Recalls
Campaign | Manufacturer | Manufacturing date | Type | # of units affected | Date Owner notified Mfg | Recall Initiated by | Manufacturers of recalled vehicles/products | Report Recieved Date | Record Creation Date | Regulation Part Number | FMVSS Number | |||||
---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|
ENGINE AND ENGINE COOLING | ||||||||||||||||
06V289000 | GENERAL MOTORS CORP. | from 03/01/2003 to 08/31/2004 | V (Vehicle) | 38439 | 08/31/2006 | MFR | GENERAL MOTORS CORP. | 08/03/2006 | 08/03/2006 | |||||||
Defect Summary | On certain trucks equipped with an 8.1l v8 (rpo l8-vin g) engine have a condition in which the engine fuel rail pulse damper retainer clip may fracture resulting in inadequate retention of the damper. | |||||||||||||||
Consequence Summary | If the damper comes loose, a fuel leak may result. fuel leakage, in the presence of an ignition source, could result in a fire. | |||||||||||||||
Corrective Summary | Dealers will replace the engine fuel rail pulse damper retainer clip free of charge. the recall began on august 31, 2006. owners may contact chevrolet at 1-800-630-2438 and gmc trucks at 1-866-996-9463. | |||||||||||||||
Notes | Gm recall no. 06080.customers may also contact the national highway traffic safety administration |
Bulletins
Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
---|---|---|---|---|---|
ENGINE AND ENGINE COOLING | |||||
PIP-4138K | 01/01/2011 | 10037933 | Gm: the service engine soon light is on, there is also a misfire or engine noise. there are multiple possible causes. *rm | 06/08/2011 | |
PIP-4138K | 01/01/2011 | 10037933 | Ready | 06/08/2011 | |
050849026 | 11/01/2005 | 10018716 | Low oil pressure message display and chimes activated while driving following hybrid (hp2) lm7 engine auto-start (reprogram the pcm). *ts | 01/11/2006 | |
3100C | 10018575 | Ses light due to dtc p0116. *tt | 01/06/2006 | ||
3639 | 10018535 | Oil pressure gauge reading low or near red zone. *tt | 01/05/2006 | ||
0509610018 | 06/01/2005 | 10017533 | Accessory drive belt chirp, squeal, or squeak type noise at cold idle. *tt | 11/09/2005 | |
3317 | 12/01/2008 | 3317F | 10017214 | Hard start / no start outside temperatures below freezing. *tt updated 7/13/09. *pe | 10/28/2005 |
3312 | 10017208 | No start, hard start, loss of power, or white smoke. *tt | 10/27/2005 | ||
050604025 | 03/01/2005 | 10015009 | Revised diagnostic trouble code (dtc) u2104. *tt | 05/13/2005 | |
050603001 | 03/01/2005 | 10014989 | Revised engine electrical and automatic transmission - 4l60e/4l65e subsections - new caution statements added. *tt | 05/13/2005 | |
050604023 | 03/01/2005 | 10015007 | Revised diagnostic trouble code (dtc) p2563. *tt | 05/13/2005 | |
050604024 | 03/01/2005 | 10015008 | Revised diagnostic trouble code (dtc) p1172 and dtc p2636. *tt | 05/13/2005 | |
3328A | 10014952 | Surge at idle or 1100 to 1400 rpm. *eh | 05/12/2005 | ||
3380 | 10014932 | Oil leak from the pcv vent tube. *tt | 05/12/2005 | ||
3375 | 3375A | 10014923 | Rough idle, service engine soon (ses)light, unstable idle, hesitation, surge or stalling. with diagnostic trouble codes p0300, p0335 or p0336. *tt | 05/11/2005 | |
3299 | 10013563 | Diesel oil leak from pcv vent tube. *eh | 04/21/2005 | ||
3292 | 10013512 | Diesel engine balance rates all showing zero. *eh | 04/20/2005 | ||
050090001 | 01/01/2005 | 10013446 | Information on the proper air filter for the duramax diesel. *eh | 04/19/2005 | |
11062003 | 11/06/2003 | 10013155 | Airflow sensor problem. *eh | 04/11/2005 | |
020601023C | 11/01/2004 | 020601023D | 10012750 | Oil leak at cooler to engine block mating surface. *eh | 03/14/2005 |
040603002 | 02/01/2004 | 10012703 | Diagnostic information for intermittent vehicle no crank dead battery. *eh | 03/10/2005 | |
040604032 | 05/01/2004 | 10012601 | Proper method to secure fuel cap during refueling. *eh | 03/08/2005 | |
040601012 | 05/01/2004 | 040601012A | 10012591 | Rattle or crackling noise from engine compartment. *eh updated 03-07-06. *kb | 03/08/2005 |
040604007A | 04/01/2004 | 040604007 | 10012594 | Service engine soon (ses) light, p0087, p0093, p1093, low power, no start, hard start, fuel in crankcase. this service bulletin replaces 040604007. *eh | 03/08/2005 |
030604036 | 10/01/2006 | 030604036A | 10012561 | Information on servicing fuel injectors to avoid contamination. *eh updated 03-19-07. *kb | 03/07/2005 |
3239 | 10011743 | Lb7 engine vibration miss or runs rough no diagnostic trouble code. this also includes lb7 c2 c3 c4 c5 d4 d5 e4 e5 k2 k3. *eh | 01/31/2005 | ||
3238C | 3238E | 10011735 | Fuel injector driver circuit codes p0201 through p0208. this also includes 2004 2005 lly c2 c3 c4 c5 e4 e5 d4 d5 k2 k3 models. *eh updated *eh | 01/31/2005 | |
3227 | 10011674 | Broken #2 and #7 injector connector terminals. this also includes lly 6.6 c2 c3 c4 c5 k2 k3 d4 d5 e4 e5. *eh | 01/28/2005 | ||
3230 | 10011689 | Diesel oil leak at right rear of engine. this includes lly c2 c3 c4 c5 d4 d5 e4 e5 k2 k3 models. *eh | 01/28/2005 | ||
3212A | 3212B | 10011584 | Fuel leaking from body of injector. this also includes 2004-2005 lly c2 c3 c4 c5 k2 k3 d4 d5 e4 e5 models. *eh | 01/27/2005 | |
3068B | 3068C | 10011576 | Turbo air charge cooler hoses oil seepage or blows off on acceleration. this also includes 2004-2005 lly c2 c3 c4 c5 k2 k3 d4 d5 e4 e5 models. *eh | 01/27/2005 | |
09132004 | 09/13/2004 | 10011255 | Rough idle with white smoke and high balance rates. a 1700 1800 light throttle combustion noise. parking lot surge under ten miles per hour with engine rpm around 800 to 1000 rpm. this also includes 2004 3500 trucks with 6.6 liter diesel en | 01/12/2005 | |
3087 | 3087A | 10010916 | Crank no start, stall, hard start, and no cranking rpm. *eh | 12/16/2004 | |
3011B | 3011C | 10010872 | Engine oil leak at main bering side bolt. *eh | 12/15/2004 | |
3187 | 06/01/2009 | PIP-3187A | 10010865 | Engine low power will not go over 2300 rpms. *eh updated 6/11/10. *pe | 12/15/2004 |
3193 | 3193B | 10010647 | Excessive oil consumption. *eh | 12/03/2004 | |
3204 | 10010663 | Coolant leak at engine mount bolt. *eh | 12/03/2004 | ||
3097 | 01/01/2004 | 10010242 | Oil pan or oil cooler line leak. *sc | 11/05/2004 | |
3121 | 01/01/2004 | 10010187 | 6.6 lb7 engine with a no charge condition with diagnostic trouble code p0380 p0621. *sc | 11/04/2004 | |
3138 | 01/01/2004 | 10010106 | Accessory drive belt chirp noise at cold idle. *tc | 11/04/2004 | |
3107 | 01/01/2004 | 10010197 | P0420 and p0430 dtsc in the detroit, michigan area with gen iii v-8 engines. *sc | 11/04/2004 | |
3121 | 01/01/2004 | 10010056 | Exhaust vibration resonance or moan. (2004-2005 gmc denali) *sc | 11/03/2004 | |
3160 | 01/01/2004 | 10010041 | Gas engines exhaust buzz or rattle noise. *tc | 11/03/2004 | |
3100 | 01/01/2004 | 3100A | 10009998 | Low power service engine soon/malfunction indicator light on diagnostic trouble code p0116 and p0299. *sc | 11/03/2004 |
3109 | 01/01/2004 | 10009948 | Engineering is investigating the 04 6.6l lb7 injectors for concerns of dtc p1093 and high return line flow rates. *sc | 11/02/2004 | |
02055 | 01/01/2004 | 10007743 | Engine oil in the turbo charge air cooler pipes and hoses. *tt | 07/09/2004 | |
02054 | 01/01/2004 | 10007740 | Elimination of low coolant message from dic. service vme. *tt | 07/09/2004 | |
02092 | 01/01/2004 | 10007754 | Gurgle noise may be heard from the engine coolant compartment on trucks built with rpo hp2 parallel hybrid system. *tt | 07/09/2004 | |
ENGINE AND ENGINE COOLING - COOLING SYSTEM | |||||
3121 | 01/01/2004 | 10010248 | Exhaust vibration resonance or moan in vehicles with gen iii v8 engines. *tc | 11/08/2004 | |
3072 | 01/01/2004 | 10009622 | The engine coolant temperature or intake air temperature sensor may read -40 degrees when monitored with tech 2. *tt | 10/13/2004 | |
02013 | 01/01/2004 | 02013A | 10007119 | Coolant leak from head cup plugs on gen iii engines. *mr | 05/26/2004 |
10012003 | 10/01/2003 | 10006572 | Blueheat coolant heater thermo top c. webasto. *mr | 05/06/2004 | |
ENGINE AND ENGINE COOLING - COOLING SYSTEM - FAN | |||||
01339 | 11/18/2003 | 10004110 | Hvac blower motor fan stays on in the high blower position. service vme. *tt | 11/18/2003 | |
ENGINE AND ENGINE COOLING - ENGINE | |||||
PIP-4492P | 08/01/2010 | 10036464 | Buick/cadillac/chevrolet/gmc/hummer/pontiac/saab: oil consumption and/or exhaust smoke-possible pcv baffle or lifter concern. upon inspection, obvious oil will be found in the intake manifold and/or pcv vacuum tube. *pe | 03/16/2011 | |
PIP-4492P | 09/01/2010 | PIP-4492Q | 10036464 | Buick/cadillac/chevrolet/gmc/hummer/pontiac/saab: oil consumption and/or exhaust smoke-possible pcv baffle or lifter concern. upon inspection, obvious oil will be found in the intake manifold and/or pcv vacuum tube. *pe updated 3/21/ | 03/16/2011 |
060139002 | 04/01/2007 | 060139002B | 10022260 | Front blower motor inoperative or may not shut off in extremely low ambient temperature conditions. *kb | 07/24/2007 |
4231 | 10021021 | Service vme. supplement to 00-02-35-003l. update on new i-shaft. *kb | 02/22/2007 | ||
030693001 | 05/01/2006 | 030693001C | 10020839 | Diagnostic information on turbocharger malfunction due to lack of engine oil for lbz, lb7, and lly duramax diesel engine. *kb | 01/24/2007 |
060604026 | 12/01/2006 | 060604026A | 10020835 | Intermittent ses/mil lamp illuminated, reduced engine power, fuel injector driver circuit. dtc's p0201, p0202, p0203, p0204, p0205, p0206, p0207, p0208. cylinder bank shut down dtc's p2146, or p2149. *kb | 01/24/2007 |
050604077 | 12/01/2005 | 10019582 | Lack of power lu3 engine) at high ambient temperatures only (if necessary, reprogram pcm with new service calibration).*ak | 03/30/2006 | |
060601003 | 01/01/2006 | 10019474 | Information on longer main bearing cap bolts required for certain 2001-2006 lb7, lly, lbz duramax diesel engines. *tt | 03/15/2006 | |
3691B | 10019426 | Generation iii v8 engine piston repairs. *tt | 03/14/2006 | ||
050604063 | 10/01/2005 | 10017760 | Lm7, l59 or l33 engines with cold start rough or incorrect idle, misfire, malfunction indicator lamp (mil) or flashing requiring o2 sensor replacement. *tt | 11/29/2005 | |
050601014 | 05/01/2005 | 10017409 | Oil leak under extreme cold temperatures (-34 degrees c) (-30 degrees f) or colder). *tt | 11/07/2005 | |
05-06-04-047 | 04/01/2008 | 050604047C | 10017389 | Service engine soon (ses) light on with reduction in engine power, diagnostic trouble codes p0202 and p2146 or p0207 and p2149 set. *tt add dtc p1294. install revised 90 degree injector connector with harness support bracket servi | 11/04/2005 |
050604008 | 04/01/2005 | 050604008A | 10017337 | Diagnostic trouble code (dtc) p1172 or p2636, fuel gauge reads empty, service engine soon (ses) light on. *tt | 11/03/2005 |
050604029 | 06/01/2005 | 050604029A | 10017336 | Flexible fuel (rpo l59) rough idle, misfire, malfunction indicator lamp diagnostic trouble code p0300. *tt | 11/03/2005 |
3343 | 10017229 | Engine oil dipstick unseated or oil leak. *tt | 10/28/2005 | ||
3322 | 10017196 | Incorrect o2 sensors and wiring harness causing ho2 sensor heater circuit codes p0135 p0141 p0155 p0161. *tt | 10/27/2005 | ||
3048A | 10017154 | Supplement to 03-06-01-024b 4.3l lu3 l35 timing chain tensioner. rattle-type noise coming from the engine at approximately 1800 to 2200 rpms. *tt | 10/26/2005 | ||
3267 | 10017155 | Diagnostic trouble code p0128 or engine will not reach operating temperature. *sc | 10/26/2005 | ||
3258 | 10017160 | 6.6l lly engine oil leak at rear housing cover bolt. *tt | 10/26/2005 | ||
3394 | 3394D | 10017120 | 6.6 lly injector driver codes. misfire, rough running, and the mil/ses light on. *sc | 10/25/2005 | |
3556 | 10016942 | Hard start or extended crank time on initial cold start when using alcohol blended fuels. *sc | 10/18/2005 | ||
702 | 02/01/2005 | 10016371 | Duramax air filter. gm tech links. *tt | 09/09/2005 | |
3346 | 3346A | 10014804 | There has been a high percentage of no trouble found (ntf) 6.6 lly engine control modules (ecms) being returned to the warranty parts center. the no trouble found (ntf) ecms are being replaced for a specific list of diagnostic trouble code | 05/10/2005 | |
3232 | 3232A | 10014870 | 1999 - 2005 gen ii cold engine misfire at idle with possible p0171 and/or p0174. *tt | 05/10/2005 | |
3282 | 3282B | 10013504 | Engine overheat on vehicles equipped with rpo vyu snowplow prep package. *tt | 04/20/2005 | |
040604070 | 08/01/2005 | 040604070A | 10012715 | Information on the revised fuel filter for the 6.6l duramax diesel. *tt | 03/11/2005 |
040604043 | 06/01/2004 | 10012163 | Unable to reset engine oil life monitor. *tt | 02/16/2005 | |
040601020 | 06/01/2004 | 10012146 | Engine oil leak near oil filter. *tt | 02/15/2005 | |
040604007E | 10/01/2005 | 040604007F | 10012150 | Service engine soon (ses) light, p0087, p0093, p1093, low power, no start, hard start, fuel in crankcase. *tt | 02/15/2005 |
040601018 | 06/01/2004 | 10012143 | Information on revised design of intake gasket and related bolts for 2004 mid-year enhancement and prior year service usage. *tt | 02/15/2005 | |
040602006 | 06/01/2005 | 040602006A | 10011206 | Engine overheating. *tt | 01/10/2005 |
040604001 | 12/01/2006 | 040604001C | 10011126 | Various intermittent driveability conditions - hesitation, lack of power, etc. *tt | 01/03/2005 |
3056 | 10010364 | Check engine light with a p0300 due to 2-4 cylinders misfiring on the same bank of the engine. *tt | 11/17/2004 | ||
3038 | 01/01/2004 | 10009648 | Engine tick, rattle or knock noise after cylinder head gasket replacement on the 6.0l engine. *tt | 10/14/2004 | |
3055 | 01/01/2004 | 10009666 | Service engine soon light with a p0300 misfire due to misfires mainly on cylinder 7. *tt | 10/14/2004 | |
3022A | 01/01/2004 | 10009617 | 04 full size trucks and utilities with vin g, n, t, v and u engines may have a high altitude, high ambient temperature stall. *tt | 10/13/2004 | |
3086 | 01/01/2004 | 10009512 | Whistle noise from the throttle body area on light throttle acceleration on vehicles with gen iii engines and electronic throttle. *tt | 10/04/2004 | |
3087 | 01/01/2004 | 10009513 | Crank no start with no cranking rpm spark or injector pulse. *tt | 10/04/2004 | |
3004 | 01/01/2004 | 10008891 | 4.8l 5.3l 6.6l 8.1l p1285 p1286 or p2133 after replacing app sensor. *mj | 08/25/2004 | |
3025 | 01/01/2004 | 10008832 | 04 model year 4.8.5.3.7.6.0 gen iii engine piston pin information. *mj | 08/24/2004 | |
1530076 | 01/01/2004 | 10008787 | Vehicles and hummer h2 with a high altitude stall. *mj | 08/23/2004 | |
3018 | 01/01/2004 | 10008804 | Engine cylinder head cup plug coolant leak. *mj | 08/23/2004 | |
3011 | 01/01/2004 | 3011A | 10008780 | Repeat engine oil leak at main bearing side bolt. *tt | 08/23/2004 |
3015 | 01/01/2004 | 10008781 | 6.0l lq4 vin u engine restriction. *tt | 08/23/2004 | |
040604007 | 10/01/2006 | 040604007G | 10008460 | Service engine soon (ses) light, p0087, p0093, p1093, low power, no start, hard start, fuel in crankcase. *tt | 08/02/2004 |
01353 | 01/01/2004 | 01353A | 10007937 | Engine misfire due to injector fretting corrosion. *tt | 07/16/2004 |
00872A | 01/01/2004 | 10007916 | Oil pan or oil cooler line leak on gen iii v-8 engines equipped with an oil cooler. *tt | 07/15/2004 | |
02051 | 01/01/2004 | 10007737 | Intermittent service engine soon (ses) light comes on and code p0700 along with diagnostic trouble code p0742 stored. *tt | 07/09/2004 | |
00266 | 01/01/2004 | 00266A | 10007596 | Loss of power, hesitates on acceleration on 4.8, 5.3 and 6.0 engines coupled with the 4l60e or 4l65e transmission. *tt | 07/02/2004 |
01845 | 01/01/2004 | 01845A | 10007566 | Normal engine operating noise characteristics. *tt | 07/01/2004 |
00700A | 01/01/2004 | 00700B | 10007584 | 4.3l l35 engine wide open throttle diagnostic trouble code (dtc) p0335, p0336, p0339. *tt *mj | 07/01/2004 |
01119A | 01/01/2004 | 01119B | 10007576 | Roll-out for the gen iii small block engines with iridium spark plugs. also includes 2003/2004 m/l vans. *tt | 07/01/2004 |
01972 | 01/01/2004 | 01972B | 10007581 | Erratic oil pressure gmt 610 or gmt800 with codes p0522 or p0523. *tt 01972a replaced and updated 01/01/04. *sc | 07/01/2004 |
00609B | 01/01/2004 | 00609C | 10007527 | Low power, will not go over 2300 rpms. 6.6l lb7 engine. *tt | 06/30/2004 |
00764B | 01/01/2004 | 10007271 | 6.6l diesel engine rough idle, clatter, stall and/or diagnostic trouble code (dtc) p1223. *tt | 06/09/2004 | |
00678B | 01/01/2004 | 00678C | 10007286 | Engine overheats on vehicles equipped with rpo vyu snowplow prep package. *tt | 06/09/2004 |
01485B | 01/01/2004 | 01485C | 10007272 | Timing chain tensioner breakpoints for service kit or production fix. rattle-type noise coming from the engine at approximately 1800 to 2200 rpms. 4.3l lu3 l35 engine. *tt | 06/09/2004 |
01619 | 01/01/2004 | 10007183 | 6.6 lly engine glow plugs are not interchangeable with the current 6.6 lb7 glow plugs.*mr | 06/03/2004 | |
02029 | 01/01/2004 | 10006934 | Inaccurate fuel gauge readings and/or engine stall. *mr | 05/19/2004 | |
01939 | 01/01/2004 | 10006565 | 4.3 4.8 5.3 6.0 lr4 lu3 lm7 l59 lq4 lq9 engines- evap code p0442. *mr | 05/06/2004 | |
01701 | 01/01/2004 | 10006395 | 4.8 5.3 lm4 lm7 lr4 engine - with o2 sensor codes p0135, p0141, p0155, p0161. sit bulletin 1452753. *tt | 04/30/2004 | |
01774 | 01/01/2004 | 10006256 | 6.6l lb7 repeat engine oil leak (left side) #2 main bearing cross bolt. *mr | 04/27/2004 | |
01499 | 01/01/2004 | 10005481 | 2004 6.6l duramax lb7 engines with extended crank during hot engine restart. diagnostic trouble code (dtc) p0193 may or may not be set. sit bulletin 1402202. *tt | 03/01/2004 | |
01485A | 01/01/2004 | 10005445 | Timing chain tensioner breakpoints for service kit or production fix for vehicle exhibiting rattle-type noise coming from the engine at approximately 1800 to 2200 rpms. sit bulletin 1408407. *tt | 02/27/2004 | |
100903 | 10/09/2003 | 10004986 | Duramax diesel fuel in oil diagnostics revisited. gm voicemail log. this includes c4500 and 5500 trucks. *tt | 01/22/2004 | |
100803 | 10/08/2003 | 10004982 | The engine diagnostic fuel leaks inside of the engine. gm voicemail log. this includes 2000 - 2004 chevroand gmc c4500 and 5500 trucks. *tt | 01/22/2004 | |
020601022C | 01/01/2005 | 020601022D | 10004742 | Information on engine ticking. including 2004 chevrolet kodiak c45/c5500 series and 2004 gmc topkick c4500/c5500 series. *tt update. *tt | 01/05/2004 |
030604060 | 10/01/2003 | 10004733 | Information on new spark plugs and gapping. various models including pontiac gto 2004. *tt | 01/02/2004 | |
030603008 | 09/01/2003 | 10004373 | Avoiding oil level sensor harness damage during lower oil pan installation. *tt | 12/04/2003 | |
030603007 | 08/01/2003 | 10004372 | Availability of starter motor solenoid if damaged during service. 2004 chevrolet kodiak c4500/5500 and gmc topkick c4500/5500 included. *tt | 12/04/2003 | |
030601023 | 08/01/2003 | 10004370 | Higher than expected oil consumption <8500 gvw. various models including 2003-2004 chevrolet kodiak (c4500-c5500 series models)and gmc topkick (c4500-c5500 series models). *tt | 12/04/2003 | |
030604053 | 10/01/2003 | 10004315 | Revised fuel injector balance test with tech 2 (manual transmission). *tt | 12/02/2003 | |
030604054 | 10/01/2003 | 10004316 | Revised fuel injector balance test with tech 2 (automatic transmission). various models including 2003-2004 chevrolet kodiak and gmc topkick. *tt | 12/02/2003 | |
030604046 | 10/01/2003 | 10004307 | Revised engine cranks but does not run diagnostic. *tt | 12/01/2003 | |
030603001A | 10/01/2003 | 030603001 | 10004304 | Starter cranks after key is released (normal condition). *tt | 12/01/2003 |
030604045 | 10/01/2003 | 10004306 | Revised diagnostic trouble code (dtc) p0093 or dtc p1093 diagnostic tables. *tt | 12/01/2003 | |
01275C | 11/18/2003 | 10004189 | Some owners of 03 g-vans or 04 c/k trucks driving at high altitude with warm ambient temperatures may complain of a stall and or lack of power or running rough condition until the vehicle cools down. *tt | 11/21/2003 | |
00634A | 11/18/2003 | 10004162 | Gen iii engine noise after hot soak restart. *tt | 11/20/2003 | |
030604030 | 03/01/2007 | 030604030C | 10002166 | Multiple driveability symptoms of long or hard starts, chuggle, rough idle and light or intermittent misfire due to clogged fuel injectors. *tt | 08/14/2003 |
ENGINE AND ENGINE COOLING - ENGINE - DIESEL | |||||
PIP-3504C | 11/01/2010 | 10037516 | Ready | 05/25/2011 | |
PIP-3504C | 11/01/2010 | 10037516 | Gm: there is a diesel engine hard start when hot. starts fine when cold. there will be no internal trouble codes. *rm | 05/25/2011 | |
PIP-4629 | 04/01/2009 | 10030207 | Chevrolet/gmc: diesel engine turbo dtc p2563 or p003a. may encounter a concern of ses light, reduced power, low power. *pe | 08/18/2009 | |
07057 | 02/01/2008 | 10024154 | Special coverage adjustment - engine glow plug on certain vehicles with 6.6l diesel v8 (rpo lb7 - vin 1) engine & california emissions (yf5/ne1) or clean fuel emissions (vcl). csc was received. *nj | 03/13/2008 | |
070601009 | 05/01/2007 | 10021839 | Diesel engine cylinder head gasket missing thickness grade markings. *kb | 06/22/2007 | |
3328B | 3328C | 10017202 | Engine rpm surge at 1100 to 1400 rpm. this condition may be noticed more when towing. *tt | 10/27/2005 | |
3314 | 10017211 | Duramax diesel engine hard start, no start, stall of diagnostic trouble code p0093, p1093. *tt | 10/27/2005 | ||
3225A | 10017137 | 01-05 6.6 lly lb7 duramax diesel engine air filter usage. *sc | 10/25/2005 | ||
3504 | 3504A | 10016491 | Hard start hot only after the engine has reached operating temperature and then shut off. *tt | 09/14/2005 | |
00968A | 01/01/2004 | 00968B | 10007534 | 6.6l lb7 lly diesel engine with rough, unstable, low idle speed or stall. *tt | 06/30/2004 |
01512 | 01/01/2004 | 10005462 | 6.6 liter duramax diesel engine fuel knock noise. various models including the 2004 gmc c4500 and c5500. sit bulletin 1406247. *tt | 02/27/2004 | |
030693001A | 08/01/2005 | 030693001B | 10004319 | Diagnostic information for turbo failure due to lack of oil or repeat turbo failures. *tt | 12/02/2003 |
ENGINE AND ENGINE COOLING - ENGINE - GASOLINE | |||||
020601027 | 05/01/2005 | 020601027A | 634283 | Information on higher than expected oil consumption. nlm | 09/28/2002 |
ENGINE AND ENGINE COOLING - ENGINE - GASOLINE - BELTS AND ASSOCIATED PULLEYS | |||||
3048 | 01/01/2004 | 10009391 | Timing chain tensioner breakpoints for service kit or production kit. supplement to 03-06-01-024b. *tt | 09/27/2004 | |
01242A | 01/01/2004 | 10006284 | 6.6l lb7 lly diesel engine drive belt chirping on shut down. sit bulletin 1460352. *tt | 04/27/2004 | |
ENGINE AND ENGINE COOLING - ENGINE - GASOLINE - TURBO-CHARGER | |||||
3401 | 3401A | 10020072 | Turbocharger oil feed line kinked or restricted. *tt | 07/19/2006 | |
3348 | 3348A | 10014816 | Noise, service engine soon (ses) light, or low power. dealer may find turbine (exhaust side) wheel rub damage, a broken turbine shaft, or turbo bearing concern. *tt | 05/10/2005 | |
10292004 | 10/29/2004 | 10013041 | This is in regards to the unnecessary changing of turbochargers due to oil seepage. *tt | 04/06/2005 | |
3068 | 3068D | 10009606 | Oil seepage from turbo air charge cooler hoses or hose blowing off during acceleration. possible diagnostic trouble code p0299. *tt updated 04-24-07. *kb | 10/08/2004 | |
01496 | 01/01/2004 | 10005493 | 6.6l lb7 duramax diesel turbocharger noises or fuel economy complaint. service vme. sit bulletin 1401355. *tt | 03/01/2004 | |
100803 | 10/08/2003 | 10004983 | Excessive duramax turbocharger whine noise or possibly a performance or a fuel economy complaint. gm voicemail log. this includes 2003-2004 4500 and 5500 trucks. *tt | 01/22/2004 | |
01400 | 11/18/2003 | 10004204 | 6.6l duramax lb7 engines with turbocharger system whine noise. *tt | 11/21/2003 | |
ENGINE AND ENGINE COOLING - ENGINE - OTHER FUEL TYPES - TURBO-CHARGER | |||||
PIP-4629 | 04/01/2009 | 10030207 | Chevrolet/gmc: diesel engine turbo dtc p2563 or p003a. may encounter a concern of ses light, reduced power, low power. *pe | 08/18/2009 | |
01896 | 3066A | 10006476 | 6.6 lly duramax diesel engine turbocharger learn procedure. *mr | 05/04/2004 | |
001496A | 01/01/2004 | 10005513 | This message is in regard to duramax turbocharger noises or possibly a performance or fuel economy complaint. service vme. 6.6 lb7 diesel engine. p0102, p0103, p0236. *tt | 03/01/2004 | |
ENGINE AND ENGINE COOLING - EXHAUST SYSTEM | |||||
030605008B | 11/01/2005 | 030605008C | 10005576 | Advance service information - exhaust system popping/snapping noise when vehicle is hot, at idle or immediately after vehicle is shut off. *tt bulletin 03-06-05-008, dated 11/01/2003 replaced. *tt | 03/04/2004 |
01531 | 01/01/2004 | 10005447 | Exhaust moan vibration. sit bulletin 1408514. *tt | 02/27/2004 | |
020605003C | 02/01/2004 | 020605003B | 10002939 | Exhaust moan/vibration. *tt update. *tt | 10/01/2003 |
ENGINE AND ENGINE COOLING - EXHAUST SYSTEM - EMISSION CONTROL | |||||
050604021 | 03/01/2005 | 10015005 | Revised inspection/maintenance (i/m) evaporative emission (evap) system set procedure. *tt | 05/13/2005 | |
ENGINE AND ENGINE COOLING - EXHAUST SYSTEM - EMISSION CONTROL - CATALYTIC CONVERTOR | |||||
3119 | 01/01/2004 | 10010101 | Engineering investigation - catalytic converter replacement. *sc | 11/04/2004 | |
ENGINE AND ENGINE COOLING - EXHAUST SYSTEM - EMISSION CONTROL - CRANKCASE (PCV) | |||||
PIP-4492P | 09/01/2010 | PIP-4492Q | 10036464 | Buick/cadillac/chevrolet/gmc/hummer/pontiac/saab: oil consumption and/or exhaust smoke-possible pcv baffle or lifter concern. upon inspection, obvious oil will be found in the intake manifold and/or pcv vacuum tube. *pe updated 3/21/ | 03/16/2011 |
PIP-4492P | 08/01/2010 | 10036464 | Buick/cadillac/chevrolet/gmc/hummer/pontiac/saab: oil consumption and/or exhaust smoke-possible pcv baffle or lifter concern. upon inspection, obvious oil will be found in the intake manifold and/or pcv vacuum tube. *pe | 03/16/2011 | |
PIP3343 | 02/01/2008 | PIP3343A | 10024344 | Possible engine oil leak due to pcv freeze-up, equipped with the 4.8, 5.3, 6.0, and 6.2 v-8 engines. *nj | 04/07/2008 |
ENGINE AND ENGINE COOLING - EXHAUST SYSTEM - EMISSION CONTROL - GAS RECIRCULATION VALVE (EGR VALVE) | |||||
3256A | 10017169 | Vehicle may be brought in for service engine soon (ses) or malfunction indicator lamp (mil) light on. *tt | 10/26/2005 |
Consumer Complaints
Fail date | miles | occurences | Purchase date |
---|---|---|---|
ENGINE AND ENGINE COOLING | |||
09/15/2009 | 70000 | ||
Tl- the contact owns a 2004 chevrolet silverado. the contact stated that the vehicle exhibited an abnormal knocking from the engine. the dealer diagnosed that fuel was leaking into the engine abnormally. the manufacturer was contacted but denied any assistance with repairs to the failure. the vehicle was repaired but the failure recurred. the failure mileage was 70,000 and the current mileage was 150,000. the vin was not available. kmj | |||
09/15/2009 | 70000 | ||
Tl- the contact owns a 2004 chevrolet silverado. the contact stated that the vehicle would make a knocking sound, which was coming from the engine. the dealer diagnosed that fuel was leaking inside of the engine. the manufacturer was contacted, but denied any assistance with repair to the failure. the vehicle was repaired prior, but the failure recurred. the failure mileage was 70,000 and the current mileage was 150,000. nw | |||
02/01/2005 | 1200 | 240 | 12/21/2004 |
About 1 month after buying a new 2004 silverado it started surging viloently when cold. it is inconsistant, sometimes lasts for blocks. i almost got rear ended last week while tryig to control the truck. gm refuses to do anything, saying there is no diagnosis codes set and they have never heard of silverado`s surging. they class it as a feature and say i need to feather the clutch. feathering the clutch in traffic is a good way to get killed. this has been going on about 4 months now. i believe they know what is wrong and it is happening with more then just my one truck; but they don't want to spend the money to fix it. | |||
02/23/2005 | 25000 | 1 | 05/18/2004 |
While pulling inside of the garage the consumer applied the brakes and the pedal went to the floor. the vehicle stopped by hitting the house wall. the braking before the crash caused the abs and the engine lights to appear on the dashboard which remained on. the consumer was able to drive to the dealer for inspection. the mechanic informed the driver that the problem could not be duplicated. *jb | |||
01/02/2005 | 2 | 07/06/2004 | |
The vehicle shuts down and lurched forward when it was cold and during inclement weather. this made it difficult for driver to maintain control of the vehicle, increasing the chance of a crash. took to dealer for checkup, but results showed that the cause was undetermined.*ak | |||
07/17/2004 | 4500 | 2 | 04/15/2004 |
Vehicle over heated while towing a 10k lbs 5th wheel trailer, vehicle is rated to tow 17k lbs 5th wheel trailer. *ak | |||
ENGINE AND ENGINE COOLING - COOLING SYSTEM | |||
11/21/2008 | 64659 | 1 | |
Had two chevy silverados that develop intake and water pump gasket failure on a 4.3 liter engine. both develop coolant leak through the gasket. the latest was in november on my 2004 chevy silverado. upon checking the owners manual in regards to the dexcool coolant it clearly states that this coolant will burn if spill on a hot engine. it that the case then why can it burn it the intake gasket fail and coolant is leaking in the engine. i had a 2000 chevy silverado with intake gasket failure and also a 2004 chevy with gasket failure. both vehicles i had repaired my concern it the gasket failure on these gm products vehicle that no one at chevrolet seems to care. both vehicles gasket failure occurred around the mid 60,000 miles range. i am concern about the failure of these gaskets that causing the coolant to leak. apparently there is a problem with the gasket or the coolant that causing the gasket to fail. i would like someone to check into the problem of the gasket failure on gm products. especially the 4.3 liter engines. i concern that according to the owners manual the dexcool coolant can burn on a hot engine then can it cause a fire on the engine while driving if the intake manifold gaskets and the water pump gasket keeps failing. i had two different year model chevy silverado with 4.3 liter engine, a 2000 and 2004 silverados where both engine got around 65,000 miles and the gaskets failed on both engine. no one can explain how this occurred. but there must be defect in the gasket design or the coolant is causing the problem. *tr | |||
03/15/2008 | 50000 | 1 | 02/05/2004 |
Starting at around 50,000 miles and during routine driving conditions i noticed a scent of anti-freeze emanating from under hood. at first unable to locate leak and continued to drive vehicle. at around 69,000 miles leak became apparent and was leaking from the water pump. dealer assessed the problem and proceeded to inform me the repair would be $670. fortunately i had an extended warranty up to 75,000. vehicle now fixed and operating properly. *tr | |||
07/12/2005 | 14000 | 5 | 08/15/2004 |
My '04 chevy silverado hd2500 with duramax overheats when towing. *jb | |||
07/14/2005 | 20000 | 3 | 05/14/2004 |
While pulling my trailer my truck overheats and when it gets hot it will take all the power from the motor making a hazard and a safety issue. i have been taking it to the dealer for one year and the say nothing is wrong with it. *nm | |||
ENGINE AND ENGINE COOLING - ENGINE | |||
08/01/2009 | 100000 | ||
Tl* the contact owns a 2004 chevrolet silverado diesel. the contact stated that while driving approximately 40 mph, the vehicle would overheat. the failure would only occur when traveling on flat road surfaces, uphill or when pulling a trailer. the contact would shut off the engine until the engine was cooled in order to drive the vehicle any further. in addition, the contact stated if he would drive while the vehicle was running hot, it would stall. the dealer advised the vehicle was not under recall and repairs would be at the expense of the owner. the approximate failure mileage was 100,000 and the approximate current mileage was 143,000. | |||
02/14/2007 | 37850 | 1 | 02/05/2004 |
Engine noise at idle. ticking which sounds like lifters or injectors hanging up. *tr | |||
11/15/2006 | 63000 | 10 | 11/19/2004 |
Tl* - the contact owns a 2004 chevrolet silverado z71. the contact stated that the speedometer did not accurately register the speed being driven in this vehicle. even when not driving the speedomenter registered a speed. the contact stated that the engine light has been on 80% of the time since he owned the vehicle.*ak updated 2/22/2007 - *nm | |||
10/01/2005 | 21000 | 3 | |
2004 chevrolet silverado stalled while driving at 21000 miles. *ts when the vehicle stalled, the dash read reduced engine power. the vehicle would not re-start, steering and the braking was limited. the vehicle finally restarted but there was no power, the vehicle idled roughly and would not travel above 3-5 miles per hour. the vehicle was diagnosed with a throttle actuator code. the throttle actuator was replaced. *sc | |||
10/13/2005 | 46000 | 1 | 10/05/2004 |
Light ticking noise from engine from about 30,000 miles by 45,000 miles the noise is much more noticeable like lifters tapping. failure was with one of the cam shaft lobes chipping off a substantial piece of metal ( brake failure as opposed to being wiped ). the repair has not yet been completed but will require new cam shaft, lifters, head bolts, gasket kit. *jb | |||
08/19/2005 | 15760 | 6 | 12/12/2004 |
Dt: 2004 chevrolet silverado. the consumer stated the vehicle stalled while driving on the road. there were no warning lights that come on before this happened. this has happened every time under 50 mph. was able to be pull over the vehicle and restarted it immediately. the dealership could not duplicate the problem. when the vehicle was restarted it voided the chips memory. this has happened six times. the consumer had the vehicle towed to dealer,and the dealership could not find the cause of the problem. the consumer sent chevrolet a registered letter with the information, the claim was denied. the problem started on june 29, 2005, and the last time this happened was august 19, 2005. every time this happened the consumer called the dealership. *ak the dealer determined there was a lower cell n the battery and replaced it but the staling problem recurred. the consumer would like for the manufacturer to buy back the vehicle. *nm | |||
05/05/2005 | 1 | 08/01/2004 | |
2004 chevrolet silverado experienced complete shutdown while driving in traffic.*mr the manufacturer replaced the ignition switch, fuel pump, computer module and installed engine diagnostic system to monitor the truck. due to all the problems the consumer experienced the manufacturer replaced the truck. *nm | |||
ENGINE AND ENGINE COOLING - ENGINE - DIESEL | |||
09/10/2004 | 4000 | 4 | |
I own a 2004 chevy 2500hd with a lly duramax and the trucks overheats evrytime i pull a trailer that weighs 2000lbs or 12000lbs it does not matter. i think you need to help us out that own this model and year of truck and make gm fix it. *nm | |||
07/29/2005 | 1539 | 6 | 08/01/2004 |
2004.5 chevy silverado 2500 duramax overheats on several occasions to 258 deg while towing 9000lb trailer 2 times transmissions has gone to 270 deg and has gone into a protective mode while climbing a hill causing us to nearly get rear ended due to no place to pull over and extremely slow speeds took to dealer 6 times with no fix. dealer refuses to go on road test and says vehicle is operating normally this presents and immediate danger due to slow speeds, possibility of a fire and the damage to my truck from over heating. *jb | |||
06/09/2005 | 22000 | 3 | 05/01/2004 |
2004.5 lly 2500hd silverado duramax towing 1700 lund prosport in ~85 degree ambient. i was required to turn of the a/c and limit the power as the engine temp continued to climb beyond 210 and into the 235-240 degree range. this is a constant probelm with this engine under minimal load. dealer has no fix for this truck which is still under warranty and gm keeps saying they are working on the problem. if i continued operating my truck as normal the engine would sustain overheating damage thus causing great damage to components further down the road. | |||
01/03/2005 | 12250 | 5 | 05/28/2004 |
On three separate occasions while applying the brake pedal it went to the floor. the vehicle failed to stop. the driver was able to maintain control of the vehicle, and drove it to the dealer for inspection. however, the mechanic could not duplicate the problem at this time. *ak the abs/brake light stayed on, there was an intermittent rattle in the flywheel, the consumer stated that the clutch has no throw. *sc *jb | |||
10/24/2004 | 1928 | 8 | 07/31/2004 |
After the vehicle is warm, one of the injector sleeves begins to leak diesel and oil into the crankcase, causing plumes of white and black smoke to come out of the tail pipe and causes the truck to sputter. a loud sound of a valve flapping violently also is heard. the truck has been to the dealership 4 times. each time, they say that nothing is wrong. one dealer in monterey said that the injectors are from a 2003 model truck and are smaller than the 2004 sleeves, therefore allowing diesel and oil to leak into the crankcase. the dealership has been unwilling to correct the problem in sacramento.*ak | |||
ENGINE AND ENGINE COOLING - EXHAUST SYSTEM - EMISSION CONTROL | |||
02/02/2005 | 8000 | 2 | |
Repeated failure of vehicle oxygen sensor.*ak | |||
ENGINE AND ENGINE COOLING - EXHAUST SYSTEM - EMISSION CONTROL - CRANKCASE (PCV) | |||
04/29/2005 | 20000 | 1 | 09/22/2004 |
Dt: driving down the highway, and a piece of pvc pipe went into the front of the gas tank and then most of the way out. right now, there are approximately 15 pounds of pvc pipe stuck in the tank. the aluminum cover only covers the back and the side of the gas tank.*ak | |||
10/24/2004 | 1928 | 8 | 07/31/2004 |
After the vehicle is warm, one of the injector sleeves begins to leak diesel and oil into the crankcase, causing plumes of white and black smoke to come out of the tail pipe and causes the truck to sputter. a loud sound of a valve flapping violently also is heard. the truck has been to the dealership 4 times. each time, they say that nothing is wrong. one dealer in monterey said that the injectors are from a 2003 model truck and are smaller than the 2004 sleeves, therefore allowing diesel and oil to leak into the crankcase. the dealership has been unwilling to correct the problem in sacramento.*ak |