Bulletins
Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
---|---|---|---|---|---|
SUSPENSION | |||||
020307002 | 03/01/2005 | 020307002A | 10014945 | Revised front caster and camber adjustment procedure. original not yet received. *tt | 05/12/2005 |
040310007D | 11/01/2005 | 040310007E | 10011197 | 20 inch wheels and tires available through gmspo. *tt updated. *nm | 01/10/2005 |
02095 | 01/01/2004 | 10007461 | Owners may inquire about the proper setup for a weight distributing hitch on vehicles equipped with rpo z55 auto ride suspension. *mj | 06/23/2004 | |
01555 | 01/01/2004 | 10005395 | D height specification missing from si. sit bulletin 1410632. *tt | 02/24/2004 | |
030309002 | 07/01/2007 | 030309002B | 10005181 | Rear leaf spring slap or clunk noise (replace spring inserts) *tt updated 10/18/07. *nj | 02/11/2004 |
030308002 | 12/01/2005 | 030308002B | 10002851 | Rattle/squeak from front of vehicle. *tt *ar | 09/26/2003 |
030310001 | 01/01/2008 | 030310001D | 10000959 | Tire slowly goes flat and/or excessive wheel vibration caused by bead splits (replace wheels with new heavy duty rim version) *tt *ar updated 4/11/08. *nj | 04/09/2003 |
SUSPENSION - FRONT - SPRINGS - LEAF SPRING ASSEMBLY - U-BOLT, LEAF SPRING TO AXLE | |||||
3340 | 09/23/2006 | 3340C | 10020874 | Left front axle shaft difficult to remove. axle differential leak seal shaft. *kb | 01/25/2007 |
SUSPENSION - REAR | |||||
PIP4054A | 02/01/2008 | PIP4054B | 10024345 | Eaton locking differential chatter shudder noise on turns, equipped with a locking rear differential rpo g80. *nj updated 7/17/2008. *pe | 04/07/2008 |
3525 | 3525B | 10016714 | Automatic level control inoperative due to water ingestion. *tt | 09/28/2005 | |
3000A | 01/01/2004 | 3000B | 10008901 | Rear axle locking differential chatter shudder noise on turns. *mj | 08/25/2004 |
Consumer Complaints
Fail date | miles | occurences | Purchase date |
---|---|---|---|
SUSPENSION | |||
06/30/1999 | 10000 | ||
From the day i picked up this truck new i complained about the rusty chassis. i was told it was surface rust and that it would not cause any problems. now the chassis is rusted to the point that i do not think the truck is safe. | |||
06/01/2000 | 05/01/2000 | ||
Have had the car in the shop 4 differant occasions for clicking or knocking noise from front and rear end when turning the wheel.....still not fixed. *ak | |||
SUSPENSION - FRONT | |||
09/01/2000 | 4 | 01/04/2000 | |
Vehicle was taken to dealer for a loud noise that could be heard from the right front wheel when the wheel was turned hard to the right, the dealership would fix this by greasing the steering stops, however after a couple hundred miles the problem would return, a service rep informed consumer that the area of the suspension was metal on metal and would need to be frequently lubricated because there was no way to retain grease on those parts. *slc | |||
10/01/2000 | 2 | 08/21/2000 | |
Rattling noises are heard from front end of vehicle, dealer replaced the catalytic converter in an attempt to correct the problem, however this did not work. *et | |||
1 | |||
Vehicle has experienced problems with front end grinding and clunking. *jb | |||
SUSPENSION - FRONT - CONTROL ARM | |||
12/01/2001 | 1 | 05/01/2000 | |
Noise in front end led to inspection-found right front control arm link missing.. *ak | |||
SUSPENSION - FRONT - CONTROL ARM - LOWER BALL JOINT | |||
07/10/2003 | 1 | ||
While driving at 10mph consumer heard some noise in the front of vehicle. dealer found front hub bearings, and upper/ lower ball joints were coming off. *ak | |||
SUSPENSION - FRONT - CONTROL ARM - UPPER BALL JOINT | |||
07/10/2003 | 1 | ||
While driving at 10mph consumer heard some noise in the front of vehicle. dealer found front hub bearings, and upper/ lower ball joints were coming off. *ak | |||
SUSPENSION - FRONT - WHEEL BEARING | |||
07/10/2003 | 1 | ||
While driving at 10mph consumer heard some noise in the front of vehicle. dealer found front hub bearings, and upper/ lower ball joints were coming off. *ak |