Investigations
| NHTSA ID | Manufacturer | Date open | Date close | Subject | Recall campaign | |
|---|---|---|---|---|---|---|
| EXTERIOR LIGHTING | ||||||
| EA11010 | Chrysler Group LLC | 09/06/2011 | 11/29/2012 | Loss of headlight illumination | ||
| The subject vehicle (sv) population includes my 2005-2006 vehicles built between march 2004 and december 2005 manufactured with a trw supplied headlight switch assembly (hsa).the hsa was the primary focus of the investigation; earlier and later vehicles utilized different hsas.consumers complain that the headlights in the subject vehicles do not illuminate when the hsa is turned on, or that the headlights extinguish while on (subject failure).no other driving lights are affected.the front marker, tail, and instrument lamps operate.also, the high beams can be illuminated by holding the turn signal stalk in the up position.as reported by consumers, turning the hsa off and on typically corrects the failure.initially the failures occur infrequently but they become progressively more frequent with age.chrysler has indicated its intention to offer of an extended lifetime warranty on the hsa, so that consumers with this problem can have their hsa replaced at no charge when they begin experiencing the subject failure.commencing sometime in early 2013, chrysler will send letters to sv owners notifying them of the lifetime warranty.the sv headlight system design is essentially the same as that described in ea 05-009, which involved headlight anomalies in earlier model chrysler minivans; refer to it to for additional information.the subject failure is caused by friction between the plastic cam and metal surfaces of the electrical contacts in the hsa, which results in the production of plastic particles (debris).analysis shows that debris can collect on the electrical contact that controls the headlights, resulting in an open circuit and preventing the headlights from turning on.subsequent operation of the hsa may temporarily displace the debris, at which time the headlights operate correctly.lubricant was applied to the plastic cam beginning in december 2005, reducing debris production.consequently, subsequent failure levels were lower.the report counts shown above include only those that involve the subject failure.reports involving other failure modes which were identified have not been included either because they were not safety related, or if they were safety related, because there was no defect trend.the single crash event listed in the failure report summary table above involved a deer strike allegedly due to loss of headlights in february 2006.no injuries were reported in this crash.an april 2004 non-crash incident ( | ||||||
| EXTERIOR LIGHTING - HEADLIGHTS | ||||||
| EA11010 | Chrysler Group LLC | 09/06/2011 | 11/29/2012 | Loss of headlight illumination | ||
| The subject vehicle (sv) population includes my 2005-2006 vehicles built between march 2004 and december 2005 manufactured with a trw supplied headlight switch assembly (hsa).the hsa was the primary focus of the investigation; earlier and later vehicles utilized different hsas.consumers complain that the headlights in the subject vehicles do not illuminate when the hsa is turned on, or that the headlights extinguish while on (subject failure).no other driving lights are affected.the front marker, tail, and instrument lamps operate.also, the high beams can be illuminated by holding the turn signal stalk in the up position.as reported by consumers, turning the hsa off and on typically corrects the failure.initially the failures occur infrequently but they become progressively more frequent with age.chrysler has indicated its intention to offer of an extended lifetime warranty on the hsa, so that consumers with this problem can have their hsa replaced at no charge when they begin experiencing the subject failure.commencing sometime in early 2013, chrysler will send letters to sv owners notifying them of the lifetime warranty.the sv headlight system design is essentially the same as that described in ea 05-009, which involved headlight anomalies in earlier model chrysler minivans; refer to it to for additional information.the subject failure is caused by friction between the plastic cam and metal surfaces of the electrical contacts in the hsa, which results in the production of plastic particles (debris).analysis shows that debris can collect on the electrical contact that controls the headlights, resulting in an open circuit and preventing the headlights from turning on.subsequent operation of the hsa may temporarily displace the debris, at which time the headlights operate correctly.lubricant was applied to the plastic cam beginning in december 2005, reducing debris production.consequently, subsequent failure levels were lower.the report counts shown above include only those that involve the subject failure.reports involving other failure modes which were identified have not been included either because they were not safety related, or if they were safety related, because there was no defect trend.the single crash event listed in the failure report summary table above involved a deer strike allegedly due to loss of headlights in february 2006.no injuries were reported in this crash.an april 2004 non-crash incident ( | ||||||
| EXTERIOR LIGHTING - HEADLIGHTS - SWITCH | ||||||
| EA11010 | Chrysler Group LLC | 09/06/2011 | 11/29/2012 | Loss of headlight illumination | ||
| The subject vehicle (sv) population includes my 2005-2006 vehicles built between march 2004 and december 2005 manufactured with a trw supplied headlight switch assembly (hsa).the hsa was the primary focus of the investigation; earlier and later vehicles utilized different hsas.consumers complain that the headlights in the subject vehicles do not illuminate when the hsa is turned on, or that the headlights extinguish while on (subject failure).no other driving lights are affected.the front marker, tail, and instrument lamps operate.also, the high beams can be illuminated by holding the turn signal stalk in the up position.as reported by consumers, turning the hsa off and on typically corrects the failure.initially the failures occur infrequently but they become progressively more frequent with age.chrysler has indicated its intention to offer of an extended lifetime warranty on the hsa, so that consumers with this problem can have their hsa replaced at no charge when they begin experiencing the subject failure.commencing sometime in early 2013, chrysler will send letters to sv owners notifying them of the lifetime warranty.the sv headlight system design is essentially the same as that described in ea 05-009, which involved headlight anomalies in earlier model chrysler minivans; refer to it to for additional information.the subject failure is caused by friction between the plastic cam and metal surfaces of the electrical contacts in the hsa, which results in the production of plastic particles (debris).analysis shows that debris can collect on the electrical contact that controls the headlights, resulting in an open circuit and preventing the headlights from turning on.subsequent operation of the hsa may temporarily displace the debris, at which time the headlights operate correctly.lubricant was applied to the plastic cam beginning in december 2005, reducing debris production.consequently, subsequent failure levels were lower.the report counts shown above include only those that involve the subject failure.reports involving other failure modes which were identified have not been included either because they were not safety related, or if they were safety related, because there was no defect trend.the single crash event listed in the failure report summary table above involved a deer strike allegedly due to loss of headlights in february 2006.no injuries were reported in this crash.an april 2004 non-crash incident ( | ||||||
Consumer Complaints
| Fail date | miles | occurences | Purchase date |
|---|---|---|---|
| EXTERIOR LIGHTING | |||
| 10/09/2010 | 27000 | ||
| Turn signal doesn't work, or else it will blink the opposite side than what is turned on. | |||
| EXTERIOR LIGHTING - TURN SIGNAL | |||
| 07/06/2006 | 7000 | 45 | 11/30/2005 |
| Turn signal will flash either right or left, and actually changes to right when turning left, and left when turning right. i have had two very near mishaps due to the person behind me not knowing which way i am turning. i took the 2006 chrysker town and country van for repairs, and they knew what was bad, but did not have the part(s) avaliable. i am still driving this very unsafe vechicle, waiting for them to get the part(s). | |||