Bulletins
| Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
|---|---|---|---|---|---|
| SUSPENSION | |||||
| 040306001 | 09/01/2004 | 10011064 | Vehicle leads/pulls characteristics and diagnosis. *tt | 12/28/2004 | |
| 3000 | 01/01/2004 | 10008849 | Vehicle leads or pulls to the left. *tt | 08/24/2004 | |
Consumer Complaints
| Fail date | miles | occurences | Purchase date |
|---|---|---|---|
| SUSPENSION | |||
| 08/10/2007 | 39455 | 1 | 09/27/2004 |
| Steering went on car while driving . not involved in accident brought to dealers and had to get whole new steering column put in , but i had to pay for the balancing and rotation of the tires. that was the steering column's fault. *tr | |||
| 03/11/2005 | 15000 | 5 | 05/07/2004 |
| Tl*the contact owns a 2004 chevrolet malibu maxx. while driving at low speeds, the vehicle makes a knocking noise in the front passenger side of the vehicle. the front suspension was replaced four times and the rack was replaced once. the vehicle has been taken to the shop fourteen times. the steering shaft has been packed with grease, which serves as a temporary repair. the dealer stated that the steering shaft will need to be greased approximately every three months. the speed was unknown. the current mileage was 25,000 and failure mileage was 15,000. | |||
| 10/20/2006 | 30000 | 5 | 10/20/2006 |
| I went to the dealership and traded my saturn vue for the 2004 malibu maxx. when i test drove the car, after the acceleration reached 4rpms, there was a high pitched whine from the engine closest to the tire. they looked at it and said that it was a loose belt. so i bought the car and they said to bring it the chevy dealership to get it fixed. i took it in and they said they couldn't duplicate the problem so i had to ride with them. also, my seat heaters were turning on automatically, car constintly pulls to the right, i have to turn the key over for a long time to get the car to fully start up. they couldn't duplicate any of the problems so i am still dealing with all of them. for the whining noise, they said it is a drive belt that needs to be replaced, but it is out of stock. how convienient. *jb | |||
| 02/06/2007 | 6500 | 45 | 07/14/2004 |
| Tl* - the contact owns a 2004 chevrolet malibu maxx lt. the vehicle pulled to the left while driving at any speed, it was much worse when driving 70 mph. when driving with left hand the steering wheel the wheel pushes the hand the left and the vehicle went to the left. the mechanic performed an alignment, but had indicated that the alignment was within factory specs. the mechanic stated they could try to adjust the castor, but not to factory specs. the failure continued to occur after the alignment was finished and became worse. there were no bulletins on this vehicle . however, there were on 2004 chevrolet malibu, not for the maxx that related to this failure ,per the contact. the current and failure mileage were 6400. *ak | |||