Bulletins
| Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
|---|---|---|---|---|---|
| SERVICE BRAKES, AIR | |||||
| 4332 | 10021395 | Adding aftermarket trailer brake controller with integrated trailer brake controller. *kb | 04/24/2007 | ||
| 3568 | 3568B | 10021133 | Service brake booster message. *kb | 03/13/2007 | |
| 4024 | 10/11/2006 | 4024B | 10020929 | Rear brake pulsation check drum to axle clearance, with rpo jf3 or jf7. *kb | 01/30/2007 |
| 4169 | 07/01/2008 | 4169D | 10020883 | Service stability lamp diagnostic trouble code (dtc) c0561. *kb updated 9/30/08. *pe | 01/26/2007 |
| 060525004 | 11/01/2006 | 10020892 | Information on reprogramming ebcm if tech 2 data for rear wheel speed sensors is reversed. *kb | 01/26/2007 | |
| SERVICE BRAKES, AIR - ANTILOCK - ABS WARNING LIGHT | |||||
| 040525002 | 06/01/2007 | 040525002D | 10022470 | Abs light on, dtc's c0265, c0201, u1041 set and/or loss of communication with brake module. (reground ebcm ground). *kb | 08/15/2007 |
| SERVICE BRAKES, AIR - ANTILOCK - CONTROL UNIT/MODULE | |||||
| 4056 | 07/01/2008 | 4056C | 10022691 | Gmc: unable to communicate with the ebcm dtc u0121. *nj vehicles equipped with jl4. updated 9/30/08. *pe | 09/20/2007 |
| SERVICE BRAKES, ELECTRIC | |||||
| 4383P | 10021939 | Part restriction on the electronic brake control module. *kb | 06/27/2007 | ||
| SERVICE BRAKES, HYDRAULIC - ANTILOCK - ABS WARNING LIGHT | |||||
| PIT4411 | 03/01/2008 | PIT4411C | 10024632 | Unwanted abs or valve activation on low speed turns. *nj | 04/30/2008 |
Consumer Complaints
| Fail date | miles | occurences | Purchase date |
|---|---|---|---|
| SERVICE BRAKES | |||
| 09/25/2012 | 21532 | 1 | |
| My brakes did not work as before the warning lights and buzzers went off. *tr | |||
| 09/25/2012 | 21532 | ||
| My brakes did not work as before the warning lights and buzzers went off. | |||
| 09/25/2012 | 21532 | 1 | |
| Warning lights and alarms on. *tr | |||
| 09/25/2012 | 21532 | ||
| Warning lights and alarms on. | |||
| 09/09/2012 | 69000 | 1 | |
| Brakes went out in driveway. towed to local garage , found all brake lines were rusted and parts of lines were snapped apart. this happened with normal driving,no incident. thank god nobody was hurt. sad to say i have lost my faith in chevy!!! ## vin failed ## chevy silverado 2007 1500 wt ## *tr | |||
| SERVICE BRAKES, ELECTRIC | |||
| 08/31/2008 | 47200 | 1 | |
| I bought my 2007 silverado on july 27,2006 i began having electrical problems no more than two weeks later it went in the shop august 08,2006 for windshield wipers malfunctioning the dealer replaced the wiper module a couple months later october 10,2006 wipers were doing the same they again replaced the module and motors ok that's fixed,then my brakes were locking up and would drag when i would stop even at speeds of 5-10 mph and also stay locked after taking off from a stop and also was pulling left then right when brakes were applied they had to change the brake pads and resurface the rotors. march 26, 2007( i had my radio burn up a cd and lights in radio burn out they had to replace the stereo and the back lights on my stereo control buttons and other buttons on steering wheel burnt out they changed those. then my accessory outlet keeps burning out any time i plug anything in it blows a fuse, my speedometer cluster lights burnt out they had to replace that) june 28, 2007 back in the shop for a knocking noise in steering shaft they had to replace the steering shaft. may 05, 2008 steering wheel lights burnt out again they replaced the buttons again. then august 31,2008 my family and i were leaving town due to a mandatory evacuation and i was pulling my trailer when i took the ramp to get off the interstate i had no trouble stopping at the stop sign but when i went to cross into the median at no more than 5-10 mph i had no brakes and was pushed into oncoming traffic which resulted in a crash i bought new tires in july 2008 and you can tell that they are being torn up by the brakes i just got my truck back from the shop and noticed the rear brakes are locking up again and dragging through turns even with no brakes applied at 5-10 mph does this seem like an electrical problem. *tr | |||
| SERVICE BRAKES, HYDRAULIC | |||
| 09/21/2011 | 80000 | ||
| Anti-lock brake system (abs) activates when not needed during low speed (<10 mph) stopping. this suddenly increases stopping distances in low speed braking situations. this is the exact same problem described in nhtsa campaign number 05v37900 issued for 1999-2002 chevrolet silverados for which a recall was issued on 8/30/2005. | |||
| 01/06/2011 | 73000 | ||
| Tl* the contact owns a 2007 chevrolet silverado 1500. the contact stated that the abs would independently engage when driving at low speeds. the dealer was contacted who advised that they would need to clean the sensor and then replace them accordingly. the vehicle was not repaired and the manufacturer was not contacted in regards to the failure. the failure mileage was 73,000. | |||
| 03/17/2011 | 47000 | ||
| Tl* the contact owns a 2007 chevrolet silverado 1500. the contact stated that he discovered that the front and rear brake lines were severely rusted. the contact planned to take the vehicle to an independent mechanic for diagnosis because of the safety concerns. the failure mileage was 47,000. the vin was unavailable. | |||
| 01/06/2011 | 73000 | ||
| Tl-the contact owns a 2007 chevrolet silverado 1500. the contact stated the abs brake engages at low speed and for no good reason. the dealer was contacted who stated they have to clean the sensor and then replace them. the vehicle was not under warranty and he would have to pay for the repaires. the vehicle was not repaired. the manufacturer was not contacted. the failure mileage was 73,000...mw | |||
| 03/17/2011 | 47000 | ||
| Tl-the contact owns a 2007 chevrolet silverado 1500. while the contact inspected the vehicle he discovered that the front and rear brake lines were severely rusted. the contact planned to take the vehicle to an independent mechanic for diagnosis because of the safety concerns. the failure mileage was 47,000. the vin was unavailable. js | |||
| 01/06/2011 | 73000 | ||
| Tl-the contact owns a 2007 chevrolet silverado 1500. the contact stated the abs brake engages at low speed and for no good reason. the dealer was contacted who stated they have to clean the sensor and then replace them. the vehicle was not under warranty and he would have to pay for the repaires. the vehicle was not repaired. the manufacturer was not contacted. the failure mileage was 73,000...mw | |||
| 03/17/2011 | 47000 | ||
| Tl-the contact owns a 2007 chevrolet silverado 1500. while the contact inspected the vehicle he discovered that the front and rear brake lines were severely rusted. the contact planned to take the vehicle to an independent mechanic for diagnosis because of the safety concerns. the failure mileage was 47,000. the vin was unavailable. js | |||
| 01/06/2011 | 73000 | ||
| Tl-the contact owns a 2007 chevrolet silverado 1500. the contact stated the abs brake engages at low speed and for no good reason. the dealer was contacted who stated they have to clean the sensor and then replace them. the vehicle was not under warranty and he would have to pay for the repaires. the vehicle was not repaired. the manufacturer was not contacted. the failure mileage was 73,000...mw | |||
| 03/17/2011 | 47000 | ||
| Tl-the contact owns a 2007 chevrolet silverado 1500. while the contact inspected the vehicle he discovered that the front and rear brake lines were severely rusted. the contact planned to take the vehicle to an independent mechanic for diagnosis because of the safety concerns. the failure mileage was 47,000. the vin was unavailable. js | |||
| 02/15/2011 | 24300 | ||
| Tl*the contact owns a 2007 chevrolet silverado 1500. while driving 25 mph he engaged the brakes and they pulsated when the antilock brake system activated. the vehicle stopped in the middle of an intersection. the failure occurred nine to ten times while driving at low speeds. the failure only occurred while making left turns and now it occurs while driving in any direction. the failure had been on going since the middle of february 2011. the dealer was unable to duplicate the failure. the failure continued to occur and the vehicle was taken to a second dealer who was also unable to duplicate the failure. the failure mileage was 24,300 and the current mileage was 24,370. | |||
| 02/15/2011 | 24300 | ||
| Tl-the contact owns a 2007 chevrolet silverado 1500. while driving 25 mph he engaged the brake and the brake pulsated and the anti lock brake activated. he stated the vehicle stopped in the middle of an intersection. the failure had occurred nine to ten times and only at low speeds. the contact stated the failure first starting while making left turns and now occurs when driving straight. the failure had been on going since the middle of february 2011. the vehicle was taken to the dealer and they were unable to duplicate the failure. the failure continued and the vehicle was taken to another dealer and they can not duplicated the failure. the failure mileage was 24,300 and the current mileage was 24,370. vwb | |||
| 03/14/2008 | 10000 | ||
| The front right inner brake pad has been prematurely wearing compared to the other pads. local chevrolet dealer has been asked to adjust pads under warranty. tech said that the vehicle can not be adjusted and that they are wearing within normal time. brake pads are not lasting more than 7 months at a time due to inner pad wearing down to the metal backing while the other pads still have 3/4 of their life left. the front pads have been replaced approximately four times in three years. the front rotors had to be replaced twice in the same amount of time due to the same issue. | |||
| 12/29/2008 | 5000 | 1 | |
| We by a 2007 silverado , in brownsville tx, 2008 new , about 5000 miles start w/ pulsation and brake problems, we take to the dealer and they change 3 time the disc brakes, and brakes pads ,, tires and chimes and still have the same problem. w this truck its a 4 doors truck when you press the brake any speed do the pulsation and make a loud sound when press hard the breaks my wife has a accident in december 2008 in mexico she said she press the brakes hard and do not stop she stop w/ the other truck she crash,, she don't have any injuries ,, any suggestion abut this problem ??? *tr | |||
| 01/17/2008 | 10386 | 1 | |
| The truck has a continuous problem when trying to stop, it is very difficult to stop when needed, i have notified my chevy service dealer many times 8 to be exact, it has had many repairs pads, rotors, calipers to the brakes every time i bring it in. it started at 10,000 miles, and continues every 5000-8000 miles. pads, rotors replaced at 10,386 -17,892- 22,171- 22,171 - 28,722 and last week at 34,362 miles chevy keeps replacing the brakes, rotors or calipers but the truck is still very hard to stop when driving, it is a safety hazard and a danger to myself and anyone else on the road at the same time. i want to report this problem as i see many other have on the 2007 chevy silverado. *tr | |||
| 06/17/2008 | 5200 | 1 | |
| While driving my 2007 silverado 1500 classic, i have had the brakes completely lock up. the first time this occurred it caused and accident, luckily no-one was injured. this happens on a regular basis, every time the brakes are applied hard. this truck has been back to the dealership at least 5 times for this problem and the same result is given each time our computer does not show any codes, so nothing is wrong. it mainly occurs at speeds around 40-60 m.p.h., but has started occurring on very humid or rainy days. i explained to the service manager that this should be some sort of safety concern and his response was, well until a code comes up on our computer, nothing is wrong. *tr | |||
| 04/30/2008 | 33200 | 1 | |
| Brake rotors on 2007 chevrolet silverado had to be resurface due to warping or metal defects, dealer said was not covered by warranty even though vehicle had only 34,200 miles on it, paid for repairs, but felt this should have been a safety issue repair, due to possible loss of control in a hard braking situation. *tr | |||
| 04/25/2008 | 48106 | 1 | |
| I bought a 2007 chevy. truck /1500 4 door crew in feb. 2007 and now have 48,106 miles (mostly highway miles) and had a brake failure in front brakes. i had the front rotors, pads and right caliper replaced on 04/25/08 at supreme chevy. they told the caliper locked up and caused the damage to the brakes. chevy. told me there is no recall for this and they have not had any problems with this. i have driven gm cars and trucks all my life and never had a problem like this before. some one is going to get hurt or worse if this problem is not addressed and fixed. i do not feel safe driving this truck anymore until chevy. tells me this chevy. trucks don't have a safety problems with the front brakes. i hope you can look into this and help with the problem. i don't want anything but just to be told this truck is safe to drive. thanks bruce rogers *tr | |||
| 03/28/2008 | 6000 | 1 | |
| 2 months after buying my vehicle the brake on my vehicle had a bad squeal. which happens when it is very humid outside. i went to the dealer they said it was weather and my brakes getting run in. 1 month later the same from the dealer no problem with the brakes, service tech's say it looks fine. 1 month ago a mechanic at my work saw pitts in my brake rotors. he says he has never seen a new vehicles with that much damage on a brake rotors on further inspection. all four rotors are pitted. this is a 2007 chevy silverado lt crew cab 4x2. #2 there is a jerking movement when u are coming to a stop at a stop sign are red light. the transmission seems to want to let the car keep going, told by dealer this was normal with my vehicle. *tr | |||
| 03/20/2008 | 17100 | 5 | 10/10/2006 |
| Tl*the contact owns a 2007 chevrolet silverado 1500. while backing out of a parking space at 15 mph, the contact depressed the brake pedal and had to use both feet to stop the vehicle completely. he drove to goodyear and a technician test drove the vehicle, but could not duplicate the failure. the dealer followed suit, but could also not duplicate the failure. the failure and current mileages were 17,100. updated 4/8/08 *cn the consumer stated pedal depressed 4 times within a 10 min period and would not move. updated 04/08/08 *tr | |||
| 03/17/2007 | 345 | 6 | 03/15/2007 |
| Tl*the contact owns a 2007 chevrolet silverado 1500. while driving 55 mph, the digital screen module displayed a malfunction message and the steering and brakes locked for approximately 5 seconds. the contact lost control of the vehicle. the engine was still running and the contact pulled to the side of the road. he called the dealer and was advised not to turn off the vehicle, but instead drive directly to the dealer. the weather was not a factor. after numerous visits to the dealer, they stated that the hybrid battery and engine failed. the hybrid control module was replaced and the dealer repaired the hybrid open fuse module. the current mileage was 23,500 and failure mileage was 345. | |||
| 10/05/2007 | 2000 | 1 | 11/01/2006 |
| Tl*the contact owns a 2007 chevrolet silverado 1500. while driving between 10-60 mph, the brakes failed. on october 5, 2007, while driving 60 mph, the contact depressed the brake pedal, but the brakes would not engage. as a result, the contact swerved into a ditch in order to stop the vehicle. three weeks before the incident, the dealer replaced the abs. the powertrain was unknown. the current mileage was 17,000 and failure mileage was 2,000. | |||
| SERVICE BRAKES, HYDRAULIC - ANTILOCK | |||
| 01/14/2008 | 18000 | 2 | 02/15/2007 |
| Driving on dry roads at night. going through s curve at about 40 mph. speed limit was 45mph. applied brakes to slow for traffic and brake pedal went to floor and did not stop the truck. this is the second occurrence in about two weeks. truck is at dealership for inspection and repairs. *tr | |||
| 12/28/2007 | 2 | 08/14/2006 | |
| 2007 chevy silverado, purchased in late 2006. took vehicle to dealer where purchased could find nothing wrong. brakes squeaking very loudly, truck is bouncing erratically and sense a steering issue. 1st dealer also told me the tires just needed to be rotated. the truck is now at another dealer and i have yet to hear the verdict. the truck makes whining noises like in old trucks when the power steering would go bad. this truck currently has 21,000 miles. *tr | |||
| 11/12/2007 | 5300 | 2 | 05/29/2007 |
| Side airbags deployed in a non accident situation while driving...two weeks prior to that brake failure. *tr | |||
| SERVICE BRAKES, HYDRAULIC - ANTILOCK - ABS WARNING LIGHT | |||
| 10/03/2007 | 18275 | 3 | 12/18/2006 |
| Reduce engine power along with service brake light comes on. vehicle shuts down, leaving vehicle with no steering. ecu was reset. next day, problem continued several times. vehicle finally shut down in the middle of the road. *tr | |||
| SERVICE BRAKES, HYDRAULIC - FOUNDATION COMPONENTS | |||
| 10/18/2007 | 7000 | 5 | 04/11/2007 |
| Under normal driving conditions at highway speeds 60-80 (more noticeable but can still feel at lower speeds when stopping) mph when the brakes are applied to slow for a toll plaza or off ramp the truck and steering wheel shake excessively. have driven with 2 mechanics and a service manager at maroone chevrolet and they have noticed this problem but state it is normal or not that bad. this is not acceptable as i tow a boat a couple times per month that is 3500 lbs. the truck is rated to pull 7800 lbs. i am worried this could cause brake failure/premature brake component wear. the vehicle was in the shop 5 times for this problem and it still continues. now the brakes squeal when they are applied and tires are wearing on the inside (a friend with the same truck is also wearing on the inside). the dealer replaced front rotors after turning them once, replaced the front and rear pads, replaced rear drums, and rebalanced the tires. condition still remains. *tr | |||
| SERVICE BRAKES, HYDRAULIC - FOUNDATION COMPONENTS - DISC - PADS | |||
| 10/18/2007 | 7000 | 5 | 04/11/2007 |
| Under normal driving conditions at highway speeds 60-80 (more noticeable but can still feel at lower speeds when stopping) mph when the brakes are applied to slow for a toll plaza or off ramp the truck and steering wheel shake excessively. have driven with 2 mechanics and a service manager at maroone chevrolet and they have noticed this problem but state it is normal or not that bad. this is not acceptable as i tow a boat a couple times per month that is 3500 lbs. the truck is rated to pull 7800 lbs. i am worried this could cause brake failure/premature brake component wear. the vehicle was in the shop 5 times for this problem and it still continues. now the brakes squeal when they are applied and tires are wearing on the inside (a friend with the same truck is also wearing on the inside). the dealer replaced front rotors after turning them once, replaced the front and rear pads, replaced rear drums, and rebalanced the tires. condition still remains. *tr | |||
| SERVICE BRAKES, HYDRAULIC - FOUNDATION COMPONENTS - DISC - ROTOR | |||
| 10/18/2007 | 7000 | 5 | 04/11/2007 |
| Under normal driving conditions at highway speeds 60-80 (more noticeable but can still feel at lower speeds when stopping) mph when the brakes are applied to slow for a toll plaza or off ramp the truck and steering wheel shake excessively. have driven with 2 mechanics and a service manager at maroone chevrolet and they have noticed this problem but state it is normal or not that bad. this is not acceptable as i tow a boat a couple times per month that is 3500 lbs. the truck is rated to pull 7800 lbs. i am worried this could cause brake failure/premature brake component wear. the vehicle was in the shop 5 times for this problem and it still continues. now the brakes squeal when they are applied and tires are wearing on the inside (a friend with the same truck is also wearing on the inside). the dealer replaced front rotors after turning them once, replaced the front and rear pads, replaced rear drums, and rebalanced the tires. condition still remains. *tr | |||
| SERVICE BRAKES, HYDRAULIC - FOUNDATION COMPONENTS - DRUM - DRUM | |||
| 10/18/2007 | 7000 | 5 | 04/11/2007 |
| Under normal driving conditions at highway speeds 60-80 (more noticeable but can still feel at lower speeds when stopping) mph when the brakes are applied to slow for a toll plaza or off ramp the truck and steering wheel shake excessively. have driven with 2 mechanics and a service manager at maroone chevrolet and they have noticed this problem but state it is normal or not that bad. this is not acceptable as i tow a boat a couple times per month that is 3500 lbs. the truck is rated to pull 7800 lbs. i am worried this could cause brake failure/premature brake component wear. the vehicle was in the shop 5 times for this problem and it still continues. now the brakes squeal when they are applied and tires are wearing on the inside (a friend with the same truck is also wearing on the inside). the dealer replaced front rotors after turning them once, replaced the front and rear pads, replaced rear drums, and rebalanced the tires. condition still remains. *tr | |||
| SERVICE BRAKES, HYDRAULIC - FOUNDATION COMPONENTS - DRUM - SHOES/LININGS | |||
| 10/18/2007 | 7000 | 5 | 04/11/2007 |
| Under normal driving conditions at highway speeds 60-80 (more noticeable but can still feel at lower speeds when stopping) mph when the brakes are applied to slow for a toll plaza or off ramp the truck and steering wheel shake excessively. have driven with 2 mechanics and a service manager at maroone chevrolet and they have noticed this problem but state it is normal or not that bad. this is not acceptable as i tow a boat a couple times per month that is 3500 lbs. the truck is rated to pull 7800 lbs. i am worried this could cause brake failure/premature brake component wear. the vehicle was in the shop 5 times for this problem and it still continues. now the brakes squeal when they are applied and tires are wearing on the inside (a friend with the same truck is also wearing on the inside). the dealer replaced front rotors after turning them once, replaced the front and rear pads, replaced rear drums, and rebalanced the tires. condition still remains. *tr | |||
| SERVICE BRAKES, HYDRAULIC - POWER ASSIST - HYDRAULIC | |||
| 06/17/2007 | 13351 | 1 | 02/28/2007 |
| Tl*the contact owns a 2007 chevrolet silverado 1500. when the contact has his foot on the brake pedal, the pedal will slowly extend down to the floorboard. he replaced the master cylinder because the mechanic stated that it was leaking. the current mileage is 16,316 and failure mileage was 13,351. | |||