Damon Intruder 2002

Model Intruder made in 2002 by Damon got 10 consumer complains there are 3 recalls as well as 4 service bulletins. Consumer complaints with reference, among others things, to equipment, power train and service brakes, hydraulic. Technical service bulletines regarding equipment, exterior lighting and structure. There were some recalls concerningequipment, service brakes, hydraulic.

Model 2002

Recalls


CampaignManufacturerManufacturing dateType# of units affectedDate Owner notified MfgRecall Initiated byManufacturers of recalled vehicles/productsReport Recieved DateRecord Creation DateRegulation Part NumberFMVSS Number
EQUIPMENT - RECREATIONAL VEHICLE
07V130000DAMON CORPORATIONfrom 04/01/1997 to 04/30/2004V (Vehicle)2512806/26/2007MFRDAMON MOTOR COACH03/20/200703/22/2007
Defect SummaryCertain travel trailers and motor homes equipped with a two-door refrigerator, manufactured by the dometic corporation, may have a defect in the boiler tube. pressurized coolant solution could be released into an area where an ignition source (gas flame) is present.
Consequence SummaryRelease of coolant under certain conditions could ignite and result in a fire.
Corrective SummaryDamon will be working with dometic in order to repair these refrigerators (please see 06e076). dometic will repair these refrigerators by installing a secondary burn housing, a thermal fuse, and a melt fuse free of charge. dometic has retained stericycle inc. to manage this campaign. stericycle will assist you in locating dealerships or service centers and will provide assistance with scheduling of appointments. owners may contact dometic/stericycle at 1-888-446-5157 or damon at 1-800-860-3812.
NotesCustomers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
SERVICE BRAKES, HYDRAULIC
09V225000DAMON CORPORATIONfrom 01/01/2001 to 05/27/2009V (Vehicle)241505/01/2009ODIDAMON CORPORATION06/16/200906/15/2009
Defect SummaryDamon is recalling 2,415 motorhomes equipped with axles that include bosch zops or zoht pin slide hydraulic disc brakes. when combined with occasional or seasonal vehicle operation may experience calipers sticking in the applied position. this can result in abnormal heat generation at the wheel end causing brake drag.
Consequence SummaryThe driver would normally detect the brake drag but if undetected the temperature increase at the wheel end can eventually lead to soft pedal conditions due to brake fluid boil, and possible extended stopping distance increasing the risk of a crash.
Corrective SummaryDealers will inspect and replace the necessary components free of charge. workhorse is handling the remedy and owner notification for this campaign please see 09v-110. owners may contact workhorse at 1-877-246-7731.
NotesOwners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov .
SERVICE BRAKES, HYDRAULIC - SWITCHES - BRAKE WARNING
03V080000DAMON CORPORATIONfrom 05/01/1999 to 02/28/2003V (Vehicle)265605/12/2003MFRDAMON MOTOR COACH03/05/200303/19/2003571105 S5.3
Defect SummaryCertain motor home chassis fail to comply with the requirements of federal motor vehicle safety standard no. 105, hydraulic and electric brake systems. the brake system warning indicator may not function as required by standard.
Consequence SummaryIn some of the affected vehicles, the brake system warning indicator will not illuminate when the ignition is in the start position or for a low brake fluid condition, if the body builder relied solely upon ford's ivm compliance statement for the brake system warning indicator.
Corrective SummaryDealers will repair the brake warning lamp circuit. owner notification is began may 12, 2003. owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact damon at 1-219-272-9212.
NotesDamon recall no. 03-106.customers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).

Bulletins


BulletinBulletin dateReplacement BulletinItem no.SummaryAdded
EQUIPMENT
0109910/01/2001627581Information regarding flush floor system, may not be properly adjusted.*jb02/12/2002
EXTERIOR LIGHTING - HEADLIGHTS
0109510/01/2001627562Information regarding headlight securement bracket may not have been secured to the fiberglass cap backer.*jb02/11/2002
STRUCTURE
0210302/01/2002635446A condition may exist during high temperature conditions, the rubber traction on the entry steps may loosen. *tt10/23/2002
UNKNOWN OR OTHER
0109810/01/2001627579Subject regarding hoses being kinked at the water heater.*jb02/12/2002

Consumer Complaints


Fail datemilesoccurencesPurchase date
EQUIPMENT
01/01/2003912/20/2001
 Consumer had difficulty checking transmission fluid. the dealer had attempted to repair the vehicle 3 times unsuccessfully. *ts *ak there was a rattle noise, the bathroom was out of line, the door /exit door didn't stay closed, the tank leaked, the windshield wiper was inoperative, and the antenna was inoperative. scc
POWER TRAIN
01/01/2003912/20/2001
 Consumer had difficulty checking transmission fluid. the dealer had attempted to repair the vehicle 3 times unsuccessfully. *ts *ak there was a rattle noise, the bathroom was out of line, the door /exit door didn't stay closed, the tank leaked, the windshield wiper was inoperative, and the antenna was inoperative. scc
SERVICE BRAKES, HYDRAULIC
05/02/201145223
 I had a safety recall # 50401c done on 05/09/2006 to replace all 4 calipers because they might hang up and cause brake overheating and maybe a accident. at that time there was no damage and no worn of cracked parts. i was asked to return again for recall # 51101c to again replace all 4 calipers to the latest style for the same reason. this time 3 of the 4 calipers on the motorhome were deemed not usable because of cracks but the work horse corp. won't pay for new rotors. i think this damage is their problem and not mine. please advise.
08/06/200920000
 Tl*the contact owns a 2002 damon intruder rv. while driving approximately 25 mph, there was an unusual smell emitting form the braking system. the vehicle began dragging and was hesitant to accelerate. the vehicle was moved off of the road. once the vehicle cooled off for several minutes, it began operating normally. the contact was advised that there was a recall on the braking system; however, the remedy was not available (nhtsa campaign id number 09v225000- service brakes, hydraulic). the vehicle had not been repaired because the recall remedy was unavailable. the failure mileage was 20,000 and the current mileage was 21,000.
STRUCTURE
10/06/2003106/23/2003
 Left top corner windshield seal failed, and was leaking a lot of water. (2002 damon intruder 369)*ak the windshield came out at the top left hand corner and caused water to enter the rv. the dealer indicated that they didn't think it would stay in place because of structural conditions that caused the seal not to hold. *nlm
STRUCTURE - BODY - DOOR
01/01/2003912/20/2001
 Consumer had difficulty checking transmission fluid. the dealer had attempted to repair the vehicle 3 times unsuccessfully. *ts *ak there was a rattle noise, the bathroom was out of line, the door /exit door didn't stay closed, the tank leaked, the windshield wiper was inoperative, and the antenna was inoperative. scc
VISIBILITY - WINDSHIELD WIPER/WASHER
01/01/2003912/20/2001
 Consumer had difficulty checking transmission fluid. the dealer had attempted to repair the vehicle 3 times unsuccessfully. *ts *ak there was a rattle noise, the bathroom was out of line, the door /exit door didn't stay closed, the tank leaked, the windshield wiper was inoperative, and the antenna was inoperative. scc

Car dealers selling


StateCityZipNamePhone
LABOSSIER CITY71112SOUTHERN RV SUPER CENTER318-746-2267
OHNORTH CANTON44720CLAY'S RV CENTER, INC.