Chevrolet C5500 2005
Model C5500 made in 2005 by Chevrolet got 6 consumer complains there are 2 recalls as well as 19 service bulletins. Consumer complaints with reference, among others things, to electrical system, fuel system, other and power train. Technical service bulletines regarding communications, engine and engine cooling and latches/locks/linkages. There were some recalls concerningequipment adaptive, suspension.
Model 2005
Recalls
Campaign | Manufacturer | Manufacturing date | Type | # of units affected | Date Owner notified Mfg | Recall Initiated by | Manufacturers of recalled vehicles/products | Report Recieved Date | Record Creation Date | Regulation Part Number | FMVSS Number | |||||
---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|
EQUIPMENT ADAPTIVE | ||||||||||||||||
08E004000 | INTERMOTIVE VEHICLE CONTROLS | E (Equipment) | 250 | 11/20/2007 | MFR | GENERAL MOTORS CORP. | 01/07/2008 | 01/08/2008 | ||||||||
Defect Summary | Certain intermotive wheelchair lift interlock, p/no. ilis605-h3 ilis activation kit (interlock option for gateway 401) sold for use as aftermarket for 2005 - 2008 chevy 560 (c4500 and c5500 kodiak) 6.6l diesel vehicles which a protection diode was used. the diode can be exposed to voltage spikes greater than what it can withstand. the diode could fail, which could prevent vehicle interlock operation when a wheelchair lift is deployed. | |||||||||||||||
Consequence Summary | Should the diode fail, it will be possible to move the vehicle with the wheelchair deployed, which could result in injury to anyone using the lift. | |||||||||||||||
Corrective Summary | Intermotive will notify owners and repair the vehicles free of charge. the recall began on november 20, 2007. owners can contact intermotive toll-free at 1-800-969-6080. this recall only pertains to aftermarket intermotive wheelchair lifts and has no relation to any original equipment installed on chevrlot and gmc vehicles manufactured by general motors. | |||||||||||||||
Notes | Customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov. | |||||||||||||||
SUSPENSION | ||||||||||||||||
07E086000 | LINK MANUFACTURING, LTD | E (Equipment) | 367 | 06/07/2007 | MFR | GENERAL MOTORS CORP. | 10/16/2007 | 10/16/2007 | ||||||||
Defect Summary | Certain link ultraride rear air suspension systems, model 8m000070, sold for installation as aftermarket equipment on gm chassis models 4500 and 5500, ambulances and shuttle buses. the axle side lateral control bracket of the suspension has cracked in some cases. | |||||||||||||||
Consequence Summary | If the lateral control rod bracket fractures, the handling of the vehicle will be adversely affected, including possible loss of vehicle control. | |||||||||||||||
Corrective Summary | Link will notify owners and provide repair kits free of charge and will reimburse for labor and inspection costs. the recall began june 7, 2007. owners can contact link toll-free at 1-800-222-6283. | |||||||||||||||
Notes | This recall only pertains to aftermarket link suspension systems and has no relation to any original equipment installed on vehicle manufactured by general motors.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov. |
Bulletins
Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
---|---|---|---|---|---|
COMMUNICATIONS - HORN ASSEMBLY | |||||
SB05-08-133-001B | 09/01/2009 | 10033631 | Isuzu/gmc/chevrolet: diagnostic information for inoperative air seats, air horn and/or exhaust brake and release of new auxiliary air compressor relay and pressure switch on rpo k16 vehicles. *pe | 08/30/2010 | |
ENGINE AND ENGINE COOLING - COOLING SYSTEM | |||||
PIE-0169 | 04/01/2011 | 10038749 | Ready | 06/27/2011 | |
PIE-0169 | 04/01/2011 | 10038749 | Gm: there is an engine coolant leak or engine knock noise. the engine coolant fan may have broken. 2005-2007 kodiak/top kick. *rm | 06/27/2011 | |
LATCHES/LOCKS/LINKAGES - DOORS - LATCH | |||||
4488 | 12/13/2007 | 4488A | 10023475 | Right outside door handle inoperative. *nj | 12/13/2007 |
SEAT BELTS - FRONT - RETRACTOR | |||||
05-09-40-002E | 10/01/2010 | 10037184 | Ready | 05/11/2011 | |
05-09-40-002E | 10/01/2010 | 10037184 | Gm: service bulletin explaining when the safety belts are supposed to lock. *rm | 05/11/2011 | |
SEAT BELTS - FRONT - WEBBING | |||||
05-09-40-002E | 10/01/2010 | 10037184 | Ready | 05/11/2011 | |
05-09-40-002E | 10/01/2010 | 10037184 | Gm: service bulletin explaining when the safety belts are supposed to lock. *rm | 05/11/2011 | |
SEATS | |||||
SB05-08-133-001B | 09/01/2009 | 10033631 | Isuzu/gmc/chevrolet: diagnostic information for inoperative air seats, air horn and/or exhaust brake and release of new auxiliary air compressor relay and pressure switch on rpo k16 vehicles. *pe | 08/30/2010 | |
SERVICE BRAKES, AIR - ANTILOCK - WHEEL SPEED SENSOR | |||||
PI-00983A | 06/01/2011 | 10039488 | Ready | 08/01/2011 | |
SERVICE BRAKES, AIR - SUPPLY - COMPRESSOR | |||||
SB05-08-133-001B | 09/01/2009 | 10033631 | Isuzu/gmc/chevrolet: diagnostic information for inoperative air seats, air horn and/or exhaust brake and release of new auxiliary air compressor relay and pressure switch on rpo k16 vehicles. *pe | 08/30/2010 | |
SERVICE BRAKES, AIR - SUPPLY - LOW PRESSURE WARNING | |||||
SB05-08-133-001B | 09/01/2009 | 10033631 | Isuzu/gmc/chevrolet: diagnostic information for inoperative air seats, air horn and/or exhaust brake and release of new auxiliary air compressor relay and pressure switch on rpo k16 vehicles. *pe | 08/30/2010 | |
SERVICE BRAKES, HYDRAULIC | |||||
PIT-4935 | 10/01/2009 | 10032455 | Chevrolet/gmc: brake assist pump motor on and warning light/chime. owners may comment when turning the steering wheel with the brake applied that the hydraulic brake assist pump turns on and the brake warning lamp and chime may sound. mo | 03/26/2010 | |
PIT-4515A | 10/01/2009 | 10032452 | Gmc/chevrolet: service brake soon indicator with dtc c0272. some customers may state the service brake soon indicator comes on. may also comment the audible brake warning buzzer is sounding. *pe | 03/26/2010 | |
SERVICE BRAKES, HYDRAULIC - ANTILOCK - WHEEL SPEED SENSOR | |||||
PI-00983A | 06/01/2011 | 10039488 | Ready | 08/01/2011 | |
SERVICE BRAKES, HYDRAULIC - POWER ASSIST | |||||
PIT-4935 | 10/01/2009 | 10032455 | Chevrolet/gmc: brake assist pump motor on and warning light/chime. owners may comment when turning the steering wheel with the brake applied that the hydraulic brake assist pump turns on and the brake warning lamp and chime may sound. mo | 03/26/2010 | |
SERVICE BRAKES, HYDRAULIC - POWER ASSIST - HYDRAULIC | |||||
PIT-4935 | 10/01/2009 | 10032455 | Chevrolet/gmc: brake assist pump motor on and warning light/chime. owners may comment when turning the steering wheel with the brake applied that the hydraulic brake assist pump turns on and the brake warning lamp and chime may sound. mo | 03/26/2010 | |
STRUCTURE - BODY | |||||
SB05-08-133-001B | 09/01/2009 | 10033631 | Isuzu/gmc/chevrolet: diagnostic information for inoperative air seats, air horn and/or exhaust brake and release of new auxiliary air compressor relay and pressure switch on rpo k16 vehicles. *pe | 08/30/2010 | |
SUSPENSION - FRONT - STABILIZER BAR | |||||
PIT-5033 | 09/01/2010 | 10036044 | Chevrolet/gmc: replacement rear stabilizer bar (relocate link brackets). if the rear stabilizer bar needs replacing, the new bar is shorter and will require relocation of the stabilizer bar link brackets. *pe | 03/09/2011 |
Consumer Complaints
Fail date | miles | occurences | Purchase date |
---|---|---|---|
ELECTRICAL SYSTEM | |||
03/31/2009 | 58856 | 1 | |
This 2005 chevrolet c 5500, stalled while idling. i had to have the truck towed to the dealer whereupon diagnosis the wiring harness across the top of the engine but under the aircleaner was rubbed through and shorted out. according to the technician who worked on it the clearance was so tight that there was no room for the wiring harness without it chafing from movement of the engine. the technician repaired the harness. *tr | |||
FUEL SYSTEM, OTHER - FUEL INJECTION SYSTEM | |||
02/27/2006 | 13176 | 2 | 09/21/2005 |
Tl*the contact owns a 2005 chevrolet c 5500. while driving 70 mph, the engine began to stall and the check engine light illuminated on the instrument panel. twenty miles after noticing the failure, the vehicle suddenly shut off. the dealer stated that one of the injectors failed. the contact did not notice any differences beforehand. the current mileage was 126,000 and failure mileage was 13,200. *updated 10/20/08 *bf the consumer stated the vehicle has been in the shop for transmission computer programming, rotors, brake lines abs, fuel and the power steering line. the consumer also stated his other vehicle exhibited the same problems/ updated 10/21/08.*jb | |||
FUEL SYSTEM, OTHER - STORAGE - FUEL GAUGE SYSTEM | |||
02/27/2006 | 13176 | 2 | 09/21/2005 |
Tl*the contact owns a 2005 chevrolet c 5500. while driving 70 mph, the engine began to stall and the check engine light illuminated on the instrument panel. twenty miles after noticing the failure, the vehicle suddenly shut off. the dealer stated that one of the injectors failed. the contact did not notice any differences beforehand. the current mileage was 126,000 and failure mileage was 13,200. *updated 10/20/08 *bf the consumer stated the vehicle has been in the shop for transmission computer programming, rotors, brake lines abs, fuel and the power steering line. the consumer also stated his other vehicle exhibited the same problems/ updated 10/21/08.*jb | |||
POWER TRAIN | |||
02/27/2006 | 13176 | 2 | 09/21/2005 |
Tl*the contact owns a 2005 chevrolet c 5500. while driving 70 mph, the engine began to stall and the check engine light illuminated on the instrument panel. twenty miles after noticing the failure, the vehicle suddenly shut off. the dealer stated that one of the injectors failed. the contact did not notice any differences beforehand. the current mileage was 126,000 and failure mileage was 13,200. *updated 10/20/08 *bf the consumer stated the vehicle has been in the shop for transmission computer programming, rotors, brake lines abs, fuel and the power steering line. the consumer also stated his other vehicle exhibited the same problems/ updated 10/21/08.*jb | |||
SERVICE BRAKES, HYDRAULIC | |||
02/27/2006 | 13176 | 2 | 09/21/2005 |
Tl*the contact owns a 2005 chevrolet c 5500. while driving 70 mph, the engine began to stall and the check engine light illuminated on the instrument panel. twenty miles after noticing the failure, the vehicle suddenly shut off. the dealer stated that one of the injectors failed. the contact did not notice any differences beforehand. the current mileage was 126,000 and failure mileage was 13,200. *updated 10/20/08 *bf the consumer stated the vehicle has been in the shop for transmission computer programming, rotors, brake lines abs, fuel and the power steering line. the consumer also stated his other vehicle exhibited the same problems/ updated 10/21/08.*jb | |||
STEERING - HYDRAULIC POWER ASSIST - HOSE, PIPING, AND CONNECTIONS | |||
02/27/2006 | 13176 | 2 | 09/21/2005 |
Tl*the contact owns a 2005 chevrolet c 5500. while driving 70 mph, the engine began to stall and the check engine light illuminated on the instrument panel. twenty miles after noticing the failure, the vehicle suddenly shut off. the dealer stated that one of the injectors failed. the contact did not notice any differences beforehand. the current mileage was 126,000 and failure mileage was 13,200. *updated 10/20/08 *bf the consumer stated the vehicle has been in the shop for transmission computer programming, rotors, brake lines abs, fuel and the power steering line. the consumer also stated his other vehicle exhibited the same problems/ updated 10/21/08.*jb |
Car dealers selling
State | City | Zip | Name | Phone |
---|---|---|---|---|
CA | SACRAMENTO | FLEEET SALES WEST |