Recalls
Campaign | Manufacturer | Manufacturing date | Type | # of units affected | Date Owner notified Mfg | Recall Initiated by | Manufacturers of recalled vehicles/products | Report Recieved Date | Record Creation Date | Regulation Part Number | FMVSS Number | |||||
---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|
ELECTRICAL SYSTEM - WIRING | ||||||||||||||||
94V024000 | CHRYSLER CORPORATION | from 07/01/1993 to 12/01/1993 | V (Vehicle) | 110000 | 03/04/1994 | MFR | CHRYSLER GROUP LLC | 02/08/1994 | 02/16/1994 | |||||||
Defect Summary | The right steering tie rod can rub through the automatic transmission wiring harness causing a short circuit which results in electrical system malfunctions including engine stalling and an inoperative park/starter interlock system. | |||||||||||||||
Consequence Summary | Electrical system malfunction causing stalling while in motion or an inoperative park/starter interlock system, which allows engine start while the transmission is not in the park position, may result in an accident. | |||||||||||||||
Corrective Summary | Install a revised wiring harness bracket and a plastic convoluted sleeve to protect the transmission wiring harness. | |||||||||||||||
Notes | System: electrical system; wiring.vehicle description: passenger cars.note: if your vehicle is presented to an authorized dealer on an agreed upon service date and the remedy is not provided within a reasonable time and free of charge or the remedy does not correct the defect or noncompliance, please contact chryler service center at 1-800-992-1997. also, contact the national highway traffic safety administration's auto safety hotline at 1-800-424-9393. |
Bulletins
Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
---|---|---|---|---|---|
ELECTRICAL SYSTEM | |||||
0801001 | 05/25/2001 | 620059 | Subject regarding airbag / clock spring service for various models including 2002 model year jeep liberty. *tt | 07/10/2001 | |
0800600REV | 12/29/2000 | 080600 | 618049 | Subject regarding wire splice repairs. *sb | 04/03/2001 |
0832097 | 09/19/1997 | 6088834 | Information regarding nhtsa authorized airbag deactivation for medical necessity. *nlm | 01/10/2000 | |
ELECTRICAL SYSTEM - WIRING | |||||
080600 | 02/25/2000 | 609995 | This bulletin provides a revised wire splice procedure and related parts. *tt | 04/12/2000 |
Consumer Complaints
Fail date | miles | occurences | Purchase date |
---|---|---|---|
ELECTRICAL SYSTEM | |||
06/09/2011 | 175000 | ||
Driving all of sudden car lunjed and all lights and motor and forward motion stopped, then all of a sudden jerked and started running normal. this has happened at least a dozen times in last year. local dealer can not find probem. so we continue to hope and pray it doesnt result in an accident. now when you start the engine, one time all gauges work and the next time none work. dealer still hasnt located problem. definitely annoying and dangerous. glad were older, rarely drive at night | |||
12/01/2005 | 124500 | 1 | 07/17/2004 |
In july 2004, i purchased a used '94 chrysler lhs w/95,000 miles in very good condition (exterior/interior) but within the first few weeks i experienced electrical problems (electric current not going to gauges, gauges going haywire), transmission problems (periodic 'limp mode', car erratically surging) and steering problems (rack 7 pinion, inner/outer tie rods). within a few months i replaced the inner/outer tie rods and front/rear stabilizer links that all improved my front suspension. just recently about a month ago, i had my local dodge dealer replace one broken transmission mount ($305) then the following week at 124,500 miles while driving to work on my local highway my transmission failed, which resulted in loss of power steering and loss of drive gears, i was able to exit safely onto my jobs parking lot before it finally gave out. i had it towed to an exclusive auto transmission shop, they had to rebuild/overhaul the transmission and torque converter ($1,800). a whopping $2,100 in repairs in about a month. there went my christmas money. *jb | |||
05/12/2005 | 2 | 07/14/2004 | |
Dt: the consumer states that the car is locking and unlocking, the door locks by itself. the trunk is also opening by itself. the owner has not taken the vehicle to have it looked at yet. she has called the dealership to check on recalls and there were not any on her car, according to her dealership. the owner bought the car used from a friend and she is also the third owner. the previous owner put in a new motor. the manufacturer has not been contacted. this has been happening with the trunk for about three weeks and the lock for about a week. the owner is locking her car doors at night and the next morning the car is unlocked and the trunk was open. she is going to have the car checked today, but she doesn't want to pay $85.00 to have the car looked at and checked. this car is a 1994 chrysler lhs. the owner suggests that this is an electrical problem. the information is all that the consumer had available to her. the owner has the vehicle regularly maintained. *nm | |||
02/26/2005 | |||
This is the second 1994 lhs i've had, and the same problems have occured on both cars.someone needs to listen to complaints before there is a loss of someones life. which i came very close to the racket pinion and tie rod.another few miles and we might not be here today.there is also problems with the heater and ac not working,cant shut it off,turn it on change it fromheat to ac.hood problems. timing belt.so many things have went wrong with both these cars and they both were 1994 ch-lhs.dont have the dates in front of me when all the things happened.i had trouble with this car 3 days after i bought it. and the last one i put money into it one time after another another,someone hit it and it was totaled out.i will never own another. any chrysler .thought i was getting a nice car,got 2 lemons.just think they need to be checked out before someone is hurt. | |||
Right steering tie rod has rubbed through transmission harness, causing a short circuit which resulted in an electrical system malfunction. a recall has been issued on vehicle's make and model. however, this vehicle was not included due to vin. vehicle was repaired at the owner's expense. *ak | |||
09/06/1999 | 15 | 09/01/1994 | |
Electrical system malfunctions causing vehicle to stall while in motion. also causing starter not to operate. i have been told by chrysler,that even though 110,00 vehicles were recalled because of this defect(campaign number 611), my vehicle is not one of those recalled. *ak | |||
1 | 10/02/1998 | ||
The vehicle electrical system is not working properly causing the heater to come on but unable to be turned off until consumer takes the circuit out. and the instrument panel lights work intermittently. nlm | |||
ELECTRICAL SYSTEM - ALTERNATOR/GENERATOR/REGULATOR | |||
1 | |||
Starter and battery failed. | |||
ELECTRICAL SYSTEM - BATTERY | |||
1 | |||
Starter and battery failed. | |||
06/18/1996 | 2 | 11/01/1993 | |
Battery failed twice times. | |||
ELECTRICAL SYSTEM - IGNITION | |||
7 | |||
While driving vehicle would constantly stall without warning. vehicle was towed home, restarted & drove to dealership. informed by mechanic a tune up was needed, which was done. half hour later, stopped for fuel & vehicle would not restart. problem happened more than 7 different times. vehicle was not included under recall #94v024000/ electrical wiring due to vin. parts have been replaced, but problem not solved. crankshaft sensor was replaced at consumer's cost. *ak | |||
3 | |||
Spark plugs replaced several times. *yc | |||
1 | |||
Owner states that while driving vehicle on highway the engine dies out, he also notes that dealer ran diagnostic test on vehicle and could not find anything wrong. *ak *slc | |||
5 | 06/01/1993 | ||
When slowing down engine dies, causing total loss of power steering and power brkaes, vehicle has been checked by two different dealers who can not duplicate the problem possibly engine related.*jb | |||
11/30/1995 | 12 | 09/01/1993 | |
Engine arbitrarily loses power/cuts out, driver loses power steering and power braking, completely unpredictable at any speed.*ak | |||
ELECTRICAL SYSTEM - IGNITION - MODULE | |||
10/01/1995 | 1 | 04/01/1994 | |
Electronic control unit failed. | |||
ELECTRICAL SYSTEM - IGNITION - SWITCH | |||
09/01/2003 | 1 | ||
Bad ignition switch... i have had 2 of these cars and same thing on both. the transmission will not shift, lights on dash and speedometer wouldn't work... put in new transmission... still would not shift... had the ignition switch changed... now it works. how many people put in new transmissions? when it is the ignition switch? since this has happened on both of my cars i believe it is a default. *la | |||
07/01/2000 | |||
While driving vehicle stalled unexpectedly which could have caused a crash. also, problems with electrical door lock. sometimes key wont come out of ignition. recall 94v0240000 dealt with this problem; but this vehicle was not included in recall due to vin. please provide further information. *ak | |||
02/06/2000 | 1 | 11/01/1998 | |
The part listed above was smoking while i was driving. when i turned the car off, it wouldn't start again. *ak possibly something froze and caused the belt (pulley) to melt. *yh | |||
07/03/1998 | 1 | ||
Ignition switch failed. | |||
ELECTRICAL SYSTEM - STARTER ASSEMBLY | |||
09/06/1999 | 15 | 09/01/1994 | |
Electrical system malfunctions causing vehicle to stall while in motion. also causing starter not to operate. i have been told by chrysler,that even though 110,00 vehicles were recalled because of this defect(campaign number 611), my vehicle is not one of those recalled. *ak | |||
ELECTRICAL SYSTEM - WIRING | |||
08/20/2006 | 0 | 06/28/2006 | |
I purchased the car in june 06, car was ok, barely drove it, when the summer arrived more driving. car stared to shut off while driving the vehicle, numerous time, called tow truck, mechanic. mechanic says car fuse blowing, major electrical issue. could not find part to replace wiring chassis and harness. so i kept driving the car, sometimes when turning left car dies out, might restart but might not. parked the car for a while to sell, cant get a buyer 4 an electrical issue. drove again, same trouble almost always when turning left, engine control fuse 20amps, blows out, replace may restart may not. had an electrical specialist look he says this was a recall, i checked looks like my car not in the vin# sequence, chrysler says no way won't help. *tr | |||
03/04/2006 | 20 | ||
Windshield wiper stops working (no power) during rainstorm. it's very dangerous to change lanes to the shoulder in the rain without wipers. slamming hood starts wipers again. all gauges (speed, tack, gas etc) either go full on/off or stop at 1/2 actual speed/ rpm without any apparent reason. at the same time, the seat belt and air bag lights illuminate. pounding on dash sometimes returns the gauges. turning off the engine and re-starting correct the gauges/lights but not the wipers. car is at dealers for repair and they can not find problem(s).*jb | |||
05/15/2001 | 43000 | 3 | 05/06/2001 |
Recall 94v024000 concerning electrical system wiring. consumer has a concern that vehicle stalls while in motion at any speed. vehicle was taken to a repair shop, and some repairs were made, but the problem recurred. dealer was not contacted.*ak | |||
08/12/2003 | |||
Consumer states that while driving vehicle caught on fire without warning.*ak | |||
11/09/2002 | |||
When sitting at a red light vehcle will completely loose power. sometimes at highway speed vehicle jerks like its going to shut down. took to dealer and dealer did some maintenance on throttle body. dealer told consumer that his vehicle identification number was not affected by the recall. 94 v 024 000. please provide any further information. ph | |||
04/01/2002 | 1 | 11/01/2001 | |
Consumer was experiencing problems with the transmission skipping and not shifting, consumer was informed that there was an internal wiring problem in the transmission, consumer was then informed by the mechanic that there was a recall on the wiring in the transmission, consumer then contacted the manufacturer to find out the process for reimbursement and was told that her vehicle was not included in the recall due to vin.(recall #94v024000)*jb | |||
1 | |||
While driving the vehicle suddenly slowed down and almost came to a complete stop, the mechanic found the problem to be the wires under the front bumper, the plastic wire protector is not produced to be completely closed therefor it allows dirt and water to gather inside of it, this debris rubbed against the wires weakening them. nlm | |||
01/19/2000 | |||
Replaced transmission twice. mechanic thinks problem is connected to wiring harness. electrical system of vehicle is irratic, gauges quit, and vehicle stalls. | |||
10/09/1997 | 1 | 10/04/1994 | |
While driving, the engine began to stall at an intersection, suddnely the car accelerated and darted into traffic, resulting from failure of the electrical wiring to the wiring harness (recall component however work denied due to previous inspections finding no problems). | |||
ELECTRICAL SYSTEM - WIRING - FRONT UNDERHOOD | |||
02/26/2005 | |||
This is the second 1994 lhs i've had, and the same problems have occured on both cars.someone needs to listen to complaints before there is a loss of someones life. which i came very close to the racket pinion and tie rod.another few miles and we might not be here today.there is also problems with the heater and ac not working,cant shut it off,turn it on change it fromheat to ac.hood problems. timing belt.so many things have went wrong with both these cars and they both were 1994 ch-lhs.dont have the dates in front of me when all the things happened.i had trouble with this car 3 days after i bought it. and the last one i put money into it one time after another another,someone hit it and it was totaled out.i will never own another. any chrysler .thought i was getting a nice car,got 2 lemons.just think they need to be checked out before someone is hurt. | |||
04/03/2002 | 1 | 04/01/1999 | |
Frame of vehicle is weak and is moving under steering gear. cause is unknown. *ak consumer states that he replaced the rack and pinion and in doing so, found that the wiring harness that goes from the solenoid control module and the solenoid control valve had been put in between the crossmember and the rack and pinion, a bolt had cut and shorted out the harness, this is the bolt that holds the mount of the rack and pinion, while turning the wheel to the left and right, the master cylinder and rack and pinion move, dealer recomended replacement of the rack bushings and right sway bar link, however stated the steering was not a problem. *slc | |||
10/01/2001 | 5 | ||
When traveling on highway vehicle will shut off without prior warning. also, consumer smelled smoke inside of vehicle. dealership was aware of problem. *ak consumer feels this should be included in recall #611. *et | |||
09/20/2000 | |||
Intermittently when accelerating to pass another vehicle transmission downshifts. when letting off the accelerator, transmission shifts up. vehicle surges and stalls. also, crank sensor was replaced last week, but the problem came back. problem was reported to the dealership. problem seems to be related to recall campaign 94v024000. please provide any further information.*ak | |||
12/09/1999 | 12 | 03/01/1997 | |
No summary listed for above vehicle. *ak | |||
03/26/1999 | 4 | 03/01/1999 | |
Transmission is leaking, connot find problem. transmissionline/fittings checked and replaced. heavy smoke under hood cannot find problem. undercarriage has excessive corrosion. vehicle has been undrivable 4 times (on tow truck 4x's in past 2 weeks). *ak | |||
05/22/1998 | 08/09/1994 | ||
While driving vehicle burst into flames underneath the hood. got out of vehicle and put flames out. vehicle had to be towed to the dealer, and they stated it could have been an engine compartment fire. *ak | |||
10/27/1998 | |||
Recall 94v024000// 611; car started bucking and engine was skipping, electronic analysis ran, dealer contacted and stated the wiring harness shorted out completely and affected another wiring harness, no repair work done. consumer paid to remedy the problem. | |||
Vehicle stalls due to wiring harness malfunction as stated in recall. chrysler claims to not be able to determine cause of stalls and denies any recall. | |||
ELECTRICAL SYSTEM - WIRING - INTERIOR/UNDER DASH | |||
02/26/2005 | |||
This is the second 1994 lhs i've had, and the same problems have occured on both cars.someone needs to listen to complaints before there is a loss of someones life. which i came very close to the racket pinion and tie rod.another few miles and we might not be here today.there is also problems with the heater and ac not working,cant shut it off,turn it on change it fromheat to ac.hood problems. timing belt.so many things have went wrong with both these cars and they both were 1994 ch-lhs.dont have the dates in front of me when all the things happened.i had trouble with this car 3 days after i bought it. and the last one i put money into it one time after another another,someone hit it and it was totaled out.i will never own another. any chrysler .thought i was getting a nice car,got 2 lemons.just think they need to be checked out before someone is hurt. | |||
01/19/2000 | |||
Replaced transmission twice. mechanic thinks problem is connected to wiring harness. electrical system of vehicle is irratic, gauges quit, and vehicle stalls. | |||
08/01/1994 | 06/21/1994 | ||
Computer module needed to be upgraded. |