Recalls
| Campaign | Manufacturer | Manufacturing date | Type | # of units affected | Date Owner notified Mfg | Recall Initiated by | Manufacturers of recalled vehicles/products | Report Recieved Date | Record Creation Date | Regulation Part Number | FMVSS Number | |||||
|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|
| FUEL SYSTEM, GASOLINE | ||||||||||||||||
| 06E043000 | HONEYWELL INTERNATIONAL, INC. | E (Equipment) | 88303 | 10/18/2006 | MFR | GENERAL MOTORS CORP. | 05/19/2006 | 05/22/2006 | ||||||||
| Defect Summary | Certain replacement fuel filters, fram brand name p/n g3727, with date codes x52911 through x60801 sequentially or x600141 and a mexico country or origin marking on the fuel filter housing manufactured from october 18, 2005, through march 21, 2006, sold for use on the vehicles listed above and on certain school buses. (to see the school bus engine sizes, click on document search and then bus applications). the connector on the fuel filter was not manufactured to honeywell's specification. as a result, the o-ring may not seat correctly on the fuel line. | |||||||||||||||
| Consequence Summary | This condition may cause an inadequate seal at the connection, potentially leading to a fuel leak. in the presence of an ignition source, a fire could occur. | |||||||||||||||
| Corrective Summary | Honeywell will notify owners and replace the fuel filters free of charge. the recall began on october 18, 2006. owners may contact fram customer service at 1-800-890-2075 (option 1). | |||||||||||||||
| Notes | This recall only pertains to aftermarket fram fuel filters and has no relation to any original equipment installed on the vehicles listed.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov. | |||||||||||||||
Bulletins
| Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
|---|---|---|---|---|---|
| FUEL SYSTEM, GASOLINE - DELIVERY - FUEL PUMP | |||||
| 300800 | 08/30/2000 | 619016 | Some vehicles may exhibit broken bushings in the fuel pump assembly resulting in a no start condition where the fuse has blown and the fuel pump will not work. *tt | 05/10/2001 | |
| 300800 | 08/30/2000 | 619023 | Some vehicles may exhibit broken bushings in the fuel pump assembly resulting in a no start condition, blown fuse and inoperative fuel pump. *tt | 05/10/2001 | |
| FUEL SYSTEM, GASOLINE - FUEL INJECTION SYSTEM | |||||
| 01624 | 01/01/2004 | 01624A | 10007238 | Gen iii engines with maf (mass airflow) sensor code p0101. *tt | 06/04/2004 |
| FUEL SYSTEM, GASOLINE - STORAGE - TANK ASSEMBLY | |||||
| 011200 | 12/01/2000 | 616400 | Subject regarding vehicles exhibiting fuel tank leakage. *tt | 02/25/2001 | |
| FUEL SYSTEM, OTHER - STORAGE - FUEL GAUGE SYSTEM | |||||
| PIT-3046E | 08/01/2008 | 10026704 | Gmc: fuel gauge fluctuation in park or neutral, causing the low fuel light to illuminate. *pe | 12/04/2008 | |
Consumer Complaints
| Fail date | miles | occurences | Purchase date |
|---|---|---|---|
| FUEL SYSTEM, GASOLINE | |||
| 10/27/2011 | 103000 | ||
| Brake line corrosion!! (all lines!), one ruptured, lost brakes, forced off road to stop, extended braking distance, almost crashed. driving home from airport at 1am, getting off highway, brake pedal went all the way to floor.... brakes kicked in approx. 90-95% of the way to the floor, but took forever to stop. another car was at traffic light off the highway, and i was forced into the grass on the side of the road before car came to full stop. towed home - i replaced master cylinder thinking thats where the failure was, but then i couldn't bleed rear brakes and noticed the puddle under the truck and crawled under to discover there was a brake line that was completely rusted through. this happened at the abs module, where 5 brake lines connect, and all the lines show dangerous corrosion levels and need to be replaced. it also affected a fuel line right there too, (fuel filter is right there).... i have owned the truck since new, and there is 1 line that looks brand new (never replaced), and all other lines in that area are dangerously corroded. very odd that one line looks good, and all the other lines are bad. i have pictures of all lines and corrosion available. | |||
| 08/02/2000 | 0 | ||
| While driving could smell fuel inside of vehicle. consumer has to roll down the windows, but smell will still be there. no leak had been found. however, technician said that cause of the smell had been a burning on differential.*ak | |||
| FUEL SYSTEM, GASOLINE - DELIVERY - FUEL PUMP | |||
| 02/01/2005 | 114000 | 2 | 04/19/2000 |
| Dt: the consumer stated that the vehicle stalled, and the fuel gauge did not work properly. while sitting at a stop sign the vehicle stalled. this happened only once. the fuel gage had not been working properly for about eight months. nhtsa recall campaign# 05v155000 concerning fuel pump failure was issued. the aforementioned symptoms were typical for faulty fuel pump wiring. the vehicle had not been inspected by the dealer. the consumer made contact by phone with both the dealer and manufacturer in an attempt to obtain recall repairs. the consumer's request was denied because this vehicle was not included in the recall due to vin. *ak (12/02/05) *sc | |||
| 10/08/2005 | 89500 | 1 | 10/16/2003 |
| Dt:the contact stated the fuel pump short circuited inside the fuel tank while driving at 70 mph and it lost power. he managed to pull the vehicle off the road without any power steering or power brakes. he found the fuse tha blew out and changed it. he was able to drive the vehicle home. took the vehicle to a certified mechanic, the fuel pump was replaced at contact's cost. he contacted the manufacturer, and there was recall, but did not include this year, make and model. *ak | |||
| 03/22/2004 | 79300 | 3 | 12/06/2003 |
| Dt: 2000 chevrolet tahoe . the car would back fire through the fuel injection. the fuel pump has been replaced three times. the car was bought less than 2 years ago. *ak | |||
| 08/22/2003 | 1 | 01/04/2003 | |
| After fueling vehicle and driving short distance, then parking on front-end-down slope, a large amount of fuel (apx 1 gallon) began dripping on ground from top of fuel tank. i turned vehicle around so front of tank was higher than rear of tank and dripping slowed and stopped. mechanic said fuel pump assembly on top of fuel tank was leaking. mechanic now in process of replacing fuel pump, and will give me old pump. mehcanic said possible cause that he has seen before is due to corrosion, however, vehicle has been operated at all times in arid, dry desert temperature that is not conducive to vehicle corrosion. *ak | |||
| 05/11/2003 | 72000 | 1 | 02/09/2000 |
| Whilst driving home from upstate ny to my home in nj, the fuel pump on my chevrolet tahoe failed suddenly and catastrophically. i was driving at 65 mph at the time and with the failure of the pump, i lost all power, including steering and brakes. i very narrowly avoided an accident and other traffic. this was very scary and trying to steer and brake without power is not easy. this is the 3rd time that a fuel pump has failed on a tahoe owned by myself, although the other 2 times the failure was while parked and not at high speed. my current car has 72,000 miles. the previous incidents were at approx the same mileage. is this normal? have any other accidents been caused by sudden and catastrophic failure of tahoe fuel pumps? *jb | |||
| 01/10/2002 | 7 | 08/01/2000 | |
| I have had the ps pump, steering gear box, fuel pump, 4wd switch, and all rotors/ brakes replaced. my sunroof rubber seal had to be replaced. all my work has been done by a gm dealership from north carolina, mo & wa. my vehicle has never been off road, it is more for looks. but i am not pleased with this $38,000 maintenance trap. i have all documented work and services.*ak | |||
| FUEL SYSTEM, GASOLINE - FUEL INJECTION SYSTEM | |||
| 03/22/2004 | 79300 | 3 | 12/06/2003 |
| Dt: 2000 chevrolet tahoe . the car would back fire through the fuel injection. the fuel pump has been replaced three times. the car was bought less than 2 years ago. *ak | |||
| 08/12/2004 | 80000 | 1 | 04/10/2001 |
| I have a 2000 tahoe chevrolet ltd. since 3/04 it has failed to start about 7 or 8 times. it usually occurs in the morning when i'm leaving for work. once we were on our way to the hospital for my 14 month old's broken arm. it turns over but will not start. i have had it checked several times. when the shop checks it several hours later, it starts. they have replaced several items. none of which have worked. they told me that they couldn't find anything wrong with it and they were just replacing things that might be causing the problem. it's very frustrating. *ak | |||
| FUEL SYSTEM, GASOLINE - FUEL INJECTION SYSTEM - INJECTORS | |||
| 1 | |||
| The truck was equipped with federal emissions instead of california emissions. he was informed of an written announcement /letter that was sent to some tahoe owners. the truck experienced the same failures as the consumer's which received the information for sequential fuel injection system. the manufacture zone rep agreed to fix it at first but is now denying. the service engine light came on while driving along with misfiring of the injectors. *jb | |||
| FUEL SYSTEM, GASOLINE - STORAGE - TANK ASSEMBLY | |||
| Fuel tank leaks. took vehicle to dealer, and dealer replaced fuel tank assembly. had fuel tank replaced 4 times,and problem still exists. please add vin. *ak | |||
| FUEL SYSTEM, GASOLINE - STORAGE - TANK ASSEMBLY - FILLER PIPE AND CAP | |||
| 02/13/2004 | 25919 | 1 | 02/28/2000 |
| I took my chevy 2000 tahoe ltd, for its first calif. smog test and was told everything was fine except the gas tank cap. the cap failed the pressure test and escaping fumes could cause an explosion. i had the cap replaced and was further told, this test failure is happening to all 2000 model year tahoes, surburbans & sliverados this technicians has tested. is this possible hazard and correcting it the responsibility of chevrolet/gm??? *jb | |||
| FUEL SYSTEM, OTHER - STORAGE - FUEL GAUGE SYSTEM | |||
| 02/01/2005 | 114000 | 2 | 04/19/2000 |
| Dt: the consumer stated that the vehicle stalled, and the fuel gauge did not work properly. while sitting at a stop sign the vehicle stalled. this happened only once. the fuel gage had not been working properly for about eight months. nhtsa recall campaign# 05v155000 concerning fuel pump failure was issued. the aforementioned symptoms were typical for faulty fuel pump wiring. the vehicle had not been inspected by the dealer. the consumer made contact by phone with both the dealer and manufacturer in an attempt to obtain recall repairs. the consumer's request was denied because this vehicle was not included in the recall due to vin. *ak (12/02/05) *sc | |||