Recalls
| Campaign | Manufacturer | Manufacturing date | Type | # of units affected | Date Owner notified Mfg | Recall Initiated by | Manufacturers of recalled vehicles/products | Report Recieved Date | Record Creation Date | Regulation Part Number | FMVSS Number | |||||
|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|
| STEERING - RACK AND PINION | ||||||||||||||||
| 02V286000 | GENERAL MOTORS CORP. | from 01/01/1996 to 06/30/1996 | V (Vehicle) | 1159156 | 01/24/2003 | ODI | GENERAL MOTORS CORP. | 11/04/2002 | 11/06/2002 | |||||||
| Defect Summary | Certain passenger vehicles and mini vans have lower pinion bearings in the power rack and pinion assembly in which the retainer tabs were not crimped properly. these and some other retainers used in vehicles assembled between january 1, 1996 and october 31, 1997, could fail and permit the ball bearings to escape. | |||||||||||||||
| Consequence Summary | If this occurs, the pinion shaft can be forced upward during left turns and back down as the steering wheel is moved back and to the right. if the pinion shaft moves further, the driver will need to exert more effort to turn the steering wheel, similar to a vehicle without power assisted steering. if the pinion shaft moves even further, the driver will require much higher effort to turn left and may not be able to turn the wheel as much as intended. with the maximum pinion shaft movement, which requires internal gear component damage, the driver can encounter high resistance to turning left, followed by unintended power assist to the right. in any of these conditions, a crash could occur. | |||||||||||||||
| Corrective Summary | Dealers will install a new lower pinion bearing unless inspect of the existing bearing indicates that replacement of the gear assembly is necessary. owner notification began january 24, 2003. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact chevrolet at 1-800-222-1020, pontiac at 1-800-762-2737, or oldsmobile at 1-800-442-6537. | |||||||||||||||
| Notes | Gm recall no. 02049.also, customers can contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236). | |||||||||||||||
Consumer Complaints
| Fail date | miles | occurences | Purchase date |
|---|---|---|---|
| STEERING - HYDRAULIC POWER ASSIST SYSTEM | |||
| After recall for the power steering assembly 02 v 286 000 was performed the power steering failed again. *nlm | |||
| STEERING - RACK AND PINION | |||
| 04/08/2004 | 2 | ||
| Experienced intermittent of power steering, lost steering control of the vehicle. replaced rack and pinion. *bf the vehicelk rack and pinion faield prior to receiving the recall notice. the driver's side power window motor failed, the alternator, air conditioning and windshield wiper assembly also failed. *nm | |||