Consumer Complaints
| Fail date | miles | occurences | Purchase date |
|---|---|---|---|
| SUSPENSION | |||
| 01/17/2013 | 69000 | 1 | |
| Lower control arm bushing fails . there is so much play when braking car pulls to one side it didn't start till car was out of warranty. *tr | |||
| 01/17/2013 | 69000 | ||
| Lower control arm bushing fails . there is so much play when braking car pulls to one side it didnt start till car was out of warranty | |||
| 12/27/2012 | 7972 | 1 | |
| The control arm bushings had to be replaced with less than 8000 miles on the car. they went so bad the car swerved and clanked and chattered when the brakes were applied. less than 8000 miles on the car??? this is a joke. i see on the internet a lot of people with same complaints. why no recall? *tr | |||
| 08/01/2012 | 97000 | 1 | |
| I noticed a slight tapping/rattling noise coming from the front driver side. the noise only occurs between the speeds of 50-60 mph and only when letting off the gas completely. then i received in the mail an ignition cylinder recall. my car had problems with locking up and difficulties turning the key. so i took the car to the dealership told them about the noise i was hearing then waited a week with no call from the dealership so i called them. they told me my car would be finished by noon, i arrived at 4 pm. they then told me my car was not yet finished. the dealership had not even put in the new ignition cylinder even after a week. i was told the noise could not be replicated. i waited for the ignition to be put in (about 30 mins) then took one of the dealership mechanics on a test drive to hear the noise. noise was heard and took it back to the shop. checked under the car and nothing wrong could be found. the lead mechanic took it for a test drive but due to the heavy downpour of rain nothing was heard. i was asked to bring the car back on monday due to possible severity of the situation. dropped the car back off at the dealership monday. a test drive and a look under the car and they found the problem, noise coming from rack and pinion while hitting bumps rack worn and needs replacement steering column making noise as well recommend replacement with out replacement the car would eventually have no steering ability at all: cost $1524 no warranty. this car has had the power steering recall replacement (the steering wheel suddenly stopped working while in a parking lot due to broken pinion) in 2010 and a transmission issue (rpm rev when the car hit 40 when the gas was not being applied) that was a worn seal it was fixed and covered by warranty in 2011. this would be the twice now with no steering ability only its a different cause? i feel like i'm being cheated. *tr | |||
| 08/01/2012 | 97000 | ||
| I noticed a slight tapping/rattling noise coming from the front driver side. the noise only occurs between the speeds of 50-60 mph and only when letting off the gas completely. then i received in the mail an ignition cylinder recall. my car had problems with locking up and difficulties turning the key. so i took the car to the dealership told them about the noise i was hearing then waited a week with no call from the dealership so i called them. they told me my car would be finished by noon, i arrived at 4 pm. they then told me my car was not yet finished. the dealership had not even put in the new ignition cylinder even after a week. i was told the noise could not be replicated. i waited for the ignition to be put in (about 30 mins) then took one of the dealership mechanics on a test drive to hear the noise. noise was heard and took it back to the shop. checked under the car and nothing wrong could be found. the lead mechanic took it for a test drive but due to the heavy downpour of rain nothing was heard. i was asked to bring the car back on monday due to possible severity of the situation. dropped the car back off at the dealership monday. a test drive and a look under the car and they found the problem, noise coming from rack and pinion while hitting bumps rack worn and needs replacement steering column making noise as well recommend replacement with out replacement the car would eventually have no steering ability at all: cost $1524 no warranty. this car has had the power steering recall replacement (the steering wheel suddenly stopped working while in a parking lot due to broken pinion) in 2010 and a transmission issue (rpm rev when the car hit 40 when the gas was not being applied) that was a worn seal it was fixed and covered by warranty in 2011. this would be the twice now with no steering ability only its a different cause? i feel like i'm being cheated. | |||
| 02/22/2012 | 50000 | ||
| Purchased 2008 car used in 2010 with approx. 10k miles. have had several issues with stereo speakers going out. car now has less than 60k miles. recently developed knock in front when going over bumps. took car to dealer to have recalled steering box fixed. chevrolet says lower control arm bushings, front struts are leaking, and sway bar end links need replaced soon. almost $1500 dollars. not covered under warranty though online search shows rampant issues. | |||
| 12/12/2011 | 69700 | ||
| Tl-the contact owns a 2008 chevrolet cobalt. the contact was driving 65 mph when the vehicle began to shake uncontrollable. the vehicle was taken to the dealer who replaced the struts, control arm, bushings axle, cv joints, sway bar bushings, brake pads, and the rotors but to no avail. the manufacturer was notified of the failure who advised that because the contact purchased the vehicle used, they could not offer any assistance. the failure mileage was 69,700. kmj | |||
| 12/12/2011 | 69700 | ||
| Tl-the contact owns 2008 chevrolet cobalt. the contact stated while driving 65 mph the vehicle shimmers and shakes uncontrollable. the vehicle was taken to the dealer who replaced the struts, control arm, bushings axle/cv joints. sway bar bushings, brake pads and rotors but the vehicle continues to shimmer and shake. the manufacturer was notified who stated because he purchase the vehicle used they cannot offer any assistance. the failure mileage was 69,700. mw | |||
| 10/25/2010 | 16000 | ||
| Vehicle was taken to the dealership in oct 2011 at apprx 16,000 miles to check loud noise coming from front suspension area. dealer replaced power steering motor according to recall and replaced part of steering column. however, that did not fix the issue. this is my elderly mother's car and she did not recognize the noise was not usual or that the repair did not address the problem. vehicle now has 20,000 miles (nov 2011) and mechanic diagnosed lower control arm bushings are shot. this is apparently a common problem for this model & year. dealer does not consider this a safety issue. i think it is--possibility of suspension components failing. | |||
| 06/10/2011 | 19300 | ||
| Tl- the contact owns a 2008 chevrolet cobalt. the contact stated that while making a turn at 5 mph, the front passenger side lower control arm bushings failed. the vehicle was taken to the dealer who replaced the lower control arm under the warranty. four months later while driving 30 mph, the contact drove over a road bump and a noise was heard from the left side of the vehicle. the vehicle was taken to a mechanic who inspected the noise and noticed that the driver side control arm bushings failed. the vehicle was repaired. the manufacturer was contacted but they offered no assistance. the failure mileage was 19,300 and the current mileage was 22,368. kmj | |||
| 06/10/2011 | 19300 | ||
| Tl-the contact owns 2008 chevrolet cobalt. the contact stated while making a turn at 5 mph the right lower control arm bushings in the front failed. the vehicle was taken to the dealer who replaces the right lower control arm under the warranty. four months later while driving 30 mph and hit a bump there was a noise coming from the left side of the vehicle. the vehicle was taken to a mechanic shop who inspected the noise and noticed the left control arm bushings failure. they replaced the left lower control arm at the owners expense of $559. the contact wanted to be reimbursed for this cost who notified the manufacturer. they refused to reimburse the amount back to the contact. they offered no other assistance. the failure mileage was 19,300 and the current mileage was 22,368. mw | |||
| 10/01/2011 | 58000 | ||
| Tl* the contact owns a 2008 chevrolet cobalt. the contact stated that he cut his hand on the front driver side interior door handle. the contact noticed that the chrome was peeling off from both door handles on the driver's side. the vehicle was not taken to have the failure diagnosed or repaired. the contact also stated that the front sway bar was previously replaced because it was worn. the failure mileage was 58,000. | |||
| 10/01/2011 | 58000 | ||
| Tl- the contact owns a 2008 chevrolet cobalt. the contact stated that he cut his hand on the front driver side interior door handle. the contact noticed that the chrome was peeling off from both door handles on the driver's side. the vehicle was not taken to have the failure diagnosed or repaired. the contact also stated that the front sway bar was previously replaced because it was worn. the failure mileage was 58,000. kmj | |||
| 10/01/2011 | 58000 | ||
| Tl-the contact owns a 2008 chevrolet cobalt. the contact stated that he cut his hand on the interior door handle on the front driver's side. upon examining the door handles, the contact noticed that the chrome was peeling off from both door handles on the driver's side. the vehicle was not taken to have the failure diagnosed or repaired. the contact also stated that the front sway bar was previously replaced because it was worn out. the failure mileage was 58,000. sm. | |||
| 01/25/2010 | 10000 | ||
| Tl-the contact owns a 2008 chevrolet cobalt. the control arm bushings has fail. whenever driving and there is a bump in the road and the vehicle runs over it the entire front end rattles as if falling apart. the vehicle was taken to the dealer previously and it was repaired under the warranty but the problem is back again. the manufacture was not call. the failure mileage was 10,000....mw | |||
| 09/10/2009 | 40000 | 1 | |
| I have a 2008 chevy cobalt that was purchased new and with 51,000 miles on it i have replaced the lower control arm on the right side, sway bar bushing, sway bar, and tires. and now i have to fix the left side i also have a friend that had the same car, same year and about the same mileage he also had to do the same repairs. *tr | |||
| SUSPENSION - FRONT | |||
| 03/14/2010 | 47950 | ||
| The vehicle is past the warranty mileage limits. i noticed several days ago a loud clunking noise while going over the slightest bump coming from the front end. i had the vehicle in for a oil change and tire rotation and asked to have the front end checked. the control arm bushings are worn out and i have to pay $300+ for the repair. granted, i am outside the mileage limits of the warranty, but this vehicle is barely three years old. it appears i'm not the first to complain either. i have been a chevrolet and gm fan for years, but with this issue plus the problems i had with my last pickup, a 2004 gmc sierra, i'm beginning to question my choices. | |||
| SUSPENSION - REAR | |||
| 04/16/2010 | 22000 | ||
| My son was driving his chevy cobalt home and when he tried to stop he had trouble. it felt like the back tire was going to fall off. he ended up hitting a car. upon inspection, we found that the rear suspension on the passenger side had lost the nut and washer. it has been repaired at our expense even though it was under warranty. | |||