Bulletins
| Bulletin | Bulletin date | Replacement Bulletin | Item no. | Summary | Added |
|---|---|---|---|---|---|
| ENGINE AND ENGINE COOLING | |||||
| 0900105 | 12/10/2005 | 0900105A | 10013774 | Cylinder head bolt re-torque procedure. gpop - issue review system. *tt | 04/26/2005 |
| ENGINE AND ENGINE COOLING - ENGINE | |||||
| 0900304 | 03/02/2004 | 0900304A | 10005992 | Accessory drive belt squeaking/chirping sound. *tt | 04/05/2004 |
Consumer Complaints
| Fail date | miles | occurences | Purchase date |
|---|---|---|---|
| ENGINE | |||
| 08/28/2012 | 69889 | 1 | |
| About 3 min after filling up vehicle stalled after pulling out of station. power steering failed and could not move out of lane. took a couple of tries to restart and move to safety. second time this problem has happened. this will cause an accident!!! *tr | |||
| 08/28/2012 | 69889 | ||
| About 3 min after filling up vehicle stalled after pulling out of station. power steering failed and could not move out of lane. took a couple of tries to restart and move to safety.second time this problem has happened. this will cause an accident!!! | |||
| ENGINE AND ENGINE COOLING | |||
| 05/01/2012 | 90000 | ||
| Tl- the contact owns a 2004 chrysler town and country. the contact was driving 25 mph when the check engine warning light illuminated. the contact then noticed that the temperature gauge was indicating that the vehicle was overheating. the vehicle was taken to an independent mechanic where it was advised to the contact that the engine oil had become too hot and was clogging the catalytic converter. the manufacturer was contacted and made aware of the failure but offered no assistance to the contact. the vehicle was not repaired. the failure mileage was 90,000 and the current mileage was 105,000. kmj | |||
| 03/10/2011 | 54800 | ||
| My van completely shut down after i filled the tank with gas. i didn't know what happend but i had no power to steer to the side of the road and had to turn off the engine and try to restart it several times before it started again. i have had this problem every time i fill the tank, from any level of gas. if i can leave the gas station and travel to .7 miles with constant pressure on the gas pedal, it sometimes won't die. if i have to brake, the engine completely chokes out. i have taken it back to the service department and they said they couldn't fix it because they needed to be able to fill it to see it happen and they weren't going to do that. finally after a year of this problem and a multitude of others, i called chrysler usa and all of the sudden, i had a manager at the service department volunteer to ride with me to see it happen. sure enough it did and they had to replace the entire fuel tank and fuel line...... | |||
| 09/01/2011 | 70000 | ||
| Tl-the contact owns a 2004 chrysler town and country. the contact stated that the vehicle stalled without warning after refueling. the failure was experienced several times. the vehicle was taken to a local mechanic who performed a diagnostic test, but was unable to locate a failure code. the vehicle was not repaired. the failure mileage was 70,000 and the current mileage was 80,000. the vin information was not available. sm. | |||
| 05/26/2010 | 45000 | ||
| Engine stalls each time the fuel tank is filled. this happens only once per fill up and only after leaving the fuel station and entering the adjacent roadway. this is a dangerous condition as there is no warning and no power to steer and pull off the road to re-start. re-starting can take a while to achieve in traffic. this is a dangerous defect apparently requiring replacement of the entire fuel tank? why is chrysler not required to recall these vehicles as it is very common and dangerous failure? | |||
| 09/01/2011 | 70000 | ||
| Tl-the contact owns a 2004 chrysler town and country. the contact stated the vehicle stalled without warning after fueling. the failure was experienced several times. the vehicle was taken to the local mechanic who performed a diagnostic and was unable to locate a failure code. the vehicle was not repaired. the vin information was not available. the failure mileage was 70,000 and the current mileage was 80,000. li | |||
| 05/26/2010 | 45000 | ||
| Engine stalls each time the fuel tank is filled. this happens only once per fill up and only after leaving the fuel station and entering the adjacent roadway. this is a dangerous condition as there is no warning and no power to steer and pull off the road to re-start. re-starting can take a while to achieve in traffic. this is a dangerous defect apparently requiring replacement of the entire fuel tank? why is chrysler not required to recall these vehicles as it is very common and dangerous failure? | |||
| 09/01/2011 | 70000 | ||
| Tl-the contact owns a 2004 chrysler town and country. the contact stated the vehicle stalled without warning after fueling. the failure was experienced several times. the vehicle was taken to the local mechanic who performed a diagnostic and was unable to locate a failure code. the vehicle was not repaired. the vin information was not available. the failure mileage was 70,000 and the current mileage was 80,000. li | |||
| 05/26/2010 | 45000 | ||
| Engine stalls each time the fuel tank is filled. this happens only once per fill up and only after leaving the fuel station and entering the adjacent roadway. this is a dangerous condition as there is no warning and no power to steer and pull off the road to re-start. re-starting can take a while to achieve in traffic. this is a dangerous defect apparently requiring replacement of the entire fuel tank? why is chrysler not required to recall these vehicles as it is very common and dangerous failure? | |||
| 05/02/2011 | 101000 | ||
| Tl* the contact owns a 2004 chrysler town and country. the contact recently purchased the vehicle and noticed that the rear beam axle developed extreme rust. the contact also stated that the mounts that held the rear leaf springs were almost completely rusted as well. in addition, the vehicle was loosing oil abnormally, but there was no signs of where the oil was leaking. the vehicle was not inspected or repaired. the failure and current mileages were 101,000. | |||
| 05/02/2011 | 101000 | ||
| Tl- the contact owns a 2004 chrysler town and country. the contact recently purchased the vehicle and noticed the rear beam axle on the vehicle has developed a lot of rust. the contact also stated the mounts that hold up the rear leaf springs are almost rusted through as well. the contact also stated the vehicle is loosing oil, but there is no oil leak. the vehicle had not been inspected. the failure mileage and current mileages were 101,000.rl | |||
| 12/01/2010 | 126300 | ||
| After refilling the tank at any gas station and restarting the vehicle, it runs rough and stalls. the stall can occur anytime from right after the engine restart or up to 5 minutes after restart. the car has stalled in the gas station on numerous occasions since first noticed in dec 2010 and several times on the road in traffic. a web search indicated that there was an apparent issue with the vehicles fuel tank and purge valve. i found dozens & dozens of complaints. this seems to fit into a safety recall category. please investigate | |||
| 06/10/2009 | 66852 | 1 | |
| Spurious engine failures. has happened approximately 10 times in past year. engine loses power (chugs) then quits completely. no problem restarting engine and continuing. dealer unable to duplicate problem. *tr | |||
| 07/16/2007 | 37400 | 1 | 02/01/2004 |
| The 2004 chrysler town and country check engine light came on and the engine was running rough, especially in idle. the odometer reading was 37,500, the vehicle was 3.5 years. old, and it has a 3.8 liter engine. a chrysler dealer ran a diagnostic check and determined that new spark plugs and wires were needed. also, some computer codes may need to be reset. cost would be $350. i bought the parts and installed them myself. i replaced many spark plugs in the old days and these were the worst looking plugs i have ever seen. the tips of the electrodes were severely rounded off on all 6 plugs. i owned chrysler/plymouth minivans since 1984 and only remember replacing spark plugs once, and probably @ a high mileage. champion warrants their platinum plugs for 5 years. chrysler's maintenance schedule says to replace spark plugs and wires @ 100,000 miles. something must be wrong with this engine. *ak | |||
| 07/01/2005 | 15 | 01/05/2004 | |
| I have a 2004 awd chrysler pacifica with about 25k miles. i have been able to start it up regularly and consistently since early july 2005. been to dealership 5x to have problem fixed. first time could not duplicate problem so they tightened negative battery cable. 2nd time no codes found, no problem found. 3rd time duplicated problem, but no solution. 4th time car towed to dealership, sent back with a recorder to record car over the weekend. 5th time replaced powertrain control module. did not fix the problem car back again. *jb | |||
| 12/08/2004 | 4030 | 8 | |
| While driving 30 mph vehicle stalld. the consumer was able to restart the vehicle. dealership was notified, but did not resolve the problem. the cause was not determined. *ak | |||
| 09/01/2004 | 8 | 01/12/2004 | |
| Upon starting the vehicle it cut off. once the vehicle gets going it will run a little, then it will cut off again. consumer stated that upon approaching a stop light or any kind of stop vehicle will cut off. *ak | |||
| 03/16/2004 | 5000 | 1 | 11/01/2003 |
| Has varying idle and poor gas mileage since 5000 miles. chrysler denies this is a problem, have talked with other owners who have this same issue. vehicle willl idle from 500 - 750 rpm in drive with a noticible miss. *ak | |||
| ENGINE AND ENGINE COOLING - ENGINE | |||
| 11/21/2005 | 21000 | 4 | 10/18/2004 |
| My 2004 chrysler town & country has been in the shop 4 times for the same problem. it was for a problem chrysler has put a bulletin out on regarding malfunction indicator lamp illumination with diagnostic codes p0300-p0306 (spark plugs). the light has come on 4 different occasions during a 7 month period. dealer replaced spark plugs all 4 times and reprogrammed the tran module. they are giving me the excuse that i am probably just getting defective spark plugs. i have had a computer in the car that i drove with and it showed nothing to them as they tell me. they say car isn't doing anything when they drive it. after 4th repair i have brought it back after driving only a few days telling them it still is not fixed, they say it doesn't do it for them and they can't do anything else unless the light comes on again. the car bucks, surges, transmission seems to mis, car has back fired going up hill, no power going up hills or inclines, car even loses power going 55 mph plus on highways, when light does finally come on car will not let you go over 10 miles per hour, feels like it is going to stall bucks and surges. the light has not come on again yet for the 5th time but it will eventually with the same codes for the spark plugs, and again i will bring it back to have it not fixed again , by them changing the spark plugs yet again. i also saw a bulletin on this site about a creak, tick, and pop sound in steering column which i asked dealer to check when it was brought in last visit, they said it was nothing, and did nothing about it, now i see other people obviously have same problem,, not fixed. i have no clue if this is a safety hazard and what, if anything, could happen . sway bar was replaced for noise when going over bumps, and rear window motor was defective and replaced also on this car. *nm | |||
| 06/01/2004 | 1 | 02/15/2004 | |
| Mechanical problems involving 2004 chrysler town and country.*mr the vehicles malfunction indicator lamp illuminated while driving. the vehicle was taken to the dealer and returned the next day. after driving the vehicle 10 miles the light illuminated again. the vehicle was returned to the dealer twice after the initial visit for the same problem. the vehicle also began to malfunction in other ways. the speedometer would indicator the incorrect speed. the engine made noise when the gear shift was moved. the engine vibrated when accelerating. the brakes malfunctioned. the air conditioning failed intermittently. the dealer has not been able to permanently resolve the problems. *nm *jb | |||
| ENGINE AND ENGINE COOLING - EXHAUST SYSTEM - EMISSION CONTROL - GAS RECIRCULATION VALVE (EGR VALVE) | |||
| 05/15/2006 | 58200 | 1 | 03/06/2004 |
| Dt*: the contact stated while driving 20 mph or less, the check engine light illuminated followed by hesitation of the engine. the vehicle was inspected by a dealer. a diagnostic test was performed and the dealer determined a spark plug needed to be replaced. afterwards, the problem returned, and the vehicle was taken to another dealer for replacement of all spark plugs, spark plug boots, and the ignition. the problem persisted, and the vehicle was taken for an additional diagnostic test and it was determined there was a faulty egr valve. other people to whom the contact spoke to had similar problems with the chrysler 3.3 litre engine. the contact has to pay $100.00 deductible every time that vehicle is taken to the dealer. the contact feels there should be a recall. updated on 06/01/2006. *ak *ts | |||