Bulletins
| Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
|---|---|---|---|---|---|
| STRUCTURE - BODY | |||||
| 831522 | 12/01/1998 | 603090 | Rear compartment (trunk) lid latch difficult to unlock / open. *yc | 02/02/1999 | |
| STRUCTURE - BODY - DOOR | |||||
| 990864026 | 10/01/1999 | 6088948 | On some convertible models, the door rattles when closing. *tt | 01/11/2000 | |
| 831518A | 11/01/1998 | 83-15-18 | 602988 | Complaints on front outside door handle sticks. *yc | 01/25/1999 |
| 98831518 | 10/01/1998 | 602760 | Comment that the front outside door handle sticks or hits something when opening the door with the door glass in the full up position. *yc | 01/11/1999 | |
| STRUCTURE - BODY - ROOF AND PILLARS | |||||
| 990857019 | 05/01/1999 | 606062 | Conditions with water leak at front header. *tt | 08/06/1999 | |
Consumer Complaints
| Fail date | miles | occurences | Purchase date |
|---|---|---|---|
| STRUCTURE | |||
| 09/13/2004 | 89000 | 1 | |
| The dashboard developed cracks without warning. the dealer states the dash material needs be to replaced. the cause has yet to be determined. please provide additional information. | |||
| 04/26/2004 | 1 | ||
| The consumer stated that the trim around the dashboard and radio cracked and peeled off. the consumer was afraid that if there was an accident or if he hit something, in addition to the air bags deploying, pieces of this plastic would come off, injuring or harming him. the consumer stated he had never seen anything like it. *ak *sc *jb | |||
| STRUCTURE - BODY | |||
| 12/03/2012 | 155000 | ||
| Tl- the contact owns a 1998 chevrolet cavalier. the contact stated that she experienced difficulty steering the vehicle. the vehicle was taken to a private mechanic where it was determined that the sub frame failed. the vehicle was repaired. the manufacturer was not contacted about the issue. the failure mileage was 155,000 and the current mileage was 156,000. kmj | |||
| 11/24/2011 | 123000 | ||
| Tl* the contact owns a 1998 chevrolet cavalier. the contact stated that the driver was driving approximately 35 mph when he was pulled over by a police officer who informed him that one of the wheels was protruding outward abnormally. the vehicle was towed to an impound lot where the contact was informed that the sub frame was severely rusted and corroded. the vehicle was not repaired. the manufacturer was not made aware of the failure. the failure mileage was 123,000. the vin was unavailable. | |||
| 11/24/2011 | 123000 | ||
| Tl-the contact owns a 1998 chevrolet cavalier. the contact stated that the driver was driving approximately 35 mph when he was pulled over by a police officer who informed him that one of the wheels was protruding outward abnormally. the vehicle was towed to an impound lot where the contact was informed that the sub frame was severely rusted and corroded. the vehicle was not repaired. the manufacturer was not made aware of the failure. the failure mileage was 123,000. the vin was unavailable. kmj | |||
| 11/24/2011 | 123000 | ||
| Tl-the contact owns a 1998 chevrolet cavalier. the contact stated that the driver was driving approximately 35 mph when he was pulled over by a police officer. the police officer informed the driver that one of the wheels was bent outward. the vehicle was towed to an impound lot and the contact was informed that the subframe was severely rusted and corroded. the vehicle was not repaired. the manufacturer was not made aware of the failure. the failure mileage was 123,000. the vin was unavailable. sm. | |||
| 12/13/2009 | 143600 | 1 | |
| The 1998 chevrolet cavalier starts to shake when it reaches 60 mph or more. it is a horrible feeling. *tr | |||
| STRUCTURE - BODY - DOOR | |||
| 10/01/1997 | |||
| Both doors have rattles sounds like crash bars weld broken or window guides lose. *ak | |||
| 12/21/1998 | 1 | 04/10/1998 | |
| Driver and passengers side door has noise. yh | |||
| 08/12/1999 | 2 | 10/01/1997 | |
| #1, the front brake rotors warped and the pads were worn. dealer refused to replace under warranty so i paid out of pocket. now second set of rotors and pads is in need of replacement. #2 trunk lid latch could not be opened with key, dealer refused to repair/replace under warranty, so i paid out of pocket. #3 reverse light switch failed, again dealer refused to replace under warranty, i paid out of pocket. switch has gone bad again and i paid to have it replace a second time. #4 driver's door hinges were bent and door did not always close tightly, dealer repaired at no charge. #5 driver's side side had a metal bar sticking through the upholstery into my back. dealer repaired at no charge. | |||
| 4 | 05/01/1998 | ||
| No summary | |||
| 11/29/1997 | |||
| Uneven amount of paint on the rim of the trunk. defective door gasket. inoperative brake lights. | |||
| 12/10/1998 | 4 | 03/24/1998 | |
| Smell of burning wires when driving. radiator hose failed prior to/after recall repairs. also, transfer case malfunctioned prior to/after recall repairs 98v013000. in addition, rear passenger's side door handle broke inside. | |||
| STRUCTURE - BODY - ROOF AND PILLARS | |||
| 06/06/1998 | 36 | 1 | 06/06/1998 |
| Convertible top leaks and has done so since the first rain when i bought the car in june of 1998. vehicle went in for repairs on several occasions with no success in fixing the problem. problem has progressively gotten worse over the last years. heavy rain floods the front seats of the vehicle as does washing. finally gave up after several unsucessful attempts. slowly over the last 2 years the window motors have gone bad preventing me from rolling the windows down. they get stuck and don't roll up. on 3 separate occasions my windows, driver and passenger side have fallen into the door panels and had to be repaired. i have spoken to a friend as well as strangers when i see them driving the same vehicle and they have all thus far expressed the same problems in regards to leaking and window motor. i refuse to pay $350 + to have a $50 window motor replaced in the vehicle. *ak | |||
| 10/20/2000 | 5 | 09/01/2000 | |
| Everytime it rains the convertable top leaks at the front drivers side it drips into the seats i have had the seal replaced, it still leaks. the chevy dealer says there is nothing else they can do. *ak | |||
| Convertible top is leaking water into the passenger comparment which has caused carpet to mold . consumer has contacted dealer. please provide any further details.*ak | |||
| STRUCTURE - BODY - TRUNK LID | |||
| 1 | 07/01/1998 | ||
| Trunk leaks water. *mjs | |||
| 08/12/1999 | 2 | 10/01/1997 | |
| #1, the front brake rotors warped and the pads were worn. dealer refused to replace under warranty so i paid out of pocket. now second set of rotors and pads is in need of replacement. #2 trunk lid latch could not be opened with key, dealer refused to repair/replace under warranty, so i paid out of pocket. #3 reverse light switch failed, again dealer refused to replace under warranty, i paid out of pocket. switch has gone bad again and i paid to have it replace a second time. #4 driver's door hinges were bent and door did not always close tightly, dealer repaired at no charge. #5 driver's side side had a metal bar sticking through the upholstery into my back. dealer repaired at no charge. | |||
| 11/29/1997 | |||
| Uneven amount of paint on the rim of the trunk. defective door gasket. inoperative brake lights. | |||
| 08/20/1998 | 4 | 03/01/1998 | |
| The button on the sunroof would not open the sunroof. i took the car in four separate times and the button still does not seem to work correctlyfirst date it was brought in 8/20/98, 2nd time 9/15/98, third 9/24/98 and last time was taken in was 2/5/99. | |||
| 11/27/1998 | 2 | 03/01/1998 | |
| This car has been taken to the dealer and the dealer recognizes the problem but consistantly refuses to take any rsponsibilities for the junk that they sold me. this car has been to the body shop for repairs on the manufacturer ground effects package the transmission that doesn't work properly the brake system the i have had to have rotors turned and within four months have brand new rotors but on. the sunroof doesn't open properly, the trunk lid hits the bumper when you close it,the engine makes a weird rattle noise when you go over a bump,the doors do not close all the way, ther is tons of rust on the inside walls of my trunk, i was also notified of a recall on the oil consumption valve two weeks after all the oil in my car had leaked out causing my engine to knock on my way home from work (had to put four quarts of oil in it three days from having an oil change, i never received the airbag recall for my vehicle. to wrap this up in a nutshell i will never buy a chevrolet product again i will result to a foriegn car maker (honda) to purchase my next vehicle. nk | |||
| 01/10/1999 | 04/01/1998 | ||
| At 8 miles before purchase of car water pump, gasket, thermostat and seal replaced because of coolant leak, at 14,000 miles water sensor replace because coolant light continued to come on, at 15,000 miles coolant coming on again and head gasket replaced. claims no damage to engine but a mechanic told me they could not tell unless they tear engine down and mic it. at 5,000 miles trunk leaked at 15,000 miles in for continued trunk leak. front passenger door sticks. rear passenger door handle sticks out further than rest. continue to have problems with car. also had to have mud flaps installed after purchase, they where suppose to come with it. had to have front passenger seat fixed because it would not move. car is in william m fowler and barbara a fowler | |||
| 07/14/1998 | 1 | 01/01/1998 | |
| There has been one thing wrong after the other ever since i bought this car and i believe it a piece of crap but i guess that i am stuck up it since chevrolet declined my buyback request. | |||
| STRUCTURE - FRAME AND MEMBERS | |||
| 01/01/2011 | 131000 | ||
| No events except the sub frame just split in half ,causing the vehical has verry little controle and pulls eraticly from one way to another, had to replace the sub frame | |||
| 08/28/2009 | 170000 | ||
| Chevy cavalier rusted sub frames. car vibrates wildly at a certian speeds. car was parked. was told vehicle warrenty had already expired and there had been no other calls related to this. was told by gm service department car (if driven) should be driven cautiously (no bumps, potholes, long distance trips) recommended we don't drive. | |||
| 06/28/2009 | 170000 | ||
| Tl* the contact owns a 1998 chevrolet cavalier. while driving 60 mph the vehicle will begin to vibrate. also when striking a small bump on the road way, the vehicle will fish tail. during the installation of new tires, she was advised that the vehicles sub frame had corrosion. it cost $3500.00 to repair the frame. no repairs were made. the failure mileage was 170000. the current mileage was 172000. | |||
| 11/20/2008 | 133000 | 1 | |
| I was stopped at red light and when the light turned green i took off and felt a pull to the passenger side. i had my brother in law check it out and the sub-frame was rotted. we replaced it but feel this needed to be brought to your attention. *tr | |||
| 07/31/2000 | 3 | 07/01/2000 | |
| Wilton motors (ct) has had it for 2 weeks without repair! | |||
| Whenever it rains passenger's side compartment fills up with water. dealer cannot find the cause. *ak | |||