Chevrolet G Series 1995
Model G Series made in 1995 by Chevrolet got 22 consumer complains as well as 28 service bulletins. Consumer complaints with reference, among others things, to air bags and engine and engine cooling. Technical service bulletines regarding electrical system and engine and engine cooling.
Model 1995
Bulletins
Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
---|---|---|---|---|---|
ELECTRICAL SYSTEM - IGNITION - MODULE | |||||
677153A | 06/01/1997 | 67-71-53 | 52572 | No upshift/2nd gear only after cold start-intermittent dtc 87 - high ratio error (replace eprom). *tw | 08/21/1997 |
ELECTRICAL SYSTEM - STARTER ASSEMBLY | |||||
01404 | 12/01/1995 | 46864 | Some customers may comment about a starter click-no-crank condition in cold ambient temperatures below 15 degrees f. *sd | 04/25/1996 | |
576403 | 05/01/1995 | 44055 | Starter motor continues to run or crank after the engine is running or turned off (solenoid ground wire). *tw | 11/01/1995 | |
ENGINE AND ENGINE COOLING - ENGINE | |||||
776306 | 02/01/1998 | 600430 | Comments of a no start, stall condition. *yc | 05/14/1998 | |
ENGINE AND ENGINE COOLING - ENGINE - GASOLINE | |||||
000601023A | 12/01/2001 | 000601023 | 628938 | Information used when diagnosing noise conditions such as engine rattle noise, spark knock at 2000 - 2500 rpm range, under a moderate to heavy load with a warmed up engine. *tt | 03/25/2002 |
000604002 | 01/01/2000 | 609709 | Subject regarding a hard, no start or excessive gray or white smoke condition on start up after recent glow plug replacement. *tt | 04/06/2000 | |
576115 | 06/01/1995 | 43026 | Unknown | 11/01/1995 | |
ENGINE AND ENGINE COOLING - EXHAUST SYSTEM - MANIFOLD/HEADER/MUFFLER/TAIL PIPE | |||||
376602A | 01/01/1995 | 37-66-02 | 39070 | New cast iron exhaust manifold and stainless steel gasket to correct engine noise condition. *tw | 03/06/1995 |
EQUIPMENT - ELECTRICAL - AIR CONDITIONER | |||||
631216 | 12/01/1996 | 50561 | Insufficient a/c performance and/or noisy compressor clutch due to premature wear of the compressor shaft seals. *tw | 05/27/1997 | |
FUEL SYSTEM, GASOLINE - DELIVERY - FUEL PUMP | |||||
666309 | 04/01/1997 | 52350 | Engine hard to start (replace fuel pump pulsator). *tw | 07/24/1997 | |
FUEL SYSTEM, GASOLINE - FUEL INJECTION SYSTEM | |||||
00064C | 09/01/2002 | 00064B | 635817 | A failure of the electronic diesel fuel injection pump, leaking to complaints of poor performance or fuel economy, hard / no starts, hesitation, as well as illumination of the service engine soon light. *tt | 11/01/2002 |
00064B | 02/01/2002 | 0006A | 629423 | Some customers may experience a failure of the electronic diesel fuel injection pump. *jg | 04/02/2002 |
00064B | 02/01/2002 | 00064A | 628910 | Special policy adjustment for vehicles experiencing a failure of the electronic diesel fuel injection pump, leading to complaints of poor performance of fuel economy, hard/ no starts, hesitation, as well as illumination of the service engin | 03/22/2002 |
00064A | 03/23/2001 | 00064 | 619204 | Special policy adjustment for vehicles experiencing a failure of the electronic diesel fuel injection pump leading to complaints of poor performance or fuel economy, hard / no starts, hesitation, as well as illumination of the service engin | 05/18/2001 |
00064A | 03/01/2001 | 00064 | 619170 | Some vehicles may experience a failure of the electronic diesel fuel injection pump, leading to complaints of poor performance or fuel economy, hard / no starts, hesitation, as well as illumination of the service engine soon light. | 05/17/2001 |
00064 | 09/19/2000 | 619065 | Deductible reimbursement clarification and vin breakpoint correction to 00064 - special policy adjustment - electronic diesel-fuel injection pump failure - repair / replace. *tt | 05/11/2001 | |
00064 | 09/01/2000 | 6092348 | Failure of the electronic diesel fuel injection pump, leading to complaints of poor performance or fuel economy, hard / no starts, hesitation, illumination of the service engine soon light. *tt | 12/05/2000 | |
POWER TRAIN - AUTOMATIC TRANSMISSION | |||||
577126A | 02/01/1997 | 51354 | Transmission fluid leak from pump body (replace bushing). *tw | 12/21/1999 | |
9674L60E04A | 04/01/1997 | 52554 | Transmission fluid leak from pump body (replace bushing). *tw | 08/14/1997 | |
577126B | 04/01/1997 | 57-71-26A | 52105 | Transmission fluid leak from pump body (replace bushing). *tw | 07/17/1997 |
577126R | 02/01/1997 | 57-71-26 | 51502 | Transmission fluid leak from pump body/replace bushing. *tw | 06/27/1997 |
577103 | 02/01/1995 | 39303 | Transmission leak at rear extention housing and prop shaft. *tw | 11/01/1995 | |
CAMP/95C32 | 06/01/1995 | 43002 | Unknown | 11/01/1995 | |
MSG01376 | 11/01/1994 | 37831 | Message to dealers announcing manufacturer recall 95c14. *tw | 01/10/1995 | |
STEERING - HYDRAULIC POWER ASSIST - PUMP | |||||
573201 | 06/01/1995 | 45845 | Power steering pump pulley misalignment (move pulley forward). *sd | 04/25/1996 | |
SUSPENSION - REAR - SPRINGS - LEAF SPRING ASSEMBLY - U-BOLT, LEAF SPRING TO AXLE | |||||
GM563402 | 04/01/1995 | 41077 | Leaf spring u-bolt anchor plate contacts jounce bumper bracket on side rail (install new u-bolts and anchor plate). *tw | 11/01/1995 | |
UNKNOWN OR OTHER | |||||
MSG95C24/C32 | 08/01/1995 | 45860 | The subject campaigns are both being revised to increase the time allowance for for the g-van models to 2.4 hours. *sd | 04/25/1996 | |
VEHICLE SPEED CONTROL | |||||
776306A | 08/01/1998 | 609676 | Fuel solenoid driver located on the side of the fuel injection pump failed, causing vehicle to no start or stall. | 04/06/2000 |
Consumer Complaints
Fail date | miles | occurences | Purchase date |
---|---|---|---|
AIR BAGS - FRONTAL | |||
07/08/1995 | 1 | ||
Frontal collision and the vans airbag did not deploy at 55 mph. tt | |||
ENGINE AND ENGINE COOLING - ENGINE | |||
10/06/1995 | 6 | ||
Oil sending unit failed. | |||
ENGINE AND ENGINE COOLING - ENGINE - GASOLINE | |||
05/28/1995 | 8 | ||
Engine failed twice. *tt | |||
ENGINE AND ENGINE COOLING - EXHAUST SYSTEM - EMISSION CONTROL - CATALYTIC CONVERTOR | |||
08/01/2000 | 2 | 07/01/2000 | |
Problem checked 2 times by dealer he says its ok van has no heat shields. *ak | |||
FUEL SYSTEM, GASOLINE | |||
11/19/2010 | 113850 | ||
Tl- the contact owns a 1995 chevrolet geo tracker. the contact stated that the pipe that holds the gas tank has rotted almost causing it fail off. the dealer had not been contacted. the manufacturer had not been contacted. the vehicle had not been repaired. the current mileage was 122,501. the failure mileage was 113,850. bw | |||
FUEL SYSTEM, GASOLINE - FUEL INJECTION SYSTEM | |||
09/24/1998 | |||
Vehicle continues to stall while driving vehicle due to fuel injection pump failure. vehicle been in/out dealer shop on numerous times and condition still occurs. dealer notified and cannot resolve problem. *ak | |||
OTHER | |||
03/25/1996 | 1 | 09/01/1995 | |
Arm rests positioned too hight, interfering w/free movement of driver's arm. | |||
POWER TRAIN - DRIVELINE - DIFFERENTIAL UNIT | |||
10/06/1995 | 6 | ||
Ring and pinion gears replaced due to noise from rear of vehicle. | |||
SEAT BELTS - FRONT - ANCHORAGE | |||
05/29/1996 | 9 | ||
Armrest holds seat belt against pillar. *sd | |||
06/01/1995 | 1 | ||
Rear captain chair seat belt too short. *dsh | |||
SEAT BELTS - FRONT - BUCKLE ASSEMBLY | |||
09/01/2000 | 1 | 06/01/1996 | |
I only used the sofa rear seat occasionally. had a child using it last friday and had to make a sudden stop. the seat belt came apart and i found that it had been pieced together with staples. the conversion company refuses to accept responsibility. after they found out i only had 14,000 miles on the van, that agreed to supply the part, but they will not pay for the labor. i have had the van for 4 years, but previously only used it to transport a handicapped child in the front or middle areas. i was very lucky that the child in the faulty seat belt was not injured. i feel that the conversion company who installed the belt was negligent and it could have caused a major injury. | |||
SEATS | |||
05/24/1995 | 4 | ||
Captains chair positon handle inoperable. *tt | |||
SERVICE BRAKES, HYDRAULIC - ANTILOCK | |||
08/09/1997 | 1 | ||
Consumer has applied the brakes and the abs brakes make a grinding noise. the brakes have been replaced at 14,000 miles, the second time 18,000 miles. then they grounded the rims at 24,000 miles, changing rotors and pads. again at 32,000 miles changed rotors and pads. *ak | |||
09/26/1995 | 5 | ||
Antilock brakes failed 5 times, once causing accident. *sd | |||
SERVICE BRAKES, HYDRAULIC - FOUNDATION COMPONENTS | |||
10/06/1995 | 6 | ||
Brakes failed to stop vehicle, resulting in accident, also front pads worn badly while rear pads show no wear at all. *dsh | |||
SERVICE BRAKES, HYDRAULIC - FOUNDATION COMPONENTS - DISC | |||
08/09/1997 | 1 | ||
Consumer has applied the brakes and the abs brakes make a grinding noise. the brakes have been replaced at 14,000 miles, the second time 18,000 miles. then they grounded the rims at 24,000 miles, changing rotors and pads. again at 32,000 miles changed rotors and pads. *ak | |||
VISIBILITY - REARVIEW MIRRORS/DEVICES - EXTERIOR | |||
02/07/1996 | 7 | ||
Right side rearview mirror makes objects look further away than they really are, causes difficulty judging when it is safe to change lanes. *dsh |