Recalls
Campaign | Manufacturer | Manufacturing date | Type | # of units affected | Date Owner notified Mfg | Recall Initiated by | Manufacturers of recalled vehicles/products | Report Recieved Date | Record Creation Date | Regulation Part Number | FMVSS Number | |||||
---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|
FUEL SYSTEM, OTHER - STORAGE - TANK ASSEMBLY - PRESSURE RELIEF DEVICES | ||||||||||||||||
07E021000 | DELPHI | E (Equipment) | 742 | 04/27/2007 | MFR | GENERAL MOTORS CORP. | 03/12/2007 | 03/12/2007 | ||||||||
Defect Summary | Certain delphi fuel pressure regulators, p/nos. fp10020-11b1, fp10026-11b1, and fp10027-11b1, sold after january 9, 2007, as aftermarket equipment for various passenger vehicles listed above. the universal pressure regulators (upr) were produced without an o'ring and retainer. | |||||||||||||||
Consequence Summary | Fuel may leak, possibly resulting in a fire. | |||||||||||||||
Corrective Summary | Delphi will notify owners and replace the upr free of charge. the recall began on april 23, 2007. owners can contact delphi at 877-411-8770. | |||||||||||||||
Notes | This recall only pertains to aftermarket delphi fuel pressure regulators and has no relation to any original equipment installed by general motors.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov. |
Bulletins
Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
---|---|---|---|---|---|
FUEL SYSTEM, GASOLINE - FUEL INJECTION SYSTEM | |||||
971101776304 | 11/01/1997 | 54066 | Subject pertaining to driveability symptoms due to fuel injector deposits. *yc | 03/30/1998 | |
FUEL SYSTEM, GASOLINE - FUEL INJECTION SYSTEM - INJECTORS | |||||
98776304A | 02/01/1998 | 600282 | Some vehicles may experience a driveability symptom of long or hard starts, chuggle, rough idle and light or intermittent misfire. *yc | 05/05/1998 | |
FUEL SYSTEM, OTHER - STORAGE - FUEL GAUGE SYSTEM | |||||
030849015 | 10/01/2003 | 10004730 | Fuel gauge needle reset procedure after battery disconnect/replacement with key in on position. *tt | 01/02/2004 |
Consumer Complaints
Fail date | miles | occurences | Purchase date |
---|---|---|---|
FUEL SYSTEM, GASOLINE - CARBURETOR SYSTEM | |||
07/15/2002 | |||
Cars add engine coolant light came on, no obvious leaks; taken to auto repair place and was informed that i had an intake leak; then informed by another repair shop there was water in my oil ; possibly because of a problem with gasket; basically same situation as odi-id758781. *ak | |||
While having vehicle serviced mechanic stated that intake manifold had a slight leak. advised consumer to have manifold replaced. consumer was concerned because there was only 35000 miles on vehicle.*ak | |||
2 | 01/01/1997 | ||
I started to notice that over the last two months i've had to add coolant to the car i did'nt notice any leakage but i kept an eye out. when i went to change the oil the other day coolant leakage was evedent and was coming from the intake manifold, closer inspection revealed that the intake manifold bolts were loose, you could move them with your fingers. dealer cost estimate for repair is 500 dollars.the tire situation is as follows, 2 sets of firestone afinnity tire that are supossed to last 80000 miles a set and we can only get aout 33000 miles both sets have been maintained by a firestone dealer and of coarse it's not the tires it is the car so they say.i have them rotated every 6000 miles and keep them inflated to the proer specs,also have them balanced and have the car s alignment performed annually. *ak (tiresize: 215/60/15)( dot number: tire size: 215/60/15 ) | |||
FUEL SYSTEM, GASOLINE - DELIVERY | |||
06/08/1997 | 1 | 06/01/1997 | |
Airbag derm module failed, disabling the airbag system. dealer and chevrolet determined failure was due to water in passenger compartment shorting out module. dealer determined, and chevrolet admitted, that water came in through holes in chassis opened up due to improper installation of patches at time of vehicle manufacture. despite this, chevrolet refused to pay for repair, due to vehicle being out of warranty. fuel line break occured at highway speeds, spraying fuel over car exhaust system and trailing cars. passing motorist motioned me to side of road, helping to prevent fire/explosion. vehicle was repaired under warranty, but to the best of my knowledge, chevrolet never notified nhtsa or investigated problem.*ak | |||
FUEL SYSTEM, GASOLINE - DELIVERY - FUEL PUMP | |||
03/01/2002 | 4 | ||
Consumer states intermittently the vehicle anti-theft light would come on while driving, within a few seconds it would start to flicker on/off, when this occurs the vehicle would cut off, dealer was unable to duplicate the problem. *jb also, consumer states dealer replaced fuse, multifunction switch, dome lamp wiring, ignition lock cylinder, power steering hose, fuel pump, engine mount, heater, left door window switch, right front seat belt, left front door handle cover, and left front door lock switch.*yd | |||
FUEL SYSTEM, GASOLINE - DELIVERY - HOSES, LINES/PIPING, AND FITTINGS | |||
06/14/1997 | 2 | ||
Walking towards vehicle & noticed strong smell of gasoline. took to dealer & was informed a defective part in gas line & they had to repaired it. month later having same problem, only gasoline spilling out of vehicle. *ak | |||
FUEL SYSTEM, GASOLINE - FUEL INJECTION SYSTEM | |||
10/21/1997 | |||
Driving at approx 10-25 vehicle will begin to stall when trying to come to complete stop or starting up vehicle. dealer claims that the vehicle is basically a lemon. changed/replaced all four fuel injectors/cleaned fuel plugs/replaced the computer, reprogrammed it. *ak | |||
FUEL SYSTEM, GASOLINE - STORAGE | |||
06/01/1999 | 6 | 06/01/1997 | |
In june of 1999, the anti-theft lock system malfunctioned which prevented consumer from starting vehicle. dealership did repairs to correct this problem. in october of 2001, anti-theft lock system malfunctioned again, preventing consumer from starting vehicle. *ak consumer stated that the anti theft system malfunctioned on 4 different occasions, the light would come on and stay on at times, also consumer went to have fuel filter replaced and was informed that the quick release connection at fuel filter needed to be replaced quickly, because when it was installed at the factory it was some how bent.*jb | |||
FUEL SYSTEM, GASOLINE - STORAGE - TANK ASSEMBLY - FILLER PIPE AND CAP | |||
10/04/2002 | 125358 | 3 | 10/02/2002 |
Engine check light and the abs light illuminated while driving. vehicle been to a repair shop on 3 separate occasions, and the problem had not been resolved. vehicle had its gas tank cap replaced, and the brake system was overhauled. but problem recurred. *ak | |||
08/01/1997 | 25 | 03/13/1997 | |
5 different times, vehicle stalling in the middle of traffic causing exteme anxiety and stress, replace the pcm. check engine light is on, due to cap cracked, replace fuel cap, clean code road test ok. gas pedal loose, replace accel pedal shaft and bracket assembly | |||
10/22/1998 | 1 | 10/18/1997 | |
Gas cap cable broke off. mjs | |||
01/11/1999 | 1 | 11/05/1997 | |
Gas cap failed. |