Chevrolet K3500 2001
Model K3500 made in 2001 by Chevrolet got 12 consumer complains, 9 investigations there is 1 recall as well as 10 service bulletins. Consumer complaints with reference, among others things, to brakes, engine and engine cooling and fuel/propulsion system. Technical service bulletines regarding engine and engine cooling, exterior lighting and fuel system, gasoline. The car had some investigations: engine and engine cooling, service brakes, hydraulic and steering. There was one recall concerning interior lighting .
Model 2001
Recalls
| Campaign | Manufacturer | Manufacturing date | Type | # of units affected | Date Owner notified Mfg | Recall Initiated by | Manufacturers of recalled vehicles/products | Report Recieved Date | Record Creation Date | Regulation Part Number | FMVSS Number | |||||
|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|
| INTERIOR LIGHTING | ||||||||||||||||
| 01V220000 | GENERAL MOTORS CORP. | from 04/01/2001 to 06/15/2001 | V (Vehicle) | 38863 | 07/09/2001 | MFR | GENERAL MOTORS CORP. | 06/26/2001 | 07/03/2001 | 571 | 105 | |||||
| Defect Summary | Vehicle description: certain pickup trucks equipped with 6.6l diesel engines fail to comply with requirements of fmvss no. 105, hydraulic and electric brake systems. these vehicles have a brake system warning light in the instrument cluster that may not illuminate when the brake fluid is low. in addition, when the brake fluid is low, the vehicle may not meet the partial system requirements of fmvss no. 105. | |||||||||||||||
| Consequence Summary | These conditions could result in reduced braking capability, which could lead to a crash. | |||||||||||||||
| Corrective Summary | Dealers will change the location of a wire connection in the underhood bussed electrical center. owner notification began july 9, 2001. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact chevrolet at 1-800-222-1020 or gmc at 1-800-462-8782. | |||||||||||||||
| Notes | Also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236). | |||||||||||||||
Bulletins
| Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
|---|---|---|---|---|---|
| ENGINE AND ENGINE COOLING - ENGINE - GASOLINE - BELTS AND ASSOCIATED PULLEYS | |||||
| 020601010 | 03/01/2002 | 632326 | Information on serpentine belt identification and diagnosis for certain hd pickup models. *tt | 07/12/2002 | |
| EXTERIOR LIGHTING - HEADLIGHTS | |||||
| 3170E | 10019186 | Ipc, interior lights and/or headlamps flicker. *ak fb2 | 02/16/2006 | ||
| FUEL SYSTEM, GASOLINE - DELIVERY - FUEL PUMP | |||||
| 010604037B | 10/01/2001 | 010604037A | 627790 | Information regarding fuel transfer pump inoperative. *yh | 02/25/2002 |
| INTERIOR LIGHTING | |||||
| 3170E | 10019186 | Ipc, interior lights and/or headlamps flicker. *ak fb2 | 02/16/2006 | ||
| POWER TRAIN - AUTOMATIC TRANSMISSION | |||||
| 000730017B | 01/01/2002 | 000730017A | 631802 | Subject regarding service parts resriction program for allison series 1000 automatic transmission. *slc | 06/20/2002 |
| 010417001B | 03/01/2002 | 010417001A | 629551 | Subject regarding launch shudder on acceleration (install new one-piece propeller shaft) *jg | 04/02/2002 |
| POWER TRAIN - AXLE ASSEMBLY | |||||
| 010417001 | 02/01/2001 | 619173 | Some extended and crew cab long box pickup models including 1999 and 2001 chevrolet k2500 models with automatic transmission may exhibit a vibration (launch shudder) during acceleration from 0-40 km/h (0-25). | 05/17/2001 | |
| POWER TRAIN - DRIVELINE - DIFFERENTIAL UNIT | |||||
| 010417001A | 06/01/2001 | 010417001 | 623047 | Some customers may comment on a vibration during acceleration from 0 - 40 km/h (0 - 25 mph). *tt | 10/25/2001 |
| UNKNOWN OR OTHER | |||||
| 010856004A | 09/01/2001 | 010856004 | 627635 | Information regarding security lamp illumination on the instument panel, engine stalls. *yh | 02/13/2002 |
| 010856004 | 08/01/2001 | 625163 | Information regarding security lamp illuminating on the instrument panel, engine stall, no start, and diagnosic trouble code b2960. *slc | 11/19/2001 | |
Investigations
| NHTSA ID | Manufacturer | Date open | Date close | Subject | Recall campaign | |
|---|---|---|---|---|---|---|
| ENGINE AND ENGINE COOLING | ||||||
| EA06016 | GENERAL MOTORS CORP. | 09/14/2006 | 11/09/2007 | CRANK POSITION SENSOR FAILURE - STALL | 07V521000 | |
| In a letter dated november 7, 2007, general motors (gm) reported to the office of defects investigation (odi) that it will conduct a safety recall (07v-521) to replace the crank position sensor (ckp) in approximately 12,000 model year (my) 2001 chevrolet silverado and gmc sierra vehicles equipped with 8.1 liter engines manufactured on or before november 15, 2000.according to gm, the ckp can fail intermittently or permanently.a permanent ckp failure would result in an engine stall without restart.an intermittent ckp failure could cause the service engine soon light to illuminate, the vehicle to run rough or the engine to stall but allows restart.as a remedy, an improved ckp will be installed in the subject vehicles.the recall campaign will start in december 2007. during the preliminary evaluation (pe06-016), and this ea investigation, gm and odi independently conducted detailed reviews of certain field data to understand the nature and rate of subject vehicle stalling due to ckp failures.gm and odi reviewed gm's warranty claims for the ckp with the objective of ascertaining an estimate of those claims representing an engine stall while driving.the ckp warranty claims without verbatim text were the largest segment of warranty claims.using those claims, gm surveyed vehicle owners to gather additional information to determine if the claim was associated with a stall while driving event.based on the survey, gm estimated that approximately 49% of all warranty repairs for the ckp involved a stall while driving.odi | ||||||
| ENGINE AND ENGINE COOLING - ENGINE | ||||||
| EA06016 | GENERAL MOTORS CORP. | 09/14/2006 | 11/09/2007 | CRANK POSITION SENSOR FAILURE - STALL | 07V521000 | |
| In a letter dated november 7, 2007, general motors (gm) reported to the office of defects investigation (odi) that it will conduct a safety recall (07v-521) to replace the crank position sensor (ckp) in approximately 12,000 model year (my) 2001 chevrolet silverado and gmc sierra vehicles equipped with 8.1 liter engines manufactured on or before november 15, 2000.according to gm, the ckp can fail intermittently or permanently.a permanent ckp failure would result in an engine stall without restart.an intermittent ckp failure could cause the service engine soon light to illuminate, the vehicle to run rough or the engine to stall but allows restart.as a remedy, an improved ckp will be installed in the subject vehicles.the recall campaign will start in december 2007. during the preliminary evaluation (pe06-016), and this ea investigation, gm and odi independently conducted detailed reviews of certain field data to understand the nature and rate of subject vehicle stalling due to ckp failures.gm and odi reviewed gm's warranty claims for the ckp with the objective of ascertaining an estimate of those claims representing an engine stall while driving.the ckp warranty claims without verbatim text were the largest segment of warranty claims.using those claims, gm surveyed vehicle owners to gather additional information to determine if the claim was associated with a stall while driving event.based on the survey, gm estimated that approximately 49% of all warranty repairs for the ckp involved a stall while driving.odi | ||||||
| SERVICE BRAKES, HYDRAULIC | ||||||
| PE04004 | GENERAL MOTORS CORP. | 01/08/2004 | 04/30/2004 | HYDRAULIC PUMP SHAFT FAILURES | ||
| The preliminary evaulation is being upgraded.during the ea odi will limitits investigation to only those vehicles equipped with a hydro-boost system, which provides power assist to the braking and steering sytems.vaccuum brake booster vehicles are excluded.odi hasexpanded the scope of the ea to include model years2003 and 2004, asduring the pe, odi learned that the hydroboast pumps were modified in febraury 2004.therefore,odi has expanded the scope to include the additional model years.odi's is concerned because thisisa sudden failure that affects two critical systems of the vehicle, brakes and steering, at the same time.the ability of the operator to handle the dual failures is a concern. further, these vehicles tend to be work vehicles, with some over 10,000 pounds gvwr and many equipped to pull large trailers.dual failures of heavily loaded vehicles and vehicles pulling trailers further increases the safety risk.odi plans to conduct testing to quantify the braking and steering performance degradation and the impact on safe vehicle control, when a hydroboast pump fails. | ||||||
| SERVICE BRAKES, HYDRAULIC - POWER ASSIST | ||||||
| PE04004 | GENERAL MOTORS CORP. | 01/08/2004 | 04/30/2004 | HYDRAULIC PUMP SHAFT FAILURES | ||
| The preliminary evaulation is being upgraded.during the ea odi will limitits investigation to only those vehicles equipped with a hydro-boost system, which provides power assist to the braking and steering sytems.vaccuum brake booster vehicles are excluded.odi hasexpanded the scope of the ea to include model years2003 and 2004, asduring the pe, odi learned that the hydroboast pumps were modified in febraury 2004.therefore,odi has expanded the scope to include the additional model years.odi's is concerned because thisisa sudden failure that affects two critical systems of the vehicle, brakes and steering, at the same time.the ability of the operator to handle the dual failures is a concern. further, these vehicles tend to be work vehicles, with some over 10,000 pounds gvwr and many equipped to pull large trailers.dual failures of heavily loaded vehicles and vehicles pulling trailers further increases the safety risk.odi plans to conduct testing to quantify the braking and steering performance degradation and the impact on safe vehicle control, when a hydroboast pump fails. | ||||||
| EA04012 | GENERAL MOTORS CORP. | 04/30/2004 | 02/28/2005 | HYDRAULIC PUMP FAILRES | 05V005000 | |
| Gm is conducting a recall on all subject vehicles build between may 1999 and october 14, 1999.significant changes were incorporated into production in early october 1999, and vehicles built after that date have lower warranty failure rates.the complaint and warranty data appear to support the effectiveness of these changes. gm made additional changes in november 1999, february 2000, may 2001, and february 2004.odi will continue to monitor this problem and will take further action, if warranted, in the future.for further technical details see the attached engineering analysis report. | ||||||
| SERVICE BRAKES, HYDRAULIC - POWER ASSIST - HYDRAULIC | ||||||
| PE04004 | GENERAL MOTORS CORP. | 01/08/2004 | 04/30/2004 | HYDRAULIC PUMP SHAFT FAILURES | ||
| The preliminary evaulation is being upgraded.during the ea odi will limitits investigation to only those vehicles equipped with a hydro-boost system, which provides power assist to the braking and steering sytems.vaccuum brake booster vehicles are excluded.odi hasexpanded the scope of the ea to include model years2003 and 2004, asduring the pe, odi learned that the hydroboast pumps were modified in febraury 2004.therefore,odi has expanded the scope to include the additional model years.odi's is concerned because thisisa sudden failure that affects two critical systems of the vehicle, brakes and steering, at the same time.the ability of the operator to handle the dual failures is a concern. further, these vehicles tend to be work vehicles, with some over 10,000 pounds gvwr and many equipped to pull large trailers.dual failures of heavily loaded vehicles and vehicles pulling trailers further increases the safety risk.odi plans to conduct testing to quantify the braking and steering performance degradation and the impact on safe vehicle control, when a hydroboast pump fails. | ||||||
| STEERING - HYDRAULIC POWER ASSIST - PUMP | ||||||
| PE04004 | GENERAL MOTORS CORP. | 01/08/2004 | 04/30/2004 | HYDRAULIC PUMP SHAFT FAILURES | ||
| The preliminary evaulation is being upgraded.during the ea odi will limitits investigation to only those vehicles equipped with a hydro-boost system, which provides power assist to the braking and steering sytems.vaccuum brake booster vehicles are excluded.odi hasexpanded the scope of the ea to include model years2003 and 2004, asduring the pe, odi learned that the hydroboast pumps were modified in febraury 2004.therefore,odi has expanded the scope to include the additional model years.odi's is concerned because thisisa sudden failure that affects two critical systems of the vehicle, brakes and steering, at the same time.the ability of the operator to handle the dual failures is a concern. further, these vehicles tend to be work vehicles, with some over 10,000 pounds gvwr and many equipped to pull large trailers.dual failures of heavily loaded vehicles and vehicles pulling trailers further increases the safety risk.odi plans to conduct testing to quantify the braking and steering performance degradation and the impact on safe vehicle control, when a hydroboast pump fails. | ||||||
| STEERING - HYDRAULIC POWER ASSIST SYSTEM | ||||||
| EA04012 | GENERAL MOTORS CORP. | 04/30/2004 | 02/28/2005 | HYDRAULIC PUMP FAILRES | 05V005000 | |
| Gm is conducting a recall on all subject vehicles build between may 1999 and october 14, 1999.significant changes were incorporated into production in early october 1999, and vehicles built after that date have lower warranty failure rates.the complaint and warranty data appear to support the effectiveness of these changes. gm made additional changes in november 1999, february 2000, may 2001, and february 2004.odi will continue to monitor this problem and will take further action, if warranted, in the future.for further technical details see the attached engineering analysis report. | ||||||
| PE04004 | GENERAL MOTORS CORP. | 01/08/2004 | 04/30/2004 | HYDRAULIC PUMP SHAFT FAILURES | ||
| The preliminary evaulation is being upgraded.during the ea odi will limitits investigation to only those vehicles equipped with a hydro-boost system, which provides power assist to the braking and steering sytems.vaccuum brake booster vehicles are excluded.odi hasexpanded the scope of the ea to include model years2003 and 2004, asduring the pe, odi learned that the hydroboast pumps were modified in febraury 2004.therefore,odi has expanded the scope to include the additional model years.odi's is concerned because thisisa sudden failure that affects two critical systems of the vehicle, brakes and steering, at the same time.the ability of the operator to handle the dual failures is a concern. further, these vehicles tend to be work vehicles, with some over 10,000 pounds gvwr and many equipped to pull large trailers.dual failures of heavily loaded vehicles and vehicles pulling trailers further increases the safety risk.odi plans to conduct testing to quantify the braking and steering performance degradation and the impact on safe vehicle control, when a hydroboast pump fails. | ||||||
Consumer Complaints
| Fail date | miles | occurences | Purchase date |
|---|---|---|---|
| BRAKES | |||
| 07/12/2012 | 96000 | 1 | |
| My truck has excessive undercarrige rust, to the point of reduced material thickness on the frame and all frame mounted components. have experience one fuel line failure and fear additonal failures of fuel and brake lines. also all suspension mounting points have large metal flakes coming off. ## vin passed ## chevrolet silverado 2001 ##. *tr | |||
| ENGINE AND ENGINE COOLING - ENGINE | |||
| 12/15/1999 | 1 | 1 | 12/15/1999 |
| I own a 2001 chevy silverado k3500 with the 6.0l engine. my vehicle has consumed oil from day one and this problem is getting worse. i traveled to ohio last month and used one quart in about 450 miles. this is outrageous. now i must give you some background on myself. my previous vehicle was a 1995 gmc sierra k3500 with a 7.4l engine, both the 2001 and the 1995 i purchased new. i followed the manufacturer's directions on breaking in the vehicle in both cases. the 1995 vehicle never consumed oil, even at 145,000 miles. i check my oil at least once a week, that is a disgrace for a vehicle that is only three years old. my vehicle also knocks and pings all the time. i have called the dealership i purchased the vehicle from at two different occasions and have received two different stories. i am tired of the run around treatment by the dealer and by chevy when i call the chevy help line, work it out with the dealer is all i'm told. i am aware of a possible class action lawsuit against chevrolet for the engine problems. i would appreciate any information or assistance you could offer in this matter. *la | |||
| ENGINE AND ENGINE COOLING - ENGINE - GASOLINE | |||
| 05/28/2004 | 1 | 08/01/2002 | |
| 2001 k3500 w/ 8100 v8. vehicle uses 3 to 4 quarts of oil in between oil changes (every 3,000 ml.). i'm not getting much action from the dealer & my warenty is almost out!!*ak | |||
| FUEL/PROPULSION SYSTEM | |||
| 07/12/2012 | 96000 | 1 | |
| My truck has excessive undercarrige rust, to the point of reduced material thickness on the frame and all frame mounted components. have experience one fuel line failure and fear additonal failures of fuel and brake lines. also all suspension mounting points have large metal flakes coming off. ## vin passed ## chevrolet silverado 2001 ##. *tr | |||
| SERVICE BRAKES, HYDRAULIC - FOUNDATION COMPONENTS | |||
| 15096 | |||
| Consumer states that brake system was so excessively rusted and corroded that the vehicle's stopping distance had tripled. the dealer turned the rotors but reinstalled same brake pads. there exists only 2.5 inches of surface on the rotors left for pads to hit. | |||
| STRUCTURE - FRAME AND MEMBERS - UNDERBODY SHIELDS | |||
| 07/12/2012 | 96000 | 1 | |
| My truck has excessive undercarrige rust, to the point of reduced material thickness on the frame and all frame mounted components. have experience one fuel line failure and fear additonal failures of fuel and brake lines. also all suspension mounting points have large metal flakes coming off. ## vin passed ## chevrolet silverado 2001 ##. *tr | |||
| SUSPENSION | |||
| 07/12/2012 | 96000 | 1 | |
| My truck has excessive undercarrige rust, to the point of reduced material thickness on the frame and all frame mounted components. have experience one fuel line failure and fear additonal failures of fuel and brake lines. also all suspension mounting points have large metal flakes coming off. ## vin passed ## chevrolet silverado 2001 ##. *tr | |||
| VEHICLE SPEED CONTROL - ACCELERATOR PEDAL | |||
| 07/17/2003 | 3 | ||
| On three separate occasions while driving on the highway accelerator pedal stopped working. vehicle would not accelerate in drive or reverse. dealer replaced the pedal software on 7/17/2003. *ak | |||
Car dealers selling
| State | City | Zip | Name | Phone |
|---|---|---|---|---|
| MI | TRAVERSE CITY | WILLIAMS CHEVROLET | ||
| OH | DAYTON | WHITE ALLAN CHEVROLET |