Chevrolet C/k Series 2002
Model C/k Series made in 2002 by Chevrolet got 6 consumer complains there are 10 investigations as well as 7 service bulletins. Consumer complaints with reference, among others things, to service brakes, suspension. Technical service bulletines regarding engine and engine cooling, exterior lighting and interior lighting. The car had some investigations: parking brake, service brakes, hydraulic and steering.
Model 2002
Bulletins
| Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
|---|---|---|---|---|---|
| ENGINE AND ENGINE COOLING - ENGINE | |||||
| 000604003B | 02/01/2003 | 000604003A | 10001298 | Rough idle after start, and/or a service engine soon (ses) light. various models including the 1995 chevrolet and gmc s/t models. *tt | 04/28/2003 |
| 030601008 | 03/01/2003 | 10001245 | Crankshaft rear oil seal leaks during extreme cold weather operation. on certain models including the chevrolet and gmc c4500/c5500 models. *tt | 04/24/2003 | |
| ENGINE AND ENGINE COOLING - EXHAUST SYSTEM - EMISSION CONTROL | |||||
| 040802 | 04/08/2002 | 636515 | Diagnosing oxygen sensor problems. *tt | 11/09/2002 | |
| EXTERIOR LIGHTING - HEADLIGHTS | |||||
| 3170E | 10019186 | Ipc, interior lights and/or headlamps flicker. *ak fb2 | 02/16/2006 | ||
| INTERIOR LIGHTING | |||||
| 3170E | 10019186 | Ipc, interior lights and/or headlamps flicker. *ak fb2 | 02/16/2006 | ||
| UNKNOWN OR OTHER | |||||
| 021103 | 02/11/2003 | 10002540 | Emerging issues seminar onthe idl broadcast system. *tt | 09/04/2003 | |
| 041502 | 04/15/2002 | 636535 | Customer complaint of a check engine light. *tt | 11/09/2002 | |
Investigations
| NHTSA ID | Manufacturer | Date open | Date close | Subject | Recall campaign | |
|---|---|---|---|---|---|---|
| PARKING BRAKE | ||||||
| PE03057 | GENERAL MOTORS CORP. | 12/08/2003 | 04/09/2004 | PARKING BRAKE FAILURE | ||
| Odi opened pe03-057 to assess parking brake ineffectiveness in the subject vehicles.these vehicles are equipped with four wheel disc brakes that incorporate a single-shoe drum-in-hat parking brake independent of the service brakes.complaint and warranty data indicate that the parking brake linings tend to wear out early in the life of the vehicle (at an average of 24 months in service), reducing the parking brake system's torque below that needed to immobilize the vehicle.gm has attributed this accelerated wear to foreign material intrusion and a failure of the brake shoe to properly self-center within its brake drum.effective with the start of my 2003 production, a newer reduced force hold-down clip was introduced to facilitate brake shoe disengagement from the drum surface.this part is also available at the service level for the my 1999-2002 vehicles.gm has indicated that the paking brake is intended to operate in conjunction with the transmission to immobilze parked vehicles, and that in many cases, accelerated parking brake lining wear is caused by rough use, vehicle modifications, and driving with the parking engaged. odi has upgraded the preliminary evaluation to an engineering analysis to gather further information concerning parking brake usage factors and the circumstances surrounding the seventeen reported vehicle crashes. | ||||||
| DP05009 | GENERAL MOTORS CORP. | 12/20/2005 | 05/31/2006 | PARKING BRAKE FAILURE | ||
| Odi's review of complaint data received since the close of ea04-011 revealed no indication that the investigation should be re-opened.more details can be found in the federal register notice enclosed in the dp05-009 public file.odi reserves the right to reopen the investigation in the future should conditions warrant. | ||||||
| EA04011 | GENERAL MOTORS CORP. | 04/09/2004 | 05/10/2005 | PARKING BRAKE FAILURE | 05V161000 | |
| In a letter dated april 20, 2005, gm notified nhtsa that it had decided that defects that relate to motor vehicle safety exist in certain model year (my) 1999-2002 c/k 1500 series (pbr parking brake system) and my 2001-2005 c/k 2500 and 3500 series (trw parking brake system) pickups with manual transmissions.according to gm, some of these vehicles may have conditions that cause the friction linings to wear to an extent where the parking brake can become ineffective in immobilizing a parked vehicle.gm's action covers an estimated total of 142,585 vehicles.dealers will install a low-force spring clip retainer for vehicles equipped with the pbr parking brake system and install a redesigned parking brake cable assembly on vehicles equipped with the trw parking brake system. a total of 58 non-duplicative complaints were received by odi and gm concerning the approximately 59,000 my 1999-2002 c/k 1500 series pickup trucks with the pbr parking brake system.these included 22 alleged rollaway incidents, resulting in a rate of 38.5 rollaway incidents per 100,000 vehicles.odi is aware of 24 complaints regarding the my 2001-2005 c/k 2500 and 3500 series manual transmission trucks recalled by gm, including 5 alleging rollaway incidents.though the conditions described in gm's letter are also present in the c/k trucks with automatic transmissions, the rollaway rate in those vehicles was similar to those observed in peer vehicles studied by odi in this investigation.this engineering analysis is closed. for additional information, see the attached closing report. | ||||||
| PARKING BRAKE - CONVENTIONAL | ||||||
| DP05009 | GENERAL MOTORS CORP. | 12/20/2005 | 05/31/2006 | PARKING BRAKE FAILURE | ||
| Odi's review of complaint data received since the close of ea04-011 revealed no indication that the investigation should be re-opened.more details can be found in the federal register notice enclosed in the dp05-009 public file.odi reserves the right to reopen the investigation in the future should conditions warrant. | ||||||
| EA04011 | GENERAL MOTORS CORP. | 04/09/2004 | 05/10/2005 | PARKING BRAKE FAILURE | 05V161000 | |
| In a letter dated april 20, 2005, gm notified nhtsa that it had decided that defects that relate to motor vehicle safety exist in certain model year (my) 1999-2002 c/k 1500 series (pbr parking brake system) and my 2001-2005 c/k 2500 and 3500 series (trw parking brake system) pickups with manual transmissions.according to gm, some of these vehicles may have conditions that cause the friction linings to wear to an extent where the parking brake can become ineffective in immobilizing a parked vehicle.gm's action covers an estimated total of 142,585 vehicles.dealers will install a low-force spring clip retainer for vehicles equipped with the pbr parking brake system and install a redesigned parking brake cable assembly on vehicles equipped with the trw parking brake system. a total of 58 non-duplicative complaints were received by odi and gm concerning the approximately 59,000 my 1999-2002 c/k 1500 series pickup trucks with the pbr parking brake system.these included 22 alleged rollaway incidents, resulting in a rate of 38.5 rollaway incidents per 100,000 vehicles.odi is aware of 24 complaints regarding the my 2001-2005 c/k 2500 and 3500 series manual transmission trucks recalled by gm, including 5 alleging rollaway incidents.though the conditions described in gm's letter are also present in the c/k trucks with automatic transmissions, the rollaway rate in those vehicles was similar to those observed in peer vehicles studied by odi in this investigation.this engineering analysis is closed. for additional information, see the attached closing report. | ||||||
| PARKING BRAKE - CONVENTIONAL - MECHANICAL | ||||||
| EA04011 | GENERAL MOTORS CORP. | 04/09/2004 | 05/10/2005 | PARKING BRAKE FAILURE | 05V161000 | |
| In a letter dated april 20, 2005, gm notified nhtsa that it had decided that defects that relate to motor vehicle safety exist in certain model year (my) 1999-2002 c/k 1500 series (pbr parking brake system) and my 2001-2005 c/k 2500 and 3500 series (trw parking brake system) pickups with manual transmissions.according to gm, some of these vehicles may have conditions that cause the friction linings to wear to an extent where the parking brake can become ineffective in immobilizing a parked vehicle.gm's action covers an estimated total of 142,585 vehicles.dealers will install a low-force spring clip retainer for vehicles equipped with the pbr parking brake system and install a redesigned parking brake cable assembly on vehicles equipped with the trw parking brake system. a total of 58 non-duplicative complaints were received by odi and gm concerning the approximately 59,000 my 1999-2002 c/k 1500 series pickup trucks with the pbr parking brake system.these included 22 alleged rollaway incidents, resulting in a rate of 38.5 rollaway incidents per 100,000 vehicles.odi is aware of 24 complaints regarding the my 2001-2005 c/k 2500 and 3500 series manual transmission trucks recalled by gm, including 5 alleging rollaway incidents.though the conditions described in gm's letter are also present in the c/k trucks with automatic transmissions, the rollaway rate in those vehicles was similar to those observed in peer vehicles studied by odi in this investigation.this engineering analysis is closed. for additional information, see the attached closing report. | ||||||
| DP05009 | GENERAL MOTORS CORP. | 12/20/2005 | 05/31/2006 | PARKING BRAKE FAILURE | ||
| Odi's review of complaint data received since the close of ea04-011 revealed no indication that the investigation should be re-opened.more details can be found in the federal register notice enclosed in the dp05-009 public file.odi reserves the right to reopen the investigation in the future should conditions warrant. | ||||||
| PARKING BRAKE - CONVENTIONAL - MECHANICAL - LINKAGE AND CABLE | ||||||
| EA04011 | GENERAL MOTORS CORP. | 04/09/2004 | 05/10/2005 | PARKING BRAKE FAILURE | 05V161000 | |
| In a letter dated april 20, 2005, gm notified nhtsa that it had decided that defects that relate to motor vehicle safety exist in certain model year (my) 1999-2002 c/k 1500 series (pbr parking brake system) and my 2001-2005 c/k 2500 and 3500 series (trw parking brake system) pickups with manual transmissions.according to gm, some of these vehicles may have conditions that cause the friction linings to wear to an extent where the parking brake can become ineffective in immobilizing a parked vehicle.gm's action covers an estimated total of 142,585 vehicles.dealers will install a low-force spring clip retainer for vehicles equipped with the pbr parking brake system and install a redesigned parking brake cable assembly on vehicles equipped with the trw parking brake system. a total of 58 non-duplicative complaints were received by odi and gm concerning the approximately 59,000 my 1999-2002 c/k 1500 series pickup trucks with the pbr parking brake system.these included 22 alleged rollaway incidents, resulting in a rate of 38.5 rollaway incidents per 100,000 vehicles.odi is aware of 24 complaints regarding the my 2001-2005 c/k 2500 and 3500 series manual transmission trucks recalled by gm, including 5 alleging rollaway incidents.though the conditions described in gm's letter are also present in the c/k trucks with automatic transmissions, the rollaway rate in those vehicles was similar to those observed in peer vehicles studied by odi in this investigation.this engineering analysis is closed. for additional information, see the attached closing report. | ||||||
| SERVICE BRAKES, HYDRAULIC - POWER ASSIST | ||||||
| EA04012 | GENERAL MOTORS CORP. | 04/30/2004 | 02/28/2005 | HYDRAULIC PUMP FAILRES | 05V005000 | |
| Gm is conducting a recall on all subject vehicles build between may 1999 and october 14, 1999.significant changes were incorporated into production in early october 1999, and vehicles built after that date have lower warranty failure rates.the complaint and warranty data appear to support the effectiveness of these changes. gm made additional changes in november 1999, february 2000, may 2001, and february 2004.odi will continue to monitor this problem and will take further action, if warranted, in the future.for further technical details see the attached engineering analysis report. | ||||||
| STEERING - HYDRAULIC POWER ASSIST SYSTEM | ||||||
| EA04012 | GENERAL MOTORS CORP. | 04/30/2004 | 02/28/2005 | HYDRAULIC PUMP FAILRES | 05V005000 | |
| Gm is conducting a recall on all subject vehicles build between may 1999 and october 14, 1999.significant changes were incorporated into production in early october 1999, and vehicles built after that date have lower warranty failure rates.the complaint and warranty data appear to support the effectiveness of these changes. gm made additional changes in november 1999, february 2000, may 2001, and february 2004.odi will continue to monitor this problem and will take further action, if warranted, in the future.for further technical details see the attached engineering analysis report. | ||||||
Consumer Complaints
| Fail date | miles | occurences | Purchase date |
|---|---|---|---|
| SERVICE BRAKES | |||
| 09/09/2012 | 119000 | 1 | |
| Lost all brakes. after inspection, it was determined that the brake lines had corroded and sprung a leak. had to stop truck with emergency brake. *tr | |||
| 09/09/2012 | 119000 | ||
| Lost all brakes. after inspection, it was determined that the brake lines had corroded and sprung a leak. had to stop truck with emergency brake. | |||
| SUSPENSION - FRONT | |||
| 09/20/2002 | 1 | 09/20/2002 | |
| New truck chevrolet c5500 has had a vibration since purchase. gm refuses to fix. has caused the side view mirror to be replaced. this vibration is getting worse and is making it difficult to properly see out of the mirror and make safe lane changes. my understanding is that there are more trucks like this with the same problem. *la | |||
Car dealers selling
| State | City | Zip | Name | Phone |
|---|---|---|---|---|
| IN | FT WAYNE | 46895 | KELLEY CHEVROLET | 260-484-5566 |