Bulletins
Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
---|---|---|---|---|---|
ENGINE AND ENGINE COOLING | |||||
PIP-4138K | 01/01/2011 | 10037933 | Gm: the service engine soon light is on, there is also a misfire or engine noise. there are multiple possible causes. *rm | 06/08/2011 | |
PIP-4138K | 01/01/2011 | 10037933 | Ready | 06/08/2011 | |
040604088 | 03/01/2005 | 040604088A | 10014959 | Replacement of connector when replacing fuel tank module/fuel pump module. *tt | 05/12/2005 |
040603002 | 02/01/2004 | 10012703 | Diagnostic information for intermittent vehicle no crank dead battery. *eh | 03/10/2005 | |
3232 | 10011692 | Misfire at idle cold and possible p0171 and or p0174. *eh | 01/28/2005 | ||
3107 | 01/01/2004 | 10010197 | P0420 and p0430 dtsc in the detroit, michigan area with gen iii v-8 engines. *sc | 11/04/2004 | |
3121 | 01/01/2004 | 10010056 | Exhaust vibration resonance or moan. (2004-2005 gmc denali) *sc | 11/03/2004 | |
3147 | 01/01/2004 | 10009957 | Concerns regarding bulletin 00-02-35-003f. all full size trucks and utilities and hummer parts available. *tc | 11/02/2004 | |
020601038 | 12/01/2002 | 10000763 | Engine knock or lifter noise. *tt | 03/28/2003 | |
ENGINE AND ENGINE COOLING - ENGINE | |||||
4231 | 10021021 | Service vme. supplement to 00-02-35-003l. update on new i-shaft. *kb | 02/22/2007 | ||
3267 | 10017155 | Diagnostic trouble code p0128 or engine will not reach operating temperature. *sc | 10/26/2005 | ||
3232 | 3232A | 10014870 | 1999 - 2005 gen ii cold engine misfire at idle with possible p0171 and/or p0174. *tt | 05/10/2005 | |
040604040 | 06/01/2004 | 10012155 | Idle instability, low or rough idle with electronic throttle control. *tt | 02/15/2005 | |
3056 | 10010364 | Check engine light with a p0300 due to 2-4 cylinders misfiring on the same bank of the engine. *tt | 11/17/2004 | ||
3081 | 10010375 | Service engine soon light and p0300 when towing, cruising uphill or on hard acceleration. *tt | 11/17/2004 | ||
3055 | 01/01/2004 | 10009666 | Service engine soon light with a p0300 misfire due to misfires mainly on cylinder 7. *tt | 10/14/2004 | |
3038 | 01/01/2004 | 10009648 | Engine tick, rattle or knock noise after cylinder head gasket replacement on the 6.0l engine. *tt | 10/14/2004 | |
3032 | 01/01/2004 | 10008762 | Service engine soon (ses) light on with p0446 due to dust in the evap vent valve on vehicles that are operated in dusty environments, such as farming or off-road applications. *tt | 08/23/2004 | |
3015 | 01/01/2004 | 10008781 | 6.0l lq4 vin u engine restriction. *tt | 08/23/2004 | |
01353 | 01/01/2004 | 01353A | 10007937 | Engine misfire due to injector fretting corrosion. *tt | 07/16/2004 |
01119A | 01/01/2004 | 01119B | 10007576 | Roll-out for the gen iii small block engines with iridium spark plugs. also includes 2003/2004 m/l vans. *tt | 07/01/2004 |
00969A | 01/01/2004 | 00969B | 10005469 | Engine whistle noise. *tt | 02/27/2004 |
030604060 | 10/01/2003 | 10004733 | Information on new spark plugs and gapping. various models including pontiac gto 2004. *tt | 01/02/2004 | |
030601023 | 08/01/2003 | 10004370 | Higher than expected oil consumption <8500 gvw. various models including 2003-2004 chevrolet kodiak (c4500-c5500 series models)and gmc topkick (c4500-c5500 series models). *tt | 12/04/2003 | |
00634A | 11/18/2003 | 10004162 | Gen iii engine noise after hot soak restart. *tt | 11/20/2003 | |
030604030 | 03/01/2007 | 030604030C | 10002166 | Multiple driveability symptoms of long or hard starts, chuggle, rough idle and light or intermittent misfire due to clogged fuel injectors. *tt | 08/14/2003 |
020604054B | 03/01/2003 | 020604054A | 10001273 | Increased accelerator pedal effort, idle instability. *tt | 04/25/2003 |
020601029 | 09/01/2002 | 10000064 | Needle bearings found in oil pan. *tt | 02/10/2003 | |
ENGINE AND ENGINE COOLING - ENGINE - GASOLINE | |||||
020604023A | 06/01/2002 | 020604023 | 634788 | Some customers may comment on a mild to severe engine ping (commonly referred to as spark knock) usually worse during acceleration and / or an illuminated malfunction indicator lamp. *tt | 10/09/2002 |
010601029B | 07/01/2002 | 010601029A | 634805 | Some customers may comment on higher than expected engine oil consumption. *tt | 10/09/2002 |
020604023 | 05/01/2002 | 634723 | Some customers may comment on a mild to severe engine ping (spark knock) during acceleration and / or illuminated malfunction indicator lamp with diagnostic trouble code p0332 set. *tt | 10/07/2002 | |
000603009A | 03/01/2001 | 000603009 | 619183 | Some vehicles may exhibit lean hesitation, sag or stumble when coolant temperature is between -6 and +20 degrees celsius. *tt | 05/17/2001 |
000603009 | 12/01/2000 | 617736 | Some customers may comment on a lean hesitation, sag or stumble condition present during light to moderate throttle accelerations. *tt | 03/26/2001 | |
021000 | 10/02/2000 | 617717 | Subject regarding customer complaint of whistle and wind rush or flutter type noise. *tt | 03/24/2001 | |
ENGINE AND ENGINE COOLING - EXHAUST SYSTEM | |||||
030605008B | 11/01/2005 | 030605008C | 10005576 | Advance service information - exhaust system popping/snapping noise when vehicle is hot, at idle or immediately after vehicle is shut off. *tt bulletin 03-06-05-008, dated 11/01/2003 replaced. *tt | 03/04/2004 |
ENGINE AND ENGINE COOLING - EXHAUST SYSTEM - EMISSION CONTROL - CATALYTIC CONVERTOR | |||||
3119 | 01/01/2004 | 10010101 | Engineering investigation - catalytic converter replacement. *sc | 11/04/2004 | |
ENGINE AND ENGINE COOLING - EXHAUST SYSTEM - MANIFOLD/HEADER/MUFFLER/TAIL PIPE | |||||
020605005A | 12/01/2002 | 020605005 | 10000726 | Exhaust / muffler heat shield rattle, popping noise under vehicle. *tt | 03/27/2003 |
Consumer Complaints
Fail date | miles | occurences | Purchase date |
---|---|---|---|
ENGINE AND ENGINE COOLING | |||
04/17/2006 | 152000 | 1 | 03/15/2002 |
Dt*: the contact stated the service engine light illuminated. a nhtsa recall was performed on the vehicle however; the recall did not remedy the problem. the recall information is not available. the dealership would not offer a second repair without charge under the recall. | |||
12/20/2004 | 100000 | 1 | 12/19/1999 |
Dt*: the contact stated parking brake was not working. the vehicle was taken to the dealership, where adjustments were made to the parking brake. the adjustments made to parking brake did not repair the vehicle. additionally, the check engine light came on intermittently. the dealership looked at the front end of the vehicle and stated there was nothing wrong. *ak updated 01/25/06. *jb | |||
10/15/2003 | 62591 | ||
I have had problems since day one on this suburban. most recently the two above. i checked the warranty work that was done on my suburban and it was over a page of claims. i just cannot remember the dates the items i checked occured. the fuel pump problem was long in the coming, they just didn't know what the problem was. i spent outside of warranty hundreds of dollars on the fuel system. this left us stranded 3 times! this last time cost me $765. today, the abs sytem died. they say it's going to cost me close to a $1000 to repair. i purchased the suburban because it was safe to carry my wife and 7 kids. so far, we have been stuck on the road, lost vacation time and just can't feel safe anymore. now i don't have brakes. thanks for letting me vent. kent dold | |||
ENGINE AND ENGINE COOLING - COOLING SYSTEM | |||
11/04/2003 | 500 | 3 | |
While driving at any speed steering wheel stuck. when this occurred it felt like driving without power steering assist. vehicle was taken to the dealer, who replaced the power steering pump. also water and fuel pumps were replaced. *ak | |||
ENGINE AND ENGINE COOLING - ENGINE | |||
03/04/2003 | 1 | ||
Without warning vehicle stalled, causing the driver to lose control of the vehicle. consumer contacted dealership on three separate occasions, but the problem still occurs.*ak | |||
The 16 lifters in the engine failed and need to be replaced, per consumer. problem recurred. *jb | |||
ENGINE AND ENGINE COOLING - ENGINE - GASOLINE | |||
01/01/2004 | 60000 | 1 | 07/10/2000 |
2000 sub idles rough,misfires replaced plugs,wires, filter, battery, oxygen sensors and used heat. stalls until warms up. checked with decoder. no codes found. have no clue to problem. any ideas? fuel pump really loud. after a couple of minutes runs and idles fine. | |||
09/01/2002 | 5 | ||
Consumer states that the vehicle has stalled on five occasion while making turn or while accelerating. vehicle taken to the dealer. feel free to provide any further information. mr | |||
06/17/2001 | 01/01/2000 | ||
Vehicle was driven about five hours prior to the fire. it was parked. the fire appears to have started in the engine area driver's side. the battery is on this side.there vehicle was bought new, and had not had any recent work on it. last fueled about a week prir to the fire. *ak | |||
04/01/2001 | 2 | 05/01/2000 | |
While making a u-turn..the whole engine shut down..brakes. lights. steering. as if the car was turned off.not very safe at all | |||
02/02/2000 | 8 | 02/03/2000 | |
Whenever brakes are in use vehicle can slow up, but fails to stop right away. stopping distance is increased. had hit a wall & a fence due to a lack of braking power. vehicle equipped with abs which was not the problem. brake pedal went to the floor. also, parking brake went to floor. taken vehicle to dealership at least 6 or 7 times. now pursuing the lemon law. battery failed. vehicle stalled. exhaust leaks and is loud. air comes through the center vent when the floor control is on. 4-wheel drive would not engage due to a short in the module. fuel sending unit was replaced. *ak *slc | |||
ENGINE AND ENGINE COOLING - EXHAUST SYSTEM - MANIFOLD/HEADER/MUFFLER/TAIL PIPE | |||
3 | 03/01/2000 | ||
Loud noises from muffler. 600 cases chevrolet not willing to fix. *ak | |||
02/02/2000 | 8 | 02/03/2000 | |
Whenever brakes are in use vehicle can slow up, but fails to stop right away. stopping distance is increased. had hit a wall & a fence due to a lack of braking power. vehicle equipped with abs which was not the problem. brake pedal went to the floor. also, parking brake went to floor. taken vehicle to dealership at least 6 or 7 times. now pursuing the lemon law. battery failed. vehicle stalled. exhaust leaks and is loud. air comes through the center vent when the floor control is on. 4-wheel drive would not engage due to a short in the module. fuel sending unit was replaced. *ak *slc |