Recalls
Campaign | Manufacturer | Manufacturing date | Type | # of units affected | Date Owner notified Mfg | Recall Initiated by | Manufacturers of recalled vehicles/products | Report Recieved Date | Record Creation Date | Regulation Part Number | FMVSS Number | |||||
---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|
SERVICE BRAKES, HYDRAULIC | ||||||||||||||||
05V043000 | GENERAL MOTORS CORP. | from 07/01/2004 to 09/30/2004 | V (Vehicle) | 77411 | 03/23/2005 | MFR | GENERAL MOTORS CORP. | 02/08/2005 | 02/08/2005 | |||||||
Defect Summary | Certain trucks, sport utility vehicles, and vans equipped with bosch hydro-boost brake assemblies, the hydraulic brake booster pressure accumulator may crack and separate from the hydro-boost assembly during normal operating conditions. | |||||||||||||||
Consequence Summary | If a separation occurred and the hood of the vehicle were open, fragments from the accumulator could cause injury to people in the immediate area. the presence of this crack or fractured surface could allow the hydraulic fluid to leak from the accumulator circuit of the booster assembly. the loss of fluid would cause increased steering and braking effort and a crash may occur without prior warning. | |||||||||||||||
Corrective Summary | Dealers will test the hydro-boost assembly for functional operation of the two-function valve. if the hydro-boost assembly fails the test, dealers will replace the assembly free of charge. the recall began on march 23, 2005. owners may contact chevrolet at 1-800-630-2438, gmc trucks at 1-866-996-9463 and hummer at 1-800-732-5493. | |||||||||||||||
Notes | Gm recall no. 05006.customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov. | |||||||||||||||
SERVICE BRAKES, HYDRAULIC - FLUID | ||||||||||||||||
05V288000 | GENERAL MOTORS CORP. | from 05/01/2004 to 06/30/2004 | V (Vehicle) | 6698 | 07/12/2005 | MFR | GENERAL MOTORS CORP. | 06/16/2005 | 06/20/2005 | |||||||
Defect Summary | Certain 2003-2005 model year 4500/5500 series chevrolet kodiak, school bus chassis, and gmc topkick vehicles; and 2003-2004 model year gmc school bus chassis vehicles equipped with an 8.1l engine and hydromax brake system. the power steering hose may come into contact with a portion of the intermediate steering shaft. a hole could be worn in the hose and a loss of hydraulic fluid would occur. | |||||||||||||||
Consequence Summary | If there is sufficient amount of fluid loss, the driver will hear a noise from the power steering pump, the brake warning light and warning tone will activate. increased effort may be required for steering and braking, increasing the risk of a crash. | |||||||||||||||
Corrective Summary | Gm will notify its customers and dealers will reroute the power steering hose. if the steel braiding of the hose is exposed, dealers are to replace the hose free of charge. the recall began on july 12, 2005. owners may contact chevrolet at 800-630-2438 or gmc at 866-996-9463. | |||||||||||||||
Notes | Gm recall no. 05051.customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov. |
Bulletins
Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
---|---|---|---|---|---|
SERVICE BRAKES, AIR | |||||
070522001 | 02/01/2007 | 10021330 | Brake light switch inoperative, brake warning buzzer sounding and brake warning light on, dtc's c0164, c0272 set. (remove and splice wire/remove chmsl fuse/replace stop lamp switch). *kb | 04/04/2007 | |
050527001 | 02/01/2005 | 10017531 | Information on air brake park brake chamber vent holes to avoid water intrusion. *tt | 11/09/2005 | |
SERVICE BRAKES, AIR - ANTILOCK | |||||
4174 | 4174A | 10022080 | Abs control module parts restriction. *kb | 07/05/2007 | |
SERVICE BRAKES, AIR - ANTILOCK - ABS WARNING LIGHT | |||||
PIP-4643 | 05/01/2009 | 10030727 | Gmc/chevrolet: the speedometer is inoperative, abs lamp may be on and if equipped the transfer case may not shift or make random phantom shifts. models include the kodiak and topkick 4500/5500 series. *pe | 11/23/2009 | |
SERVICE BRAKES, AIR - ANTILOCK - WHEEL SPEED SENSOR | |||||
PI-00983A | 06/01/2011 | 10039488 | Ready | 08/01/2011 | |
SERVICE BRAKES, AIR - SUPPLY - COMPRESSOR | |||||
SB05-08-133-001B | 09/01/2009 | 10033631 | Isuzu/gmc/chevrolet: diagnostic information for inoperative air seats, air horn and/or exhaust brake and release of new auxiliary air compressor relay and pressure switch on rpo k16 vehicles. *pe | 08/30/2010 | |
SERVICE BRAKES, AIR - SUPPLY - LOW PRESSURE WARNING | |||||
SB05-08-133-001B | 09/01/2009 | 10033631 | Isuzu/gmc/chevrolet: diagnostic information for inoperative air seats, air horn and/or exhaust brake and release of new auxiliary air compressor relay and pressure switch on rpo k16 vehicles. *pe | 08/30/2010 | |
SERVICE BRAKES, HYDRAULIC | |||||
PIT-4515A | 10/01/2009 | 10032452 | Gmc/chevrolet: service brake soon indicator with dtc c0272. some customers may state the service brake soon indicator comes on. may also comment the audible brake warning buzzer is sounding. *pe | 03/26/2010 | |
PIT-4935 | 10/01/2009 | 10032455 | Chevrolet/gmc: brake assist pump motor on and warning light/chime. owners may comment when turning the steering wheel with the brake applied that the hydraulic brake assist pump turns on and the brake warning lamp and chime may sound. mo | 03/26/2010 | |
4173 | 4173B | 10022081 | Hydraulic brake booster parts restriction. *kb | 07/05/2007 | |
060522005 | 12/01/2006 | 060522005A | 10021099 | Hydraulic brake booster master cylinder diagnostics, hydra max system. *kb | 03/05/2007 |
4042 | 10020051 | Diagnostic guide for bosch hydraulic brake booster. *tt | 07/14/2006 | ||
3479 | 09/01/2008 | 3479D | 10014886 | Location of auxiliary brake control harness/wire u86 option. *tt updated 12/2/08. *pe | 05/11/2005 |
SERVICE BRAKES, HYDRAULIC - ANTILOCK - ABS WARNING LIGHT | |||||
PIP-4643 | 05/01/2009 | 10030727 | Gmc/chevrolet: the speedometer is inoperative, abs lamp may be on and if equipped the transfer case may not shift or make random phantom shifts. models include the kodiak and topkick 4500/5500 series. *pe | 11/23/2009 | |
060525001 | 01/01/2006 | 10019476 | Antilock brake system (abs) lamp illuminated, diagnostic trouble code (dtc) c0550) set. *tt | 03/15/2006 | |
3767 | 3767A | 10018570 | Abs light on with dtc c0550 on medium duty models c65 and c75. *tt | 01/06/2006 | |
SERVICE BRAKES, HYDRAULIC - ANTILOCK - WHEEL SPEED SENSOR | |||||
PI-00983A | 06/01/2011 | 10039488 | Ready | 08/01/2011 | |
SERVICE BRAKES, HYDRAULIC - POWER ASSIST | |||||
PIT-4935 | 10/01/2009 | 10032455 | Chevrolet/gmc: brake assist pump motor on and warning light/chime. owners may comment when turning the steering wheel with the brake applied that the hydraulic brake assist pump turns on and the brake warning lamp and chime may sound. mo | 03/26/2010 | |
SERVICE BRAKES, HYDRAULIC - POWER ASSIST - HYDRAULIC | |||||
PIT-4935 | 10/01/2009 | 10032455 | Chevrolet/gmc: brake assist pump motor on and warning light/chime. owners may comment when turning the steering wheel with the brake applied that the hydraulic brake assist pump turns on and the brake warning lamp and chime may sound. mo | 03/26/2010 |
Consumer Complaints
Fail date | miles | occurences | Purchase date |
---|---|---|---|
SERVICE BRAKES, HYDRAULIC | |||
05/01/2008 | 3000 | 1 | 12/31/2007 |
Tl*the contact owns a 2005 chevrolet kodiak. the contact has been experiencing issues with the exhaust brakes on his vehicle. the brakes have been replaced numerous times over the years, but the failure persists. the exhaust brakes have been shutting off at the wrong time. the brakes are supposed to shut off when coming to a stop or traveling 15 mph; however, they have been shutting off while traveling 30-45 mph. as a result, the vehicle has no braking system. the vehicle has been taken to the dealer and repair shops approximately four times. during each visit, the mechanic replaces different parts within the exhaust braking system, but they have been unable to repair the failure. since the vehicle is currently not under warranty, the dealer refuses to remedy the failure. the failure mileage was 3,000 and current mileage was 14,000. the fuel gauge was inoperative. the consumer stated the fule gauge pegs out and is not accurate. the cruise control was inoperative. updated 02/04/09. *jb |