Bulletins
| Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
|---|---|---|---|---|---|
| VEHICLE SPEED CONTROL | |||||
| 3115 | 01/01/2004 | 10010198 | High idle when clutch is depressed. *sc | 11/04/2004 | |
| VEHICLE SPEED CONTROL - CABLES | |||||
| 012803 | 01/28/2003 | 10005112 | Throttle cable rattle noise heard in the front of dash area, most noticeable at the center defroster duct. gm voicemail express. *tt | 01/30/2004 | |
| VEHICLE SPEED CONTROL - CRUISE CONTROL | |||||
| 3481 | 3481A | 10016717 | Cruise control shuts off when the hazards are switched on. *tt | 09/28/2005 | |
Consumer Complaints
| Fail date | miles | occurences | Purchase date |
|---|---|---|---|
| VEHICLE SPEED CONTROL | |||
| 12/23/2010 | 171000 | ||
| I drove my 02 chevy cavalier on thursday back from tahoe,ca and my gas pedal got stuck down and kept increasing in speed, so i prayed and then started to mess with my cruise control and finally came back up, this morning same thing happened, so i called chevrolet customer service and the rep-eric told me that i need to pay for a diagnoses before i can get any answers, he called up the closest dealer and they could not give him a quote, i would rather buy a new car if i have to pay money for a diagnoses. this incident is a mechanical problem which occurs on its own. i cant afford another car as of right now and am still using my car for work. what would you say i should do?? | |||
| 02/27/2010 | 77115 | 1 | |
| I bought this car a 2002 chevy cavalier in 2005, and at the time there was 25k original miles so i was told. since then i have found out there has been 5 recalls on this car for various safety hazards, none of which i was ever told about prior or during my purchase of this vehicle. the signals have failed, i had to pay for them to be replaced, the bearings on the tires caused dry rot and i had to pay to replace those, both were on the recall list. the engine would over heat in the idle position, and they replaced an air filter sitting that as the problem and it wasn't. the pedal sticks when i accelerate and sometimes gets stuck, the rockerarms have started to go bad and it has caused the valve stems to bend,thus causing the oilpump to seize up and now my cars engine has a blown gasket,this is under the engine component system recall, which was reported in 2007. i was never notified. and now im paying 350 per month for a car that is not running. *tr | |||
| 2 | |||
| While driving 60 mph, without warning the vehicle suddenly accelerated. the driver was able to maintain control of the vehicle and took it to the dealer for inspection. the mechanic was unable to duplicate the problem. please provide further detail. *jb | |||
| 05/16/2003 | 1 | ||
| The vehicle experienced sudden acceleration while driving. the dealer inspected the vehicle but could not duplicate or correct the problem. *nlm | |||
| 07/19/2002 | 1600 | 1 | |
| When leaving doctor's office and turning right onto busy 4-lane highway car accelerated from creeping speed to full throttle. when i applied the brakes, they made a terrible sound and went clear to the floor before stopping. i was scared to death and could have been killed. dims 11 ivoq entry posted after 12/12/02 to artemis------769747. *ak | |||
| 05/13/2002 | |||
| While putting vehicle in crusie control gas pedal went all the way to the floor, and vehicle started to accelerate. contacted dealer. *ak | |||
| VEHICLE SPEED CONTROL - ACCELERATOR PEDAL | |||
| 07/31/2007 | 100000 | 15 | 07/02/2007 |
| Tl*the contact owns a 2002 chevrolet cavalier. while driving 17 mph, the accelerator pedal extended to the floor when it was depressed. she depressed the brake pedal, but the vehicle failed to stop. the contact drove into a ditch to avoid being hit by a tractor trailer that was traveling 95 mph. the entire passenger side of the vehicle was destroyed from the rear to the front end. the air bags failed to deploy. five passengers sustained injuries. a police report was filed. the current mileage was 129,000 and failure mileage was 100,000. | |||
| 11/29/2003 | 1 | ||
| While reversing accelerator became stuck and the rear end of the vehicle hit a light pole. the plastic cover at the anchorage point of the seat belt struck the front passenger in the back of the head. the passenger had to get 14 stitches. *ak | |||
| VEHICLE SPEED CONTROL - CABLES | |||
| 07/07/2003 | 5424 | 6 | 12/14/2001 |
| Engine and vehicle speed sometimes, but intermittently, do not respond to driver control - vehicle accelerates on its own. when that happens, had to ride brakes to control speed. this happened five times with increasing severity over a period of time - on the sixth time the vehicle reached 60mph without the accelerator being touched. review of odi compliants shows an increasing number of similar related complaints on this model with age. had purchased car to give to my newly licensed daughter, who, due to lack of experience, was initially unsure if the problem was with her or the car. the last time scared her, and the dealer's rep said it was an accident waiting to happen. dealer did a good job in persisting with the problem, which was finally (after two days) traced to the accelerator control cable dust cover coming loose and wedging itself between the cable an actuator in a difficult to detect location.*ak | |||
| VEHICLE SPEED CONTROL - CRUISE CONTROL | |||
| 11/03/2006 | 3 | ||
| Cruise control stayed on after hitting breaks even tried swtiching it off and that did not work only when i pressed in on the clutch did it disengage. but not befor the engine reved up to over 5000 rpm. this could damage the engine | |||
| 01/15/2005 | 1 | 02/02/2002 | |
| While traveling on interstate i-75 at approx 75-78 mph with my car's cruise control set, i changed lanes to go around a slower vehicle at which time i was also coming up to a vehicle in the lane i switched to so when i tapped my brake pedal to release the cruise control it did not disengage, so i rapidly starting pushing the button on the end of the cruise control mechanism which did not slow me down either-i turned the button of on the cruise control it did not shut off! i got over into the slow lane to prepare to exit the x-way by literally standing on my brake pedal and i could only get it down to about 58 mph with my rpm's still at over 3000 when i exited i got the front end of the car to the shoulder i was going to fast still to properly place the car and i decided i needed to put it into neutral and shut it off, i missed neutral and went into reverse at 58-60 mph it jolted us backwards i quick reached down and put it back into drive and we flew forward and at that point i crammed the gear shift into park at 60 mph- my engine was roaring and you could smell nothing but burning. my father drove to where we were and since he is retired g.m. repair person he knew how to disconnect the cruise control cable and he had me follow him and said everything seemed ok- i now have gotten the car to team hodges chevrolet where it was purchased for them to inspect and a report has been made to chevrolet. *nm | |||