Bulletins
| Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
|---|---|---|---|---|---|
| SUSPENSION | |||||
| 3009 | 05/01/2008 | 3009H | 10021013 | Suspension vibration or frame beaming at 40 - 60 mph. *kb updated 8/25/08. *pe | 02/22/2007 |
| 020307002 | 03/01/2005 | 020307002A | 10014945 | Revised front caster and camber adjustment procedure. original not yet received. *tt | 05/12/2005 |
| 040310002 | 04/01/2004 | 10012626 | New flexible spare tire hoist tool available to assist in lowering/removing spare tire. *tt | 03/08/2005 | |
| 3009A | 3009B | 10008845 | Suspension vibration or frame beaming at 40 -60 mph. *mj | 08/24/2004 | |
| 00313 | 01/01/2004 | 10008867 | Squeak or creak noise from underbody over bumps. *mj | 08/24/2004 | |
| 030310006 | 09/01/2005 | 10005554 | Reference guide for the technician to upgrade a vehicle from factory wheels and tires to 20 inch wheels and tires, which are available through gmspo. *tt | 03/02/2004 | |
| 01555 | 01/01/2004 | 10005395 | D height specification missing from si. sit bulletin 1410632. *tt | 02/24/2004 | |
| 030309002 | 07/01/2007 | 030309002B | 10005181 | Rear leaf spring slap or clunk noise (replace spring inserts) *tt updated 10/18/07. *nj | 02/11/2004 |
| 030308002 | 12/01/2005 | 030308002B | 10002851 | Rattle/squeak from front of vehicle. *tt *ar | 09/26/2003 |
| 030310001 | 01/01/2008 | 030310001D | 10000959 | Tire slowly goes flat and/or excessive wheel vibration caused by bead splits (replace wheels with new heavy duty rim version) *tt *ar updated 4/11/08. *nj | 04/09/2003 |
| 270901 | 09/27/2001 | 626427 | Some vehicles equipped with 4-wheel drive extended cab and short bed may experience a bump or clunk on stop or acceleration. *slc | 12/14/2001 | |
| 000310008 | 12/01/2000 | 623044 | Some customers may comment that they are unable to lower the spare tire. *tt | 10/25/2001 | |
| SUSPENSION - FRONT | |||||
| 01712 | 01/01/2004 | 10006411 | Left front of vehicle sits low. sit bulletin 1454860. *tt | 05/03/2004 | |
| 990308002A | 05/01/2004 | 990308002B | 611289 | Front suspension coil spring noise. *tt | 06/01/2000 |
| SUSPENSION - FRONT - SPRINGS - LEAF SPRING ASSEMBLY - U-BOLT, LEAF SPRING TO AXLE | |||||
| 3340 | 09/23/2006 | 3340C | 10020874 | Left front axle shaft difficult to remove. axle differential leak seal shaft. *kb | 01/25/2007 |
| SUSPENSION - REAR | |||||
| PIP4054A | 02/01/2008 | PIP4054B | 10024345 | Eaton locking differential chatter shudder noise on turns, equipped with a locking rear differential rpo g80. *nj updated 7/17/2008. *pe | 04/07/2008 |
| 3000A | 01/01/2004 | 3000B | 10008901 | Rear axle locking differential chatter shudder noise on turns. *mj | 08/25/2004 |
| 3028 | 01/01/2004 | 10008797 | Replacement tailgate cables bind at shoulder bolt. *mj | 08/23/2004 | |
| 01570 | 01/01/2004 | 10005412 | Spring slap noise from the rear of the gmt 400 series truck. *mn | 02/25/2004 | |
| SUSPENSION - REAR - SPRINGS - LEAF SPRING ASSEMBLY - U-BOLT, LEAF SPRING TO AXLE | |||||
| 00347A | 11/18/2003 | 10004123 | Rear spring slap or clunk noise. *tt | 11/19/2003 | |
Consumer Complaints
| Fail date | miles | occurences | Purchase date |
|---|---|---|---|
| SUSPENSION | |||
| 02/27/2013 | 140242 | ||
| Was driving my 2000 1500 and had brake failure. upon inspection not only did i find extensive rust on lines but my rear shackles are rotting through and some places on the frame. started to think there no way this should not be happening to this truck. only 140000 miles this has got to be a case of poor quality. not only is this a safety issue and should be checked on but it is an expensive fix. i did slide off the road but i came to a safe stop in a field luckily my e-brake worked and noody else was around. could you please investigate this and take care of it. chevrolet should stand by their product but they don't care about us, they just want their money. also there is a lot of rust on body of truck, like actual holes in bedside and passenger side rocker panel is bad. thank you for your time and consideration ,sincerely chevy truck owner:( | |||
| 04/02/2001 | 100000 | 100 | 09/05/2000 |
| Tailgate fails to stay shut :seat suspension broke. *jb | |||
| 01/01/1901 | 1 | ||
| 2000 chevrolet silverado developed a vibration in the front end while driving at 55 to 60 mph.*mr the vibration transmitted to the steering wheel while driving. the consumer explained that this condition could occur 5 miles apart or 20000 miles apart. *nm | |||
| 04/10/2002 | 6 | 04/14/2000 | |
| Consumer complained of defective engine making constant noise. vehicle also vibrated while driving. in addition, dealer replaced water pump and engine belts. *ak | |||
| 11/24/2001 | |||
| While driving had problem controling vehicle, it pulls to the right.*ak | |||
| 01/01/2001 | |||
| There is constant vibration at 25-35 mph that can be felt through steering wheel. vehicle has been taken to dealer 4 times, dealer insists that vibration is normal for this type vehicle. *ak | |||
| 05/10/2001 | 3 | 09/01/1999 | |
| I`ve replaced the tires 3 times in 2001. i`ve had tires balanced numerous times. i`v e replaced all 4 shocks in 2001. *ak (tiresize: 16) | |||
| 08/01/1999 | |||
| The truck vibrates when you go over 65mph. this includes the steering wheel, the seats, cup holders, etc. the whole truck vibrates. we have had it in 4 times and than the dealership said that is how it is suppose to ride. | |||
| 1 | |||
| There has been vibration problems with the truck since may. now when hitting a bump or any irregularities in the road or depressing brake pedal at the same time, abs system avance. truck has been taken to the dealership several times for vibration problems. dealership has not been able to solve this problem, and stated that this was a normal condition . *ak | |||
| 02/01/2000 | 1 | 11/01/1999 | |
| Severe vibration of truck affecting driveability at speeds of 40-45 and 62-72mph. at highway speds the steering wheel vibrates and at times will be forced out driver's hand if driver does not have a strong grip on the wheel. vehicle is a safety hazard due to vibration and sudden steering wheel pull and may cause a crash. | |||
| 07/12/2000 | |||
| Vehicle was leaking coolant out of the radiator. currently, vehicle was pulling to left and right and into oncoming traffic. consumer has contacted dealership, at this time no reply from the mechanic.*ak | |||
| 02/29/2000 | |||
| Vehicle severely vibrated while accelerating. vehicle has been in dealer's shop on several occasions, and dealer has performed various repairs/parts replacement, but problem continued to reoccur. feel free to provide further details.*ak | |||
| 01/01/2000 | 11/01/1999 | ||
| The truck started a vibrating/shaking at highway speeds at about 1000 miles. i have been put off and outright lied to about the problem. at times it is so severe that it will cause the cd player to skip. three different dealers ackowledge the problem is common to these trucks. chevrolet customer service has tried to blame the dealers for inaction, but i have a local dealer that has been authorized by chevy to try different shocks, springs etc. to solve the problem on other trucks, and has had some success. i only want them to try to do something since nothing has been done up till now. the vibration can be dangerous since it sometimes starts without warning. my wife will not drive the truck at highway speeds.*ak | |||
| 04/06/2000 | 3 | 11/01/1999 | |
| When vehicle driven 62-65 mph or at hwy speeds, steering wheel will shake and vibrate. condition worsens when vehicle is driven over bumps or rough conditions.vibration will continue, once started, until the vehicle is stopped. startng over sometimes will fix the problem. the dealer rep decribed the problem as steering dithers and said they could not fix. gave me the chevorlet customer service number. currently i am told the 'avm' form cheverolet (dan satello) will contact me in two weeks. no offer made to assist me in the mean time, in any form. i did ask for a rent car and was refused, also asked if it was safe to drive and recieved no answer. the dealer note on my repair receipt was no problem at this time and could not duplicate the problem. *ak | |||
| 12/28/1999 | |||
| While traveling 60-65 mph vehicle started vibrating. dealer and manufacturer have been contacted. owner told that chevrolet is working on it and that a tsb will be issued when the problem is figured out. *ak *ml | |||
| 10/20/1999 | |||
| Vehicle experiencing the following problem 1.) brake booster had to be replaced on two occasions; 2.) thottle sticking, unble to correct the throttle from sticking. 3.) when applying brake pedal in wet road conditions, it commenced to pulsate intermittently, causing extended stopping distance, and 4.) squeaking sound coming from the suspension. vehicle been in/out of dealer shop on three occasions, and problems are still reoccurring.*ak | |||
| On 3-jan-2000, while making a u turn power steering shaft broke in half. had the vehicle towed to dealership. they replaced the entire power steering pump. on 10-jan-2000, driving down highway between 60-65mph, steering wheel would vibrate. took it to the dealer again, andjhe ordered 4 new tires, and had them put on. 3 tires had soft spots which were bad tires. they ordered 3 more tires and had them put on. the tire size p235/75r16. *ak | |||
| 09/27/1999 | 1 | 09/01/1999 | |
| Vehicle has had a driveline vibration since purchased new . dealer replaced the tires 3 times and then decided it was not the tires . after failing to correct the problem , dealer states that gm says there is not a problem and that the vibration is normal and within specs. i know this vibration should not be there and i am not the only person to complain to gm . they ( gm ) have taken back either by buying back or trade assist many of these vehicles , which , by the way , are within spec. . there is also no know build date for more of these vehicles . i have been offered the trade assist for my vehicle which would be acceptable were it not for the $0.20 a mile they want to charge me for milage already on the vehicle , but also for all the miles while waiting for them to provide me with another vehicle . i may be in the wrong place to complain about this but i don't have any guidence in persuing a resolution to this problem . h e l p !! | |||
| 08/21/1999 | |||
| While driving vehicle approximately 65mph vehicle would start to shake violently. if driving at lower speed, shaking would not be noticeable. have taken vehicle to dealer to check & have not release it as of yet. *ak | |||
| 09/01/1999 | |||
| Rough idle and vehicle shakes and vibrates at highway speeds---steering wheel shakes violently when going over a bump in road. *ak | |||
| 08/01/1999 | 07/01/1999 | ||
| This is concerning and very aggravating as it has (2) times caused me to slow down to 50 very quickly by hitting the brakes to stop the vibrations and steering wheel shake. thought i would loose control. it actually makes you have an upset stomach with the constant vibrations. | |||
| SUSPENSION - FRONT | |||
| 08/09/2004 | 70000 | 1 | |
| While driving at any speed front end vibrated violently. *ak | |||
| 01/02/2002 | 1 | ||
| The front wheel bearings on the left and right side failed causing three inches of looseness up and down, left and right on both wheels, since the vehicle had exceeded the 36000 mile warranty by 2000 mile the consumer had to pay for repairs, the consumer is requesting reimbursement for the safety related problem. nlm | |||
| 01/06/2001 | 1 | 01/01/2001 | |
| We've had drivetrain vibration trouble with our truck since it was almost new. it has been in the service dept. several times for this problem. the dealership has replaced different items without fixing the problems. the dealership has reduced some of the vibrations. the vibration gets bad enough that the dome light cover has fallen off due to vibrations. from what we've researched g.m. has had problems with the '99,2000 &2001 silverado trucks and have been unable to fix the problems. the last visit to the service dept., we were told that yes there is vibration with our truck, but it's within gm specs and they can't or won't do anything else with it. we now have a problem when shifting from reverse to drive with our foot on the brake the truck sometimes jumps foward. we are going through arbitration with the better business bureau and speaking with the gm rep. about these problems, he felt that these problems were not safety related. i told him that if a truck jumps foward with the brake on is a safety problem. i told him the vibration problem was a safety issue also due to the stress put on vibrating parts in the short or long run. the gm rep. is acting like we have the only truck with this problem, which is not the case. there is not enough room here to tell more about these problems and were more then happy to discuss these problems. | |||
| 02/29/2000 | |||
| At 2000 miles front tires started to show noticeable wear, dealer said front end out of alignment could have cause the tire wear, rotated the back tires to the front and realigned the front end, same wear appeared at 5000 miles. goodyear said low inflation cause permanent damaged. the pressure is 35lbs on all four tires, although the labels says 28lbs on front and 35lbs on the rear. | |||
| 10/02/2000 | 09/01/2000 | ||
| Well first off 1: vibrations at speeds of 40+ the front end feels like it going to fall apart the sterring wheel shakes violently when slowing as the the vibrating is going on, you have to come to a complete stop and put it park and then proceed and it might go away, it's like the driveline or shaft gets out of balance, and the brake barley work its like they are fighting against you putting pressure on them. #2: when you hit a bump with brakes applied the peddal starts pumping back and forth and you can barely stop. #3: front left suspension squeaks and rattles when making a right or left turn its like your shifting the weight and something is looose. #4: transmission clunks when putting into gear from park or into reverse almost as if a u-joint was bad but noise comes from tranny and driveshaft. and when coming to a stop you can feel the tranny down shifting like its just dropping out of gear the whole truck rocks. well chevy need to do something before someone dies,, after reading the previous complaints i thought i just had a lemon but i see i'm not alone i took the trk to the dealer for the vibration and was told no problem existed but the vibration went away for awhile do they know something and just are told be quiet. help me i should have got ford | |||
| 06/06/2001 | 1 | 06/01/2001 | |
| Truck excessively vibrtes at highway speeds, this is a very unsafe condition. is there going to be a recall on these trucks since so many of them are defective? *ak | |||
| 05/15/2000 | |||
| When driving between 40-50 mph vehicle vibrates. can be felt through steering wheel/ gas pedal and seat. consumer thinks it may be drivetrain related. to dealer 4 times, no remedy. dealer balanced tires, replaced driveshaft and adjusted suspension. *ak | |||
| 04/23/2001 | |||
| Was traveling 60mph and lost control of vehicle due to its drifting. it went sideways and off the road. then, vehicle went air borne after straddling. driveway was of concrete tile. landed on bumper, then flipped on top. air bags failed to deploy. driver suffered injuries and was hospitalized.*ak | |||
| 04/23/2001 | 3 | ||
| While driving at highway speed could feel strong vibration coming from front of vehicle. had taken vehicle to dealer three times. *ak | |||
| 09/05/2000 | 3 | 09/01/2000 | |
| Cannot align caster within +/- tolarence. vehicle wil pull to right if caster is put in +/- tolarence. *ak | |||
| 03/20/2001 | 1 | 07/04/2000 | |
| Tires had made a lot of noise from begining after buying vehicle. currently, tires were wearing from inside out where aligment could not fix problem.*ak consumer did not give any inormation regarding tire type or size. oil light illuminated, dealer put in a new valve, oil problem still continued, oil was found covering and underneath the chassis. consumer states windows rattle. *slc | |||
| From 10mph and higher steering wheel vibrates uncontrollably. dealer has replaced three defective wheels and two tires. *ak | |||
| 2 | 02/22/2000 | ||
| While traveling, to keep vehicle from pulling to right, consumer has to apply pressure to steering wheel and pull to left. dealer has been contacted. *ak consumer states that dealer replaced the gear box, however the steering was worse than ever, dealer then rotated front tires left to right, consumer has noticed improvement however there is still a light pull to the right. *slc | |||
| 05/20/2000 | 05/01/2000 | ||
| Truck has a vibration that the dealer can not correct. feels like a tire out of balance. tires balanced and vibration is not as bad, each time tires are balanced they are found to be out of balance. service manager has told me that i would have to live with this. manufacture says all trucks have this vibration. the rear left door will not close in freezing weather till the truck has been ran long enough to warm the interior, (about 5 miles),since the front door latches to the rear door it will not close completely. service manager at dealer states he has not heard about this problem.*ak | |||
| 11/07/2000 | 08/01/2000 | ||
| Truck was fine for first two months then small vibrations. dealer said two bad tires and changed them (no better). two weeks later dealer checks tires and says three bad tires . changed all four (no better). now dealer wants me to pay for an upgrade to michelins to solve the problem . why should i have to pay for gm`s cheap tires? *ak | |||
| 09/01/2000 | |||
| Dealer refused to replace mirror even though truck under warranity and i have additional coverage. *ak | |||
| 08/01/2000 | 06/01/2000 | ||
| I made 4 or 5 attempts to have this fixed but it has not as of yet. the truck vibrates.shakes front end pops real loud. *ak | |||
| 09/01/2000 | 6 | 08/01/2000 | |
| Truck has had several parts replaced for vibration, spends more time in shop than at home. *ak | |||
| 10/30/1999 | 3 | 10/01/1999 | |
| Vehicle has had a vibration since new. vibrations can start as slow as 35mph & continue to 70+mph. dealer has unsuccessfuly tried to repair many times. now says they can't fix. i have filed under fl's lemon law statue for a refund. | |||
| 09/05/2000 | 4 | 03/31/2000 | |
| Front end pulled to the right side. consumer has to keep control of vehicle by keeping both hands on the steering wheel. *ak | |||
| 10/08/1999 | 7 | 10/01/1999 | |
| Vibration in vehicle, oil consumption, brakes, popping noise in front-end. *ak | |||
| While traveling vehicle hit a pothole. vehicle would travel from side to side. dealer has been contacted. please provide further information.*ak | |||
| 04/01/2000 | 02/01/2000 | ||
| Truck has a vibration between 60-65 mph that also shakes the steering wheel. also noticed the left mirror is shaking,leading to believe it may be a problem on left side of vehicle. contacted gm told me they did have a vibration problem in the silverado but no fix yet. *ak | |||
| 1 | |||
| The front end makes noise whenever the vehicle is in four wheel drive and turning in either direction. yh | |||
| 08/01/1999 | 0 | ||
| Truck vibrated. consumer was told by dealer that truck could not be repaired because dealer did not know when vehicle was vibrating. consumer did not want to drive vehicle because he was told there was a problem with front end of vehicle. *ak | |||
| 11/24/1999 | 11/01/1999 | ||
| Vibrates at 5 mph/1500 rpm. vibration is more severe when towing. in shop 3 times, nothing resolved. rough idle and vibration since truck was delivered. now has 2100 mile on it, and still same condition. *ak | |||
| 03/01/2000 | 3 | ||
| While driving about 65 mph could feel vibration coming from the front end and would lose control *ak | |||
| 07/03/1999 | 07/01/1999 | ||
| Vehicle has been to 3 dealers numerous times. contacted chevrolet no solution available. no safety defected listed within summary. *ak | |||
| SUSPENSION - FRONT - CONTROL ARM - LOWER ARM | |||
| 10/01/1999 | |||
| General motors notified me that the bushings in the lower control arm and the bushings in the rack and pinion needed to be replaced to correct a serious vibration problem . there is also a gm service bulletin containing this information. these two conponents are part of the steering. gm has informed me that they will not replace these bushings a the present time. having a defective steering assembly causes a safety problem for me and my family. any other required documentation i will be glad to provide. | |||
| SUSPENSION - FRONT - HUB | |||
| 10/26/2005 | 2 | 05/01/2001 | |
| Dt: the contactreceived nhtsa recall 05v379000 concerning abs. he took the vehicle to the dealership, and had the work performed. the abs iwas still activating, therefore, the problem had not been corrected. he took the vehicle back to the dealership. the hub assembly was corroded and needed to be replaced. according to the manufacturer, the recall did not cover this, and it will have to be replaced at the contact's expense. *ak | |||
| 03/22/2004 | 46261 | 2 | 01/02/2003 |
| Dt: the consumer stated that 2000 chevrolet silverado was having a problem with the abs engaging at low speeds, 5-10 mph. the consumer contacted gm, and this vehicle not included in the recall. the consumer took the truck to a repair shop and had the truck fixed. the repair shop replaced the hub bearing. the dealership was contacted, and they said that it happened a lot. the bearing was replaced on the left front, and that seemed to have fixed the vehicle.*ak | |||
| 08/02/2005 | 1 | ||
| Anti-lock brakes kick in when attempting to stop on dry pavement driving slow. when this occurs, the stopping distance is greater. the greater stopping distance increased the chance of hitting something. the dealer replaced the front, driver side hub assembly. *nm | |||
| 06/25/2005 | 30000 | 2 | 11/15/1999 |
| Dt: at low speeds the abs system locked, and vehicle will not stop. the abs motor popped and pushed the pedal back. this past saturday couldn't get the vehicle to stop and hit another vehicle. took vehicle to the dealer, and they replaced the front hubs sensor, but problem recurred. *ak | |||
| 09/01/2004 | 31000 | 1000 | 06/24/2004 |
| 2000 chevy silverado z-71, 4wd, v-8 extended cab 31,000 miles. i purchased the vehicle used on june 24, 2004. in september, 2004 i noticed that the abs brake system would activate as i slowed (< 10 mph) to a stop. this issue began intermittantly but worsened as i continued to drive the vehicle. by jan, 2005, the abs would activate every time i applied the brakes at slow speeds (< 10 mph). no trouble lights came on. i did not have any accidents with this issue but had one very close call in a parking lot. this incident caused m to investigate and fix the problem. in late january, i had a gm dealer investigate the issue and they recommended replacing the left front hub assembly. given the high price the dealer was going to charge for the replacement part and the labor, i elected to purchase a replacement front hub assembly from a local auto parts store (autozone). i replaced the left front hub assembly per the vehicle's service manual directions. and the problem went away. the hub i removed was heavily corroded with signs that the seal on the inboard side of the hub was corroded with a portion of the excluder lips missing. i still have the hub assembly that was removed from the vehicle and would be glad to provide it for teardown inspection. in addition, i am a degreed mechanical engineer that works for a leading axle and driveshaft manufacturer and would be glad to discuss this serious safety issue further. i believe that seal failed and this allowed debris / corrosion to enter the hub assembly which then subsequently caused a signal interuption between the tone whee and speed sensor. thus, the abs system believed that the left front hub was not rotating and caused the abs system to activate. my issue is very much like the issue described in the may 27, 2005 issue of the detroit free pess titled gm truck owners insist brakes are a problem. | |||
| 10/04/2004 | 99000 | 150 | 02/11/2001 |
| Abs brakes engage each time i come to a slow stop( i.e. pulling up to a stop sign or red light) extending my stopping distance. dealer states that the abs speed sensors and front hubs must be replaced but cannot tell me what is wrong. the abs warning light does not come on although according to the dealer( kelly chevrolet, butler, pa) the system is malfunctioning.*ak | |||
| 09/10/2004 | 36550 | 2 | |
| While driving at a low speed brakes failed. the emergency brake was the only thing that stopped the vehicle. repairs were made on the hub. after repairs brakes failed again, consumer's vehicle rear ended another vehicle. *ak v | |||
| 32000 | 1 | 10/01/2000 | |
| The antilock braking system began to pulsate when braking at 5 mph and as a result the vehicle did not stop. the front hubs were found to be the cause and were replaced. *nm *sc | |||
| SUSPENSION - FRONT - SHOCK ABSORBER | |||
| 1 | |||
| The manufacturer of the vehicle did not install front shock absorbers. yh | |||
| SUSPENSION - FRONT - STABILIZER BAR | |||
| 01/15/2004 | 94000 | 20 | 11/22/2002 |
| I have a 2000 chevy silverado 1500, about 4 months ago the problem started, when i am traveling at or above 40 mph the truck vibrates. you can feel this vibration thru the steering wheel and also when the 4 wheel drive is on and i turn the wheel to park the wheels seem as if they are resisting almost as if the whole wheel is just going to break this started last winter. *ak | |||
| SUSPENSION - FRONT - WHEEL BEARING | |||
| 03/22/2004 | 46261 | 2 | 01/02/2003 |
| Dt: the consumer stated that 2000 chevrolet silverado was having a problem with the abs engaging at low speeds, 5-10 mph. the consumer contacted gm, and this vehicle not included in the recall. the consumer took the truck to a repair shop and had the truck fixed. the repair shop replaced the hub bearing. the dealership was contacted, and they said that it happened a lot. the bearing was replaced on the left front, and that seemed to have fixed the vehicle.*ak | |||
| 04/01/2005 | 50000 | 4 | 04/08/2000 |
| Dt: consumer states at 44,000 miles the rotors, pads and wheel bearings were replaced. six months later the wheel speed abs sensor have failed. could not stop the vehicle when going between 2 and 8 mph. consumer took vehicle to a goodyear dealership, and was told there was a technical service bulletin on the abs brakes. number not available. consumer was going to call general motors today. the problem occurred regularly. *ak | |||
| 11/07/2000 | 37000 | 30 | 05/15/2000 |
| Tailgate cables broke while standing on tailgate loading materials-no injury (july 2003). left front day time running light blew and burnt the socket. have seen numerous other same models with same problem (2001). back passenger doors on the extended cab do not fully lock during 30 degree weather and below until the interior heats up. (dec-feb 2000-2004) left front wheel hub bearing is defective after 38,000 miles. (dec 2004) *la | |||
| 08/18/2003 | 49994 | 11/30/1999 | |
| Vehicle is 2000 chevy silverado 4 wheel drive with approx 50k miles. at slow (under 15 mph) speed coming to a stop driver side front abs engaged and almost hit car in front. at first i thought maybe wet road but it nows does it every morning when coming to a stop at the end of my road dealer said i need to replace front wheel bearing. have an appointment for first week in sept. and will have all parts saved. *nlm | |||
| 01/01/2002 | 38607 | 3 | 12/01/1999 |
| The consumer took the vehicle to be inspected. this is when the mechanic noticed that the front wheel bearings on the left and right side needed to be replaced. there was three inches of looseness up and down, left and right on both wheel because of bearing failure. the vehicle was taken to the dealer and they agreed that the bearing were worn. the vehicle had exceeded the 36000 mile warranty by about 200 miles, therefore the consumer had to pay for the repairs. the consumer was also informed that there were no grease fittings which is why the bearings had to be replaced. *scc manifold/gasket leaked due to poor design. *nm | |||
| SUSPENSION - REAR | |||
| 08/01/2003 | 1 | 08/05/2000 | |
| Problems with 2000 chevrolet silverado rotors, wheels, tailgate strap, drive shaft, and 4-wheel drive.*mr nar see odi#10037613 es03-006296. at 12000 miles both rear rotors had to be replaced, 2000 miles later both front rotors had to be replaced. a clunking sound was heard in the rear of the vehicle. the consumer believes it either the rear suspension or drive shaft. all four of the vehicle's wheels had to be replaced at 6000 miles because they were rusting. the tailgate strap broke at 17000 miles. when the four wheel drive was engaged there was a growling noise. *nm | |||
| 12/02/2000 | |||
| Rear end of vehicle has fallen apart, and consumer has vehicle at the dealership getting rear end fixed. contacted dealer, and the dealer was not willing to do anything. *ak | |||
| 10/01/1999 | 8 | 10/09/1999 | |
| Vehicle is pulling to left and right upon braking. consumer is especially concerned about drifting to left because of traffic. *ak driver side window molding comes loose when the window rolls down. right front wheel and spare wheel are bent. cruise control is inoperative at times. right rear axle experienced a leak. blower is noisy on low speeds. *jb | |||
| 04/01/2000 | |||
| Rear end of vehicle shakes violently. vehicle has been inspected,unable to located problem. *ak | |||
| 05/20/2000 | 4 | 05/01/2000 | |
| Problem #1 truck has a vibration since purchase date. dealer checked the balance of the tires 4 times and found them out of balance, tires were then balanced and rotated. but the vibration still existed. service manager stated that this was a problem i would have to live with. manufacture states all trucks have vibration. problem #2 the rear door will not latch after being opened in freezing weather, the front door will not close completely as it latches to the rear door. the doors can be closed completely after the interior has been warmed up enough for the locks to thaw, about 5 miles of travel with the heater running.*ak | |||
| 1 | |||
| Rear of vehicle leans to driver's side, dealer has attempted to fix vehicle 3 times, however has been unsuccessful. keyless entry transmitter inoperable. *slc | |||
| 06/20/2000 | 6 | 09/15/1999 | |
| Severe vibration from rear, causing rear to bounce across the road at approximately 40 mph or more. vehicle been in dealer's shop on six occasions and problem still reoccurring. *ak the manufacturer replaced the entire front suspension. *yh | |||
| 05/23/2000 | 04/13/2000 | ||
| While driving the weld that holds the sway bar to the frame broke, causing difficulty in steering. dealer has been contacted. *ak *ml | |||
| 10/01/1999 | 1 | 08/01/1999 | |
| Vehicle has annoying vibration when hitting bumps. steering wheel shakes when driving down the road. tires have been balanced, steering gear replaced, new shackles, hubs, and tires and the vehicle still vibrates. service managers states that it's just a truck. *ak | |||
| SUSPENSION - REAR - SHOCK ABSORBER | |||
| Owner took truck to have suspension lifted. in doing so, mechanic placed faulty rear shock mounts on truck, which broke while driving. after repairs were done on shocks,driveline started vibrating. mechanic did a partial repair of driveline, not resolving failure completely. please describe details.*ak | |||
| 04/01/2001 | 1 | 12/01/1999 | |
| When brakes are applied vibration runs through vehicle, dealership has examined vehicle, and stated that premature wear of rear disc rotors were causing vibration.*ak also the front axle seal was leaking as well as the rear shocks, and the brake pads were cracked.*jb | |||
| SUSPENSION - REAR - SPRINGS - LEAF SPRING ASSEMBLY | |||
| 01/08/2001 | 10 | ||
| Power steering went out/transmission rebuilt/ tires were wearing unevenly/rear springs had to be reinstalled *ak the power steering pump failure resulted in a loss of power assist to brakes causing accident. there were no injuries but the passenger door caved in. *yh | |||
| SUSPENSION - REAR - SPRINGS - LEAF SPRING ASSEMBLY - SHACKLE | |||
| 11/28/2004 | 1 | ||
| 2000 chevrolet silverado - rear suspension - spring shackle bolt nut found missing - no work has ever been done to rear suspension.*ak | |||