Investigations
| NHTSA ID | Manufacturer | Date open | Date close | Subject | Recall campaign | |
|---|---|---|---|---|---|---|
| STEERING - HYDRAULIC POWER ASSIST - PUMP | ||||||
| PE04004 | GENERAL MOTORS CORP. | 01/08/2004 | 04/30/2004 | HYDRAULIC PUMP SHAFT FAILURES | ||
| The preliminary evaulation is being upgraded.during the ea odi will limitits investigation to only those vehicles equipped with a hydro-boost system, which provides power assist to the braking and steering sytems.vaccuum brake booster vehicles are excluded.odi hasexpanded the scope of the ea to include model years2003 and 2004, asduring the pe, odi learned that the hydroboast pumps were modified in febraury 2004.therefore,odi has expanded the scope to include the additional model years.odi's is concerned because thisisa sudden failure that affects two critical systems of the vehicle, brakes and steering, at the same time.the ability of the operator to handle the dual failures is a concern. further, these vehicles tend to be work vehicles, with some over 10,000 pounds gvwr and many equipped to pull large trailers.dual failures of heavily loaded vehicles and vehicles pulling trailers further increases the safety risk.odi plans to conduct testing to quantify the braking and steering performance degradation and the impact on safe vehicle control, when a hydroboast pump fails. | ||||||
| STEERING - HYDRAULIC POWER ASSIST SYSTEM | ||||||
| EA04012 | GENERAL MOTORS CORP. | 04/30/2004 | 02/28/2005 | HYDRAULIC PUMP FAILRES | 05V005000 | |
| Gm is conducting a recall on all subject vehicles build between may 1999 and october 14, 1999.significant changes were incorporated into production in early october 1999, and vehicles built after that date have lower warranty failure rates.the complaint and warranty data appear to support the effectiveness of these changes. gm made additional changes in november 1999, february 2000, may 2001, and february 2004.odi will continue to monitor this problem and will take further action, if warranted, in the future.for further technical details see the attached engineering analysis report. | ||||||
| PE04004 | GENERAL MOTORS CORP. | 01/08/2004 | 04/30/2004 | HYDRAULIC PUMP SHAFT FAILURES | ||
| The preliminary evaulation is being upgraded.during the ea odi will limitits investigation to only those vehicles equipped with a hydro-boost system, which provides power assist to the braking and steering sytems.vaccuum brake booster vehicles are excluded.odi hasexpanded the scope of the ea to include model years2003 and 2004, asduring the pe, odi learned that the hydroboast pumps were modified in febraury 2004.therefore,odi has expanded the scope to include the additional model years.odi's is concerned because thisisa sudden failure that affects two critical systems of the vehicle, brakes and steering, at the same time.the ability of the operator to handle the dual failures is a concern. further, these vehicles tend to be work vehicles, with some over 10,000 pounds gvwr and many equipped to pull large trailers.dual failures of heavily loaded vehicles and vehicles pulling trailers further increases the safety risk.odi plans to conduct testing to quantify the braking and steering performance degradation and the impact on safe vehicle control, when a hydroboast pump fails. | ||||||
Consumer Complaints
| Fail date | miles | occurences | Purchase date |
|---|---|---|---|
| STEERING - HYDRAULIC POWER ASSIST SYSTEM | |||
| 03/09/2000 | 08/31/1999 | ||
| Happened to be turning around in a parking lot, pulled out into the highway with bumper to bumper traffic, felt power steering jump. then, there was no power steering or brakes, even at a low speed 5mph. the only way to stop vehicle was with the emergency brakes. *ak *ml | |||
| STEERING - LINKAGES | |||
| 11/13/2003 | 25000 | 2 | |
| The steering linkages failed while driving. as a result, vehicle produced a violent shaking motion. recal 00v054000 was issued; however, this vehicle was not included due to vin. *ak | |||