Bulletins
| Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
|---|---|---|---|---|---|
| ELECTRICAL SYSTEM | |||||
| 08089-B | 11/01/2008 | 08089-C | 10027804 | General motors corp: special coverage adjustment; analog onstar deactivation. *pe updated 2/17/09. *pe | 02/09/2009 |
| 3571 | 10017152 | Power door lock inoperative. *sc | 10/25/2005 | ||
| 3042 | 3042A | 10009664 | Battery drain on vehicles equipped with power sliding doors. *tt | 10/14/2004 | |
| ELECTRICAL SYSTEM - SOFTWARE | |||||
| 08089-B | 11/01/2008 | 08089-C | 10027804 | General motors corp: special coverage adjustment; analog onstar deactivation. *pe updated 2/17/09. *pe | 02/09/2009 |
| ELECTRICAL SYSTEM - WIRING | |||||
| 57 | 07/01/2003 | 10016464 | Wire harness may be stretched, or the pcs may not be oriented in the same position, after installing a service replacement valve body assembly. gm tech link. *tt | 09/13/2005 | |
Consumer Complaints
| Fail date | miles | occurences | Purchase date |
|---|---|---|---|
| ELECTRICAL SYSTEM | |||
| 05/28/2007 | 136000 | 1 | |
| The passenger power sliding door of my 1999 chevy venture stopped working in the closed position. when this happened the horn quit, and the low coolant light blinks on frequently. a local mechanic said that there was a bulatin out to reprogram the computer on this vehicle, and that it was a programming error. i am disabled and i depend on this door for my wheelchair ramp, etc. *tr | |||
| 10/15/2006 | 97900 | 1 | 03/03/1999 |
| I have experienced numerous electrical problems, including the abs, tcs, and air bag lights coming on intermittently, and the dealer has said there's nothing wrong and reset it. my electric passenger side door would open for no reason when i'm trying to shut it. now, my brake light was out, so i replaced the bulb. that did not solve the problem. my husband then looked at it and determined that the wire pins/plugs are burnt and exposed on both sides. now i have no brake or tail lights, no blinkers, no reverse lights, and at night the top brake light is the only light and it stays on all the time. when i put the brakes on the dash lights dim and the radio lights turn off, the emergency lights come on, and the blinker goes at different speeds. when i called the dealer, they told me to call gm. when i called gm i explained even though it's out of warranty, i feel electrical problems that i haven't done anything to make, should be covered by the manufacturer. they said i need to pay for a diagnosis, and they may reimburse me, if they feel it's a manufacturers defect. then call them back and they'll determine if they will cover any repairs. in the mean time, i'm concerned about a fire if the wire plugs/pins are burnt and exposed. *jb | |||
| 04/28/1999 | 20000 | 3 | 04/01/1999 |
| This will be a list of most of the problems. i have complained of smelling anti-freeze since i purchased the van new. it currently has 94k on it and i have done all scheduled maintenance on it. i think the clock work oil changes is the only reason it still runs. manifold gaskets, intake, head...have been replaced twice and need it again, really bad. but i just do not have 5-800 bucks laying around to do a gasket job again since i just did it a year ago. the anti-freeze diluting the oil has messed up a couple pistons. they slap very bad ok here is my list (i have dealer invoices for everything fixed the first time and receipts for parts and labor the second time, or my husband got sick of paying for the same crap so he would fix things) (he is in the automotive testing and design field) *jb | |||
| 05/12/2006 | 3000 | 17 | 12/31/1989 |
| I have had so many problems 1. the inner brake pads wore down to the steel ruining the inside of both rotors about 3,000 miles. under warranty. but the brake pads. 2. battery acid is corroding about 4,000 miles the dealership pay all still under warranty 3. battery again but it turn out to be the alternator about 6,500 the dealership pay under warranty. 4. the tread completely separated from the sidewall. p215/70r15, fire stone on all four tires. dealership did not cover tire have no warranty on new vehicle 7,000 miles 5. water leak, and carpet is wet every time it rains i feel it is coming from the windshield. warranty does not cover. 8,000 still does it at 50,256. 6. lighter keep shorting out and ac keep mess up under the warranty 7. while driving the check oil light and the battery line came on. the vehicle shut off, loosing all power the intake manifold under warranty 38,000 miles. 8. intake manifold fix came home my lights was mess up when put on my brakes the four way flasher came on when i put my left turn signals the right one would came on put the right turn signals the left one would come on took it back they had to repaired entire wiring system because of over hearted burn it up under warrant 9. battery acid is corroding the battery pan and surrounding components, positive cable connected to battery has fallen off,38,500 not cover 6 year was up. 10. power steering fluid spraying fluid onto the engine and serpentine belt the dealership did not put cap back on power steering. 11. power locks will not operate from door switches only from the remote power window. back ac does not work. 12. connector left and right melt tail lights, stop lights, turn signals about 42,000. 13. there is a thump noise when stopping and taking off. 14. strong smell of fuel when parked. 15. clouding of lens 16. serpentine belt replace at 50,256 17. leaking from lower intake manifold gasket. at 50,000. *nm | |||
| 05/12/2001 | 32334 | 50 | 05/12/2001 |
| Day of purchase, major engine failures replacement of nearly everything then some. continues to arc electrical sparks under the hood. electrical shorting of all components within the van internal engine issues not correctable just bandaiding fuel issues with oil coolant and arcing constitutes a fire and possibly death. i have all serviced repair documents if one should need to view them. *nm | |||
| 08/04/2004 | 21000 | 4 | 03/07/1999 |
| Numerous intermittent electrical problems. the air-bag light indicator on the instrument panel would stay on after starting, but only intermittently. instrument panel air-bag light would intermittently stay on. i took the vehicle to a chevrolet service center on 3 different occasions. onboard computer was replaced at my expense, left rear tail light was replaced at my expense.battery corroded and was replaced at my expense. problems went away briefly after service but came back instrument panel abs & tcs (traction control system) lights will come on and stay on after vehicle has been driven for 5 minutes or so, but not on every trip only intermittently. also when applying the brakes the emergency flasher / turn signal lights will come on. vehicle has 55k miles and is no longer under warranty, this vehicle is dangerous in my opinion.*ak | |||
| 09/13/2002 | 11/14/1998 | ||
| Van caught on fire driver's side rear (by the gas tank) while we were travelling about 65 mph, at night time, on a crowded freeway. there was no warning, the only indication i had that something was wrong was that the abs light came on. other people on the freeway were honking etc because they could see what i could not. by the time i got down to about 40 mph, all the lights went out. i got it over to the side of the road. smoke filled the passenger compartment. we got out and ran. a wrecker driver put out most of the fire before the fire dept. got there. i had the van picked up and brought home. i contacted general motors and asked that they come take a look at this thing. they declined to be responsible and refused to send anyone. i took it to an electrical shop and they determined that the fire started at the plug in the back where you can plug in a tv or whatever. i was told that this couldn't/shouldn't happen but it did. i have had other electrical as well as mechanical problems with this thing. i bought it new, no one else has ever driven it so i know the history. i had the wiring redone bypassing that plug but i now have a check engine, pass key & airbag llights coming on. the vehicle is totalled to me as both i and my kids are afraid to ride in it. unfortunately i still have to drive it some because it is our only vehicle. | |||
| 02/14/2003 | 64000 | ||
| Windsheild wipers come on by there self at random,and on different settings. headlights will work at random. i keep hearing a popping sound coming from under the dash,but of course service tech cannot find a problem with this vehicle. | |||
| 01/08/2002 | 3 | ||
| There was an electrical short in the vehicle?s fuel tank sender and system. the fuel tank was replaced. the low fuel warning light had failed. the fuel gauge fluctuated and the vehicle?s lamp malfunctioned.*yh | |||
| 07/18/2002 | 1 | 03/17/1999 | |
| While driving abs light illuminated, turn signal performed erratically due to pig-tail, circuit board socket failure. *ak consumer stated that bad seal on pig tail caused moisture to enter circuit board. *yh | |||
| ELECTRICAL SYSTEM - BATTERY | |||
| 09/07/2002 | 8 | 03/01/2099 | |
| Battery went dead after only 3 years/sliding side door stopped working. *ak | |||
| 12/01/2001 | 1 | 03/16/1999 | |
| Battery acid is corroding the battery pan and surrounding components, also positive cable connected to battery has fallen off, dealer has been contacted. *ak consumer stated the battery by delco, also headlights are developing spiderwebbing and clouding of lens, and rear hatch pinches palm of hands or fingers, the rear hatch handle broke off.*slc | |||
| ELECTRICAL SYSTEM - FUSES AND CIRCUIT BREAKERS | |||
| 10/20/2000 | 50 | 02/01/1999 | |
| Numerous intermittent electrical problems. february 2000, the air-bag light indicator on the instrument panel would stay on after starting, but only intermittently. took it in for service on 2/22/00 and they cleaned connections to driver side impact air-bag. problem went away until july 2001. again instrument panel air-bag light would intermittently stay on. may 2000 - doors would lock and unlock continually and locks would not work with remote or key while this is happening. interior lights would flash on and off. i took the vehicle to a chevy service center on 5/11/00 & 5/16/00 and both times they could not reproduce error / failure and nothing was done. after a few weeks the door and interior lights problem stopped.january 2002 instrument panel abs & tcs (traction control system) lights will come on and stay on after vehicle has been driven for 5 minutes or so, but not on every trip only intermittently. also when applying the brakes the emergency flasher / turn signal lights will come on. vehicle has 43k miles and is no longer under warranty, but problems started 1 year (13,000 miles) after purchase. | |||
| ELECTRICAL SYSTEM - IGNITION | |||
| 03/30/2008 | 97585 | ||
| Tl*the contact owns a 1999 chevrolet venture. the contact lost her key to the vehicle and attempted to use the pass key to move the vehicle. the vehicle started, but then shut off. she made three attempts to restart the vehicle, but was unsuccessful. the contact found the original key and attempted to start the vehicle. the wheel would not move and she was unable to start the vehicle. she inserted the key and heard a beeping sound, which indicated that the battery was functioning. she called several dealers and mechanics, who stated that they could not assist with the issue. the current and failure mileages were 97,585. | |||
| ELECTRICAL SYSTEM - IGNITION - SWITCH | |||
| 06/15/1999 | |||
| After purchasing the vehicle the car would not start.consumer has contacted dealer. *ak | |||
| ELECTRICAL SYSTEM - WIRING | |||
| 12/12/2000 | 2 | ||
| While traveling at various speeds engine will start to over rev for no reason. pressing brakes does not seem to help. dealer has repaired entire wiring system,and the problem still occurs.*ak | |||
| ELECTRICAL SYSTEM - WIRING - INTERIOR/UNDER DASH | |||
| 10/20/2000 | 50 | 02/01/1999 | |
| Numerous intermittent electrical problems. february 2000, the air-bag light indicator on the instrument panel would stay on after starting, but only intermittently. took it in for service on 2/22/00 and they cleaned connections to driver side impact air-bag. problem went away until july 2001. again instrument panel air-bag light would intermittently stay on. may 2000 - doors would lock and unlock continually and locks would not work with remote or key while this is happening. interior lights would flash on and off. i took the vehicle to a chevy service center on 5/11/00 & 5/16/00 and both times they could not reproduce error / failure and nothing was done. after a few weeks the door and interior lights problem stopped.january 2002 instrument panel abs & tcs (traction control system) lights will come on and stay on after vehicle has been driven for 5 minutes or so, but not on every trip only intermittently. also when applying the brakes the emergency flasher / turn signal lights will come on. vehicle has 43k miles and is no longer under warranty, but problems started 1 year (13,000 miles) after purchase. | |||
| 4 | 11/01/1998 | ||
| No summary listed for abov evehicle. *ak | |||
| 07/18/2000 | |||
| While driving there was an electrical fire behind the instrument panel. driver was able to exit safely. fire was put on by the owner. fire department did respond. vehicle will be towed to the dealership. not sure if vehicle will be totalled. please provide any further information.*ak | |||