Recalls
Campaign | Manufacturer | Manufacturing date | Type | # of units affected | Date Owner notified Mfg | Recall Initiated by | Manufacturers of recalled vehicles/products | Report Recieved Date | Record Creation Date | Regulation Part Number | FMVSS Number | |||||
---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|
FUEL SYSTEM, GASOLINE | ||||||||||||||||
06E043000 | HONEYWELL INTERNATIONAL, INC. | E (Equipment) | 88303 | 10/18/2006 | MFR | GENERAL MOTORS CORP. | 05/19/2006 | 05/22/2006 | ||||||||
Defect Summary | Certain replacement fuel filters, fram brand name p/n g3727, with date codes x52911 through x60801 sequentially or x600141 and a mexico country or origin marking on the fuel filter housing manufactured from october 18, 2005, through march 21, 2006, sold for use on the vehicles listed above and on certain school buses. (to see the school bus engine sizes, click on document search and then bus applications). the connector on the fuel filter was not manufactured to honeywell's specification. as a result, the o-ring may not seat correctly on the fuel line. | |||||||||||||||
Consequence Summary | This condition may cause an inadequate seal at the connection, potentially leading to a fuel leak. in the presence of an ignition source, a fire could occur. | |||||||||||||||
Corrective Summary | Honeywell will notify owners and replace the fuel filters free of charge. the recall began on october 18, 2006. owners may contact fram customer service at 1-800-890-2075 (option 1). | |||||||||||||||
Notes | This recall only pertains to aftermarket fram fuel filters and has no relation to any original equipment installed on the vehicles listed.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov. | |||||||||||||||
FUEL SYSTEM, OTHER - STORAGE - TANK ASSEMBLY - PRESSURE RELIEF DEVICES | ||||||||||||||||
07E021000 | DELPHI | E (Equipment) | 742 | 04/27/2007 | MFR | GENERAL MOTORS CORP. | 03/12/2007 | 03/12/2007 | ||||||||
Defect Summary | Certain delphi fuel pressure regulators, p/nos. fp10020-11b1, fp10026-11b1, and fp10027-11b1, sold after january 9, 2007, as aftermarket equipment for various passenger vehicles listed above. the universal pressure regulators (upr) were produced without an o'ring and retainer. | |||||||||||||||
Consequence Summary | Fuel may leak, possibly resulting in a fire. | |||||||||||||||
Corrective Summary | Delphi will notify owners and replace the upr free of charge. the recall began on april 23, 2007. owners can contact delphi at 877-411-8770. | |||||||||||||||
Notes | This recall only pertains to aftermarket delphi fuel pressure regulators and has no relation to any original equipment installed by general motors.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov. |
Consumer Complaints
Fail date | miles | occurences | Purchase date |
---|---|---|---|
FUEL SYSTEM, GASOLINE | |||
05/04/2004 | 199000 | 1 | 05/15/1998 |
Vehicle caught on fire 15 minutes after being parked in the driveway. the local fire department arrived to extinguish the fire. the fire also damaged another vehicle, the right side of the garage, and an upper room. the cause of the fire was determined to have been caused by one of two things, either fuel leakage or electrical. the dealer was not notified.*ak vehicle has had fuel injection system repaired in 2001 and 2002. right signal repaired in jan. 2004, headlight dimmer switch repaired in april for texas inspection. then vehicle caught on fire in may. *bf *nm | |||
09/02/2000 | 1 | ||
Consumer was traveling about 35mph on a side street, applied brakes and lost control of vehicle, he ended up inside of a parking lot, subframe fell in the street.*ak. consumer discovered that there was a recall for the exact same model of vehicle for the same problem, but his vehicle was not included, also the rear brakes were inoperative, a starter, 2 alternators, 2 water pumps, a bad crankcase oil leak, 2 serpentine belts, the left front window was inoperative, a new thermostat, a fuel pump, fuel injector, tie rod end, the rear strut fell apart, the steering joint became completely disengaged from the subgrame, the light switch on the steering column was inoperative.*jb | |||
FUEL SYSTEM, GASOLINE - CARBURETOR SYSTEM | |||
08/01/1995 | |||
Oil leaks from manifold. tt | |||
12/23/1994 | 1 | ||
Engine oil leak due to intake manifold failure. *ak | |||
FUEL SYSTEM, GASOLINE - DELIVERY | |||
11/01/1999 | 05/31/1991 | ||
Consumer noticed corrosion and rust on the fuel line/brake line, and suspension components, in both front and rear. if parts rust all the way through, it could eventually lead to loss of control. also, both rear caliper slide pins seized, causing premature brake pad wear. both rear calipers and all brake pads had to be replaced. *ak | |||
FUEL SYSTEM, GASOLINE - DELIVERY - FUEL PUMP | |||
09/02/2000 | 1 | ||
Consumer was traveling about 35mph on a side street, applied brakes and lost control of vehicle, he ended up inside of a parking lot, subframe fell in the street.*ak. consumer discovered that there was a recall for the exact same model of vehicle for the same problem, but his vehicle was not included, also the rear brakes were inoperative, a starter, 2 alternators, 2 water pumps, a bad crankcase oil leak, 2 serpentine belts, the left front window was inoperative, a new thermostat, a fuel pump, fuel injector, tie rod end, the rear strut fell apart, the steering joint became completely disengaged from the subgrame, the light switch on the steering column was inoperative.*jb | |||
FUEL SYSTEM, GASOLINE - DELIVERY - HOSES, LINES/PIPING, AND FITTINGS | |||
10/18/1999 | 9 | 09/21/1991 | |
While traveling 55 mph vehicle stalls without indication. dealer has been notified, can' t duplicate problem. also,alternator/battery/computer, and fuel filter line failed and were replaced by dealer. *ak | |||
04/14/1993 | 1 | ||
Replaced fuel filter. *ak | |||
FUEL SYSTEM, GASOLINE - FUEL INJECTION SYSTEM - INJECTORS | |||
09/01/1996 | 1 | 06/01/1991 | |
Fuel injectors failed, causing vehicle to stall. | |||
08/07/1996 | 2 | ||
Electronic control module failed, also fuel injectors/wiring harness failure. *ak | |||
FUEL SYSTEM, GASOLINE - STORAGE - TANK ASSEMBLY | |||
08/28/1995 | |||
Plastic liner shattered in fuel tank, froze fuel gauge, had to replace fuel tank. *ak |