Bulletins
Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
---|---|---|---|---|---|
ENGINE AND ENGINE COOLING | |||||
030604036 | 10/01/2006 | 030604036A | 10012561 | Information on servicing fuel injectors to avoid contamination. *eh updated 03-19-07. *kb | 03/07/2005 |
ENGINE AND ENGINE COOLING - ENGINE | |||||
SB-08-06-04-054A | 01/01/2010 | 10034364 | Chevrolet/gmc: snow or ice ingestion into air cleaner element, malfunction indicator lamp (mil) illuminated, engine power is reduced message displayed, dtc p0101 set (perform repair as outlined). *pe | 11/08/2010 | |
08142 | 10/01/2008 | PB-08142A | 10025303 | Ecm eeprom - reprogram ecm. all 2007 and certain 2008 cheverolet silverado and express and gmc sierra and savana equipped with 6.6l duramax va diesel (rpo lmm - vin 6) engine. csc was received. *pe updated 5/5/09. csc letter was | 07/28/2008 |
070604013 | 05/01/2007 | 10021841 | Chuggle, surge or hesitation may be felt with active fuel management system cylinder deactivation transition from v8 mode to v4 mode. *kb | 06/22/2007 | |
060603013 | 09/01/2007 | 060603013B | 10021448 | Intermittent low battery voltage, engine will not crank, engine cranks but will not start, charging system light on, service battery charging system message displayed, dtc b1405 and/or b1516 set. (reprogram bcm). *kb updated 11/02 | 04/27/2007 |
4040 | 4040A | 10021394 | Harsh tcc apply or tcc cycling. *kb | 04/24/2007 | |
060603011 | 01/01/2007 | 060603011A | 10021118 | Humming or buzzing from rear of vehicle and/or possible dead battery. (check fuel pump relay and replace, if necessary). *kb | 03/07/2007 |
060604066 | 03/01/2007 | 060604066A | 10021106 | Lbz, lly, engine with rough idle, poor performance, black/white exhaust smoke, mil/ses light on and one or more of the following dtc's p003a, p060b, p0230, p0403, p0401, p0606, p2146, p2149, p2152, p2155. (reprogram ecm and replace egr mot | 03/05/2007 |
3999 | 3999B | 10021076 | Loss of power when driving in extreme winter weather. *kb | 03/01/2007 | |
4006 | 10021023 | Whine howl noise from the rear differential on vehicles equipped with an 8.6 rear axle. *kb | 02/22/2007 | ||
4231 | 10021021 | Service vme. supplement to 00-02-35-003l. update on new i-shaft. *kb | 02/22/2007 | ||
3939 | 10/05/2006 | 10020965 | Transfer case control module investigation. *kb | 02/02/2007 | |
060603009 | 10/01/2006 | 10020948 | Diagnostic information on battery draw no start - body control module, bcm power timer. *kb | 02/01/2007 | |
060845007 | 09/01/2006 | 10020889 | No start/loss of low speed lan, dtc's set. *kb | 01/26/2007 | |
060604042 | 09/01/2006 | 060604042A | 10020880 | Lr4, ly2, l33, lh6, lm7, l59, lc9, lmg, ly5, ls2, lq9, lq4, l76, ly6 throttle actuator control (tac). module codes, mil/ses dtc's p2108, p1516, u0107, reduced engine power. *kb | 01/25/2007 |
3317 | 12/01/2008 | 3317F | 10017214 | Hard start / no start outside temperatures below freezing. *tt updated 7/13/09. *pe | 10/28/2005 |
040604001 | 12/01/2006 | 040604001C | 10011126 | Various intermittent driveability conditions - hesitation, lack of power, etc. *tt | 01/03/2005 |
ENGINE AND ENGINE COOLING - ENGINE - DIESEL | |||||
SB-08-06-04-054A | 01/01/2010 | 10034364 | Chevrolet/gmc: snow or ice ingestion into air cleaner element, malfunction indicator lamp (mil) illuminated, engine power is reduced message displayed, dtc p0101 set (perform repair as outlined). *pe | 11/08/2010 | |
4147 | 12/01/2007 | 4147C | 10022592 | Duramax diesels with ses light and dtc p0402. *kb updated 2/27/08. *nj | 08/27/2007 |
ENGINE AND ENGINE COOLING - ENGINE - GASOLINE - TURBO-CHARGER | |||||
3068 | 3068D | 10009606 | Oil seepage from turbo air charge cooler hoses or hose blowing off during acceleration. possible diagnostic trouble code p0299. *tt updated 04-24-07. *kb | 10/08/2004 |
Investigations
NHTSA ID | Manufacturer | Date open | Date close | Subject | Recall campaign | |
---|---|---|---|---|---|---|
ENGINE AND ENGINE COOLING | ||||||
EA08010 | GENERAL MOTORS CORP. | 06/12/2008 | 09/08/2008 | NON-CRASH ENGINE COMPARTMENT FIRES | 08V441000 | |
In a letter dated august 27, 2008, general motors corp. (gm) notified nhtsa that it will conduct a safety recall (nhtsa recall number 08v-441) to address a safety relateddefect that can result in engine compartment fire in approximately 850,000 vehicles equipped with a heated windshield washer fluid option.the subject vehicles of this investigation comprise over three-quarters of the recall population. according to gm, a short circuit on the printed circuit board for the windshield washer fluid heater module may overheat the control-circuit ground wire. this may cause other electrical features to malfunction, create an odor or cause smoke and in rare cases it may cause a fire.as a remedy, gm dealers will install a wire harness with an in-line fuse. in addition to the subject vehicles, several other gm models with the heated windshield washer fluid option are included in recall 08v-441: my 2006-2008 buick lucerne (manufactured august 2005 through november 2007); my 2008 buick enclave (manufactured february 2007 through april 2007); my 2006-2008 cadillac dts (manufactured may 2007 through november 2007); my 2007-2008 saturn outlook (manufactured august 2006 through april 2007); and my 2007-2008 gmc acadia (manufactured august 2006 through april 2007) vehicles.gm is instructing owners to take their vehicle to a dealer for service if they experience symptoms of windshield washer heater module short circuits. gm's recall resolves the safety defect concerns pursued by this investigation.this engineering analysis is closed. | ||||||
PE08010 | GENERAL MOTORS CORP. | 02/04/2008 | 06/12/2008 | NON-CRASH ENGINE COMPARTMENT FIRES | ||
In response to an information request letter sent by the office of defects investigation(odi) during preliminary evaluation pe08-010, gm provided odi with 41 allegations of non-crash engine compartment fires including 16 allegations of fires originating with the ignition in the off position.one of the fires was determined to be caused by an arson event.odi has also received 5 reports, 4 of which are of duplicative of reports provided by gm, alleging non-crash engine compartment fires in the subject vehicles.in total, odi is aware of 41 non-crashengine compartment fires in the subject vehicles that are unrelated to arson.eight of the 41 fire allegations also allege property damage as a result of the fires.this preliminary evaluation has been upgraded to an engineering analysis (ea08-010) to further assess the scope, frequency, origin and cause of the alleged non-crash related engine compartment fires in the subject vehicles. | ||||||
ENGINE AND ENGINE COOLING - ENGINE | ||||||
PE08010 | GENERAL MOTORS CORP. | 02/04/2008 | 06/12/2008 | NON-CRASH ENGINE COMPARTMENT FIRES | ||
In response to an information request letter sent by the office of defects investigation(odi) during preliminary evaluation pe08-010, gm provided odi with 41 allegations of non-crash engine compartment fires including 16 allegations of fires originating with the ignition in the off position.one of the fires was determined to be caused by an arson event.odi has also received 5 reports, 4 of which are of duplicative of reports provided by gm, alleging non-crash engine compartment fires in the subject vehicles.in total, odi is aware of 41 non-crashengine compartment fires in the subject vehicles that are unrelated to arson.eight of the 41 fire allegations also allege property damage as a result of the fires.this preliminary evaluation has been upgraded to an engineering analysis (ea08-010) to further assess the scope, frequency, origin and cause of the alleged non-crash related engine compartment fires in the subject vehicles. | ||||||
EA08010 | GENERAL MOTORS CORP. | 06/12/2008 | 09/08/2008 | NON-CRASH ENGINE COMPARTMENT FIRES | 08V441000 | |
In a letter dated august 27, 2008, general motors corp. (gm) notified nhtsa that it will conduct a safety recall (nhtsa recall number 08v-441) to address a safety relateddefect that can result in engine compartment fire in approximately 850,000 vehicles equipped with a heated windshield washer fluid option.the subject vehicles of this investigation comprise over three-quarters of the recall population. according to gm, a short circuit on the printed circuit board for the windshield washer fluid heater module may overheat the control-circuit ground wire. this may cause other electrical features to malfunction, create an odor or cause smoke and in rare cases it may cause a fire.as a remedy, gm dealers will install a wire harness with an in-line fuse. in addition to the subject vehicles, several other gm models with the heated windshield washer fluid option are included in recall 08v-441: my 2006-2008 buick lucerne (manufactured august 2005 through november 2007); my 2008 buick enclave (manufactured february 2007 through april 2007); my 2006-2008 cadillac dts (manufactured may 2007 through november 2007); my 2007-2008 saturn outlook (manufactured august 2006 through april 2007); and my 2007-2008 gmc acadia (manufactured august 2006 through april 2007) vehicles.gm is instructing owners to take their vehicle to a dealer for service if they experience symptoms of windshield washer heater module short circuits. gm's recall resolves the safety defect concerns pursued by this investigation.this engineering analysis is closed. |
Consumer Complaints
Fail date | miles | occurences | Purchase date |
---|---|---|---|
ENGINE AND ENGINE COOLING | |||
07/14/2007 | 70000 | ||
Tl. the owns a 2007 chevrolet silverado 3500. the contact stated while driving 70 mph the vehicle stalls. the contact stated this happens at least four times since ownership and fears the vehicle could stall while towing and cause a crash. the contact has taken the vehicle to the dealer and the dealer reprograms the computer. the contact stated the repair only remedies the issue temporarily. the contact stated the vehicle was unsafe to drive. the failure mileage was 70,000. jo | |||
03/31/2008 | 500 | ||
Tl*the contact owns a 2007 chevrolet silverado 3500 duramax diesel truck. while driving 65 mph, the vehicle lost power and would not accelerate above first gear. the failure occurred on two separate occasions. the computer has been reset a total of three times. recall number 08142 (engine control module) was referenced. the contact is preparing to take another trip and is concerned that the engine will lose power again. the failure mileage was 500. | |||
ENGINE AND ENGINE COOLING - EXHAUST SYSTEM | |||
07/26/2007 | 2 | 20 | 07/17/2007 |
2007.5 chevy 3500 diesel pickup: when the exhaust re-gen cycle is interrupted, exhaust fumes enter the passenger compartment. gm has stated the system is operating as designed they will do nothing further. *tr |