Recalls
Campaign | Manufacturer | Manufacturing date | Type | # of units affected | Date Owner notified Mfg | Recall Initiated by | Manufacturers of recalled vehicles/products | Report Recieved Date | Record Creation Date | Regulation Part Number | FMVSS Number | |||||
---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|
FUEL SYSTEM, OTHER - STORAGE - TANK ASSEMBLY - PRESSURE RELIEF DEVICES | ||||||||||||||||
07E021000 | DELPHI | E (Equipment) | 742 | 04/27/2007 | MFR | GENERAL MOTORS CORP. | 03/12/2007 | 03/12/2007 | ||||||||
Defect Summary | Certain delphi fuel pressure regulators, p/nos. fp10020-11b1, fp10026-11b1, and fp10027-11b1, sold after january 9, 2007, as aftermarket equipment for various passenger vehicles listed above. the universal pressure regulators (upr) were produced without an o'ring and retainer. | |||||||||||||||
Consequence Summary | Fuel may leak, possibly resulting in a fire. | |||||||||||||||
Corrective Summary | Delphi will notify owners and replace the upr free of charge. the recall began on april 23, 2007. owners can contact delphi at 877-411-8770. | |||||||||||||||
Notes | This recall only pertains to aftermarket delphi fuel pressure regulators and has no relation to any original equipment installed by general motors.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov. |
Bulletins
Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
---|---|---|---|---|---|
FUEL SYSTEM, GASOLINE | |||||
836317 | 07/01/1998 | 615083 | Some operators of vehicles equipped with land mobile communcation systems, such as those utilized by law enforcement agencies, may comment on fuel pump related radio frequency interference during vehicle operation. *tt | 12/27/2000 | |
736313 | 06/01/1997 | 52563 | Reduced engine performance, restricted fuel flow (clean fuel tank, replace in-line fuel filter and fuel pump strainer). *tw | 08/14/1997 | |
FUEL SYSTEM, GASOLINE - FUEL INJECTION SYSTEM | |||||
971101776304 | 11/01/1997 | 54066 | Subject pertaining to driveability symptoms due to fuel injector deposits. *yc | 03/30/1998 | |
FUEL SYSTEM, GASOLINE - FUEL INJECTION SYSTEM - INJECTORS | |||||
98776304A | 02/01/1998 | 600282 | Some vehicles may experience a driveability symptom of long or hard starts, chuggle, rough idle and light or intermittent misfire. *yc | 05/05/1998 |
Consumer Complaints
Fail date | miles | occurences | Purchase date |
---|---|---|---|
FUEL SYSTEM, GASOLINE - DELIVERY - FUEL PUMP | |||
01/27/2003 | 39900 | 1 | 04/08/1998 |
Fuel filter burned up inside gas tank. the wires were burned and the plastic body was burned and charred. mechanic was surprised that there was no fire or explosion. he said it was probaly a manufacturer defect and being that i had a full tank of gas saved the car from going on fire. | |||
07/04/2000 | 0 | ||
While driving and went to accelerate and engine shutdown. mechanic listened to car, and could not hear fuel pump turning on. then, said that fuel pump had broken. mechanic drained fuel out, and noticed that electrical harness that was plugged into fuel pump shorted out, and caused it to melt. mechanic insisted that plug was never connected completely by manufacturer. consumer said when there would be a short and gas low enough, it could explode.*ak | |||
05/17/1999 | 07/01/1996 | ||
Fuel pump was noticed burning while being removed from engine; manufacturer notified. *ak | |||
The engine cut off, lost all power due to the fuel pump burning up. dealer said that fuel pump needed to be replaced. *ak | |||
1 | 07/26/1996 | ||
Fuel pump failed. | |||
FUEL SYSTEM, GASOLINE - DELIVERY - HOSES, LINES/PIPING, AND FITTINGS | |||
6 | 11/01/1995 | ||
Driving at approximately 35-40 mph ,going up or down hill vehicle will begin to hesitate, eventually causing the vehicle to stall. dealer cannot duplicate problem, but has replaced fuel filter and vehicle speed sensor. defect is still occurring. *ak | |||
FUEL SYSTEM, GASOLINE - FUEL INJECTION SYSTEM | |||
04/10/2003 | 3 | ||
The fuel injection system was defective, it was service on 3 occasions. *jb | |||
2 | 10/01/2098 | ||
Vehicle was serviced about 2 yrs ago because it started losing power and was running rough. the power window on driver side stopped functioning. brakes grind when wet even though they have been replaced. noticed around this time that the car temperature gauge sometimes creeped up above normal. it seemed to be losing anti-freeze. the heater stopped working. i refilled the anti-freeze. it seemed to take care of the problem but it slowly returned. vehicle was also very slowly losing oil. last month (10/02) i started home from work. the car suddenly overheated. strong fumes came into through the vents, burning my eyes. i had to stop repeatedly to let the car cool so that i could get home. i work only 3 miles from home. when i got home, the oil stick contained oil halfway up the stick. started over flowing from the oil cap when i restarted. smoke was heavy from the back. had someone check the car. the car is not functionable. will not turn over. replaced the starter but didn't help. there is oil in the radiator, water in the oil. seems to be fuel in the anti-freeze. appears to be a blown head gasket or more. have found out that this make and model year was recalled for motor problems previously paralleling these same problems. dt | |||
7 | |||
This vehicle has experienced a engine check light on or flashing many times throughout the past couple of years. it has stalled on the highway & had to be towed in multiple times. bulletins apply but the dealer said they had all been done, not according to the repair orders. it is an on going problem that they refuse to acknowledge despite the fact they have experienced the problem. letter has been sent to the dealer president without resolution & now one sent to gm. | |||
04/01/1999 | |||
There is a leak coming from power steering and from the o rings which is running from under the hood onto the engine. *ak | |||
FUEL SYSTEM, GASOLINE - FUEL INJECTION SYSTEM - FUEL RAIL | |||
1 | 07/26/1996 | ||
Vacuum hose failed resulting in it falling apart. | |||
FUEL SYSTEM, GASOLINE - FUEL INJECTION SYSTEM - INJECTORS | |||
1 | |||
6 fuel injectors failed. nl | |||
FUEL SYSTEM, GASOLINE - STORAGE - TANK ASSEMBLY | |||
Sending assembly in fuel tank melted. *ak |