Bulletins
Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
---|---|---|---|---|---|
STRUCTURE | |||||
3043D | 3043E | 10009981 | Water leak on drivers floor. *tc | 11/03/2004 | |
3112 | 01/01/2004 | 10010073 | Roof ditch molding may loose. *sc | 11/03/2004 | |
01914 | 01/01/2004 | 10006818 | Roof weld joint reveal molding replacement (ditch molding). *tt | 05/14/2004 | |
01833 | 01/01/2004 | 10006666 | Intentional lack of sealant at headboard of pickup box. *mr | 05/07/2004 | |
01943 | 01/01/2004 | 10006492 | Water leak left right floor. *mr | 05/04/2004 | |
STRUCTURE - BODY | |||||
01292004 | 01/29/2004 | 10013034 | Orange peel paint condition. *tt | 04/06/2005 | |
02242004 | 02/24/2004 | 10013002 | Lack of seam sealer at the headboard of the pick-up box on regular and extended cabs. *tt | 04/05/2005 | |
040851001 | 02/01/2004 | 10012684 | Repair procedure for paint concern. *eh | 03/10/2005 | |
040857004 | 09/01/2006 | 040857004B | 10011234 | Water on driver's floor. *eh | 01/11/2005 |
3105 | 01/01/2004 | 10010224 | Body side moldings become loose/rpo b84. *sc | 11/04/2004 | |
3043A | 01/01/2004 | 3043B | 10009381 | Water leak on drivers floor. *tt | 09/27/2004 |
02061A | 01/01/2004 | 10007854 | Water leaks on drivers floor. *tt | 07/13/2004 | |
01612 | 01/01/2004 | 10007141 | Paint orange peel condition. *tt | 05/27/2004 | |
01537 | 01/01/2004 | 10005477 | Regular production accessory installation information. dealerships should refrain from installing bed extenders. the current build of certain vehicles prevents the tailgate from being closed when the bed extender brackets are properly ins | 03/01/2004 | |
STRUCTURE - BODY - BUMPERS | |||||
09142004 | 09/14/2004 | 10011258 | Bumper bolt breakage during removal prior to installing trailer hitches. *eh | 01/12/2005 | |
3053 | 10010368 | Bumper bolt and or nut breaks when attempting removal. *tt | 11/17/2004 | ||
3053A | 01/01/2004 | 3053B | 10009676 | When removing the rear bumper to install a trailer hitch, the right bolt may break or the spot weld holding the nut in place breaks loose. *tt | 10/15/2004 |
STRUCTURE - BODY - DOOR | |||||
03102005 | 03/10/2005 | 10014849 | Removal of door trim. *eh | 05/10/2005 | |
3200 | 10010591 | Drivers or passengers door switch bezel. *eh | 12/01/2004 | ||
STRUCTURE - BODY - TAILGATE | |||||
3575 | 10017301 | Rear tailgate hard to open. *tt | 11/02/2005 | ||
STRUCTURE - FRAME AND MEMBERS | |||||
PIT-3749D | 11/01/2010 | 10037570 | Ready | 05/25/2011 | |
PIT-3749D | 11/01/2010 | 10037570 | Gm: on some truck models there is some frame corrosion. *rm | 05/25/2011 | |
STRUCTURE - FRAME AND MEMBERS - UNDERBODY SHIELDS | |||||
01942 | 01/01/2004 | 01942A | 10006494 | Rattle noise rear of extended cab. *mr | 05/04/2004 |
Consumer Complaints
Fail date | miles | occurences | Purchase date |
---|---|---|---|
STRUCTURE | |||
11/15/2009 | 95000 | ||
Tl*the contact owns a 2004 chevrolet colorado. the contact observed water leaking on the front drivers side floor panel area. the water accumulation resulted to mold. the vehicle was taken to an authorized dealer for inspection. there was uncertainty of the repair performed on the vehicle. the failure continued after the service repair. the manufacturer was notified which there was no resolution. the failure mileage was 95,000. the current mileage was 99, 333. | |||
08/15/2007 | 55000 | 8 | 05/04/2004 |
I noticed my floor was soaking wet after a long rain... i checked the windows and doors to make sure they were not left open...my truck leaks somewhere from within. my buddy said it is probably the firewall... now my truck smells like mildew and continues to leak, im afraid it might mold and cause me or my family to get sick. the windows always fog up as a result of the dampness, making it harder to see at night. *tr | |||
09/24/2007 | 50000 | 1 | 10/05/2004 |
This is pertaining a chevy 2004 colorado ls pick-up truck with black paint. i'm noticing the paint is blistering. this is not only happening on the hood, but also along the side panels. when the paint comes off, it is going to bare metal. *tr | |||
01/25/2005 | 13742 | 5 | 05/29/2004 |
Recurring incidence of failure of driver side window and lock/unlock buttons on both drivers side and passenger side door pad inoperable at indeterminate periods of time. odi 10150643: recurring narrative complaint #1 dealer response; dealer customer copy invoice: left front window inop, window works everytime, never duplicated customer complaint. door locks will not operate with remote locks working everytime. we tried. never duplicated customer complaint. cd player/radio power will shut itself completely off. upon pushing power knob, and selecting cd aux button the cd player will not play, eject, or load 6-disc cd player. dealer customer copy invoice: sometimes cd player will not take or eject cd. cd player not taking or ejecting cd. found calibration for radio. recalibrate radio with tech 2. cd working ok now. upon engaging abs system on dangerous road conditions the driver must apply extreme pressure on brake pedal. abs system engages with extreme vibration and noise, brake pedal will be engaged to the floor and pedal will push back with resistant and then fails to respond. resulting in car taking longer to come to a complete stop and tires to lock up without shifting power to alternate tire. dealer customer copy invoice: when you stop real hard feels like pedal goes to floor and vehicle doesn't want to stop. test operation of brakes. operating as designed at this time. advise customer of abs operation no problem found with brakes. driving on ideal road conditions and/or off road conditions, back of bed rattles and loud rattling noise is observed inside and outside of vehicle. dealer customer copy invoice: bed of truck rattles. test drove found trailer hitch rattling. also front license bracket loose and making a lot of noise. remove bracket and install bigger push in tabs. adjust hood, it was a little loose and making noise. lube hood latch also. courtsey transportation-rental- total invoice... 0.0. *nm | |||
09/01/2005 | 1 | 04/01/2004 | |
2004 chevrolet colorado does not have acceleration when pulling out into traffic from a stop.*mr the consumer stated he discovered water in the floorboard. *jb | |||
05/01/2005 | 7 | ||
2004 chevrolet colorado experiencing problems with the air bags, defective tires, body structure, water leakage, electrical problems, and slippage of the automatic transmission.***no answer required***. *mr the starter was stuck, the wiring harness in the roof laying on the door caused a short when the door was fully opened, power mirror was inoperative, the door locks opened on their own and there were missing screws in the fender. the consumer requested reimbursement for the replaced tires and for the missing screws. *sc the master switch wa replaced and the seams behind the brake booster area were resealed. *jb | |||
06/09/2004 | 1 | ||
Paint on truck, midnight blue, very delicate. chips and scratches all over truck. scratches down to primer. owned just over a month, excellent truck, skimpy paint job.*ak | |||
04/12/2004 | 1 | 03/12/2004 | |
The wind noise is absolutely unbearable. after you get up to 40 mph and close the windows it souinds like a tornadp inside the truck, and this should not be. called the reginal rep and was told that is the way it is and there is nothing they can do about it. *ak | |||
STRUCTURE - BODY | |||
11/16/2009 | 76000 | 1 | |
Found large amount of water on the passenger side of the cabin (front and back) of 2004 colorado after a heavy rain. windows and doors were closed. carpet is soaking wet and is beginning to smell like mildew. seats and sides of cabin area were not wet. *tr | |||
02/08/2009 | 1 | ||
I have water leaking into the cab onto my drivers side floorboard right next to the kick panel. i have tried to fix it using tsb bulletin no: 04-08-57-004a from august 2006. the problem has not been resolved and the problem is still the same. *tr | |||
11/18/2006 | 51451 | 0 | 02/24/2004 |
Water leaking into cab of 2004 chevrolet colorado, per dealer this would not be covered, talked to local gmc dealer they stated this was a problem with this same model but (gmc) and have fixed numberes pickups. they fixed the pickup and charged me $780.00 for this repair | |||
STRUCTURE - BODY - DOOR | |||
05/02/2005 | 24649 | 4 | 06/10/2004 |
6 months after purchasing a brand new 2004 chevrolet colorado zq8 3.5l extended cab i noticed while driving on the highway wind noise coming from the passenger door as if the door was not completely closed. 2 months later and it was so loud i had to turn my radio over half volume just to listen to my radio. i had the truck seen by the dealership which i bought it and they said that the cause was misaligned. the b4000 door assembly front right align 9635 w5 0.30. they adjusted the door and for 2 months there was no wind noise. the problem keeps occurring needing alignment. i also have a problem with the screws coming loose on the driver side door causing a metal binding sound everytime i open and close the door. each time i open and close the door the screws are loose enough to were i can hand tighten them. i also had a computer problem in this vehicle as well. a year after having my vehicle out of nowhere and no warning my truck would not start. it would crank over but would not start. i had it towed to the dealership and the invoice states: scan computer codes p2610 stored in pcm. mandy codes stored in bcm. ran bulletin search. found pcm failure replace pcm. reprograms and clear codes recheck ok. however since the new computer was placed in the truck the alarm light will come on and stay on every once in a while. *nm | |||
07/20/2004 | 0 | 1 | 07/20/2004 |
Drivers door hitting bottom rear of door jam, repaired and painted under warrntya. pasengers door not closing without slamming. rear door rehung and front door rehung and close ok but there is a 3/32 inch gap at the bottom in between the doors and a 3/8 inch gap at the top. the dealer says that is ok and i should accept it since the doors work of. i do not agree and feel that if that is as good as it gets that the vehicle was bent, racked, torqued during manufacture or transport.*ak | |||
06/26/2004 | 1 | ||
Problems with door locks on 2004 chevrolet colorado.*mr several hours after the truck was delivered the consumer discovered that there was only one key access to the vehicle on the driver's side. there was no key lock on the passenger side. someone has to unlock the driver's side door then crawl over to unlock the passenger side door from the inside. the dealer was informed and told the customer that the vehicle was delivered from the factor that way. *nm | |||
06/21/2004 | 6843 | 2 | 03/25/2004 |
Water leak from driver's side door.*ak | |||
STRUCTURE - BODY - TAILGATE | |||
07/28/2007 | 75000 | 1 | 06/01/2004 |
Tl*the contact owns a 2004 chevrolet colorado. the contact stated that when he opened the tailgate, the cable failed and the tailgate would not remain open. the dealer did not inspect the vehicle, however, they stated that there was a recall for the cable. there was no recall listed on the nhtsa website. as of august 3, 2007, the vehicle has not been repaired. the current and failure mileages were 75,000. updated 02-01-08. *kb the consumer stated both cables were failed at the same time and dealer replaced both cables at 8/10/07 at n/c. updated 02/01/08 *tr | |||
02/01/2004 | 200 | 1 | 01/27/2004 |
Less than a week after i purchased the 2004 gm colorado pickup truck the tailgate open on the expressway and the cabinet i was hauling fell off the truck into the road causing an accident. i was sure the door was shut securely but somehow it just opened up.*ak |