Bulletins
| Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
|---|---|---|---|---|---|
| ENGINE AND ENGINE COOLING | |||||
| PIP-4138K | 01/01/2011 | 10037933 | Gm: the service engine soon light is on, there is also a misfire or engine noise. there are multiple possible causes. *rm | 06/08/2011 | |
| PIP-4138K | 01/01/2011 | 10037933 | Ready | 06/08/2011 | |
| 040604088 | 03/01/2005 | 040604088A | 10014959 | Replacement of connector when replacing fuel tank module/fuel pump module. *tt | 05/12/2005 |
| 3232 | 10011692 | Misfire at idle cold and possible p0171 and or p0174. *eh | 01/28/2005 | ||
| 3121 | 01/01/2004 | 10010056 | Exhaust vibration resonance or moan. (2004-2005 gmc denali) *sc | 11/03/2004 | |
| 3147 | 01/01/2004 | 10009957 | Concerns regarding bulletin 00-02-35-003f. all full size trucks and utilities and hummer parts available. *tc | 11/02/2004 | |
| ENGINE AND ENGINE COOLING - ENGINE | |||||
| 3267 | 10017155 | Diagnostic trouble code p0128 or engine will not reach operating temperature. *sc | 10/26/2005 | ||
| 3232 | 3232A | 10014870 | 1999 - 2005 gen ii cold engine misfire at idle with possible p0171 and/or p0174. *tt | 05/10/2005 | |
| 3081 | 10010375 | Service engine soon light and p0300 when towing, cruising uphill or on hard acceleration. *tt | 11/17/2004 | ||
| 3058 | 01/01/2004 | 10009673 | Goodwrench engine and replacement crankshaft information. *tt | 10/14/2004 | |
| 01119A | 01/01/2004 | 01119B | 10007576 | Roll-out for the gen iii small block engines with iridium spark plugs. also includes 2003/2004 m/l vans. *tt | 07/01/2004 |
| ENGINE AND ENGINE COOLING - ENGINE - GASOLINE | |||||
| 010601029B | 07/01/2002 | 010601029A | 634805 | Some customers may comment on higher than expected engine oil consumption. *tt | 10/09/2002 |
| 020604023A | 06/01/2002 | 020604023 | 634788 | Some customers may comment on a mild to severe engine ping (commonly referred to as spark knock) usually worse during acceleration and / or an illuminated malfunction indicator lamp. *tt | 10/09/2002 |
Consumer Complaints
| Fail date | miles | occurences | Purchase date |
|---|---|---|---|
| ENGINE AND ENGINE COOLING | |||
| 03/01/2010 | 100000 | ||
| Continuously having to fill with coolant due to leak. no leak from hoses etc. the problem comes from a defect in heads that are produced by castech. went on line to research this and found numerous numerous complaints about this and gm/chevrolet will not fix. extended warrenty companies will not fix because it is a defective part. dealerships will not talk about it but if you talk to an mechanic at a dealership and describe the problem they are quick to tell you exactly what it is and that it is a defect. the coolant seaps through the poorly manufactured castech heads. called some of the local mechanics and they are saying the same thing-defective part. now like i said i have checked on line and hundreds or more people are having this problem and are having to have the heads replaced and engines at out of pocket. i did not see where a lot of people are complaining on this site because like me they did not know where to go. i found out from a lawyer who also had this problem to complain on this site. he just simply got rid of his tahoe. one said they were stuck on the side of the interstate with young kids and no phone and no way of affording to getting home from out of town. now that is bad. | |||
| 11/15/2010 | 147000 | ||
| Tl- the contact owns a 1999 chevrolet tahoe. the contact stated when he tried to turn the engine on it would turn on and it will turn back off immediately. the security light would flash and the vehicle would reset itself. the failure only occurred in cold weather and happened ten different times. the vehicle was not taken to the dealer and has not been repaired. the contact replaced the battery on the vehicle but the failure continued to occur. the approximate failure mileage was 147,000. ds | |||
| 12/14/2005 | 106000 | 2 | 06/10/2003 |
| I brought my 1999 chevrolet tahoe to alexandria buick-pontiac-gmc in alexandria, virginia on december 14, 2005 because the abs light kept coming on in the dashboard. mechanic diagnosis was speed sensors were missing. he replaced the hub assemblies and speed sensors. total repair was $1064.54. i then found out that a recall on the problem i had just repaired was going on in the rust belt states and canada. the recall was for the whole northeast part of the country down to and including washington dc. i work in washington and live about 5 miles from the city. i wrote the gm claims department with copies of every receipt and a copy of the recall letter. they contacted me and told me the repair was indeed one included within the recall, but they were denying the claim because i live in virginia and the recall is only valid in salt belt states of connecticut, delaware, illinois, indiana, iowa, maryland, massachusetts, maine, michigan, minnesota, missouri, new hampshire, new jersey, new york, ohio, pennsylvania, rhode island, vermont, west virginia, wisconsin and the district of columbia. i want the recall to be opened back up and to include additional states. i spend every single day in washington, what makes my claim any different from the person that lives 5 miles away from me, but happens to live across the state border? what is different from someone who lives in washington and works in virginia? since my home address was virginia, my claim was denied. the recall campaign # is 05v379000. *nm the engine light illuminated, the serpentine belt was repalced. the water pump was leaking abd the pinion seal was replaced. updated 02/09/06. *jb | |||
| 12/23/2005 | 6800 | 1 | 01/18/2001 |
| Smells of antifreeze in cab. took to mechanic, intake manifold gasket must be replaced. this is due to bad part installed. this is a known problem with gmc. *jb | |||
| 10/27/2004 | 200000 | 1 | |
| The consumer was unable to roll up the rear powered windows. the engine warning light also illuminated while vehicle was being operated. the cause was not determined. please provide more information. *jb | |||
| 08/28/2003 | 1 | ||
| The air conditioner lines on my 1999 chevy tahoe started to leak and gm has told me throughout the summer that the part needed (part #15010337) is on backorder. this has been a hot summer, and with young children and aging adults, this is not just unaccepatble, but dangerous.*ak | |||
| 06/10/2003 | 70000 | 1 | 09/01/2002 |
| 350 cid engine threw rod at 69,000 miles. replaced with new mr goodwrench engine. new engine stops mysteriously on highway after about 300 miles. restarts easily before it coasts to a stop. one time it had to sit nearly half an hour before restarting. dealer cannot fix the problem.*ak | |||
| ENGINE AND ENGINE COOLING - COOLING SYSTEM | |||
| 07/15/2002 | 1 | ||
| The heater hose is attached at the intake manifold with a quick-connect fitting that is made of pot metal. when this fails (and it is inevitable due to the type of metal used) the engine loses all coolant and leaves you stranded. there is no quick repair for this failure. older engines had a connector into the intake manifold made of steel or brass which was more reliable and usually did not break off flush with the manifold. nlm | |||
| ENGINE AND ENGINE COOLING - ENGINE | |||
| 01/25/2011 | 141000 | ||
| Tl* the contact owns a 1999 chevrolet tahoe. the contact stated the engine failed while driving 5 mph. the vehicle was taken to the dealer who replaced the engine but shortly after, the replacement engine also failed. the manufacturer was not contacted to report the failure. the failure mileage was 141,000. | |||
| 01/25/2011 | 141000 | ||
| Tl-the contact owns a 1999 chevrolet tahoe. the contact stated the engine blew up. the vehicle was taken to the dealer who installed a new motor but the new motor blew up also. the manufacturer was not contacted. the failure mileage was 141,000...mw | |||
| 12/01/2006 | 1 | ||
| 1999 tahoe engine failed. *ts the consumer stated there was no indication of any kind that there was a problem. *jb | |||
| 01/01/2006 | 139000 | 1 | 05/01/2001 |
| Intake manifold cooling system leak. *jb | |||
| 02/09/2005 | 2 | ||
| While turning on the defogger water was leaking from the vents. also, driver noticed that vehicle was running hot. drive took vehicle to the dealer for inspection and mechanic determined that the heater core and head gasket needed to be replaced. *ak | |||
| The engine stalled and the fuel injectors have been replaced twice. please provide further details. *nlm | |||
| ENGINE AND ENGINE COOLING - ENGINE - GASOLINE | |||
| 06/16/2005 | 127117 | 2 | 05/01/1999 |
| Intake manifold leaked at gasket and at stub out for heater hose. coolant leaked out of intake manifold. intake manifold had to be replaced | |||
| 09/01/2002 | 14 | 09/06/1999 | |
| Exhaust pipe fell off while driving. pipe has been repaired by dealer several times and continues to fall off. consumer is concerned about exhaust fumes when operating vehicle. also, vehicle will stall intermittently while driving.*akthe clutch assembly was also replaced. the engine stalls intermittently. there is a noise emmiting from the fuel pump. *jg | |||
| 07/15/2001 | 15 | 04/01/2000 | |
| The vehicle repeatedly stalls (without warning) when the outside temperature reaches 75 degrees or higher.*ak | |||
| 07/19/1999 | 1 | 07/10/1999 | |
| All the engine oil leaked out of the engine in a span of fifteen minutes during a three mile drive. nlm | |||
| 04/06/2001 | 8 | 11/01/1999 | |
| Engine just stops running without warning or symptoms as if the key were turned off. starts again without problem.. no warning lights on dash except battery symbol at time of stall. could be fatal if passing on 2 lane.. extremely dangerous on freeway. countless hours trying to locate problem to no avail... i traded the car. unsafe to drive.. worried it will be sold without being fixed. *ak | |||
| ENGINE AND ENGINE COOLING - ENGINE - GASOLINE - BELTS AND ASSOCIATED PULLEYS | |||
| 12/31/2005 | 28000 | 3 | 04/06/2000 |
| Dt*: the contact stated while driving the abs activated, causing the contact' to lose control of the vehicle. the contact applied pressure to the brakes twice before the vehicle stopped. after the first incident there was extended stopping distance at low speeds. the dealership determined there was corrosion on the abs sensors. the abs sensors were cleaned in december of 2004. the abs problem recurred, and outdoor temperatures decreased. *ak the serpentine belt was replaced. updated 01/19/06. *jb | |||
| ENGINE AND ENGINE COOLING - EXHAUST SYSTEM | |||
| 03/19/2004 | 1 | ||
| Air conditioning manifold hose is broken on 1999 chevrolet tahoe - extended warranty does not cover replacement. according to two mechanics contacted - they are apparently a frequent repair made on this vehicle. one of the two mechanics spoken to was in the process of repairing the very same item at the time of the phone call.*ak | |||
| 12/15/2001 | 1 | 12/01/2002 | |
| There is a popping sound coming from underneath the vehicle. the dealer determined that the plastic fuel tank is expandable and causes this popping sound. nlm dealer remedied problem and found the exhaust system to be the problem. *slc | |||
| 04/21/2001 | 1 | 06/01/1999 | |
| Bad engine i would like gmc to buy it back.general motors executive group. *ak | |||
| ENGINE AND ENGINE COOLING - EXHAUST SYSTEM - EMISSION CONTROL | |||
| 2 | |||
| O2 sensor failed and replaced, service engine soon light stays on after fixed. yh | |||
| ENGINE AND ENGINE COOLING - EXHAUST SYSTEM - MANIFOLD/HEADER/MUFFLER/TAIL PIPE | |||
| 05/14/2004 | 70 | 1 | 10/19/2001 |
| My husband and i were in route one evening when the check engine light came on. following the manual's instructions: check the coolant gages, it had a reading of nearly 260. we pulled over at the next exit, into the parking lot of a gas station. we checked the coolant recovery tank, it was empty. inspected the engine fan, it was operating normally. waited 1 1/2 hrs to let engine cool down. removed radiator cap. radiator was dry. i asked the gas station for the recommended brand 'dex-cool'. fortunately, they didn't carry that brand. (the reports i've read today, indicate brand dex-cool coolant is the #1 cause in gasket corrosions, it eats plastic. added a 50/50 coolant and arrived home without further incident. the following morning i took my vehicle to a reputable mechanic. after giving him a very brief description of what we'd experienced the evening prior, he immediately stopped me in mid-sentence and said vickie, you don't even have to finish telling me. i know exactly what the problem is. it's common for this engine in chevy's from 1996 - 1999 to leak coolant from the intake manifold near the rear firewall he went on to say, that their service center has had many customers come in with the same complaint frequently. he estimated the cost to replace the intake manifold gasket is between $250 - $300. if this is such a common problem, then gm should not only be required to notify the owners, but should assist in the cost to replace the defective gaskets. the mechanic also stated, if the fluid enters the engine, which could very well happen, then the engine would lock-up. this is a safety issue, and can easily be prevented. need there be a fatality before gm voluntarily notifies the owners and rectify this problem? i demand that gm inform current owners of this problem, reimburse owners who've already paid to have their vehicles repaired, and finally, stop recommending the use of dex-cool brand coolant in the owners manual!!! *ak | |||
| 08/19/2003 | 1 | ||
| Composite manifold is leaking, cause unknown. dealer notified. *ak | |||
| 01/01/2003 | 67256 | 1 | |
| The manifold leaked water into the engine. the dealer has been made aware of the problem. ph scc | |||
| 09/01/2002 | 14 | 09/06/1999 | |
| Exhaust pipe fell off while driving. pipe has been repaired by dealer several times and continues to fall off. consumer is concerned about exhaust fumes when operating vehicle. also, vehicle will stall intermittently while driving.*akthe clutch assembly was also replaced. the engine stalls intermittently. there is a noise emmiting from the fuel pump. *jg | |||
| 12/27/1999 | 2 | 06/01/1999 | |
| Pinion bearing failed at less than 2000 miles. drivers side door mis-aligned. bad seals at connections for tranmission coolin glines. clunk when accel. from stop and shifting hard. reoccurring noise in passenger side dashboard. reoccurring fan type noise under hood. reoccurring failure of exhaust gaskets. | |||
| The exhaust manifold was falling out causing vehicle to lose gas mileage. vehicle experienced pulsated brakes when driving on the hwy at 55 mph. dealer replaced brakes and surfaced rotors to correct the problem. brakes failed after serviced. however, the calibers got very hot which boilded the oil in the brakes system which caused the failure. *yc | |||