicles listed.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov. |
Consumer Complaints
Fail date | miles | occurences | Purchase date |
---|---|---|---|
FUEL SYSTEM, GASOLINE | |||
12/14/2011 | 259856 | ||
While driving on i-95 in my 1994 chevrolet c2500 with the 6.5 l naturally aspirated diesel, my truck suddenly stalled and i lost all my engine powered components (power steering, brakes, etc.) i pushed on the brake pedal very hard but was barely slowing down. i finally got the truck slowed down enough to get off on the shoulder of the freeway. i then had to sit there for 30 minutes to allow the pump mounted driver to cool down before i could turn around and garage my vehicle. it happened several (5-10) times over the course of a 30 mile trip. i have seen many instances of the same thing happening to other 6.5l diesel owners. this is unacceptable. something needs to be done about the pump mounted drivers (pmds) on this engine. they overheat and cause the engine to fail. i will be replacing the pmd on my engine and that will take care of the problem. this could have caused a major accident if i would have needed to brake suddenly while my engine was stalled. it | |||
12/12/1998 | |||
There is a fuel leakage, and the fuel is getting into the engine. *ak | |||
FUEL SYSTEM, GASOLINE - DELIVERY - FUEL PUMP | |||
5 | 03/01/1994 | ||
An approved gm repair facility has replaced the fuel injector pump on this vehicle 5 times. it causes the truck to hesitate when accelerating and jerk severly when decelerating. i know of other vehicles of the same model that have had the same problem with these pumps. i am currently looking for another truck to purchase and cannot get a fair trade-in on this truck because of the repairs that have been unsuccessful. something needs to be done to resolve this problem with newer models if it exists and to compensate present unsatisfied owners. | |||
04/19/1994 | 5 | 10/18/1993 | |
Fuel injection pump failed several times, causing loss of control due to power steering and brakes lose, also engine hesitates/stalls. | |||
03/01/1994 | 5 | ||
Multiple fuel pump failures, sometimes at up to 65 mph. | |||
FUEL SYSTEM, GASOLINE - FUEL INJECTION SYSTEM | |||
11/17/2000 | 4 | 10/01/1994 | |
Injector pump cuts out at 55-70mph also shuts off when turning sitting still will die this is a safty problem .every one i talk to has problems with injectors also cheverolet amitt.problem i have 4 put on still having problems.it will happen when i am turning in front of traffic.please help to stop injuries or death if not already happen. *ak | |||
1 | |||
Injector pumps are defective, the injectors have gone out without warning several times while turning in front of traffic and the engine dies.*et | |||
01/05/1998 | 3 | 02/16/1994 | |
While driving or just when the engine is on fuel injection pump will stop working and vehicle will stall, causing loss of steering and brakes. fuel injection pump has been replaced 3 times. *ak *ml | |||
08/01/1999 | 2 | 12/01/1994 | |
Fuel system was cutting off during drive. taken in and worked on by dealer. real axle seals have been replaced 2/3 times (97/99). driver's seat has separated from the frame. battery/alternator malfunction recently. will be taking in vehicle to dealer about seat and battery/alternator situation this week. i just have to get the batteries recharged enough to get the truck started. just had all 8 glow plugs replaced end of nov 1999 right after the warranty completed.( dot number: ad11c98356 tire size: lt 245/75r ) | |||
01/01/1997 | 2 | 10/31/1994 | |
Due to defective fuel injector pump vehicle stalled unexpectedly which may resultin a crash. dealer replaced fuel injector pump twice. common problem. please provide further information. *ak | |||
09/15/1999 | 16 | 10/01/1994 | |
Injector pumps failure, pump has gone out while turning and at all speeds every one i talk to has had pump problems several times could cause injury or death. gm has a problem with them, all the mechanics at several dealers said the have problems please check this out. ak | |||
10/28/1999 | 4 | ||
While driving down fuel injection pump malfunctioned, causing vehicle to stall/ die. this can cause the driver to lose control because driver loses power steering and and power brakes. took to dealer 3 times for same problem. consumers warranty has expired, and dealer will not fix it again. consumer feels that the dealer never really corrected the problem. *ak | |||
The vehicle stalls out and dies without warning. engine check light illuminates just before the vehicle stalls. dealer has replaced the fuel injection pump three times. manufacturer has been notified. *ak | |||
3 | |||
The vehicle stalled out at 65mph and all power steering and power brakes went out. this was due to the vehicle needing a fuel injection pump. dlr has replaced the pump twice. problem still exist. mjs | |||
FUEL SYSTEM, GASOLINE - FUEL INJECTION SYSTEM - INJECTORS | |||
11/12/2001 | 2 | ||
On several occasions, vehicle will shutdown without prior warning. consumer took vehicle to dealership. mechanic put in a new fuel injector. *ak consumer believes this part is under recall and is requesting reimbursement. |