Bulletins
| Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
|---|---|---|---|---|---|
| ENGINE AND ENGINE COOLING - ENGINE - GASOLINE | |||||
| 876002A | 07/01/1998 | 876002 | 615073 | Some v6 engines may, on a very infrequent basis, have an oil odor condition that is generally encountered after the engine's oil has been changed.typically the odor lasts approximately 1000 miles after the change of oil and then does not re | 12/26/2000 |
| ENGINE AND ENGINE COOLING - EXHAUST SYSTEM | |||||
| 98033 | 10/19/1998 | 615100 | Voluntary emission campaign involving the evaporative emission canister purge solenoid valve replacement and, convertible only, prom replacement. *tt | 12/27/2000 | |
| 98033 | 11/10/1998 | 603002 | Evaporative emission canister purge solenoid vlave replacement and convertible only, prom replacement. *yc | 01/25/1999 | |
| 98033 | 10/01/1998 | 602746 | Voluntary emission recall campaign - evaporative emission conister purge solenoid valve replacement and, convertible only, prom replacement. *yc | 01/11/1999 | |
| ENGINE AND ENGINE COOLING - EXHAUST SYSTEM - EMISSION CONTROL - GAS RECIRCULATION VALVE (EGR VALVE) | |||||
| 676001 | 02/01/1997 | 51353 | Excessive oil consumption (replace pcv harness). *tw | 12/15/1999 | |
Consumer Complaints
| Fail date | miles | occurences | Purchase date |
|---|---|---|---|
| ENGINE AND ENGINE COOLING | |||
| 11/02/2003 | 153336 | 1 | |
| While driving 35 mph, consumer slowed to make a turn and vehicle stalled. the consumer was unable to steer due to the steering wheel being immobile. dealer was informed, but the manufacturer was not.*ak | |||
| ENGINE AND ENGINE COOLING - COOLING SYSTEM | |||
| 09/08/1999 | 1 | 03/01/1993 | |
| May owners have had this fail dealer has kit. repair cost $350 should be a recall.they know it!! | |||
| 07/21/1999 | 1 | 07/01/1993 | |
| On july 18, 1999, i left my car at the dealership. i wanted and oil change, check the battery as it was sluggish when starting and to check on a squeak in the rear of the car. the short version is the dealer called and advised that the coolant coupler is about to break off in the lower intake. the cost to repair would be about $700. i was not happy and did not let the dealer make this repair. when i picker up the car as the other items had been fixed, i had the mechanic show me the problem. he indicated that the coupling was about to break off. i asked him what would cause this problem and he advised that the coupling was poorly made by chevrolet and that the part was inherently defective as they had used very thin aluminum to make the part and that the engine coolant ate away the tube from the inside. he also indicated that the newer intake's coolant coupling was made of more substantial metal and that the replacement parts were made of better metal. he said that he see's these all the time. the part cost $12 and the rest is labor. i discusssed with the service manager who confirmed what the mechanic said. i called chevrolet, but did not get any type of answer except the car was out of warranty. i asked if there was anyone to appeal and the women said no. bottom line is it appears that a cheap part was used in manufacturing the vehicle that is not readily apparent during the warranty period. the other thing is i am not to sure that the mechanic might not have just broke the tube and is trying to blame it on chevrolet and make me pay for his mistake. if anything else is needed, please call or write. | |||
| 2 | |||
| 2 fuel pumps and 1 water pump failed. | |||
| 03/27/1996 | 2 | 03/01/1993 | |
| Head bolts in the engine broke several times. | |||
| ENGINE AND ENGINE COOLING - ENGINE | |||
| 09/16/2000 | 1 | 08/01/1997 | |
| Freeze plugs, piping from engine crumbling into transmission, fuel pump, alternator, corroded battery, engine mounts broken, the alternator dying made my cruise control go out a month earlier before it died. no warning lights came or come on. back end of car humms when it gets warmed up and continues until 30 seconds after i turn off car. | |||
| 09/25/1996 | 4 | 07/01/1996 | |
| The timing belt broke one month after purchasing. it has been replaced four times. the first time it was put on wrongly, went back to dealer, the second time it lasted one year, the third time it lasted two years, the fourth time was replaced on 12/27/99. *ak | |||
| 01/01/1996 | |||
| The mounts that hold the motor broke, causing a knocking noise and the engine bouncing up and down which may cause a loss of vehicle control. please provide further information. *ak | |||
| 03/25/1996 | 5 | ||
| Cylinder head bolt broke. *dsh | |||
| ENGINE AND ENGINE COOLING - ENGINE - GASOLINE | |||
| 12/27/2001 | 1 | ||
| While driving the vehicle caught on fire in the engine compartment (ohio traffic crash report). nlm | |||
| 12/14/1996 | 1 | 06/21/1993 | |
| Intermittent stalling. | |||
| 08/17/1995 | 7 | ||
| Engine failure. | |||
| ENGINE AND ENGINE COOLING - ENGINE - GASOLINE - BELTS AND ASSOCIATED PULLEYS | |||
| 1 | |||
| Whenever serpentine belt gets wet it slipps on the pulley, causes loss of power steering and power brakes and alternator light comes on. tt | |||
| ENGINE AND ENGINE COOLING - EXHAUST SYSTEM | |||
| 10/19/2000 | 10/01/2000 | ||
| Manufacturer notified for odi #736006 and odi #736059. no safety defec tmentioned in summary. *ak | |||
| 10/17/2000 | 10/01/2000 | ||
| Distinct odor of gas outside of car in rear trunk area/distinct odor of exhaust and oil coming into driver/passenger seating area of car thru front. dealer will not look into, my wife and baby were very sick on 11/5/00 due to odor traveling into auto thru ventilation system. chief mechanic is unable to smell what we experiance, and will not run diagnostic nor will inspect further to correct the situation. | |||
| 09/01/1996 | |||
| Parts have been replaced on left front brake, but it still squeals and locks up. and the exhaust can be smelled inside car, a very suffocatiing smell with the doors shut and windows up. *ak | |||
| 08/17/1995 | 7 | ||
| Pollution control devices failure. | |||
| ENGINE AND ENGINE COOLING - EXHAUST SYSTEM - EMISSION CONTROL | |||
| 05/31/1996 | 1 | 03/01/1993 | |
| Map/heat sensor failed, causing motor to overheat/burn out. | |||
| ENGINE AND ENGINE COOLING - EXHAUST SYSTEM - EMISSION CONTROL - CATALYTIC CONVERTOR | |||
| 10/19/2000 | 10/01/2000 | ||
| Please refer to odi #736006 for further information. this morning at the va hospital my carbon monoxide level reading was 10, which is equivalent to a one pack a day smoker. i am a non-smoker, the ventilation and/or exhaust system is in dire need of proper analysis and repair. my wife and baby were very sick on 11/5/00 following a trip to a near by town, after we traveled on the highway. | |||