Bulletins
Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
---|---|---|---|---|---|
ENGINE AND ENGINE COOLING | |||||
PIP-4568K | 01/01/2011 | 10037941 | Ready | 06/08/2011 | |
PIP-4568K | 01/01/2011 | 10037941 | Gm: service engine soon light is on with a misfire and a possible tick noise. *rm | 06/08/2011 | |
PIP-4138K | 01/01/2011 | 10037933 | Gm: the service engine soon light is on, there is also a misfire or engine noise. there are multiple possible causes. *rm | 06/08/2011 | |
PIP-4138K | 01/01/2011 | 10037933 | Ready | 06/08/2011 | |
3187 | 06/01/2009 | PIP-3187A | 10010865 | Engine low power will not go over 2300 rpms. *eh updated 6/11/10. *pe | 12/15/2004 |
ENGINE AND ENGINE COOLING - COOLING SYSTEM - FAN | |||||
08-01-38-002 | 04/01/2008 | 10025224 | Blower motor inoperative (replace blower motor) for extended and crew cab models only. *pe | 07/18/2008 | |
ENGINE AND ENGINE COOLING - COOLING SYSTEM - HOSE | |||||
08-04-19-004 | 08/01/2008 | 10026624 | Gmc: correct front axle vent hose routing. the front axle vent hose is mounted in the left side of the engine compartment, and may not be correctly routed. *pe | 11/19/2008 | |
ENGINE AND ENGINE COOLING - ENGINE | |||||
PIT-4769B | 03/01/2011 | 10038624 | Ready | 06/24/2011 | |
PIT-4769B | 03/01/2011 | 10038624 | Gm: the air bag light is on with a stored trouble code. *rm | 06/24/2011 | |
PIP-3783C | 12/01/2010 | 10037809 | Gm: the engine light is on and the vehicle lacks power. there are multiple possible trouble codes. *rm | 06/06/2011 | |
PIP-3783C | 12/01/2010 | 10037809 | Ready | 06/06/2011 | |
SB-07-06-03-002C | 07/01/2010 | 10036524 | Cadillac/chevrolet/gmc: information on inspecting top post battery cable bolts, clamps and nuts during pre-delivery inspection (pdi). *pe | 03/28/2011 | |
PIP-4492P | 09/01/2010 | PIP-4492Q | 10036464 | Buick/cadillac/chevrolet/gmc/hummer/pontiac/saab: oil consumption and/or exhaust smoke-possible pcv baffle or lifter concern. upon inspection, obvious oil will be found in the intake manifold and/or pcv vacuum tube. *pe updated 3/21/ | 03/16/2011 |
PIP-4492P | 08/01/2010 | 10036464 | Buick/cadillac/chevrolet/gmc/hummer/pontiac/saab: oil consumption and/or exhaust smoke-possible pcv baffle or lifter concern. upon inspection, obvious oil will be found in the intake manifold and/or pcv vacuum tube. *pe | 03/16/2011 | |
PIT-5028 | 09/01/2010 | 10036324 | Pontiac/saturn/buick/gmc/chevrolet/cadillac/hummer: vehicle start and stalls after theft deterrent module replacement. model years 2006-2011. does not apply to vehicles with keyless access system. *pe | 03/14/2011 | |
SB-02-06-04-0371 | 09/01/2010 | 10035764 | Chevrolet/gmc: check engine light on, fuel tank hard to fill, dtcs p0442, p0446, p0455 or p0449 set (replace evaporative emission (evap) vent valve solenoid assembly and add/relocate fileter box using service kit). *pe | 03/04/2011 | |
SB-08-06-04-054A | 01/01/2010 | 10034364 | Chevrolet/gmc: snow or ice ingestion into air cleaner element, malfunction indicator lamp (mil) illuminated, engine power is reduced message displayed, dtc p0101 set (perform repair as outlined). *pe | 11/08/2010 | |
SB-09-06-01-006 | 05/01/2009 | 10030724 | Gmc/cadillac/chevrolet: check engine light on, engine misfire, hard start, rough idle, hesitation, loss of power, poor performance, noise, dtcs p0300, p0301, p0302,p0303, p0304, p0305, p0306, p0307, p0308 set (replace engine). *pe | 11/23/2009 | |
PIT-4846A | 05/06/2009 | 10030244 | Cadillac/chevrolet/gmc: locations of high speed gmlan wiring concerns. gauges inoperative, no crank, harsh transmission shifting, no transmission shifting, door locks cycling and indicators on. *pe | 09/02/2009 | |
TB-09-06-04-022 | 05/01/2009 | TB-09-06-04-022A | 10030110 | General motors: malfunction indicator lamp (mil) illuminated, intermittent dtc p0191, slow fuel rail pressure (frp) decay, wiring harness connections, voltage fluctuations/interruptions (follow correction information below). *pe | 08/03/2009 |
08-06-03-007 | 07/01/2008 | 10026007 | Gmc: no start, no crank, intermittent electrical operations (check for poor connections within engine wiring harness junction block). *pe | 09/23/2008 | |
08-07-30-021 | 05/01/2008 | 10025668 | Loss of high speed gmlan communications, intermittent no crank, ipc gauge fluctuation, intermittent door lock cycling, transmission may not shift, dtcs u0073, u0100, u0101, u0102, u0121, u0140 set (repair backed out terminal in transmission | 08/28/2008 | |
08-07-30-021 | 04/01/2008 | 10025402 | Loss of high speed gmlan communications, intermittent no crank, ipc gauge fluctuation, intermittent door lock cycling, transmission may not shift, dtcs u0073, u0100, u0101, u0102, 70140 (repair backed out terminal in transmission harness co | 08/06/2008 | |
08142 | 10/01/2008 | PB-08142A | 10025303 | Ecm eeprom - reprogram ecm. all 2007 and certain 2008 cheverolet silverado and express and gmc sierra and savana equipped with 6.6l duramax va diesel (rpo lmm - vin 6) engine. csc was received. *pe updated 5/5/09. csc letter was | 07/28/2008 |
PIP4321 | 02/01/2008 | PIP4321A | 10024285 | Oil leak at rear of engine. equipped with a 4.8, 5.3, 6.0 or 6.2 v8 engine. *nj | 04/01/2008 |
PIT4284 | 02/01/2008 | PIT4284A | 10024282 | Engine stalls after being remote started. *nj | 04/01/2008 |
PIP4344 | 02/01/2008 | 10024204 | Short duration cold start lifter tick noise. equipped with the 5.3 or 6.0 active fuel management engines. *nj | 03/24/2008 | |
3917 | 12/01/2007 | 3917E | 10022901 | Engine has low power on acceleration or when towing. equipped with the 6.0l ly6 and l76 engine. *nj updated 1/29/08. *nj | 10/03/2007 |
4200 | 10022796 | Perceived hesitation or lack of power during throttle reapply at slow speeds. *kb | 09/27/2007 | ||
02-06-04-037 | 04/01/2008 | 020604037D | 634786 | Some customers whose vehicles are operated in dusty type environments, such as farming or mining off-road type applications, may comment about the illumination of the instrument panel ses light, with diagnostic trouble code p0446 set. *tt | 10/09/2002 |
ENGINE AND ENGINE COOLING - ENGINE - DIESEL | |||||
PI-0474 | 05/01/2011 | 10038744 | Gm: an 'engine power is reduced' message appears and there is a stored trouble code. this is caused by wear of the internal fuel injector. *rm | 06/27/2011 | |
PI-0474 | 05/01/2011 | 10038744 | Ready | 06/27/2011 | |
PIP-3504C | 11/01/2010 | 10037516 | Ready | 05/25/2011 | |
PIP-3504C | 11/01/2010 | 10037516 | Gm: there is a diesel engine hard start when hot. starts fine when cold. there will be no internal trouble codes. *rm | 05/25/2011 | |
PIP-4574M | 08/01/2010 | 10036485 | Buick/chevrolet/gmc/pontiac/saab: excessive oil consumption and/or blue exhaust smoke-investigation update. in most cases did not start until the engine accumulated approximately 30,000 miles or more. *pe | 03/21/2011 | |
SB-08-06-04-054A | 01/01/2010 | 10034364 | Chevrolet/gmc: snow or ice ingestion into air cleaner element, malfunction indicator lamp (mil) illuminated, engine power is reduced message displayed, dtc p0101 set (perform repair as outlined). *pe | 11/08/2010 | |
PIP-4660 | 06/01/2009 | 10032888 | Gmc/chevrolet: engine coolant sensor dtcs p011a, p2184, and p2185. dealer may encounter concern of ses light on or dtcs p011a, p2184 and p2185. diesel engines have 2 ect (engine coolant temperature) sensors. *pe | 06/08/2010 | |
PIP-4664 | 06/01/2009 | 10032889 | Gmc/chevrolet: dtc p0101 with non gm air filter. may encounter concern of reduced power and ses light on. diagnostics may reveal maf (mass air flow) sensor dtc p0101. if diagnostics were inconclusive its possible dtc p0101 is setting du | 06/08/2010 | |
PIP-4629 | 04/01/2009 | 10030207 | Chevrolet/gmc: diesel engine turbo dtc p2563 or p003a. may encounter a concern of ses light, reduced power, low power. *pe | 08/18/2009 | |
SB-08-06-04-029B | 07/01/2009 | SB-08-06-04-029C | 10030123 | General motors: lbz, lly, lmm mil/ses light n dtc p0087-fuel rail pressure (frp) too low, lack of performance, no power, engine runs rough, no start (diagnose fuel system components). *pe updated 3/1/10. *pe | 08/05/2009 |
PIP-4380 | 07/01/2008 | 10026108 | Gmc: egr low flow dtc p0401. vehicles that are equipped with the 6.6l diesel engine rpo code lm. *pe | 09/30/2008 | |
07-06-04-033A | 05/01/2008 | 10025681 | Lmm, clean exhaust filter light illuminated, mil/ses light illuminated with dtc(s) p244b and/or p2463 set (perform all si diagnostics for dtc(s) set, if ntf, replace air filter). vehicles with 6.6l duramax diesel engine. *pe | 08/29/2008 | |
PIP4348 | 04/01/2008 | 10024712 | Duramax diesel dpf regeneration changes - vehicles equipped with the 6.6 duramax diesel engine rpo code lmm. *nj | 05/13/2008 | |
4529 | 12/01/2007 | 10023721 | High idle, elevated idle, and pto all different options. *nj | 01/29/2008 | |
PIP4307 | 04/01/2008 | PIP4307D | 10023740 | Ses light on due to dtc p0101 and/or p0106 - inspect air filter and/or map sensor . with 6.6l diesel engine (rpo, lbz, lly, or lmm). *nj updated 5/13/08. *nj | 01/29/2008 |
ENGINE AND ENGINE COOLING - ENGINE - GASOLINE - TURBO-CHARGER | |||||
PIP-4372B | 07/01/2008 | 10026650 | Gmc: oil leak at turbocharger air intake pipe. initial inspection ma reveal a leak that looks as it is coming from the rear of the engine. *pe | 11/24/2008 | |
ENGINE AND ENGINE COOLING - ENGINE - OTHER FUEL TYPES - TURBO-CHARGER | |||||
PIP-4888 | 03/01/2011 | 10038605 | Ready | 06/24/2011 | |
PIP-4888 | 03/01/2011 | 10038605 | Gm: information on inspecting and replacing turbos. *rm | 06/24/2011 | |
PIP-4857 | 11/01/2010 | 10037499 | Ready | 05/24/2011 | |
PIP-4857 | 11/01/2010 | 10037499 | Gm: there may be reduced power and an internal trouble code in high temperatures or when near the towing limit. *rm | 05/24/2011 | |
PIP-4629 | 04/01/2009 | 10030207 | Chevrolet/gmc: diesel engine turbo dtc p2563 or p003a. may encounter a concern of ses light, reduced power, low power. *pe | 08/18/2009 | |
PIP-4372B | 07/01/2008 | 10026650 | Gmc: oil leak at turbocharger air intake pipe. initial inspection ma reveal a leak that looks as it is coming from the rear of the engine. *pe | 11/24/2008 | |
ENGINE AND ENGINE COOLING - EXHAUST SYSTEM | |||||
PIP-4574M | 08/01/2010 | 10036485 | Buick/chevrolet/gmc/pontiac/saab: excessive oil consumption and/or blue exhaust smoke-investigation update. in most cases did not start until the engine accumulated approximately 30,000 miles or more. *pe | 03/21/2011 | |
ENGINE AND ENGINE COOLING - EXHAUST SYSTEM - EMISSION CONTROL | |||||
SB-02-06-04-0371 | 09/01/2010 | 10035764 | Chevrolet/gmc: check engine light on, fuel tank hard to fill, dtcs p0442, p0446, p0455 or p0449 set (replace evaporative emission (evap) vent valve solenoid assembly and add/relocate fileter box using service kit). *pe | 03/04/2011 | |
ENGINE AND ENGINE COOLING - EXHAUST SYSTEM - EMISSION CONTROL - CRANKCASE (PCV) | |||||
PIP-4492P | 08/01/2010 | 10036464 | Buick/cadillac/chevrolet/gmc/hummer/pontiac/saab: oil consumption and/or exhaust smoke-possible pcv baffle or lifter concern. upon inspection, obvious oil will be found in the intake manifold and/or pcv vacuum tube. *pe | 03/16/2011 | |
PIP-4492P | 09/01/2010 | PIP-4492Q | 10036464 | Buick/cadillac/chevrolet/gmc/hummer/pontiac/saab: oil consumption and/or exhaust smoke-possible pcv baffle or lifter concern. upon inspection, obvious oil will be found in the intake manifold and/or pcv vacuum tube. *pe updated 3/21/ | 03/16/2011 |
PIP3343 | 02/01/2008 | PIP3343A | 10024344 | Possible engine oil leak due to pcv freeze-up, equipped with the 4.8, 5.3, 6.0, and 6.2 v-8 engines. *nj | 04/07/2008 |
Investigations
NHTSA ID | Manufacturer | Date open | Date close | Subject | Recall campaign | |
---|---|---|---|---|---|---|
ENGINE AND ENGINE COOLING | ||||||
PE08010 | GENERAL MOTORS CORP. | 02/04/2008 | 06/12/2008 | NON-CRASH ENGINE COMPARTMENT FIRES | ||
In response to an information request letter sent by the office of defects investigation(odi) during preliminary evaluation pe08-010, gm provided odi with 41 allegations of non-crash engine compartment fires including 16 allegations of fires originating with the ignition in the off position.one of the fires was determined to be caused by an arson event.odi has also received 5 reports, 4 of which are of duplicative of reports provided by gm, alleging non-crash engine compartment fires in the subject vehicles.in total, odi is aware of 41 non-crashengine compartment fires in the subject vehicles that are unrelated to arson.eight of the 41 fire allegations also allege property damage as a result of the fires.this preliminary evaluation has been upgraded to an engineering analysis (ea08-010) to further assess the scope, frequency, origin and cause of the alleged non-crash related engine compartment fires in the subject vehicles. | ||||||
EA08010 | GENERAL MOTORS CORP. | 06/12/2008 | 09/08/2008 | NON-CRASH ENGINE COMPARTMENT FIRES | 08V441000 | |
In a letter dated august 27, 2008, general motors corp. (gm) notified nhtsa that it will conduct a safety recall (nhtsa recall number 08v-441) to address a safety relateddefect that can result in engine compartment fire in approximately 850,000 vehicles equipped with a heated windshield washer fluid option.the subject vehicles of this investigation comprise over three-quarters of the recall population. according to gm, a short circuit on the printed circuit board for the windshield washer fluid heater module may overheat the control-circuit ground wire. this may cause other electrical features to malfunction, create an odor or cause smoke and in rare cases it may cause a fire.as a remedy, gm dealers will install a wire harness with an in-line fuse. in addition to the subject vehicles, several other gm models with the heated windshield washer fluid option are included in recall 08v-441: my 2006-2008 buick lucerne (manufactured august 2005 through november 2007); my 2008 buick enclave (manufactured february 2007 through april 2007); my 2006-2008 cadillac dts (manufactured may 2007 through november 2007); my 2007-2008 saturn outlook (manufactured august 2006 through april 2007); and my 2007-2008 gmc acadia (manufactured august 2006 through april 2007) vehicles.gm is instructing owners to take their vehicle to a dealer for service if they experience symptoms of windshield washer heater module short circuits. gm's recall resolves the safety defect concerns pursued by this investigation.this engineering analysis is closed. | ||||||
ENGINE AND ENGINE COOLING - ENGINE | ||||||
PE08010 | GENERAL MOTORS CORP. | 02/04/2008 | 06/12/2008 | NON-CRASH ENGINE COMPARTMENT FIRES | ||
In response to an information request letter sent by the office of defects investigation(odi) during preliminary evaluation pe08-010, gm provided odi with 41 allegations of non-crash engine compartment fires including 16 allegations of fires originating with the ignition in the off position.one of the fires was determined to be caused by an arson event.odi has also received 5 reports, 4 of which are of duplicative of reports provided by gm, alleging non-crash engine compartment fires in the subject vehicles.in total, odi is aware of 41 non-crashengine compartment fires in the subject vehicles that are unrelated to arson.eight of the 41 fire allegations also allege property damage as a result of the fires.this preliminary evaluation has been upgraded to an engineering analysis (ea08-010) to further assess the scope, frequency, origin and cause of the alleged non-crash related engine compartment fires in the subject vehicles. | ||||||
EA08010 | GENERAL MOTORS CORP. | 06/12/2008 | 09/08/2008 | NON-CRASH ENGINE COMPARTMENT FIRES | 08V441000 | |
In a letter dated august 27, 2008, general motors corp. (gm) notified nhtsa that it will conduct a safety recall (nhtsa recall number 08v-441) to address a safety relateddefect that can result in engine compartment fire in approximately 850,000 vehicles equipped with a heated windshield washer fluid option.the subject vehicles of this investigation comprise over three-quarters of the recall population. according to gm, a short circuit on the printed circuit board for the windshield washer fluid heater module may overheat the control-circuit ground wire. this may cause other electrical features to malfunction, create an odor or cause smoke and in rare cases it may cause a fire.as a remedy, gm dealers will install a wire harness with an in-line fuse. in addition to the subject vehicles, several other gm models with the heated windshield washer fluid option are included in recall 08v-441: my 2006-2008 buick lucerne (manufactured august 2005 through november 2007); my 2008 buick enclave (manufactured february 2007 through april 2007); my 2006-2008 cadillac dts (manufactured may 2007 through november 2007); my 2007-2008 saturn outlook (manufactured august 2006 through april 2007); and my 2007-2008 gmc acadia (manufactured august 2006 through april 2007) vehicles.gm is instructing owners to take their vehicle to a dealer for service if they experience symptoms of windshield washer heater module short circuits. gm's recall resolves the safety defect concerns pursued by this investigation.this engineering analysis is closed. |
Consumer Complaints
Fail date | miles | occurences | Purchase date |
---|---|---|---|
ENGINE AND ENGINE COOLING | |||
11/15/2007 | 1000 | 1 | |
I took my new chevy truck into the dealer for some new factory equipment (bug deflector and bed liner) to be installed by them. while the dealer had my 2007 chevy truck they loaded 2008 power train software into it's computer without my permission. the 2008 software changed the way my truck runs. the power train now has a speed limiter on it and the stability control was changed. it will not go as fast it as use to go before the change. i was told by the dealer and gm they would not put my truck back the way it was as when i bought it. they told me that the reason was the goodyear tires and the truck design were unsafe without the 2008 software installed and would not change my truck back to the 2007 configration . i have not gotten any recall or safety notices about this issue. i think gm and the dealer made a mistake and do not want to correct it. if there is a problem with the tires (goodyear wrangler tires) and the 2007 truck design (gm silverado 1500 lts crew cab) gm is trying to cover it up. there are hundreds of thousands of 2007 gm trucks, cars, suv's even cadillac's that have the same power train in them that my truck has and they are not changing the computer programs in all those vehicles. i was told they would be changed only if the trucks, suv's and cars were brought in for any kind of service work, but would not be changed if not serviced by gm. sense there have been no recall notices about these issues i think gm is trying to cover something up . the very least trying to cover up their dealers and there mistake by altering my truck without my permission or they do have a serious problem that the public should be aware of. please look into this. the same tires are on fords and dodges and they don't software limit there performance. i paid top dollar for gm's best truck with the biggest engine made for it, i could have saved a lot of money by buying a six cylinder engine instead of the big v-8. if i knew gm was going to de-rate mine. *tr | |||
ENGINE AND ENGINE COOLING - ENGINE | |||
01/20/2009 | 33600 | 1 | |
30 minutes after ignition turned off and parked after driving in 4-wheel down a 1/2 mile snowy driveway, my 2007 silverado duramax 2500hd pick-up truck was totally engulfed in flames and burned to a crisp. forensic fire inspector said it started in front right engine compartment; no arson. fire department put it out; police report said no arson. *tr |