Bulletins
| Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
|---|---|---|---|---|---|
| ENGINE AND ENGINE COOLING | |||||
| 9702019774T | 02/01/1997 | 52933 | Various information regarding overnight cold soak conditions. *yc | 11/13/1997 | |
| ENGINE AND ENGINE COOLING - COOLING SYSTEM | |||||
| 010602012 | 12/01/2001 | 628890 | Some owners may comment on leakage of a few drops of coolant after parking their vehicle. *tt | 03/21/2002 | |
| ENGINE AND ENGINE COOLING - COOLING SYSTEM - RADIATOR ASSEMBLY | |||||
| 676204 | 12/01/1996 | 50564 | Coolant loss, visible coolant leakage, low coolant lamp on or coolant odor caused by coolant leakage. *tw | 05/27/1997 | |
| ENGINE AND ENGINE COOLING - ENGINE | |||||
| 10172002 | 10/17/2002 | 10009489 | Engine starts and immediately stalls and then can be restarted and will run normally. *tt | 10/01/2004 | |
| 010601002A | 12/01/2002 | 010601002 | 10000782 | Revised piston pin removal / installation procedure. *tt | 03/31/2003 |
| 970501776109 | 05/01/1997 | 53011 | Exhibiting diagnostic trouble codes p0300, p0301, p0302, p0303, and p0304 indicating engine misfire conditions. *yc | 11/06/1997 | |
| ENGINE AND ENGINE COOLING - ENGINE - GASOLINE | |||||
| 020601014 | 04/01/2002 | 634708 | Subject regarding revised lower intake manifold installation. *tt | 10/07/2002 | |
| 010601010A | 06/01/2001 | 0106010101 | 620810 | Subject regarding polymer service pistons. *tt | 08/30/2001 |
| 990604005A | 04/01/2001 | 990604005 | 619360 | Some owners may comment on driveability symptons of long or hard starts, chuggle, rough idle and light or intermittent misfire due to clogged fuel injectors. *tt | 05/24/2001 |
| 130301 | 03/13/2001 | 619231 | Experiencing a no crank no start, crank no start, no start or a start doesn't run that may be accompanied by a theft system light and / or a service engine soon light. *tt | 05/19/2001 | |
| 876002A | 07/01/1998 | 876002 | 615073 | Some v6 engines may, on a very infrequent basis, have an oil odor condition that is generally encountered after the engine's oil has been changed.typically the odor lasts approximately 1000 miles after the change of oil and then does not re | 12/26/2000 |
| 000604005 | 01/01/2000 | 609712 | Some owners may comment on a cold engine idle hunt or surge. *tt | 04/07/2000 | |
| 990604005 | 02/01/1999 | 776304A | 604343 | Some owners may experience a driveability symptom of long or hard starts, chuggle, rough idle and light or intermittent misfire. *tt | 04/26/1999 |
| 98576124A | 06/01/1998 | 57-61-24 | 601915 | Comments on a ticking type noise that begins shortly after cold engine start-up and gradually diminishes as the engine warms up. *yc | 08/28/1998 |
| 970701776517 | 07/01/1997 | 52943 | Experiences with unstabled engine idle. *yc | 11/13/1997 | |
| ENGINE AND ENGINE COOLING - EXHAUST SYSTEM | |||||
| 971101776529 | 11/01/1997 | 54193 | Subject pertaining to instrument cluster resets when on-board ham radio is keyed. *yc | 03/30/1998 | |
Consumer Complaints
| Fail date | miles | occurences | Purchase date |
|---|---|---|---|
| ENGINE | |||
| 10/02/2006 | |||
| Car goes into lockdown frequently because of the theft alert system and you have to wait 10 minutes before the car will start. i believe this is a safety concern and potenetial hazard to anyone is operating this vechile. i called dealership to discuss this problem and there reply is well the car is old and you need to see about purchasing another one. i got this reply in 2007. i have also researched it on the internet and found that this is a common problem in chevy malibu's, which to me constitutes a manufacturing defect as well as a safety concern. | |||
| ENGINE AND ENGINE COOLING | |||
| 10/26/2010 | 146534 | ||
| Intake manifold on my 1997 chevy malibu has started to go bad i know its the lower gasket i called chevy after seeing so many other people with the same problem i was told chevy would not replace it due to it being over ten years old well it seems like with was a problem waiting to happen as soon as they sealed the manifold at the factory i think gm should replace this item once free of charge per car also my rack and pinion seems to stick on my left side ive replaced the power steering pump and checked the rack and pinion seems the ball bearing wanting to come out or is gone i told gm i dont think they replaced it when they recalled it and they told me the first owner did but wont send me paperwork on the repair or the dealership that did the work | |||
| 04/17/2009 | 53900 | 1 | |
| I have a 1997 chevy malibu (54,000) miles that seized up in traffic due to antifreeze in the oil. i have recently learned that the antifreeze (dexa-cool) use by gm has a long history of causing premature engine failures by eating away the gaskets, water pumps and other associated engine cooling components. i?m not able to take advantage of the class action law suit since my problem happened long after the closing date. i feel a national recall should be initiated by nhtsa. *tr | |||
| 02/04/2007 | 187000 | 6 | |
| I was driving my car on the byway and took the interstate merge lane while increasing my speed to merge into traffic i felt a snap in my steering wheel and gas pedal, i then lost the dash and the car immediately overheated, i had no real power to turn the wheel and the gas pedal was a loose push. being that i had merged onto the interstate when this occurred i had to drive an additional 5 miles to the next exit. not everyone has a cell phone. when i got to the next exit i was almost unable to turn the wheel enough to get it into the nearest parking lot, it was harder to turn than my first truck a 1959 ford twin i beam pickup. i fortunately didn't hit any one or anything. upon raising my hood after parking the car i am appalled to see that the tensioner pulley and one of the idler pulleys are gone and my serpentine belt is shredded. i have replaced the parts but since then i also found that within 5 miles the dreaded gaskets that so many people have complained about, and mine we already eating fluids in sipps before this, were gone. i have replaced the broken pulleys serpentine belt alternator waterpump and gaskets not a month later the other idler pulley that was unaffected in the first incident went. when the first two were replaced that dreaded squeaking stopped for about 3 days and started back up again. something must not be straight for me to have to keep replacing the moving parts that run on the serpentine belt and everytime one of them goes you loose your power steering and the car is hard to turn. not only that but the tail lights would be a better place for a gold fish than a light bulb. everytime it rains, or snows i have to replace tail lights. this car is the bane of my existence. i have the first idler pulley part still the rest of them were lost to the highway the thing is melted. *tr | |||
| 01/01/2005 | 50000 | 4 | |
| Suddenly brakes stopped working, and consumer's vehicle was involved in four collisions. . in the most recent collision consumer's vehicle struck the rear end of a truck at 30 mph. also, vehicle stalled and cuts off in traffic. *ak | |||
| 02/17/2004 | 8366 | 5 | |
| Vehicle stalled while driving. when this occurred the vehicle was towed to the dealer, who performed a diagnostic test in which no failure code was found. dealer was unable to find the cause of the problem.*ak | |||
| 07/14/2004 | 1 | ||
| While driving at any speed intermittently vehicle stalled. driver consumer had managed to get vehicle out of traffic. had tried to restart vehicle, and some times had to wait an hour to restart vehicle. however, vehicle was inspected by two separate dealerships, but could not duplicate or correct the problem.*ak | |||
| 10/04/2002 | 125358 | 3 | 10/02/2002 |
| Engine check light and the abs light illuminated while driving. vehicle been to a repair shop on 3 separate occasions, and the problem had not been resolved. vehicle had its gas tank cap replaced, and the brake system was overhauled. but problem recurred. *ak | |||
| 10/15/2003 | 96017 | ||
| Basically this is to complain about the gm 3.1l v6 engine in my 1997 chevrolet malibu. i understand that there are 1100 such complaints and would appreciate some help with my situation also. in the last couple of weeks my vehicle has begun to have a multitude of problems that had led up to my current fiasco. about 2 weeks ago after an oil change my 97 malibu began to have problems with a lifter ticking. my mechanic suspects a collapsed lifter; this has not been repaired yet. my car also now runs very rough and does not have the power it used to have. today 10/2/03 i had to drive into seattle and began to have a severe heating problem with the car. my wife and i were deathly afraid we were going to be stranded on the freeway somewhere or stuck in a part of seattle we did not feel very safe in. the temp gauge began to rise very quickly as we arrived at our destination just south of seattle, the needle was pegged and the temp light actually came on. i had dex-cool anti-freeze leaking all over the engine and all over the ground. we waiting approx 30 minutes before we started out again and yes were afraid the entire way home that we would get stranded on the road somewhere. i got the car to my mechanic and he has informed us that we probably need a new engine, on a car that only has 95,000 miles on it. i have read other complaints on the internet about the faulty gaskets which result in anti-freeze leaking into the engine causing bad camshafts, bad bearings and who knows what else. if i had the resources to dump the piece of junk i just might, however i do not have the recourses to do that, i must get it fixed. right now a $4000.00 dollar repair will not be good for my family. frankly i am tired of being sold junk, 20000.00 dollars might not be much too some people but it is to me. my car now is barely worth $4000.00 and the thought of putting $4000.00 into it just to get it running again makes me sick. i will think twice the next time about purchasing a gm product. | |||
| 12/17/2003 | 89000 | 1 | |
| Intake manifold gasket, 1997 chevrolet malibu (3.1 v6 engine). my understanding is that this is an extremely common problem with gm products, particularly this engine and car. i also searched the complaints dadabase and i found that it appears to be a common problem. also, theft system light coming and excessive brake pad wear and rotor warping appears to be a very common problem. this was fixed once, the problem is reaccuring. $1200 in major repairs so far on a 1997 chevrolet malibu, not to mention the other small but frequent repairs. i am dissatisfied with both of my recent gm products because they both had similar problems that lead to costy repairs or engine failure at 120,000 miles on a 1994 grand am and 89,000 miles on a 1997 malibu. i have had to fix the radio numerous times (cable comes unplugged quite often). *ak | |||
| 10/02/2003 | 95300 | 5 | 05/10/1997 |
| Basically this is to complain about the gm 3.1l v6 engine in my 1997 chevrolet malibu. i understand that there are 1100 complaints and would appreciate some help with my situation also. in the last couple of weeks my vehicle has started to have a multitude of problems that had led up to my current fiasco. about 2 weeks ago after an oil change, my 97 malibu began to have problems with a lifter | |||
| 08/09/2002 | 361620 | 15 | 06/25/2001 |
| Abs light comes on after i lose brake. chronic problems associated with this year vehicle are abs sensor, belt tensioner breaks away, cooling system heat controls, wiring to the rear lights. these are problems that this year model has that should be recalled. especially when the break sensor goes out and brakes are lost. why has nothing been done to force chevrolet to fix these problems? it is not just one car but all of 1997 malibu that has the problem. it is a definite safety issue. *jb | |||
| ENGINE AND ENGINE COOLING - COOLING SYSTEM | |||
| 09/17/2007 | 75000 | 1 | |
| Car engine overheating not due to thermostat or water pump. *tr | |||
| 09/12/2008 | 74000 | 1 | |
| Automotive cooling system> vehicle began loosing coolant on driveway. took vehicle to repair shop. was informed that vehicles entire cooling system was corroded. and needed to be replaced. the cause was attributed to the use of the coolant dex-cool this was required by general motors to keep up warranty on the vehicle. now i find that this was the wrong thing to use and i will be out $1800 in repair work. i believe g.m. should be responsible for the largest part of this expense. *tr | |||
| 09/14/2004 | 40000 | 5 | |
| Complaint #1 a/c cuts on and off. complaint #2 suspension knocking, serviced 4 times, still have same problems.*ak | |||
| 09/15/1997 | 14000 | 1 | 07/15/1977 |
| I bought a 1997-malibu ls brand new. before it turned 14,000 miles had to have work done on brakes. before even turning 30,000 miles i had to replace a complete brake job, (2nd set) tires, water pump, wheel cylinders, my head lights pop on, and i have a little over 33,000 miles.the dealer were i bought the car said unless they see the lights pop on.they could do nothing. gm sent out a recall. which i did take my car into dealer. i took it to the dealer i bought it from a few times.i moved back to indiana and took it to coyle chevrolet in new albany. i have had nothing but problems with this car.both dealers said there was nothing i could do as a consumer..i am mad as hell-and feel i was ripped off, and will not recommend to no one to ever buy a malibu. i had one in 1969. and, it was the best car. when you pay around $25,000.00 for a new car-you would think you would not have all the brake trouble. i to this day do not feel safe with these brakes. i am a single women and thought by buying a new car i would feel safer. please check into this. as soon as i can afford to get rid of this car i plan too. i have spent several hundred dollars on out of pocket repairs. battery-2 brake jobs-abs brakes-wheel cylinders-roaries-water pump. *la | |||
| 11/20/2003 | 78000 | 3 | 12/01/1997 |
| Brakes gone (again). been replacing about every 10000 miles. this car has been one thing wrong after another. already replaced lower control arms at 7500 miles, leaking antifreeze gasket, a/c control head (twice), and the brakes are ongoing. *ak | |||
| 07/21/2003 | 8000 | 12 | 04/14/1997 |
| Many problems with my 1997 malibu, suspension noise/leaky water pump/key agnition, and lock collar. 32600 miles on the car many repairs. *ak | |||
| 03/10/2003 | 95000 | 0 | 04/08/2002 |
| Poor manufacturing and quality of vehicle components. *nlm | |||
| 05/06/2003 | 15000 | 3 | 04/07/1997 |
| Coolant leaking, engine overheats after highway driving. brakes and rotors fail consistently within 15000 miles of replacement. *nlm | |||
| 08/08/2000 | 1 | 10/31/1997 | |
| Consumer stated there was a fluid leak coming from the engine, the dealer replaced the coolant hose, consumer also stated while driving, the vehicle began to vibrate, consumer was informed that 2 of the 3 engine mounts failed, which caused damage to the front exhaust pipe converter.*jb | |||
| 09/01/2001 | 2 | 04/01/1998 | |
| I bought this 1997 malibu with 20,000 miles on odometer in 1998. in one month i noticed coolant system warning light coming on. i added anti freeze and water to system. this would last about a month and i would have to add more coolant. on 2/ 26/2002 the light came on and i added more coolant. i drove about 4 miles and coolant warning light came on again. i checked oil dip stick and it registered about two inches above full. i knew then that water was in my oil. the coolant had never leaked out where i could see it on the ground. i had to pay $430.00 to have gaskets replaced for the intake manifold . my other problem is that the front disk brakes are wearing out much faster than any car that i have owned. i have replaced two set of front disc pads and have had rotors turned and replaced. i am very light on brakes and have had extremely good ware on other autos. after 2000 miles they are making a noise again. the pads are guarantied for life by the manufacturer .*ak | |||
| 07/16/1998 | 1 | 04/01/1997 | |
| No summary listed for above vehicle. *ak (dot number: 0 tiresize: 215r60-15) | |||
| 10/05/1999 | 10/01/1998 | ||
| Coolant seeps out. *ak | |||
| ENGINE AND ENGINE COOLING - COOLING SYSTEM - RADIATOR ASSEMBLY | |||
| 04/22/2004 | 02/08/1998 | ||
| My first issue is with the lights on the malibu. my light developed condensation in them which in the rear caused the light to glow dim, and caused e to get pulled over on a number of times. in the front it has caused the glass shield to fog causing me to fail vehicle inspection. there have are many other electrical malfunctions on my car such as the theft lock system, the power moon roof, the manufacturer's cd player, the headlight control switch. then it has a problem with emissions. the headliner is falling off the ceiling. *nm | |||
| ENGINE AND ENGINE COOLING - ENGINE | |||
| 09/17/2007 | 75000 | 1 | |
| Car engine overheating not due to thermostat or water pump. *tr | |||
| 09/25/2003 | 59000 | 1 | |
| While driving at any speed and without any warning vehicle stalled. *ak | |||
| 07/10/1997 | 07/14/1998 | ||
| Losing water from radiator reservoir into the intake manifold gasket. i have researched this problem and it seems to be very common on 97 chevy malibu. | |||
| 03/18/2003 | 87500 | 1 | 02/01/1999 |
| Coolant poured out of vehicle. manifold gasket was a lemon. repair place informed us, this was a common problem with chevrolet vehicle's. *jb | |||
| 01/26/2003 | 0 | ||
| There has been numerous problems with the brakes, they have been replaced every 20,000 miles. the cruise control has been fixed a few times and needs repair again. now, the engine has started to consume oil and i have been told it needs replacement. the malibu is a lemon of a car. | |||
| 12/04/2002 | 1 | ||
| The tensioner pulley for the accessory belt completely broke off from the engine block. the dealer had to remove the engine to drill out the old bolt and to get the new assembly in. this is a piece that should never just break. dt | |||
| 01/31/2002 | 1 | 10/31/1997 | |
| Renee borstad, director/superintendent of the board of chosen freeholders writes on behalf of parker flores, also, 2 of the 3 engine mounts on vehicle failed, incurring damages where extensive repairs and replacement was needed. *jg | |||
| 07/15/2002 | |||
| Cars add engine coolant light came on, no obvious leaks; taken to auto repair place and was informed that i had an intake leak; then informed by another repair shop there was water in my oil ; possibly because of a problem with gasket; basically same situation as odi-id758781. *ak | |||
| 01/31/2002 | 1 | 10/31/1997 | |
| Renee borstad, director/superintendent of the board of chosen freeholders writes on behalf of parker flores, also, 2 of the 3 engine mounts on vehicle failed, incurring damages where extensive repairs and replacement was needed. *jg | |||
| 08/08/2000 | 1 | 10/31/1997 | |
| Consumer stated there was a fluid leak coming from the engine, the dealer replaced the coolant hose, consumer also stated while driving, the vehicle began to vibrate, consumer was informed that 2 of the 3 engine mounts failed, which caused damage to the front exhaust pipe converter.*jb | |||
| 03/01/2002 | 4 | ||
| Consumer states intermittently the vehicle anti-theft light would come on while driving, within a few seconds it would start to flicker on/off, when this occurs the vehicle would cut off, dealer was unable to duplicate the problem. *jb also, consumer states dealer replaced fuse, multifunction switch, dome lamp wiring, ignition lock cylinder, power steering hose, fuel pump, engine mount, heater, left door window switch, right front seat belt, left front door handle cover, and left front door lock switch.*yd | |||
| 08/08/2000 | 1 | 10/31/1997 | |
| Consumer stated there was a fluid leak coming from the engine, the dealer replaced the coolant hose, consumer also stated while driving, the vehicle began to vibrate, consumer was informed that 2 of the 3 engine mounts failed, which caused damage to the front exhaust pipe converter.*jb | |||
| 10/30/2001 | |||
| Motor mounts are defective. if consumer would continue to drive then motor and transmission could fall out of vehicle. please provide.*ak | |||
| 02/01/2001 | 8 | 04/11/1997 | |
| When the defroster is turned on, fuses in vehicle short out, causing all gauges and electrical systems to fail including the lights. a private mechanic replaced compressor in vehicle to correct this defect.*ak vehicle also has a head gasket leak. *slc | |||
| 05/24/1999 | 1 | 05/01/1997 | |
| The vehicle stalled on highway when the drive belt snapped due to broken pulley assembly. yh | |||
| 04/15/1999 | 1 | 05/01/1997 | |
| Engine failed due to gasket leaks. yh | |||
| 05/24/1999 | 1 | 05/01/1997 | |
| The vehicle stalled on highway when the drive belt snapped due to broken pulley assembly. yh | |||
| 04/15/1999 | 1 | 05/01/1997 | |
| Engine failed due to gasket leaks. yh | |||
| 05/24/1999 | 1 | 05/01/1997 | |
| The vehicle stalled on highway when the drive belt snapped due to broken pulley assembly. yh | |||
| 10/25/2000 | 05/01/1997 | ||
| Loud squeaking noise coming from the idle pulley. had that part replaced with new part. by the time i got home noise was back. brought car back to mechanic this morning. he is checking to see if new part was defected or if belt needs replacement. i am very disappointed with the malibu's performance. in the 3 years that i have the car, i have replaced front and back brakes, alternator, battery, etc. etc. and now the idle pulley (hopefully nothing else major). | |||
| The right side engine mount has sheared off, causing engine to have no support on that side, it was hanging. *ak | |||
| 07/28/1999 | 3 | 06/01/1997 | |
| The oil pan on the car has defective gaskets the engine manifold has defective gaskets the emergency brake light does not work the brakes have had to be replaced twice in less than 36,000 miles. *ak | |||
| 1 | |||
| Consumer experiences electrical shock when removing oil filter. | |||
| ENGINE AND ENGINE COOLING - ENGINE - GASOLINE | |||
| 04/22/2002 | 4 | 05/01/2000 | |
| No summary listed for above vehicle. *ak | |||
| While driving and without warning vehicle will completely shut down, cause unknown. please give any further details.*ak | |||
| 03/16/2001 | 2 | ||
| While driving engine overheated. vehicle was taken to dealer to be repaired. once again had to be repaired, and dealer said that engine had been worn out.*ak | |||
| 04/14/1997 | |||
| Vehicle would shake while driving. suspension was bad in the front. also, battery did not work & needed charging/ windshield needed replacing due to wind singing/ vehicle would stall/ brake rotors were warped, and tires were wearing out excessively due to the poor suspension. vehicle at dealer. *ak | |||
| 04/02/1998 | 13 | 10/18/1997 | |
| Vehicle has experienced continued problems with engine failure at idle , several repair attempts however continues to experience failures. mjs | |||
| 10/02/1999 | 3 | 07/01/1997 | |
| Upon initial start up with cold engine, engine runs fine until driver attempts to accelerate. upon acceleration engine runs extremely rough, has no power, and will stall as soon as pressure is released from accelerator pedal. engine is difficult to restart. once restarted engine continues to run rough, etc until near normal operating temperatures are reached. vehicle is unsafe to drive until normal operating temperatures are attained due to stalling and lack of power. this vehicle has been into the dealer's shop at least twice. on the last servicing on september 10, 1999, dealer rep laced throttle position sensor and reprogrammed ignition computer with newer version of manufacturer's software. dealer charged $64 for new software which i strongly believe should be covered by manufacturer's warranty or the extended warranty i purchased with this vehicle. | |||
| 04/12/1999 | |||
| Abs brake light was on. consumer had to get the sensor replaced. also, leaves are getting into the engine. *ak | |||
| 04/15/1997 | |||
| Oil leaks and transmission is pulling .consumer contacted dealer. *ak | |||
| 09/01/1997 | 1000 | 09/01/1997 | |
| I have made sevearl attempts to have this vehicle looked at regarding the sounds i hear upon startup. the clicking at first sounded like tappets or valves out of adjustment. the vehicle has a 75000 mile warranty. i called the dealer closest to me and he informed me that this particular engine a 3.1 l were notorious for wrist pin tolerance defects he told me it was an engineering problem and there was nothing to worry about. it should clear up after the metals have expanded inside the engine. i guess you can call me consciecious but the word defect has a tendency to unnerve a person after paying for a new car. and having had mechanical training i know any tolerances where parts are allowed to move freely even when warming up are parts that are usually wearing. wearing parts mean a unpredicible situation and i worry for my family's safety when we bought a new car to have piece of mind. this tolerance thing is unsafe since wrist pins are what hold the pistons on the connecting rods. there can be no tolerance gap on a part as important even if it stops after a while. i was told there is a technical bulletin on this problem but my mechanic can never seem to find it. my warranty is up in another 8000 miles. i am afraid that the engine will give away after our warranty has expired and as usual then it will be a big deal to the mechanics and dealer when they can take my money to fix a nothing to worry about. | |||
| 10/21/1997 | |||
| Driving at approx 10-25 vehicle will begin to stall when trying to come to complete stop or starting up vehicle. dealer claims that the vehicle is basically a lemon. changed/replaced all four fuel injectors/cleaned fuel plugs/replaced the computer, reprogrammed it. *ak | |||
| ENGINE AND ENGINE COOLING - ENGINE - GASOLINE - BELTS AND ASSOCIATED PULLEYS | |||
| 02/04/2007 | 187000 | 6 | |
| I was driving my car on the byway and took the interstate merge lane while increasing my speed to merge into traffic i felt a snap in my steering wheel and gas pedal, i then lost the dash and the car immediately overheated, i had no real power to turn the wheel and the gas pedal was a loose push. being that i had merged onto the interstate when this occurred i had to drive an additional 5 miles to the next exit. not everyone has a cell phone. when i got to the next exit i was almost unable to turn the wheel enough to get it into the nearest parking lot, it was harder to turn than my first truck a 1959 ford twin i beam pickup. i fortunately didn't hit any one or anything. upon raising my hood after parking the car i am appalled to see that the tensioner pulley and one of the idler pulleys are gone and my serpentine belt is shredded. i have replaced the parts but since then i also found that within 5 miles the dreaded gaskets that so many people have complained about, and mine we already eating fluids in sipps before this, were gone. i have replaced the broken pulleys serpentine belt alternator waterpump and gaskets not a month later the other idler pulley that was unaffected in the first incident went. when the first two were replaced that dreaded squeaking stopped for about 3 days and started back up again. something must not be straight for me to have to keep replacing the moving parts that run on the serpentine belt and everytime one of them goes you loose your power steering and the car is hard to turn. not only that but the tail lights would be a better place for a gold fish than a light bulb. everytime it rains, or snows i have to replace tail lights. this car is the bane of my existence. i have the first idler pulley part still the rest of them were lost to the highway the thing is melted. *tr | |||
| 05/01/1997 | |||
| Air conditioner cuts off, engine fails to start (security system), carpet has disentegrated, front end problems, brake pad replaced and belt. *ak | |||
| ENGINE AND ENGINE COOLING - EXHAUST SYSTEM | |||
| 03/01/2008 | 74000 | 1 | |
| I would like to get a replacement,discount or free service on my 1997 malibu. i've had my car since 2004 and had to get another motor in 2005 which is needed now .this car has put me down a lot not only problems with the motor but the ignition locked up and i had to replace that as well as the brakes and rotors that last about 2 or 3 months. i also have a problem with the lights not working properly they only work on high beam. i can't find a more reasonable mechanic that's willing to repair the motor that i currently have due to the type which is a 2.4 and a used motor cost about half the price of a new one. please help! *tr | |||
| 05/25/2002 | 40000 | 1 | 09/07/1997 |
| Intake manifold gasket leaks on my 1997 chevrolet malibu. the local chevrolet dealer verified this problem with my car and recommended gasket replacement at a cost of $585. mileage is only 46,000. i must continue to add coolant at regular intervals otherwise engine will overheat.*ak | |||
| 01/14/1999 | 2 | 09/01/1997 | |
| No summary | |||
| ENGINE AND ENGINE COOLING - EXHAUST SYSTEM - EMISSION CONTROL | |||
| 03/22/2005 | 33000 | 4 | 05/15/1997 |
| Steering wheel made an irritating sound when turned. the dealership was notified. upon inspection they indicated that the steering gear had an internal fault, and replaced it. cause of the internal fault was not disclosed to the consumer. *ak recall campaign# 03v527000. the steering was repaired. a year later the entire steering assembly had to be replaced again. the check emissions light would come on intermittently. there were noises when the vehicle was turned left due to the steering gears internal fault and the gear was replaced, the left front tire had a steel belt showing on the inside. *sc *jb | |||
| ENGINE AND ENGINE COOLING - EXHAUST SYSTEM - MANIFOLD/HEADER/MUFFLER/TAIL PIPE | |||
| 06/01/2005 | 50000 | 4 | 05/01/2005 |
| Tl* the contact owns a 1997 chevrolet malibu. while driving 55 mph the contact smelled antifreeze and noticed some on the engine. the mechanic stated that the manifold gasket was defective. the failure was remedied at approximately 50,000 miles. thirty days later the same failure occurred. once again, the mechanic stated that the manifold gasket was defective and performed the repairs. the failure recurred. the manifold gasket was replaced on two more occasions. the current mileage is 80,000 , and failure mileage was 50,000. *ak | |||
| 02/27/2006 | 67000 | 1 | 09/10/2004 |
| Dt*: the contact stated there was antifreeze on the ground under the engine. an independent repair shop determined the intake gasket needed to be replaced. | |||
| 07/05/2004 | 27000 | 3 | 07/03/2000 |
| I have had to replace the intake manifold gasket twice on the car already. the last repair was in march of 2004. it is only three months from the last replacement, and it is leaking anti freeze again. i would repair the car, but apparently it is not going to do any good. each repair was over four hundred dollars. there has got to be some kind of major defect with this part. i have only owned the car for four years and it only has 81,000 miles on it, and yet this is the third time the gasket has failed.*ak | |||
| 01/03/2003 | 1 | 12/04/2001 | |
| My car has always used an excessive amount of anti-freeze. apparently, my chevy malibu is not the only, and from the mechanic i talked to today, he says that it is the engine. i now have to get a new manifold, which to me costs a lot of money. it seems to me that if the same cars all over are having the same problem it would be some sort of manufacter defect and the consumers should not be responsible. *ak | |||
| 12/17/2003 | 88000 | 2 | |
| Excessive brake pad useage with this car. the intake manifold had to be replaced at 88,000 miles. i am very very dissatisfied with this car and do not plan on purchasing another gm at this time. *ak | |||
| 03/02/2003 | 54000 | 03/23/1976 | |
| Coolant-oil leak problem with the lower intake manifold. *nlm | |||
| 07/28/1999 | 3 | 06/01/1997 | |
| The oil pan on the car has defective gaskets the engine manifold has defective gaskets the emergency brake light does not work the brakes have had to be replaced twice in less than 36,000 miles. *ak | |||